Escolar Documentos
Profissional Documentos
Cultura Documentos
Mechatrofice
HOME
SOCIAL PROFILES
Godown Wiring
7:25 PM
Godown Wiring
Search
No comments
Godown wiring uses to operate lamps/loads in a sequential manner, where only one load operates at a time. As
its name implies " Godown wiring ", it is used in godowns, tunnel like structures, long passages.. etc, where light
is only required for passage or it requires only at one position at a time.
Popular Tags
In godown wiring load are not controlled by randomly switching, user should follow a linear sequence in
switching from one end to another. That is, for to close the circuit of final load the remaining switches should be
On, but it opens when any switch is OFF. That is the load is in series with remaining switches from the begin
end.
Godown wiring makes the feasibility for the user to turn off the load when switching another, its circuit
arrangement is in such a way that, from common pole we can switch to both 1 & 2 poles, the 1st pole is
connected to load and 2nd to common pole of next and this sequence repeat. In godown wiring as the
remaining switches are in position common to the 2nd pole (c-2) then it is in contact with the common pole of
next switch by this arrangement we can connect infinite number of loads and switching one load OFF previous
load and ON next.
point...
Switch S1 in the circuit is SPST (single pole single throw) and remaining are SPDT (single pole double throw).
In godown wiirng the number of loads can be connected further to any extend.
Godown wiring - Components required
Component
specification
Quantity
MCB
250V , 50Hz , 5A
Switch
SPDT , 250V , 5A
Switch
SPST , 250V , 5A
Lamp
230V
music...
Fix Broadband Error 769 : The
specified destination is not
reachable
Connecting through WAN Miniport
(PPPOE)... Error 769: " The
specified destination is not
reachable. " Error 769 occurs mainl...
DSL not stable troubleshooting
and solution
If the DSL light blinking but can't
be stable, it might be due to signal
weakness in the line or due to
damage in modem. If you are u...
Series wiring
Parallel wiring
staircase wiring
+12 Recommend this on Google
http://mechatrofice.blogspot.in/2013/07/godown-wiring.html
1/2
10/30/2014
0 comments:
Infrared burglar alarm circuit
The circuit diagram shown below is
an infrared burglar alarm, which
works of main parts IR LED and an
IR Diode. The circuit can be used ...
Post a Comment
Links to this post
Subscribe to: Post Comments (Atom)
19
Find us on Facebook
LABELS
http://mechatrofice.blogspot.in/2013/07/godown-wiring.html
2/2