Escolar Documentos
Profissional Documentos
Cultura Documentos
The distinction between silt & clay cannot be based on particle size because the
significant physical properties of the two materials are related only indirectly to the size
of particles. Furthermore, since both are microscopic, physical properties other than
particle size must be used as criteria for field identification. There are 4 nos of field test
that we can easily conduct on the field to identify silt & clay. These are
o
Dry strength
Toughness to plasticity
Dispersion
Let us discuss each one of them one by one.
Dry Strength
The dry strength provides one basis for distinction. A small briquette of the soil is
molded and allowed to dry in the air. It is then broken and a small fragment about 1.0
cm in size is pressed between thumb and forefinger. The effort required to break the
fragment provides a basis for describing the strength as ver low, low, medium, high or
very high. A clay fragment can be broken only with great effort, where as a silt fragment
crushes easily.
Toughness / Plasticity
The property of plasticity is characteristic of clays and may be used as the basis for a
simple field test. At certain moisture contents a soil that contains appreciable quantities
of clay can be deformed and remolded in the hand without disintegration. Thus, if a
sample of moist soil can be manipulated between the palms of the hands and fingers and
rolled out into a long thread, it unquestionably contains a significant amount of clay. As
moisture is lost during continued manipulation, the soil approaches a nonplastic
condition and becomes crumbly. Just before the crumbly state is reached, a highly
plastic clay can be rolled into a long thread, with a diameter of approximately 3mm,
which has sufficient strength to support its own weight. Silt, on the other hand, can
seldom be rolled into a thread with a diameter as small as 3mm without severe cracking,
and is completely lacking in tensile strength unless small amounts of clay are present.
The record of a simple plasticity test should indicate not only whether a plastic thread
can be formed, but also the toughness of the thread as it nears the crumbling stage. This
condition is described as weak and friable, medium, or tough.
Disperson
The fourth procedure, known as the dispersion test, is also useful for distinguishing
between silt & clay, and for making a rough estimate of the relative amounts of sand, silt
and clay in a material. A small quantity of the soil is dispersed with water in a glass
cylinder or test tube and then allowed to settle. The coarser particles fall out first and
the finest particles remain in suspension the longest. Ordinarily sand settles in 30 to 60
sec. Materials of silt size settles in 15 to 60 min, whereas that of clay size remains in
suspension for at least several hours and usually for several days unless the particles of
clay combines in groups or floccules.