Escolar Documentos
Profissional Documentos
Cultura Documentos
Cable Specifications
This appendix describes the ports and connectors that are used to configure the Cisco ONS 15104 to
other network components. It covers the following information:
• Cable Accessory Kit on page B-2
• Console Port Signals and Pinouts on page B-2
• Ethernet Port Signals on page B-4
• Fiber Connectors on page B-4
For configuration examples using cables with Cisco ONS 15104 ports and connectors, see
“Connecting to Your Network” in Chapter 4, “Installing the Cisco ONS 15104.”. See Figure B-1 to
review the locations of the Ethernet and console ports and fiber-optic connectors.
17596
port
ONS 15104
CISCO OPTICAL REGENERAT OR 100-240 VAC\ 50/60 HZ
1.0-0.5 A 60 W
LINK
ETHERNET ACT CONSOLE TX RX
0 1 LINK P/1
TX RX
LINK P/0 SYSTEM SYSTEM
POWER
FAIL READY
Activity
(Ethernet) SONET Rx System Power
Fail
Activity System Power connector
(console) Ready
Link ports for the
OC-48 controllers
Regen1 and Regen0
Note Single-mode long-reach simplex cables with SC connectors are available from the following
cable vendors: AMP, Anixter, AT&T, Red-Hawk, and Siemens. These cables are not available from
Cisco Systems.
18146
ONS 15104
CISCO OPTICAL REGENERATO R 100-240 VAC\ 50/60 HZ
1.0-0.5 A 60 W
LINK
ETHERNET ACT CONSOLE TX RX
0 1 LINK P/1
TX RX
LINK P/0 SYSTEM SYSTEM
POWER
FAIL READY
Console port
connector (RJ-45)
RJ-45-to-RJ-45
rollover cable
Laptop computer
RJ-45-to-DB-9 or
RJ-45-to-DB-25 adapter
H3824
Table B-1 shows the pin-outs for the DB-9 adapter. Use the RJ-45-to-RJ-45 roll-over cable and
RJ-45-to-DB-25 female DTE adapter (labeled Terminal) to connect the console port to a terminal.
Table B-1 Console Port Signaling and Cabling Using a DB-9 Adapter
Table B-2 lists the pinouts for the asynchronous serial console port, the RJ-45 to RJ-45 roll-over
cable, and the RJ-45 to DB-25 female DTE adapter (labeled Terminal).
Table B-2 Console Port Signaling and Cabling Using a DB-25 Adapter
Fiber Connectors
The Cisco ONS 15104 has two pair of fiber connectors for bidirectional transmission. The left fiber
connector interfaces with an OC-48 regeneration port that transmits data. The right fiber connector
interfaces with an OC-48 regeneration port that receives data. The SC connector supports
single-mode, fiber-optic transmissions. The SC connector is the default connector for the
Cisco ONS 15104 as specified by the Telecommunications Industry Association (TIA) as the
Fiber-Optic Cable Intermatability Standard (FOCIS-3). (See Figure B-4.)
TX RX
18145
TX RX
0 1
TX RX
2 simplex connectors