Escolar Documentos
Profissional Documentos
Cultura Documentos
The close proximity of cables to moving parts makes proper routing a must. If components are removed or replaced,
any cables disturbed by the procedure must be replaced as
close as possible to their original positions.
Samsung Electronics
3-1
3-2
Samsung Electronics
6. Pull the ADF unit (Platen Cover) upward and remove it.
Samsung Electronics
3-3
12. Unlatch the Scan Dummy and take out the Glass
from the Scan Upper.
14. Push the Belt Holder and take out the Belt, as shown
below.
Scan Dummy
15. Pull up the CCD Shaft and take out the Scanner
Module.
Scanner Module.
CCD Shaft
16. Remove two screws and take out the Motor Bracket.
Motor Bracket.
3-4
Samsung Electronics
Sensor ASS Y
Scan Motor
OPE Harness
Samsung Electronics
3-5
Side Cover R
ADF connector
3-6
Samsung Electronics
Pick-up Assy
ADF Upper
Samsung Electronics
3-7
OPE Cover
OPE Board
3-8
Samsung Electronics
Extension Guide
Samsung Electronics
3-9
3-6 SMPS
1. Before you remove the SMPS, you should remove:
Scanner ASSY
Rear Cover
SMPS
3. Pull up the Hook on both end, take out the LIU Board.
LIU Board
Modular
3-10
Samsung Electronics
Speaker
Samsung Electronics
3-11
5. Push the Holder Pulley to the right and take out the
Belt.
C-cab
Cartridge Carrier
3-12
Samsung Electronics
Samsung Electronics
3-13
3-14
Samsung Electronics
Samsung Electronics
3-15
Exit Belt
Exit Roller
Base Frome
3-16
Samsung Electronics
Feed Roller
Samsung Electronics
3-17