Escolar Documentos
Profissional Documentos
Cultura Documentos
related land use scenario by year 2020 vis--vis the present land use. A discussion
of each component likewise presents the general and specific proposals on land use
policy.
Chapter 5 sets the proposed plan implementation scheme while Chapter 6
integrates the RPFP with existing plans and planning processes both horizontally and
vertically. Likewise, the Chapter presents the plans temporal aspect or its three
major phases of plan implementation. Chapter 6, inclusive of the implementation
scheme, is a discussion of the proposed monitoring and evaluation system. The
implementation support activities i.e. plan information, capability building and
research in Chapter 7 wraps up the Plan.
RPFP ASSESSMENT
The succeeding discussion presents the developments in the region relative to the
accomplishment of goals, objectives, the spatial development framework and
sectoral policies and strategies as enunciated in the first edition of the RPFP.
Assessment of Goals
The goal is to achieve a sustainable land use mix thereby effecting
a. a rational distribution of the population;
b. poverty reduction;
c. a more equitable sharing of the fruits of development among subregional areas and among men and women; and
d. attainment of environmental integrity
Generally, indicators that would have clearly shown the degree of fulfillment of
these goals were not complete. First, was the absence of an existing land use map
that would have shown changes in landuse over time. Second, there was
uncertainty on which set of indicators to use in assessing whether population
distribution was rational or not.
On poverty reduction, the incidence of poor families decreased from 46.9 to 46.0
percent or about 40 thousand less poor families. Incidence of poor families among
provinces saw increases in Camarines Norte, Catanduanes and Masbate. In terms of
magnitude, Camarines Norte was the only province that had more than 4 thousand
additional poor families. There is a need, therefore, to prioritize those areas in
program/project implementation for them to catch up in socio-economic
development.
Environmental integrity remained threatened as indicated by the deteriorating
state of our forests. Unsustainable land use is evident especially in areas falling
under slopes 18 percent and above but are planted with coconut.
Assessment of Objectives
In terms of objectives, the following general assessment indicated that still much
has to be done to fully attain them:
Mining
Protected Areas
Pasture/Grazing Lands
Pasture and grazing areas shall be maintained with sufficient and high
yielding varieties of forage grasses and legumes to improve soil water
absorption capacity, minimize soil compaction and erosion and increase
soil nutrients. Insufficient forage covers of existing pasture and
grazing lands particularly in Masbate shall be supplemented with trees
These were not implemented due to the high costs to the investor.
There were 26 identified industrial sites distributed throughout the
region but these had no on-site development and locators yet.
Settlements
Infrastructure
DEVELOPMENT CHALLENGES
Physical and Environmental Constraints
The region has a number of physical and environmental constraints, which can be
perceived as development challenges, to wit:
establishing a more equitable access to assets, income, basic and support services
and infrastructure. The state shall also promote food security, including sufficiency
for staple food particularly rice and white corn. The production of rice and white
corn shall be optimized.
RA 8550 An Act Providing for the Development, Management and
Conservation of the Fisheries and Aquatic Resources, Integrating all Laws
Pertinent Thereto and for Other Purposes or otherwise known as The
Philippine Fisheries Code of 1998. The state shall ensure that the objectives
of the fishery sub-sector are attained; and these are: 1) conservation, protection and
sustained management of the countrys fishery and aquatic resources; 2) poverty
alleviation and provision of supplementary livelihood among municipal fisherfolks; 3)
improvement of productivity of aquaculture within ecological limits; 4) optimal
utilization of off-shore and deep-sea resources; and 5) upgrading of post-harvest
technology.
RA 9003 An Act Providing for an Ecological Waste Management
Program, Creating the Necessary Institutional Mechanisms and
Incentives, Declaring Certain Acts Prohibited and Providing Penalties,
Appropriating Funds Therefore, and for Other Purposes otherwise known
as Ecological Waste Management Act of 2000. Under this Act, it is a
declared policy of the state to adopt a systematic, comprehensive and ecological
solid waste management program to ensure the protection of public health and
environment utilizing environmentallysound methods that maximize the use of
valuable resources and encourages resources conservation and recovery.
RA 7279 An Act Providing for a Comprehensive and Continuing Urban
Development and Housing Program, establish the Mechanism for
Implementation, and For Other Purposes otherwise known as Urban
Development and Housing Act of 1992. It shall be the policy of the state to
undertake a comprehensive and continuing Urban Development and Housing
Program, in cooperation with the private sector. Specifically, this program aims to:
1) uplift the conditions of the underprivileged and homeless citizens in Urban areas
and in resettlement areas by making available to them decent housing at affordable
cost, basic services and employment opportunities; 2) provide for the rational use
and development of urban land in order to bring about the following: a) equitable
utilization of residential lands in urban and urbanizable areas with particular
attention to the needs and requirements of the underprivileged and homeless
citizens and not merely on the basis of market forces; b) optimize the use and
productivity of land and urban resources; c) to develop urban areas conducive to
commercial and industrial activities which can generate more economic
opportunities to the people; d) to reduce urban dysfunctions, particularly those that
adversely affect health, safety and ecology; and e) to have access to land and
housing by the underprivileged and homeless citizens.
Other major objectives are: a) adopt workable policies to regulate and direct
urban growth and expansion towards a dispersed urban net and more balanced
urban-rural interdependence; b) provide for an equitable land tenure system that
shall guarantee security of tenure to program beneficiaries but shall respect the
rights of small property owners and ensure the payment of just compensation; c)
encourage the more effective peoples participation in the urban development
process; and d) improve the capability of local government units in undertaking
urban development and housing programs and projects.
PD 1586 : Environmental Impact Statement System. Provides the
establishment and institutionalization of a system whereby the exigencies of socioeconomic undertakings can be reconciled with the requirements of environmental
quality. It also caused for the declaration of certain projects, undertakings or areas
in the country as environmentally critical. For this purpose, the proper land and
water use pattern for the areas of said critical projects shall be prepared.
RA 7638 Department of Energy Act of 1992. which provides that the State
shall ensure continuous, adequate and economic supply of energy to achieve selfreliance in the countrys energy requirements. It also provides for the integrated
and intensive exploration, production, management and development of the
countrys indigenous energy resources, and through the judicious conservation,
renewal and efficient utilization of energy to keep pace with the countrys growth
and economic development and taking into consideration the active participation of
the private sector in the various areas of energy resource development.
RA 7916: The Special Economic Zone Act of 1995 provides that the State
shall actively encourage, promote, induce and accelerate a sound and balanced
industrial, economic and social development of the country to be able to generate
jobs especially those in the rural areas, increase their productivity and their
individual and family income. Also, to improve the level and quality of their living
conditions through the establishment of special economic zones in suitable strategic
locations in the country and through measures that shall effectively attract legitimate
and productive foreign investments.
RA 7881: An Act Amending Certain Provisions of RA 6657 Entitled An
Act Instituting a Comprehensive Agrarian Reform Program to Promote
Social Justice and Industrialization, Providing the Mechanism for its
Implementation and for Other Purposes. This amends Sec 2 of RA 6657 which
are exempted from the Comprehensive Agrarian Reform Program: a) lands actually,
directly and exclusively used for parks, wildlife, forest reserves, reforestation, fish
sanctuaries and breeding grounds, watersheds and mangroves; b) private lands
actually, directly and exclusively used for prawn farms and fishponds; c) lands
actually, directly and exclusively used and found to be necessary for national
defense, school sites and campuses, including experimental farm stations operated
by public or private schools for educational purposes, seeds and seedling research
and pilot production center, church sites and convents, mosque sites and Islamic
centers, communal burial grounds and cemeteries, penal colonies and penal farms
actually worked by the inmates, government and private already developed.
Development Administration
Land using activities at the regional level are regulated and implemented by
several line agencies, most of whom are members of the Regional Land Use
Committee (RLUC), in collaboration with local government units.
Based on record regarding the presence of physical plans at the local government
level:
Four of the six provinces had approved Provincial Physical Framework Plans
before 2002. These provinces include Albay, Camarines Norte, Masbate and
Sorsogon.
Only about 50% of all cities and municipalities have comprehensive land use
plans.
These imply that at least 50 percent of local government units (LGUs) are guided
by a land use plan in the identification and implementation of development
proposals. LGUs that do not have approved land use plans run a higher risk of
implementing unsustainable land using activities. Thus, compromising long-term
benefits, i.e., higher family incomes and sustainable development of investment
potentials, that would have been accrued from the rational use of physical
resources. The state of the environment, that will provide a healthy life support
system and continuous supply of resources, as also put at a risk of fast degradation.
All provinces, however, have organized Land Use Committees, which are tasked to
review city/municipal comprehensive land use plans for Sanggunian approval.
PHYSICAL ENVIRONMENT
Physical Characteristics
Land Area
The regions land area of about 1.8 million hectares is roughly 6.04 percent of the
countrys 30 million hectares (Table 3.01). Around 69 percent or two-thirds of the
regions land area is part of mainland Luzon while the rest is the combined land area
of the island provinces of Masbate and Catanduanes.
Table 3.01 Land Area by Province (In hectares), Region V: CY 2001
Province
Bicol Region
Albay
Camarines Norte
Camarines Sur
Catanduanes
Masbate
Sorsogon
Total Area
Percent of
(Hectares)
Regional Total
1,813,039
100.00
256,577
14.00
232,007
13.00
548,160
30.00
149,216
8.00
415,178
23.00
211,901
12.00
Percent of
National Total
6.04
0.86
0.78
1.78
0.51
1.37
0.72
Camarines Sur has the largest land area with 548,60 hectares or 30 percent of the
regional area while Catanduanes has the smallest with 149,216 hectares or 9
percent.
As to municipal areas, Labo in Camarines Norte has the largest municipal land
area of 58,936 hectares followed by Milagros in Masbate with 56,530 hectares. In
contrast, Camaligan and Gainza both of Camarines Sur, have the smallest land areas
of 468 and 1,475 hectares respectively. Among the seven cities in the region,
Sorsogon City is the largest with 27,611 hectares followed by Ligao City (24,675
hectares) and Masbate City with 18,800 hectares.
Topography
The regions topography may be generally described as ranging from slightly
undulating to rolling and from hilly to mountainous. Bicol is endowed with numerous
mountains and volcanoes. The most famous, Mt. Mayon in Albay, has the highest
elevation at 2,462 meters above sea level. Other volcanoes and mountains
dominating the countryside and their corresponding elevations include: Mt. Malinao
(1,548 meters), Mt. Masaraga (337 meters) and Mt. Catburawan (473 meters) in
Albay; Mt. Isarog (1,966 meters) and Mt. Iriga (1,143 meters) in Camarines Sur; and
Bulusan Volcano (1,560 meters) in Sorsogon.
In Camarines Norte, a rolling to rugged terrain surrounds the plains of Labo,
Talisay, Vinzons and Daet. This rugged topography stretches from Mt. Labo to the
Camarines Norte-Camarines Sur boundary and thence to a rolling strip along the
western coast of Camarines Sur, Albay and Sorsogon. The rugged landforms of
Eastern Bicol, Cordillera in the northeast extending from Calinigan Mountain
(Caramoan Peninsula) to Mt. Mayon, on the other hand, separates the plains of
Lagonoy, San Jose, Goa, Tigaon and Sangay from Bicol Plains. The Bicol Plains, a
main physiographic feature in the region, is a wide depression that trends
northwesterly from the western slopes of Mt. Mayon and stretches across the central
part of Camarines Sur. Three lakes--Buhi, Baao and Batoare located within this
valley.
Small patches of plains that are utilized for lowland farming intermittently break
the rolling terrain in the western coasts of Albay and Sorsogon. In Sorsogon, the
most noted physiographic feature is the fertile Irosin-Juban Valley, which is
surrounded by rough terrains of Bulusan Volcano in the southeast and Mts. Juban
and Batuan in the southwest. This valley is also noted as schistosomiasis and
filiariasis outbreak areas. Such water and mosquito-borne diseases pose a big threat
to public health in the area.
In the islands of Masbate, the relief conditions are almost similar in all three
islands (Ticao, Burias and Masbate). The terrain ranges from slightly undulating to
rolling and from hilly to mountainous. In each island, rugged topography is
concentrated on the north and gradually gives way to hills and rolling areas in the
south, southeast and southwest. The highest point in the province is the conical
peak of 700 meters above sea level located in Masbate, Island.
A rugged topography in its central core generally characterizes the island of
Catanduanes. Along its coastal regions, narrow strip of plains are found. A narrow
depression both in the northern and southern cores.breaks the rough terrain of the
island in its midsection.
Coastal Area
The regions coastal area is deeply embayed. This is characterized by the
presence of numerous bays and gulfs. These are: the Ragay Gulf, San Miguel Bay
and Lagonoy Gulf outlining the coasts of Camarines Norte and Camarines Sur; Albay
Gulf and Sorsogon Bay in Albay and Sorsogon. In addition, the region is endowed
with natural harbors, which serve as refuge for ships during heights of weather
disturbances in the vicinity.
Volcanoes, Faults and Earthquake Zones
The distribution of faults, volcanic and earthquake belts in the region is shown in
Figure 3.03. A parallelism between the Bicol Volcanic Belt, the Philippine Fault Zone
and the deep Philippine trench can be noticed.
The Bicol Volcanic Belt or Chain spans a total of 240 kilometers from Camarines
Norte in the north down to Sorsogon in the south. A total of sixteen volcanoes
approximately 24 kilometers apart, lie along the 200 kilometer chain which runs
parallel to and west of the Philippine Trench.
There are three active volcanoes, which have erupted within the past 600 years)
and their last recorded eruptions are: Mt. Mayon (2001); Mt. Bulusan (1988) and
Mt. Iriga (1628). (Table 3.02).
Figure 3.03
Volcanoes, Earthquake Fault and Tsunami Prone Area
Source: P hiVolcs
Most famous among the active volcanoes is the majestic Mt.Mayon with its near
perfect symmetry, fiery outbursts and destructive mudflows. It consists of deposits
formed basically by four major volcanic activities: airfall disposition, pyroclastric
flows, rain triggered debris flows and lava flows.
Mt. Iriga, with a peak of 1,143 meters above sea level, is likewise, of the
stratovolcano type. The main historical event for Mt. Iriga was a large volume
debris avalanche in 1628 AD, which dammed the Barit River and created Lake Buhi
presently known as the habitat of the smallest edible fish in the world, the
sinarapan.
Bulusan Volcano, located near the central part of Sorsogon province, peaks at
1,550 meters above sea level. Its last eruption was in 1988.
Associated with non-active volcanoes are geothermal fields. Tapped for power
generation, these fields operate geothermal power plants in Tiwi and Bacon-Manito
area in Albay and Sorsogon, respectively, for a combined Total Generating Capacity
of 512.574 MW and 317.67 MW dependable capacity. Sources of geothermal power
are Mt. Malinao in Albay and Pocdol Volcano in Sorsogon.
In addition to its location along the volcanic belt, the region lies near the center of
the Philippine Fault Zone (PFZ), which is a major earthquake generator in the
Philippine Archipelago (Figure 3.03). The zone, about 1,300 kilometers long, is
characterized by a bundle of parallel to sub parallel active faults confined with a
narrow zone trending north-northwest and south-southwest. It is characteristic of an
active fault, like the PFZ, to generate potentially destructive tremors since those are
shallow-seated or occur near the earths surface (less than 80 kilometers deep).
Another major source of earthquake in the region is the Philippine trench. A
trench is defined as a long, narrow and generally steep-sided very deep depression
in the ocean floor. The axis of a trench marks the position of a subduction zone,
where old oceanic lithospheric plates begin their descent into the earths interior.
A study conducted by Efren A. Uy and Benito T. Punsalan published in 1987
indicated that the Bicol Region is prone to earthquakes of Intensity V from the
above-cited source zones.
The narrowness and topography of the two island provinces, contribute largely
to the occurrence of numerous short minor rivers that serve as the drainage
channels for ten basin areas in Masbate and three for Catanduanes.
Lakes consist another vital inland water resource for the region, environmentally
and economically. There are numerous lakes, but most have small volume water
impounding capacities. The more important freshwater ponds in the region are:
Lakes Bato, Baao and Buhi in the Bicol Plains and Bulusan and Aguingay in
Sorsogon.
Lake Buhi is located at the eastern side of Mt. Iriga about 105 meters above sea
level and is surrounded by hills more than 300 meters high. It is well known for the
smallest edible fish called tabios or sinarapan. The lake is believed to have been
formed during Mt. Irigas large volume avalanche in 1628 AD, which dammed Barit
River. Located at the southwestern boundary of Camarines Sur and Albay is Lake
Bato. This serves as the discharge area for numerous small rivers and streams from
a large portion of Albays third congressional district. The lake has an outlet
waterway that runs from its northern shore towards Balatan finally discharging to
Burias Pass. The waterway is joined by another outlet channel from Lake Baao,
which is located north of Bato Lake.
Bulusan Lake, on the southeastern side of Bulusan Volcano, is 635 meters above
sea level. The lake occupies the depression between two lava flow lobes abutting a
hill on the southeast slope of the volcano. With a depth of 33 meters, the lake
covers an area of 16.5 hectares and has a circumference of 2,000 meters. The
intermittent Lake Aguingay is situated at a higher elevation about 1,100 meters
above sea level. This lake appears and disappears depending on the weather
condition and even expands to three times the area of Bulusan Lake during extreme
rainfall depths.
Slope
Slope greatly affects the use and management of the land. It determines to a
large extent the appropriate use and the optimum management practices to be
adopted to prevent and/or minimize its rapid degradation.
About 56 percent of the regions total land area is nearly level to moderately
sloping lands (0-18 percent). These are mostly the alluvial plains, mountain
footslopes, floodplains and valleys. The remaining 44 percent are mostly hilly and
mountainous (above 18 percent slope) which includes the ranges of hills on the
western and eastern section and some mountain peaks on the central part of the
region (Figure 3.05).
Table 3.03 Slope Classification by Province, Bicol Region
Total
Area
0-8
8-18
18-30
30-50
Source: Land Resources Evaluation P roject, Region V, 1987, Land M anagem ent B ureau
Camarines Norte, Camarines Sur and Masbate have more level to gently sloping
lands than hilly to mountainous areas (Table 3.03). This physical characteristic is
one major contributory factor to Camarines Surs achieved status as the regions rice
granary. The suitability of this level to gently sloping areas for wetland farming is
considerably high. In the case of Camarines Norte and Masbate, though they have
higher percentages of level lands compared to the other slope categories, both
provinces have not exhibited marked rice production figures due mainly to the
limiting role of water in rice farming. Either they lack irrigation facilities or their
water supply is so minimal that it cannot sustain submerged farming practices.
Thus, other uses for this level to gently sloping lands have been found, i.e.
pineapple production for Camarines Norte and livestock farming for Masbate.
In contrast, the provinces of Albay, Catanduanes and Sorsogon have more sloping
lands than level areas. This could be the main reason why abaca and coconut have
become the principal crops grown in these provinces. These crops are more or less
suitable for the above terrain provided some other factors are present.
LAND USE
Based on the latest existing land use data from the Local Resources Evaluation
Project in 1988 (Figure 3.06), more than half of the total land area is utilized for
agriculture and other development activities while 9 percent which have potentials
for agricultural use are underutilized. The province, which has the largest expansion
area is Masbate with 52,600 hectares while Sorsogon has the least areas available
for agricultural expansion (Table 3.04). Thus, said provinces have more
underdeveloped lands.
Table 3.04 Land Use Opportunity by Province, Bicol Region: 1988
AGRICULTURE
Province
Total
Area
(has.)
Active
Has.
%
49,317 19.30
OTHERS
Wetlands,
PreserRivers,
vation
Lakes
Has.
%
Has.
%
Has.
%
30,291 11.87 2,927 1.15 11,728 4.59
24,773 11.70
14,794
33,750 15.98
85,964 16.30
56,747 10.80
11,415
7.60
43,755 29.00
46,949 31.06
52,599 13.00
57,601 14.20
Expansion
Albay
256,577
Has.
%
141,200 55.30
Has.
19,794
Cam. Norte
232,007
124,797 59.10
Cam. Sur
548,160
275,559 52.30
Catanduanes
149,216
44,078 29.20
Masbate
415,178
271,450 67.10
Sorsogon
211,901
142,535 66.60
TOTAL
1,813,039
FORESTRY
9,828
%
7.80
4.10
Rehabilitation
29,740
7.00
9.50
1,447
7,683 3.64
5,452 2.58
2,588 1.71
2,363 1.56
4,447 1.10
31,700 14.80
7,219 3.37
3,122 1.46
Source: Land Resource Evaluation Project, Department of Agriculture. There is no available data for land use opportunity for
Camarines Norte, thus, the difference in land area with previous tables
Land Classification
Majority (69.3 percent) of Bicols land area is classified as alienable and disposable
(Table 3.05 and Figure 3.07). Camarines Sur accounts for the largest share (28
percent) followed by Masbate with 24 percent share.
Land Classification
(I n Hectares)
Total Land Area (Bicol Region)
Certified Alienable & Disposable
Unclassified Forest Land
Classified Forest Lands
Established Forest Reserve
Established Timber Lands
National Parks, GRBS & Wild Life Area
Civil Reservation
Fishpond
1,813,039
1,256,436
30,822
525,781
72,522
424,252
25,927
73
Percent
to Total
100.00
69.30
1.70
29.00
4.00
23.40
1.43
.004
3,082
0.17
1998
Source: Regional Socio Economic Trends, Bicol Region: CY 1999 , recomputed using
data on land area from the DENR
disposable lands and public lands regardless of tenure status. Within the croplands
there are 179,692 hectares of prime lands devoted to rice production. Some
116,064 hectares of those prime lands are fully irrigated while 63,628 hectares are
non-irrigated. The irrigated rice lands are found within the Bicol River Basin area in
the provinces of Albay and Camarines Sur. These areas, however, are subjected to
yearly flooding and siltation as calamities regularly occur. The Irosin-Juban valley in
the Sorsogon province is another area where big tracts of rice land can be found.
Palay production increased at an annual average of 2.3 percent for the last eight
years. Such good production is associated with the prevalence of favorable weather
condition in the region; when calamities strike, production goes down (as in 1998
when a drought and a strong typhoon visited the region).
Among the provinces, Camarines Sur remains as the regions rice granary,
accounting for more than half of the regions palay production. In terms of area
harvested, the last eight years saw an annual decline of 1.4 percent. From a high
305,140 hectares in 1996, this declined to 277,136 hectares in 2003. Among the
provinces, Albay had the highest rate of decline at 4.5 percent per year. The
average yield of palay increased by 4.07 percent per year or from 2.14 metric tons
per hectare in 1996 to 2.75 metric tons per hectare in 2003. Camarines Sur and
Albay realized high palay average yields. However, the regions average yield for
palay was still low when compared to the national average yield of 3.37 metric tons
per hectare.
The volume of corn production declined at an average of 5 percent annually for
the last eight years. The 1996 production of 101,482 metric tons went down to
66,361 metric tons in 2003. Albay experienced the most rapid decline at 8.6 percent
per year. In 1996, Albay was the leading corn producer of the region, accounting
for 41 percent of the total regional production. In 2003, Albay slid to third position,
contributing only 25 percent of the regions total corn production. Except for the
province of Masbate, all Bicol provinces experienced a decline in corn production.
The area harvested for corn, likewise, declined at an average rate of 4.6 percent
(from 120,140 hectares in 1996 to 81,762 hectares in 2003). Albay and
Catanduanes recorded the most rapid drops in area harvested. The leading corn
producing province was Masbate, with 60 percent of the total regional area for the
year 2003. The regional average yield of corn for the last eight years ranged from
0.74 to 0.86 metric tons per hectare. This fared badly with the national average
yield of 1.62 to 1.92 metric tons. While the regional average yield remained
constant, the national average yield increased. Among the provinces, Camarines Sur
had the highest average harvest of 1.48 metric tons per hectare.
Coconut production increased by an average of 15.6 percent per year, from
758,750 metric tons in 1997 to 1,232,615 metric tons in 2001. Masbate and
Camarines Sur remained as the leading coconut producing provinces of the region.
Camarines Sur registered the highest annual increase in production at 51.2 percent.
In terms of area harvested, the period 1997 to 2001 posted a decline of 1.9
percent every year. Except for those of Camarines Sur and Masbate, the area
harvested for coconut among all other Bicol provinces shrunk with Camarines Norte
having a declining rate of 5.4 percent every year. Except for Catanduanes, however,
all Bicol provinces increased their average yields of coconut. Camarines Sur
registered the highest increase in average production at 47.7 percent. Masbate
attained the highest average yield at 4.91 metric tons in 2001. Coconut is highly
susceptible to strong winds, hence, its average output is totally affected by the
occurrence of typhoons.
The regions abaca hectarage during the said period declined by 0.01 percent per
year, which was greatly felt in Catanduanes that experienced the highest rate of
decline at 3.13 percent per year. The average yield of abaca increased by 5.35
percent per hectare per year compared to the national average yield of 800
kilograms per hectare. Bicols average yield was very low at 300 to 350 kilograms
per hectare per year.
Abaca production had fluctuated from 1997 to 2001, although it registered a 0.3
percent increase per year. Catanduanes led the abaca producing provinces,
accounting for more than half of the total regional production. Sorsogon was a far
second with 20 percent of the total. Camarines Sur and Catanduanes also boosted
their abaca production while Albay, Camarines Norte and Sorsogon experienced
waning outputs.
Area harvested for abaca declined by an average of 2.2 percent per year. The
downtrend was experienced by all provinces, except Camarines Sur. Albay had the
highest rate of decline at 8.2 percent per year. The average yield of abaca
increased by 2.4 percent per hectare per year. Compared to the national average,
Bicols yield was very low at 0.41 to 0.53 metric tons per hectare.
The province of Camarines Sur had the only commercial growing area for
sugarcane in the Bicol region. From 1997 to 2001, its sugarcane production
increased by 4.1 percent per year (or from 216,587 metric tons in 1997 to 252,235
metric tons in 2001).
Area harvested for sugarcane also increased by 2.2 percent per year. As of 2001,
total area harvested for sugarcane was 6,913 hectares. The average yield of
sugarcane per hectare increased by 0.5 percent or from 34.12 metric tons in 1997 to
36.49 metric tons per hectare in 2001. Compared to the national average yield,
Bicols average was only 57 of the national figure.
The volume of mango production grew by 14.1 percent or from 887 metric tons in
1996 to 1,170 metric tons in 2002. Camarines Norte registered the bulk of the
increase with an annual growth rate of 144.5 percent; likewise for Sorsogon, albeit
with 2.6 percent. All other Bicol provinces experienced drops in their mango yield.
Area harvested for mango increased by 24.8 percent per year. The greatest
increase in area harvested was in Camarines Norte at 717 percent. Albay,
Catanduanes and Masbate did not experience a change in their mango production
areas. Average yield of mango declined by 4.3 percent per year. All Bicol provinces
had declining average yields of mango with Camarines Sur having the highest at
15.3 percent decline every year.
Banana production experienced a 35.5 percent annual growth rate from 1996 to
2002. Except for Catanduanes, all Bicol provinces had increasing banana
production. Albay had the highest growth rate at 101 percent followed by Sorsogon
with 98 percent. Since banana production is highly susceptible to strong winds, its
1998 yield went down to around 25,500 metric tons due to a strong typhoon that hit
Bicol.
In terms of area harvested, the region registered an 11.6 percent average
increase per year. The highest increase was registered in Albay province with 58.6
percent. Camarines Sur had the highest area harvested for banana at 9,539
hectares in 2002. This represents almost half of the total area harvested for banana
in 2002. Average yield of banana for Bicol is 3.44 metric tons. This is approximately
one-fourth of the national average yield of 13.23 metric tons per hectare. Except for
Catanduanes, all Bicol provinces attained increases in annual average yield. The
highest average yield was registered in Albay at 12.61 metric tons per hectare.
Pineapple production increased by an average of 5.5 percent per year from 1996
to 2002. Its bulk came from the province of Camarines Norte, which accounted for
94 percent of the regional production. Except for Catanduanes, all other Bicol
provinces had increasing trends in pineapple production.
The overall area harvested for pineapple decreased by 0.5 percent per year.
Sorsogon had the largest average of 12.6 percent increase in area harvested for
pineapple while Camarines Sur had only 1.1 percent average. The average yield of
pineapple increased by 6.2 percent per annum. The highest average yield was in
Camarines Norte at 26.77 metric tons per hectare in 2002.
The volume of calamansi production had been decreasing by an average of 9.2
percent per year from 1996 to 2002. Among the provinces, only Sorsogon
registered an annual average increase in production of 6.7 percent. Camarines
Norte, a leading calamansi-producing province in 1996 (with 2,228 mt), slumped in
2002 as it dipped to only 221 metric tons, roughly 10 percent of its 1996 production
level.
In contrast to the decline in the volume of production, the area harvested for
calamansi increased by 1.6 percent per year. Sorsogon had the highest increase at
6.7 percent per annum while that for Camarines Sur increased by 0.6 percent. The
average yield of calamansi per area harvested declined by 9.9 percent per year.
Camarines Norte registered the most drastic drop from 27.17 metric tons per
hectare in 1996 to 2.8 metric tons per hectare in 2002. In contrast, the national
aveage yield of calamansi increased by 16 percent per annum.
The area harvested for camote decreased by 4.7 percent per year from 1996 to
2002. Only the province of Albay increased its area harvested for camote with a 3.6
percent growth rate. The average yield per hectare declined by two percent per
year. Masbate and Sorsogon had increased average yields while the rest of the
provinces experienced diminished harvests.
Cassava production declined by an average of 5.1 percent during the period 1996
to 2002 (from 224,951 metric tons in 1996 to 156, 521 metric tons in 2002).
Masbate and Sorsogon had increased cassava production, although their shares of
the regional production were minimal. Camarines Sur remained as the leading
cassava producing province, accounting for more than 80 percent of the regional
output.
Area harvested to cassava increased by an average of 1.2 percent per year. The
province of Camarines Sur increased its area harvested by an average of 3.2 percent
per year. In 1996 the average yield of cassava was 7.69 metric tons per hectare.
This went down to five metric tons per hectare in 2002.
Cabbage production form 1996 to 2002 declined by an average of 11.3 percent
per year (from 2,188 metric tons in 1996 to 699 metric tons in 2002). Albay,
Camarines Sur and Sorsogon were the cabbage producing provinces of the region.
Albay produced 1,746 metric tons in 1996 but this went down to 311 metric tons
in 2002.
Area harvested to cabbage declined by 11 percent per year (from 270 hectares in
1996 to only 91 hectares in 2002). Albay, which used to have 207 hectares devoted
to cabbage production had only 33 hectares as of 2002. Average yield of cabbage
declined by 0.9 percent per year.
The volume of eggplant production in 1996 was 5,942 metric tons but this went
down to 5,255 metric tons in 2002. The average annual decrease was 1.9 percent.
Albay, the leading eggplant producing province, yielded 3,701 metric tons in 1996.
This declined to 2,414 metric tons in 2002 for a 5.8 percent annual decrease.
Area harvested to eggplant decreased from 1,204 hectares in 1996 to 1,169
hectares in 2002. In Albay, the decrease was 4.3 percent per year while in
Camarines Sur it increased by 2.6 percent per year. The average yield of eggplant
went down by 1.5 percent per year. From 4.94 metric tons per hectare in 1996 this
dropped to 4.5 metric tons per hectare in 2002.
Garlic is grown in the provinces of Albay and Camarines Sur. The volume of garlic
production dropped sharply from 397 metric tons in 1996 to only 13 metric tons in
2002. In 1996, Camarines Sur produced 360 metric tons but this dropped to nine
metric tons in 2002. Area harvested also decreased from 102 hectares in 1996 to 5
hectares in 2002. Average yield also decreased from 3.89 metric tons per hectare in
1996 to only 2.6 metric tons per hectare in 2002.
Pili production improved by an average of 15.6 percent per annum or from 2,156
metric tons in 1998 to 3,833 metric tons in 2003. Among Bicols provinces, Sorsogon
and Albay were the leading pili producing provinces. Catanduanes and Camarines
Norte had minimal pili production, while Masbate had negligible yield.
Area planted to pili increased by an average of 7 percent per year. Sorsogon had
the highest increase in area planted (from 716 hectares in 1998 to 1,133 hectares in
2003). The number of pili-bearing trees increased from 66,567 in 1998 to 98,390 in
2003.
Coffee production from 1997 to 2001 declined by an average of 11.5 percent per
year (from 1,534 metric tons in 1997 to 830 metric tons in 2001). Among the
provinces, only Sorsogon had an increased volume of production at 46.2 percent per
year. Camarines Norte had declined most in production at 23.3 percent per year.
Area harvested for coffee likewise declined by 1.5 percent per year, the most rapid
having been registered in Albay at 8.1 percent. In 1997, the total area harvested for
coffee was 3,390 hectares, by 2001 this was reduced to 3,189 hectares. Average
yield declined by 10.6 percent per annum (from 450 kilograms per hectare in 1997
to 260 kilograms per hectare in 2001). Among the provinces, only Sorsogon
registered an increase in average yield (from 200 kilograms per hectare in 1997 to
590 kilograms per hectare in 2001).
Livestock and poultry production areas refer to lands where animals and poultry
are raised. Pasture lands, most of which were located in the province of Masbate,
dominated the areas devoted to livestock raising in the region (as of 1988 there
were 109,355 hectares in Bicol). Most of the livestock produced in the region,
however, came from small farms. Animals were raised in coconut lands as pasture
areas. Hog raising was also of the backyard type with few commercial growers.
Similarly poultry production is with a handful of commercial egg producers located
mostly in Baao, Camarines Sur and Ligao City in Albay.
Inland fishing areas of the region consisted of lakes, rivers, streams and creeks.
These areas occupied 4,419 hectares, where freshwater fishes like bangus, tilapia
and carp were grown. The regions lakes are mostly located in Camarines Sur, where
Bato, Baao and Buhi lakes are found. Tilapia growing in fish cages is dominant in
these lakes. Estuarine areas are also present in the region. These are devoted to
fishponds where bangus and prawns are produced. As of 1988, there were 10,279
hectares of fishponds in the Bicol Region.
Mineral Lands
Of the regions 1.76 million hectares land area, approximately 33.8 percent
(595,708.56 hectares) were covered with mineral production sharing agreements
(MPSAs), financial and technical assistance agreements (FTAAs), exploration permits
(EPs), industrial permits (IPs), and mining lease contracts (MLCs). These are located
mostly in the provinces of Camarines Norte, Camarines Sur and Masbate. Approved
mining rights which are mineral lands cover 3,306.52 hectares.
Mining activities in the region can be divided into two areas, the non-metallic and
metallic sectors. The non-metallic sector is relatively stable. This is due to the
availability of processing plants within the country. The metallic sector always
experiences fluctuation in prices and its price is dictated by the world demand for
metals. Not unless our country will have its own processing and manufacturing
plants will the metal prices be stable locally.
Approximately 95 percent of the region had been geologically mapped in a scale of
150,000 wherein potential mineral occurrences had been identified. These known
minerals are point locations. Geo-hazard mapping is an on-going activity of the
Mines and Geo-Sciences Bureau.
Bicol is rich in human and natural resources and is blessed with the world-famous
Mayon volcano, six natural parks, 11 forest reserves, 19 waterfalls, 203 caves, six
lakes, a number of hot and cold springs, 14 dormant volcanoes and two active
volcanoes. In addition, there are long stretches of fine back, white and cream
beaches along coastlines of coastal municipalities for beach lovers and snorkeling.
INDUSTRY DEVELOPMENT AREAS
The industry sector plays a vital role in production land use. By providing
livelihood and employment opportunities for the people, it generates investments
that help reduce the incidence of poverty and thus, help steer the region toward
sustainable growth.
Since the early seventies, the government has recognized countryside
development as a major strategy to accelerate regional development. Several
programs were adopted to disperse and re-channel development activities outside
the Metropolis. Limited investments in the countryside, however, held back the
industrial dispersal programs and policies of the government. The priority given by
the national government on infrastructure development in Metro Manila proved
inconsistent with the objectives of the industrial dispersal policy, i.e., to decongest
Metro Manila and encourage industries to locate outside the metropolis.
Consequently, industries continued to locate in the metropolis and its suburbs,
leaving the countryside untapped.
The governments countryside development strategies included the following: (1)
the development of Regional Growth Centers (RGC) popularly known as Regional
Agro Industrial Centers (RAICs); (2) the establishment of growth networks and
corridors to strengthen linkages among provinces and regions; and (3) the
enactment of RA 7916 or the Special Economic Zone Act of 1995 as amended by RA
8748 and of RA 7227 or the Bases Conversion and Development Act. The identified
growth centers were envisioned as development hubs of the underdeveloped
regions.
Consistent with those strategies, Region V identified during the late 1980s the City
of Legazpi as the site for the Bicol Regional Industrial Center (BRIC). The presence
of major infrastructure facilities critical for an industrial center, like the seaport and
airport, were the primary factors for assigning the location to Legazpi City.
Barangay Lamba, Legazpi City was identified as the site for the BRIC. A feasibility
study conducted under the supervision of the Regional Development Council (RDC) V
revealed that developing the area would not be financially viable due to high
investment requirements. The RDC V through Resolution No. 13 Series of 1993
approved the transfer of the site by the City Government of Legazpi to Bgy.
Homapon, where the conversion of a 57 hectare agricultural land was approved and
a road network was constructed. The offsite road project was funded under the
Social Development Fund of the President (P7.125M) and DPWH Fund (P5.0M).
Seven years after, the BRAIC site remains a barren land. The landowner had not
initiated any onsite development because no investor was willing to locate in the
area. Its Conversion Order signed on September 26, 1996 stipulated that the
development of the area should proceed at the rate of five hectares per year, not to
exceed a total of five years from the issuance of this Order. It further stated that
any violation of the terms and conditions shall be ground for the recall or
cancellation of this Order. The decision of the PARO on this matter is still being
awaited.
A corridor-type strategy deemed to accelerate agri-industrial development in infraready areas, thus requiring less government investments, was conceived by the RDC
V in 1993. The project, dubbed as the Legazpi-Iriga-Naga Growth Corridor (LINGC)
covered the four cities of Legazpi, Ligao, Iriga and Naga, and selected municipalities
in Albay, Camarines Sur and Camarines Norte (Table 3.06 and Figure 3.08). Later
on, it included Daet, Camarines Norte and was renamed as the Legazpi-Iriga-NagaDaet Growth Corridor (LINDGC).
Camarines Sur
Camarines Norte
City/Municipality
Legazpi City
Ligao City
Municipality of Daraga
Municipality of Camalig
Municipality of Guinobatan
Municipality of Oas
Municipality of Polangui
Iriga City
Naga City
Municipality of Bato
Mu nicipality of Nabua
Municipality of Baao
Municipality of Bula
Municipality of Pili
Municipality of Daet
The completion of the LINDGC master plan in January 1999 could pave the way to
the rapid development and emergence of several business centers along the growth
corridor. The implementation of some government projects identified in the master
plan is on going, such as: Pantao Port, Legazpi Port, Legazpi Airport, Bicol River
Basin-related projects (i.e., the River Basin and Watershed Management Program)
and several solid waste management projects of the LINDGC-member local
government units.
The enactment of the Special Economic Zone Act in 1995 paved the way to the
identification of several ecozones in the region. Five areas were initially recognized
in Bicol as ecozones, namely: the cities of Naga and Iriga in the Province of
Camarines Sur; Legazpi and Tabaco in the Province of Albay; and Sorsogon in the
Province of Sorsogon (Figure 3). In addition, some LGUs also considered other
areas in their municipalities as sites for special economic zones (Figure 3.09). This
was consistent with the PEZA Law, which stipulated that other areas may be
identified as ecozones although they do not meet the criteria set for ecozone
establishments provided that the said area shall be developed only through local
government and/or private sector initiative without any financial exposure on the
part of the national government, and that the area can be easily secured to curtail
smuggling.
Table 3.07 presents the list of proclaimed and PEZA Boards approved special
economic zones in the Bicol Region. Notably, only the Legazpi City Special Economic
Zone and the Global Industrial Maritimes Complex in Jose Panganiban, Camarines
Norte had Presidential Proclamation issued by President Fidel V. Ramos on June 9,
1998 (Presidential Proclamation No. 1249) and by President Gloria Macapagal-Arroyo
on December 2, 2003 (Presidential Proclamation No. 508), respectively. As in the
BRAIC, there were no locators in Legazpi Ecozone despite some groundworks
undertaken onsite by the City Government of Legazpi. The other proposed ecozones
in the region already have their PEZA Board Resolutions, however, they have yet to
meet other requirements to qualify for a proclamation by the President of the
Philippines. (Table 3.08).
Table 3.07. List of Special Economic Zones in Region V
PROVINCE
Albay
ECOZONE/
LOCATION/
DEVELOPER
Legazpi City Special
Economic Zone
Sitio Caridad,
Banquerohan, Legazpi
City
City Government of
Legazpi
Tiwi Ecozone
Bagumbayan, Tiwi
Tiwi Ecozone
Corporation
Rapu-Rapu Economic
Zone
Rapu-Rapu
Rapu-rapu Minerals,
Inc.
Camarines Norte Global
Industrial/Maritime
Complex
Larap, Jose
ESTIMATED
PREFERRED
PROJECT
INDUSTRIES
COST
33.13 PhP206 M
Food processing and
beverage, light metals
industry, electronics and
appliance manufacturing,
furniture and fixtures,
garments, textiles and
wearables, ceramics & nonmetallic minerals
processing, organic
chemicals, gifts, toys and
housewares
31.30
PhP98.774 M Electronics/computer
peripherals, garments,
ready-to-wear apparels and
wood-based products
41.39
$23.0 M Minerals
AREA
(in ha.)
30.00
Camarines Sur
Panganiban
Bicol Industrial Park
Sitio Banasi, San Jose,
Bula
FPI Industrial Park,
Inc.
Isarog Heights Special
Economic Zone
Cadlan, Pili
Manubay AgroIndustrial and
Development Corp.
Naga Agro-Industrial
Center
Pacol. Naga City
Pacol Industrial
Development Corp.
Sta. Rita Industrial
Park
San Jose & Sagurong,
Pili
Sta. Rita Ecozone
Corporation
100.00
supplies/armaments
PhP620 M Food processing, wood
products, ceramics, textiles,
wearing apparels,
electronics-computers
124.32
105.00
219.00
Table 3.08. Proposed Industrial Centers in Bicol Region by Province (in ha)
Province
Albay
Camarines Norte
Camarines Sur
Catanduanes
Masbate
Sorsogon
TOTAL
RAIC
57
57
PICs
PIEs
TOTAL
57
30
614.32
70
100
400
1,271.32
30
614.32
70
100
400
1,214.32
Product Lines
Pulp and Paper
Products
Coco Products
Coco Products
Cement
Pulp and Paper
Products
Coco oil, copra cake
Metallic mineral
products
Various coco oil based
products such as
soaps & cooking oil
NUMBER
879
1,607
25,230
27,716
By business activity, Wholesale and Retail Trade had the most number with 16,723
or 60.34 percent, far second was Community, Social and Personal Services with
3,423 (12.35%) and the least was in Agriculture, Hunting and Fishing with 2.23
percent.
Table 3.11 Number of SME Establishments by Business Activity
Bicol Region, 2002
BUSINESS ACTIVITY
PERCENT
SHARE (%)
NUMBER
619
2.23
56
0.20
204
0.74
56
0.20
1,052
3.80
78
0.28
Fishing
Mining & Quarrying
Manufacturing
Electricity, Gas & Water
Construction
414
1.49
0.03
16,723
60.34
1,055
3.81
1,947
7.02
Finance, Intermediation
728
2.63
675
2.44
Education
103
0.37
139
0.50
437
1.58
3,423
12.35
27,716
100.00
Problems that inhibit SMEs from expanding are: the high cost of financing or
interest rate, stringent collateral requirements by financing institutions, inadequate
or inefficient infrastructure support system that contribute to high cost of doing
business in the region, limited market, poor product design and packaging, lack of
access to market information and poor forward and backward linkages among and
between production sectors.
For the Information and Communication Technology (ICT) sector, the region
houses six companies engaged in Business Process Outsourcing (BPO), located in
the two cities of the region, namely: Legazpi City (4) and Naga City (2). These
companies are operating in line with data conversion, medical transcription, web
design, digital animation and maintenance services for US companies. The
combined employment of these companies totals to 1,102, with data conversion as
the highest employer. Almost all companies started operation in 2003, except for
one (1) company which started in 1999.
Supporting the ICT sector are Bayantel & Digitel, the main telecommunication
providers & Internet Service Providers (ISPs) in the region with bandwidth ranging
from 56kbps to 1 mbps. Both companies can deliver T3 connection (US standards
48mbps) or a combination of E-1 connections (European Standards currently used in
the Philippines). All provinces have ISPs with Camarines Sur having the most
number of ISPs (8). There are four (4) companies that cater to Plain Old Telephone
(POTS), using non-digital copper wiring. There are at least 46 schools and training
institutions which offer ICT-related disciplines ranging from short-term courses to
bachelors degree in computer science and majority of these are located in the
provinces of Albay and Camarines Sur.
The 0.12 km. per sq. km. increase in road density in the region meant an additional
2,254.23 kilometers of constructed/improved roads. Passable year-round, those
roads significantly increased and improved the accessibility and mobility of goods
and services. Barangay roads, comprising 58% of the regions total road density,
remained as the dominant track for road transport.
The road improvements, which included critical roads and bridges throughout the
region, were undertaken through major foreign-assisted projects. These included the
following: (1) Construction of Quirino Highway in Camarines Sur; (2) Rehabilitation
of Maharlika Highway (Calauag-Sta.Elena, Sta.Elena-Labo, Labo-Daet, and DaetSipocot sections); (3) Masbate Rural Road Network Development Projects (Packages
1 and 2); (4) ADB-funded Mobo-Cataingan Road in Masbate; (4) road component of
Sorsogon IAD Project, and Farm to Market Road Development from the DAR and DA.
The cumulative road network is shown in Table 3.12.
Table 3.12. Existing Road Length, By Classification and
Surface Type of National Road, Bicol Region: as of CY 2002
Road Length (In Kms.) By
Surface Type of National
Land
Total
Road
Category
Road
Area
Road
Density
ConGravel/ Total
(Sq.Km.) (Kms.) National Prov'l Mun./City Brgy. (km/sq.km.)
Asphalt
crete
Earth (km.)
Albay
2,552.6 17,24.8 399.70 420.30
205.90 698.90
0.70 238.00
67.20 94.50 399.70
Cam. Norte
2,071.6 13,94.7 200.30 146.60
119.60 928.10
0.70 41.50 136.60
22.30 200.30
Cam. Sur
5,266.8 41,25.7 659.40 771.60
448.80 2,245.90
0.80 272.10 110.30 277.00 659.40
Catanduanes 1,511.6 9,60.1 315.10 156.20
58.20 430.60
0.60 63.70
7.30 244.10 315.10
Masbate
4,047.7 9,87.6 381.00
74.30
91.40 441.00
0.20 93.20
98.10 189.70 381.00
Sorsogon
2,141.4 16,42.9 307.70 228.30
127.30 979.60
0.80 249.80
31.40 26.50 307.70
Total
17,591.7 108,35.8 2,263.20 1,797.30 1,051.20 5,724.10
0.60 958.20 450.80 854.10 2263.20
Percentage
20.90
16.60
9.70
52.80
- 42.30
19.90 37.70 100.00
(%)
Province/
City
The railway development and rehabilitation in the region consisted of three major
components: 1) the 224 kilometer Mainline South (MLS) from Lucena City to Naga
City, 2) 100 kilometers from Naga City to Legaspi City, and 3) study for the Sorsogon
Railway Extension project from Camalig, Albay to Matnog, Sorsogon. These
components were recommended in the previous RPFP for improvement and
development.
The first two railway sections were rehabilitated within the planning period, the
former in CY 1995 and the latter in CY 1999. They included the refurbishing of the
rolling stocks. The supplementary feasibility study for the Sorsogon Railway
Extension project was completed and was already approved/endorsed by the RDC V
for financing through the Official Development Assistance.
Notwithstanding the rehabilitation of the PNR MLS, the nagging issues and
concerns of the railway transport system centered on the poor condition of the
railroad tracks and rolling stocks that often resulted to train derailments and longer
travel time as compared to buses covering the same route. The most recent PNR
accident was in 2004, which brought about deaths and injuries to train passengers
thus forcing the management to indefinitely suspend the PNR operations along the
Manila to Legazpi City route. A major reason for the continued deterioration of the
PNR MLS is its lack of maintenance.
A current effort to address the woes of the railway system is a Feasibility Study on
the rehabilitation of the MLS, which includes the Sorsogon Railway Extension Project.
The project was approved and endorsed by the RDC V and is subject for approval by
the Investment Coordination Committee (ICC). The proposed project will provide the
linkage with the North Rail project that is currently on-going.
Railways
The railway development and rehabilitation in the region consisted of three major
components: 1) the 224 kilometer Mainline South (MLS) from Lucena City to Naga
City, 2) 100 kilometers from Naga City to Legaspi City, and 3) study for the Sorsogon
Railway Extension project from Camalig, Albay to Matnog, Sorsogon. These
NUMBER
9
5
36
6
7
13
70
As of CY 2004, there were 9 National Ports. The Base Port is Legaspi City Port,
being the site of the Regional Operations of the PPA. The rest are terminal ports, of
which the Tabaco City Terminal Port, owing to its strategic location and facilities, is
also classified as an International Port. Except for Legaspi City and Jose Panganiban
Ports, the rest have RORO ramp facilities. Generally, the physical condition of the
national ports in the region needs further improvement and upgrading. Some of the
national ports lack basic facilities such as passenger terminals, warehouses, berthing
facilities, and others to accommodate more and larger vessels. The construction of
the Pantao Port in Libon Albay is on-going.
In terms of foreign trade, Tabaco Port takes a major role being the main port of
entry in the region. In CY 2000, the port recorded eleven (11) foreign ship calls with
gross registered tonnage (GRT) of 63.090 metric tons of handled cargoes, down by
50% compared to the CY 1999 GRT of 129,770 metric tons.
There are 38 local ports, implemented by the LGU with assistance from the DOTCPMO Ports. These include 32 municipal ports and six Barangay Ports. The Fish
Ports, operated either by LGU or BFAR under the DA, consist of Municipal and
Barangay Fish Ports. At present, there are eight (8) fishing ports, seven of which are
municipal fishing ports and one is a barangay fishing port located in Legaspi City.
Water Resources
Some 30 river basins provide an estimated annual runoff of 12,804 MCM of
surface water across the region. (Please refer to Annex 3.3 and Figure 3.14). Such
abundant yield provides the resource for the development of water supply, irrigation,
fisheries, hydro-thermal and other uses, like recreation. The infrastructure elements
of water resource development include the facilities for water supply, irrigation, and
flood control and drainage.
Groundwater, the other major water resource, has an estimated storage of 22,449
MCM regionwide. Its distribution by province is presented in Table 4.3. Of the
regions major river basins, the Bicol River Basin contributes the highest estimated
storage while Masbate Island Basin contributes the least.
Table 3.14 Distribution of Groundwater by Province in the Bicol Region
Groundwater
50-Yr
Estimated Estimated Recommended
Mining
Basin
Provinces/s
Storage
Inflow
Estimate
Withdrawal
(MC) MCM/year Safe Yield
MCM / year
MCM / year
Bicol River
Cam. Norte, Cam.
11496
2074
2074
2304
Basins
Sur, Catanduanes
& Albay
Albay-Sorsogon Albay & Sorsogon
9150
779
779
962
Masbate Island Masbate
1803
531
531
567
Basins
Total for
22449
3384
3384
3833
Region V
In terms of water usage, as of December 1999, the water rights granted by NWRB
was 96.40 %, which was equivalent to 94,905.74 liters per second (lps). The
irrigation sector was granted the highest, accounting for 94.02 percent of the total
grant while the least was for industrial use. (Table 3.15).
Table 3.15 Water Rights Usage-Wise, Bicol Region: as of December 1999
Water Use/Source
Liters/Seconds
Percentage
Municipal
2,876.82
2.92
Ground Water
2259.00
Surface Water
617.82
Industrial
616.82
0.63
Ground Water
37.60
Surface Water
578.85
Irrigation
92563.34
94.02
Ground Water
1226.45
Surface Water
92336.89
Other Uses
2393.73
2.43
Ground Water
21.55
Surface Water
2372.18
Total
98450.34
100.00
Ground Water
3544.60
3.60
Surface Water
94905.74
96.40
Source: NWRB
Water Supply
The water supply system in the region includes public and privately-owned water
sources for domestic and commercial uses. The public water supply systems are
categorized into three service levels, namely: Levels I, II, and III.
Despite having a large water resource potential, Bicols total households that were
provided with potable water supply was still low at 66.11 percent (Table 3.16). As of
2002, the province of Camarines Sur had the highest household coverage (80.24
percent) while the least served provinces were Camarines Norte (49.88 percent) and
Masbate (50.77 percent).
Table 3.16 Household Served by Water Supply, By Province, Bicol Region: CY 2002
Level I
Level II
Level III
Total
Number
No.
of
%
of
No.
of
%
of
No.
of
%
of
No.
of
% of
Province/Region
of
HH
HH
HH
HH
HH
HH
HH
HH
Household
Served served Served served Served served Served served
Albay
1,133,413
21,674 55,329 25.52 18,173 8.32 54,496 25.14 127,998 59.05
Cam Norte
469,680
91,706 5,660 6.17 17,576 19.17 22,504 24.54 45,740 49.88
Cam Sur
1,610,976
299,174 148,587 49.67 35,742 11.95 55,735 18.63 240,064 80.24
Catanduanes
221,903
42,270 6,337 14.99 14,638 34.63 7,454 17.64 28,430 67.26
Masbate
734,569
144,145 46,375 32.17 21,742 15.08 5,071 3.52 73,188 50.77
Sorsogon
679,851
130,796 30,246 23.12 34,874 26.66 30,852 23.59 95,972 73.38
Region
4,850,392
924,854 292,534 31.63 142,745 15.43 176,112 19.04 611,392 66.11
2002
Pop'n
Level I
An average of 31.63 percent of the total households was served. Among the six
provinces, Camarines Sur had the highest coverage (49.67 percent).
Level II
An average of 15.43 percent of the total households was served. The province of
Catanduanes had the highest service coverage (34.63 percent), mostly sourced from
springs. Almost all of the regions municipalities/cities had this type of water facility.
Level III
An average of 19.04 percent of the regions total households was served. The
province of Albay had the highest systems coverage (25.14 percent), while Masbate
had the lowest (3.52 percent). There were 39 operational water districts
strategically located in the urban areas of the region (Annex 3..4).
Irrigation
Cognizant of the importance of irrigation in achieving food security and sustainable
agricultural development, the Agriculture and Fisheries Modernization Act (AFMA) of
1997 accorded highest priority to irrigation-related endeavors. Still, the potential
benefits from irrigation development in the region has not been fully harnessed. As
of 2002, the level of irrigation development remained at only half of the estimated
potential irrigable areas of 239,660 hectares. Only 118,541 hectares were irrigated
(Table 3.17).
Table 3.17 Status of Irrigation Development, Bicol Region: as of December 2002
Estimated National Communal Private
Remaining
Total
Irrigation Irrigation Irrigation
Potential
Total
Irrigation
Irrigable System
System
System
Area to
Province/Region
Dev't.
Area
(NIS)
(CIS) ** (PIS) ***
be Deve(%)
(in hss.)
loped
No.
Area
No.
Area
No.
Area
No.
Area
*
(Has)
Albay
54,620 4 1,946 102 10,643 249 11,584 355 24,173
44.26
30,447
Cam Norte
22,590 2 2,910 66 4,177
3
182
71
7,269
32.18
15,321
Cam Sur
123,700 6 14,690 203 40,759 120 13,653 329 69,102
55.86
54,598
Catanduanes
3,770 - 74 2,288
74
2,288
60.69
1,482
Masbate
19,880 - 105 3,743 47 1,027 152
4,770
23.99
15,110
Sorsogon
15,100 2
950 119 6,951 88 3,038 209 10,939
72.44
4,161
Region
239,660 14 20,496 669 68,561 507 29,484 1190 118,541
49.46 121,119
About 58% of the estimated irrigable area had communal irrigation systems; 17%
had national irrigation systems; and the rest had private irrigation systems. The
province of Camarines Sur shared the highest irrigated area (58.21%), more than
the combined irrigated areas of the five (5) other provinces. Figure 3.16 shows the
location of these irrigated areas.
The poor performance of the irrigation sector was due to a host of interrelated
technical, hydrologic, socio-economic, institutional, environmental and political
issues. Essentially, such issues must be properly addressed if the benefits from
irrigation development will have to be optimized. In 1989, there were 113,337
hectares of total service area irrigated as compared to 118,541 hectares irrigated in
2002. This meant an increase of just 5,204 hectares or 4.6%.
Flood Control and Drainage
Flood control, drainage and shore protection mitigate the loss of lives and
properties within settlement areas and productive agricultural lands from the threats
of typhoon-induced floods and tidal surges.
In 1989, some 1,778.365 kilometers of Flood Control and Drainage structures
were constructed. From 1990 to 2003, the mitigation intervention was minimal with
only 4.5 kms of flood control and drainage structures erected and a meager 2.3 kms
of similar structures rehabilitated. (Annex 3.5). New constructions, however, were
done in all the provinces, except Sorsogon. Rehabilitation works such as repair, river
dredging, clearing of floodways and other similar activities were also undertaken in
the provinces of Albay and Camarines Norte.
On shore protection and seawalls, some 27.731 kilometers were constructed in
1989. From 1989 to 2003, only 500 linear meters were constructed in the provinces
of Camarines Norte, Camarines Sur, Catanduanes, and Masbate.
Financial constraints tended to limit the governments interventions along this subsector. This was reflected in the design of structures (e.g. a low 1:5 year return
period) such that the focus was more on flood mitigation rather than on flood
control. Also, some structures were poorly constructed resulting to inefficient and
ineffective response to the calamity in flood-prone areas. Thus, the need to
strengthen disaster preparedness, response and rehabilitation in threatened areas
with priority on the formulation of an integrated flood control program by all
concerned sectors.
Power/Energy
The energy sector in the region involves power generation, transmission, and
electrification.
Power Generation
IIn 1989, there were only 15 generating units in the region with a total capacity of
335.4 MW. These improved to 46 generating units in 2000 with an aggregate
generating capacity of 512.574 MW (Table 3.18). Due to the temporary shutdown of
some units in the Tiwi geothermal for rehabilitation, however, the dependable
energy was down to only 317.67 MW (61.98 percent).
The list of existing power generation in the region is shown in Annex 3.6 while the
location of the power sources are shown in Figure 3.17.
Figure 3.17 Existing Power Generation Sources
Energy resource development, during the period under review, included the
exploration and production of local energy sources, such as coal, geothermal,
hydrothermal, and other renewable energy.
Coal Development
While coal deposit was identified in the island of Rapu-Rapu, this primary energy
source has yet to be developed.
Geothermal Energy Development
Exploration and establishment of geothermal power plants were conducted in
Albay and Sorsogon provinces, as follows: (a) Completion of the BacMan II Unit II
(Cawayan), which started operation in 1994; (b) On- going Establishment of BacMan
II - Unit II (Bogtong); (c) On-going establishment of BacMan Binary, (d) Initial
exploration of Mt. Labo and Bulusan Geothermal Power Plant to establish the extent
of the reserve, and (e) evaluation of the feasibility study on the BacMan III, also
known as Tanawon. The available geothermal resources for development as
proposed by the DOE are listed in Table 3.19.
3.19 Potential Geothermal Resources for Development in the Bicol Region
Installed
Year of
Name
Location
Capacity (MW) Commissioning
1. Tanawon
40.0
2007
Sorsogon
2. Manito/Manito Lowlands
20.0
2008
Albay
3. Manito/Kayabon
40.0
2008
Albay
4. Rangas
40.0
2010
Sorsogon
Hydrothermal Development
The potential sites for hydrothermal development in the region are indicated in
Annex 3.7. Of these, four potential sites were identified by the DOE for hydropower
generation. (Table 3.20).
Table 3.20 Potential sites for Hydropower development in the Bicol Region
Year of
ClassifiInstalled
Name
CommisLocation
cation Capacity(MW)
sioning
Kapilihan MHP
Mini-Hydro
3.0 2005 Virac, Catanduanes
Colasi MHP
Mini-Hydro
1.0 2007 Camarines Norte
Dugui MHP
Mini-Hydro
4.0 2008 Virac, Catanduanes
Hitoma MHP
Mini-Hydro
3.0 2011 Caramoran,
Catanduanes
Name
PHESI
PHESI
Location
Catanduanes
Masbate
Power Transmission
As of CY 2002, the length of transmission lines (T/L) in the Bicol mainland totaled
1,709.17 Circuit Kilometers (CKM), distributed as follows: (1) 34.5 KV T/L,
connecting the Barit Hydro Plant I Buhi to the Luzon Grid, 0.7% of the total T/L
length; ( 2) 69 KV T/L, 24.1%; (3) 230 KV T/L, 51.7%; and (4) +/-350 KV
T/L, 23.5%. (Table 3.22).
Table 3.22 Existing Power Transmission Lines in the Bicol Region: 2002
Province
Albay
Sorsogon
Camarines Sur
Camarines Norte
Total
Percent
34.5 KV
11.12
11.12
0.70
69 KV
103.31
113.48
157.94
38.27
413
24.16
Length
230 KV
+/-350
Total
KV
180.99
146.15
430.45
42.46
170.04
325.98
512.33
85.02
766.41
148.06
186.33
883.84 401.21 1,709.17
51.71
23.47 100.00
Electrification
The assessment of the sub-sector follows:
Rural Electrification
As of June 2004, the region attained 100 percent energization of its municipalities
or 91.56% of the total barangays. In actual figures, only 293 barangays out of
3,471 remained to be energized. Most of those areas are located in Masbate. In
terms of viable areas covered by the Electric Cooperatives, some 3,417 (98.44%) of
the total barangays are potential. Out of those potential barangays, 93.01% or
3,178 barangays have been energized or a total of 239 barangays have yet to be
energized by the electric cooperatives (Figure 3.18).
Figure 3.18 Energized Barangays
Power Distribution
Distribution is similar to transmission, except that the former uses only lower
voltage lines that distribute electricity to the end users for residential, commercial
and industrial uses. From the transmission level, a total capacity of 235.97 MVA
substations (Annex 3.8) are currently installed in strategic locations in each of the
provinces of the Bicol Peninsula. These substations serve as the primary channels
that bring down the voltage level, so that power could be transmitted safely over
densely populated areas. For distribution to the utilities and industry users, they use
the 69 KV transmission lines. However, the substations installed capacity of
188.776 MVA (installed capacity = plant factor x substation capacity) is not enough
to support the energy demand of 140.63 MW. It is below the normal reserve or
twice the demand equivalent to 281.262 MW. Among the Electric Cooperatives
(ECs) substations, only SORECO II is capable of supporting its maximum load
demand while MASELCO substation is under-rated.
From the substations, the electric energy is further trimmed down to a lower level
before its distribution to the end users. The ECs operate at a voltage of 13.2/7.62
KV line to ground system. As of December 2001, the region had a total of
7,338.11circuit kilometers of distribution lines, the breakdown by EC is shown in
Table 3.23.
Table 3.23 Existing Distribution Lines by Electric Cooperatives in the BicolRegion
as of 2001
Electric
Double Three
Cooperatives
Circuit Phase
Albay
- 347.36
ALECO
347.36
Camarines Norte
1.30 431.79
CANORECO
1.30
431.79
Camarines Sur
13.48 707.02
CASURECO I
247.09
CASURECO II
4.05
164.22
CASURECO III
3.00
140.27
CASURECO IV
6.43
155.44
Catanduanes
4.84 208.29
FICELCO
4.84
208.29
Masbate
3.55 299.52
MASELCO
3.55
278.12
TISELCO
21.40
Sorsogon
2.47 307.49
SORECO I
183.59
SORECO II
2.47
123.90
TOTAL
25.64 2,301.47
Vee
Single
Open
Total
Phase Phase Secondary
40.25 478.45
221.45 1087.51
40.25
478.45
221.45 1,087.51
147.63 346.77
228.15 1,154.34
147.63
346.77
228.15 1,154.34
230.90 1255.43
464.11 2,657.46
40.39
314.78
171.02
773.28
77.38
350.11
181.10
776.86
42.17
364.14
19.03
568.61
70.96
226.40
92.96
552.19
29.53 133.83
163.14 539.63
29.53
133.83
163.14
539.63
0.84
69.16
12.86 382.38
41.09
0.17
322.93
0.84
28.07
12.69
63.00
168.18 657.67
362.65 1,498.46
71.09
264.09
125.63
644.40
97.09
393.58
237.02
854.06
617.33 2,941.31 1,452.36 7,338.11
Systems Loss
The operational efficiency of the ECs is mainly determined from the system losses
caused by both the technical and non-technical factors. As of CY 2001, the average
system loss of the ECs was 20.89 percent, higher by 0.81 percent than that of the
CY 2002 level (Table 3.24). The loss remains more than five percentage points
higher than the maximum allowable loss of 15 percent but is lower than 5
percentage points from the penalty system loss of 25 percent.
Among the ECs, only FICELCO met the standard posting of a low system loss of
11.78 percent, down by one percentage-point from the CY 2000 level. SORECO
recorded the highest system loss of 27.33 percent. Although it went down by 0.41
percent from the CY 2000 level, still it was higher than the penalty systems loss. The
other ECs posted system losses of between 17 to 25 percent. ALECO was already
within the penalty limits. The Comparative System Loss By Electric Cooperative for
CY 2000 and 2001 are shown in Table 3.24.
Table 3.24 Comparison of System Loss by EC, 2000 and 2001
Systems
Electric
CY 2000
CY 2001
LossReduction/
Cooperative
(In Percent)
(In Percent)
Increase
REGION V
20.08
20.89
0.81
ALECO
21.19
24.89
3.70
CANORECO
20.74
20.90
0.16
CASURECO I
16.22
21.14
4.92
CASURECO II
16.00
17.56
1.56
CASURECO III
24.34
23.80
-0.54
CASURECO IV
20.35
21.93
1.58
FICELCO
12.83
11.78
-1.05
MASELCO
21.45
21.68
0.23
TISELCO
21.92
17.51
-4.41
SORECO I
19.69
21.29
1.60
SORECO II
27.74
27.33
-0.41
Source: NEA V
Power Rates
The comparative power rate by electric cooperatives is shown in Table 3.25. At
the regional level, the rate increased from P 3.35 KWH from 1991 to P 5.47 KWH in
2000.
Source: NEA V
The high power rates in the region can be attributed to the following factors: a)
the cost of electricity generated and purchased; b) the nature of the market served;
and c) the efficiency of the cooperatives.
On the cost of electricity, NPC sold power at a uniform rate based on a One Grid
One Price policy. As of August 2002, its wholesale price in the Luzon Grid was
pegged at P 1.6032/KWH for Utilities Group (i.e. ECs in the region, except SORECO
I, had a rate of P 1.785/KWH since it is within the category of Small Utility Group of
the NPC) and P 1.4238/KWH for Non-Utilities Group (i.e. GCC). In spite of this, the
average power cost among the ECs still varied from MASELCOs P 3.45 to FICELCOs
P 3.76 per KWH.
The 1990 MANTECH study on the rationalization of power rates in the Bicol Region
showed that the discrepancy in power rates was a function of the service area
served by the ECs considering the distribution expenses per KWH sold and the load
factors and the presence or absence of large commercial and industrial consumers.
While the efficiency of ECs was also a factor contributing to the selling rate, it was
determined by their financial performance and operational efficiency.
Financial Performance
As of December 2001, all electric cooperatives in the region incurred losses in
their operation. For the whole region, the deficit of the cooperatives amounted to P
332 million pesos. The losses incurred by most of the cooperatives were attributed
to the operating cost, depreciation cost, and interest on loans. The net margin and
collection efficiency by electric cooperative is shown in Table 3.26.
Source: NEA V
Collection Efficiency
As of December 2001, the average collection efficiency of the ECs rated 91%
(Table 3.26). FICELCO had the highest collection efficiency of 98% while TISELCO
(island cooperative of Masbate) had a low 72%.
Communication
The communication services sector facilitates the socio-economic processes. It
provides accessible and affordable information infrastructure and services. In
consonance with the national vision, the region has established a regulatory
environment conducive to the sustainable growth and development of the
information infrastructure and services. It promotes and sustains the environment
that fosters a healthy relationship among stakeholders particularly between the
service providers and the consumers. The regions communications facilities cover
telephone, broadcast, postal and telegraph services. The telecommunication
providers in the country are presented in Annex 3.9 while the inventory of
telecommunications facilities in the region are shown in Annex 3.10.
Telephone Services
The Telecommunications network covers the following services: 1) Local Exchange
Carrier Service, 2) Inter-Exchange Carrier, 3) International Gateway Facility, 4)
Radio Mobile, 5) Radio paging Service, 6) Value-Added Service, and 7) Satellite
Operators Service. The nations telecommunication industry structure is shown in
Table 3.27.
The regions Local Exchange Carrier Service showed that in 2002, Bicol had 12
service providers (Table 3.28), which covered a total of 135,422 installed capacity
and 66,701 subscribed lines or 2.75 telephone density and 1.36 subscribed
telephone density. The situation was a drastic improvement compared to 1989
when there were only seven service providers and a telephone density of 0.037.
The other components of telecommunication services consisted of: a) InterExchange Carrier Operations served by six (6) operators, b) International Gateway
Facility served by five (5) operators, c) Radio Mobile served by 3 Cellular Mobile
Telephone System and one (1) Public Trunk Repeater Services, d) Radio Paging
There were fourteen (14) telephone service players in the region, consisting of 13
private operators and one government-operated (TELOF) (Annex 3.10.). With the
liberalization of the telecommunications industry, the telephone density increased
from 0.037 in 1989 to 2.75 per 1000 population in 2002. The accessibility and
availability of telephone lines also increased from a density of 2.35 lines per 1,000
population to 2.39. That corresponded to 111,354 lines and 57,797 connections. The
details are presented in Table 3.30.
Table 3.30 Telephone Density, 1999
Indicator
CY 1999
CY 1998
% Increase
Exchange
69
67
2.99
Capacity/Lines
111,354
107660
3.43
Connections
57797
51122
13.06
Telephone Density
2.39
2.35
1.70
Source: www,ntc.gov.ph
Post Postal
Offices Stations
Albay
24
Cam Norte
13
Cam Sur
47
Catanduanes
11
Masbate
13
Sorsogon
28
Total
136
Percentage
(%)
78.00
16
3
2
8
2
38
2002 Inventory
Regular
Extension
Private
District
Total
Post
Post
Postal Total
office
Office Stations
40
I
19
12
6
37
16
II
19
9
4
32
49 III
26
10
8
44
19
IV
26
13
4
43
15
28
174
90
44
22
156
24.00 100.00
58.00
28.00
14.00 100.00
The reduction was the initial step made to keep the Postal Corporation
operationally viable as a result of tough competition from the CMTS. Further, Bicols
Philpost operational area was clustered into four districts. Their respective covered
areas are shown in Table 3.33.
Postal operations in the late 90s covered mainly mail volumes posted/delivered
and money orders issued/ paid. The current postal operations cover various postal
activities to make the Corporation viable with some considerable decrease in its
revenue-generating products and services (Annex 3.11). Remarkably, Philpost V
increased its 2002 revenue over that of 2001 through intensive marketing of postal
products and services that were not affected by the advancement in communications
technology. These involved postal products and services such as: 1) Postal IDs, 2)
Philatelic Stamps, 3) COD Commissions, 4) 3rd class mails, 5) M-BAGS, 6)
Presentation to Customs Fees, 7) Postage Charge Account, 8) Metered Machine
Stamps. Despite stiff competition from the CMTS, the corporation increased its
revenues by 0.17% in 2002. It also attained 89.61% of the target revenues.
However, the total revenue generated was only one-third of the total current
operating expenditures of the Corporation. Philpost V needs to concentrate more on
income generating activities and to trim down its organizational structure to the
desired level of viability.
Facilities and Services
In 1989, the TELOF under the Department of Transportation and Communication
(DOTC), operated a total of 146 telecommunication facilities, broken down as
follows : 1) 6 units Teletype, 2) 67 units landline, 3) 64 units Radio HF/CW, and 4)
9 units Radio VHF. These constituted a service ratio of .037 per 1000 population,
which was very low.
The TELOF operations and services covered four areas: 1) Telegraph services, 2)
Telegraphic transfer, 3) Social telegram, and 4) telephone services (Annex 3.12). In
2001, TELOF operated a total of 122 telegraph stations but these decreased to 113
telegraph stations in 2002. The reduction was caused by the entry of the cellular
phone industry, whose carriers (Globe and Smart) installed cells sites in different
areas in the region. On the other hand, the telegraphic transfer stations also went
down from 59 to 58 telegraphic stations. The three TELOF telephone exchanges
(Ligao, Ragay, and Canaman/Camaligan) increased their switching capacity from 844
in 2001 to 992 in 2002. Their total number of subscribers, however, slightly
diminished from 582 to 551 for the period 2001-2002. The decrease was attributed
to the transfer of subscribers to private telephone companies and to the extensive
use of CMTS.
During the period 2001 to 2002, TELOF operations showed that its volume of
activities handled decreased, except for the relayed messages which increased by
about 41.86%. Nevertheless, its total revenue increased by 16.86%.
Social Infrastructure
Social infrastructure provides the facilities for education, health, other public
buildings and solid waste management facilities. The efficient provision of such
facilities, contributes to the regions economic development, that is, the level of
service to the people especially in the rural areas of the region.
Schools
The schools in the region fall within the category of any of the following four (4)
educational levels: Pre-Elementary, Elementary, Secondary, and Tertiary. As of
2002, there were 4,259 schools in the region distributed as shown in the Table 3.34.
Table 3.34 Number of Schools By Level, By Province Province/City, Bicol Region: As of 2002
LEVEL
Pre-Elementary
Elementary
Secondary
Tertiary
No.
Province/
Total
Private
Sch.
%
City
Sch.
PriExten
PriPubPriAttach
Purely
Dist Public
Public
Total Public
Total
Total
Vate
sions vate
lic Vate
to
Pre- Total
Elem School
Albay
26
1
28
24 52
531 39 570
62
30 26 118 15 11 26
766 18.00
Cam. Norte
14
66
11
30 41
249 11 260
36
11 14
61
4 10 14
376 8.80
Cam. Sur
38
45
30
6 36
837 55 892
121
30 44 195 16
9 25 1148 27.00
Catanduanes 20
226
- 226
34
4
1
39
2
2
4
269 6.30
Masbate
28
47
4
8 12
605 13 618
68
6 23
97
2
8 10
737 17.30
Sorsogon
20
3
8 11
440
7 447
59
12 14
85
5 14 19
562 13.20
Iriga City
3
1
10
3 13
39 14
53
7
1
4
12
6
6
84 2.00
Legaspi City
4
11
9 20
40 13
53
2
6
7
15
1 12 13
101 2.40
Naga City
3
9
17
16 33
23 24
47
7
1
8
16
2 13 15
111 2.60
Sorsogon
4
9
7
6 13
65
8
73
11
8
19
105 2.50
City
Total
160
178
121
110 231 3055 184 3239
407 101 149 657 47 85 132 4259 100.00
%
- 5.40
- 76.10
- 15.43
- 3.10 100.00
Source: DepED V, CHED V
were in good condition, d) 1,712 classrooms were still needed to meet the
enrollment requirements (Annex 3.15).
Health Facilities
The health facilities in the region are served by both government and private
entities. Currently, there are 136 hospitals in the region, of which 85 hospitals are
operated by private institution and 51 hospitals are operated by the government.
These include 137 Municipal Health Centers (MHCs), and 1,045 Barangay Health
Stations (BHS). The details are shown in Table 3.35.
Figure 3.20 Location of Tertiary (Government) Schools
Table 3.35 Summary of Health Facilities by Province/City, Bicol Region: As of December 2002
Other
No. of Hospital
Health
No.
Facilities
of No.
Province/
Pop.
Government
Private
Grand
Muni- of
City
2000
Total
No.
Comcipa- Brgy
No. of
Reg'l/
Mun./
of
Dist.
munity/
Ter- Secon- Prility
MHCS
Prov'l
City
Total
Total
BHS
Hos.
Meditiary dary mary
Hos.
Hos.
care
Albay
15 548 1,091,810
5
1
6
3 13 16
22
17 161
Cam.
12 282 422,273
1
1
1
1
4
1
3
5
9
13
16
94
Norte*
Cam. Sur
35 1,000 1,594,149
2
3
5
3 13
2
7
9
22
48 288
Cat' nes
11 315 215,356
1
4
2
7
1
2
3
10
11
58
Masbate
20 520 636,225
1
3
4
1
9
3
9 12
21
21 186
Sorsogon
14 505 515,857
1
4
2
2
9
2
5
7
16
16 173
Sub-total 107 3,170 4,475,670
Legaspi
70 157,010
1
1
4
2
6
7
23
City
Ligao City
55
90,603
- 11
2
2
3
Tabaco
47 107,166
1
1
2
3
5
6
6
City
Iriga City
36 137,810
3
3
3
11
Naga City
27
70,087
3
1
4
4
24
Masbate
30
71,441
2
5
7
7
City
Sorsogon
36 134,678
2
2
2
2
27
City
Sub-total
- 301 768,795
Total
107 3,471 5,244,465
7 22
15
7 51
8
26 51 85 136 137 1,045
Source: DOH
* Includes the additional barangays from Quezon Province
Table 3.37 Summary of Land Area Required for Solid Waste Management
by Province, Bicol Region
Province/City
Population
Land Area (Has.) *
2000
2010
2020
2030
2000 2010 2020 2030
1,094,154 1,303,434 1,552,744 1,849,740 28.45 33.89 40.37 48.09
Albay
Camarines
459,573
504,840
554,567
609,191 11.95 13.13 14.42 15.84
Norte
Camarines Sur 1,556,057 1,845,982 2,189,926 2,591,954 40.46 48.00 56.94 67.39
Catanduanes
215,840
246,363
281,179
320,929
5.61
6.41
7.31
8.34
Masbate
709,707
840,732
995,347 1,179,817 18.45 21.86 25.88 30.68
Sorsogon
652,773
799,080
978,179 1,197,420 16.97 20.78 25.43 31.13
Total
4,688,104 5,540,431 6,551,942 7,749,051 121.89 144.05 170.35 201.48
Source: Computation
Assumption: 2.6 Has. Per 100,000 population
Bicol Natural Park, under Proclamation No. 431 dated December 29, 2000,
within the municipalities of Lupi and Sipocot, in Camarines Sur as well as of
Basud and San Lorenzo Ruiz in Camarines Norte, covering an area of 5,201
hectares;
Mt. Isarog Natural Park, under Proclamation No. 214 issued on June 20, 2002,
covering the municipalities of Pili, Ocampo, Tigaon, Goa, Calabanga,
Tinambac in the province of Camarines Sur and Naga City, with a total area of
10,112.35 hectares;
Mayon Volcano Natural Park, under Proclamation No. 413 issued on Nov. 21,
2000, covering the municipalities of Bacacay, Malilipot Sto. Domingo, Daraga,
Camalig, Guinobatan, and the cities of Tabaco, Legazpi and Ligao, with a total
area of 5,458.55 hectares;
Bulusan Volcano Natural Park, under Proclamation No. 421 issued on
November 27, 2000, covering the municipalities of Bulusan, Irosin, Juban,
Barcelona, and Casiguran, with a total area of 3,673.29 hectares;
Libmanan Caves National Park located in Libmanan, Camarines Sur, covering
an area of 19.40 hectares, whose proposed Proclamation was submitted to
the DENR Central Office;
Caramoan National Park in Caramoan, Camarines Sur, covering an area of
347 hectares, whose proposed proclamation was also submitted to the DENR
Central Office.
Figure 3.21 National Integrated Protected Areas (NIPAs)
Table 3.38 Protected Areas , Area Coverage, Location, and Status, Bicol Region: CY 2003
Name of Protected Area Area Coverage
Area (Has.)
No. of
Dwellers
Status
Natural Park
Bicol Natural Park
26
Pili, Ocampo,
TIgaon, Goa, Naga
City, Calabanga,
Tinambac , Cam.
Sur
Tabaco, Bacacay,
Maliilipot, Sto.
Domingo, Legaspi
City, Daraga,
Camalig,
Guinobatan, Ligao,
Albay
Bulusan, Irosin,
Juban, Barcelona,
Casiguran
12
Submitted to CO (Prop.
347 Proc.)
115
Mangrove Areas
Bongsanglay Natural Park Batuan Masbate
Watershed Areas
Juban-Magallanes WFR
Juban, Magallanes,
Sorsogon
29
Catanduanes WFR
Baras, Bagamanoc,
Caramoran,
Gigmoto, Pandan,
Panganiban, San
Miguel, San Andres,
Viga, Virac
344 (accdg.
To
LGU)
0 (accdg.
To
DENR
data)
Tugbo WFR
Mobo, Masbate
Matang-Tubig WFR
Monreal , Masbate
13
58
48
Garchitorena Cam.
Sur
Cawayan, Masbate
Cawayan Masbate
Biodiversity Conservation Priority areas were identified in the Bicol region under
the Philippine Conservation Priorities shown below (Table 38A).
Table 3.38A Biodiversity Conservation Priority Areas in Bicol Region
Conservation
Priority Areas
Priority
Level
Estimated Area
Location
Region
Within
Biodiversity
Corridors
Terrestial
Ragay Gulf
Very High
Mt. Labo
Very High
74,637.39
V & IV
Bicol Corridor
Extremely
High Critical
28,896.06
Camarines Sur
Bicol Corridor
Catanduanes Island
Very High
63,607.37
Catanduanes
Extremely
High Urgent
20,882.42
Camarines Sur
Very High
7,414.69
Camarines Sur
Caramoan
Peninsula
Lake Nabua
Bicol Corridor
Extremely
High Critical
Bicol Corridor
Lake Bato
Extremely
High Urgent
BaconManito
Insufficient
Data
Mt. Bulusan
National Park
Very High
19,053.15
Sorsogon
Albay, Sorsogon,
Masbate &
Northern Samar
VIII & V
Marine
Ticao- San
Bernardino StraitLagonoy Gulf
Extremely
High
325,362.38
377,474.37
Mt. Villion-Mapili
Very High
18,009.75
Masbate
Mobo-Uson
Very High
9,164.63
Masbate
Daraga-PlacerMalatugon
Very High
8,103.94
Masbate
EHu Extremely High Urgent are areas that require the most urgent attention
because they are at immediate risk of losing a high percentage of their biodiversity.
Failure to initiate appropriate conservation interventions soonest could lead to
significant loss of biodiversity in these areas.
EHc -- Extremely High Critical areas fit one of these two types: (1) either they
have extremely high biodiversity importance (EHP) with very high socio-economic
pressure, or (2) they have very high biodiversity importance (EHB) but with
extremely high economic pressure.
VH Very High - priority areas that either have extremely high biological
importance (EHB) but with a lesser degree of socio-economic pressure (HP/MP) or
have very high biological importance (VHB) but with very high or socio-economic
pressures (VHP/HP).
The Bicol region has 11 Proclaimed Watershed Forest Reserve (WFR) areas shown
in Table 3.39.
Table 3.39 Major Proclaimed Forest Reserve Areas, Bicol Region: 1998
Name of Watershed
Bicol Region
Total Area
Covered
Proc. Date.
Proc. No.
37,734
810
10/27/92
84
762
11/25/66
128
43
06/23/33
43
5,545
11/18/91
837
1,160
01/09/98
1151
470
09/26/32
500
26,010
06/23/87
123
1,305
05/02/94
368
247
05/02/94
369
350
05/02/94
370
1,032
11/23/92
108
Some NIPAS component areas overlapped with the conservation priority areas as
identified under the Philippine Conservation Priority areas e.g.; Caramoan National
Park, Lagonoy Biotic area, Abasig-Matogdon, Mananap Natural Biotic Area,
Catanduanes Watershed Forest Reserves, Mt. Isarog Natural Park, Tiwi National
Park, and Bulusan Volcano National Park. There is a need to assess the NIPAS and
redefine boundaries to ensure that protected areas contain the appropriate biological
important areas.
Non-NIPAS Areas
Non-NIPAS areas are those that have outstanding physical and aesthetic features,
anthropological significance and biological diversity but have not been included in
the NIPAS and need to be protected for the same reasons of NIPAS areas.
Wetlands (coastal & freshwater), which are in the form of lakes, swamps,
marshes and river systems and which were created by tectonic, geologic and
hydrological processes. They may or may not contain water permanently.
Lakes, which are temporary features on the earths surface. Shallow lakes are
likely to degenerate and disappear rapidly due to pollution and siltation.
There are three (3) lakes in the Bicol Region: Bato, Baao-Bula and Buhi, all in the
province of Camarines Sur, with a combined surface area of 6,000 hectares. These
lakes are home to 10 identified freshwater fish species that include the endangered
tabios or sinarapan (acclaimed as the smallest fish in the world), freshwater prawn
and freshwater clam. Lake Buhi, formed due to large volume of debris avalanche or
mega landslides, has shallow depths and very irregular outline. About 5,800
fishermen are currently dependent on the Basins lake system for livelihood.
Lake Buhi in Camarines Sur is considered as a wetland critical to Biodiversity. It
has the following resident species: Resident Bird: Common Bittem, Wandering
Whistling duck, White-collared Kingfisher; and Endemic Birds: Philippine Mallard,
Stay Breasted Rail (Tikling), White-eared Brown Fruit Dove, Van Hasselts Sunbird,
Banded Rail. Fish species found in the Lake include Sinarapan, Tilapia, Carpa, Perch,
and Mirapina.
Rivers offer a very wide range of resources both at the national and community
levels. They serve as the main conducts of the fish movement to and from coastal
areas. The migratory fish are the most resources of inland waters in rivers and lakes.
Rivers also serve as sources of hydroelectric power, water, waterway transportation
and as venues for recreational and cultural events such as the fluvial parades and
water sport activities.
The Bicol River, located in the mainland Bicol, straddles across three (3) provinces
from the northern tip of Mt. Labo, Basud Camarines Norte to Camarines Sur (which
accounts for three-fourth of the Basin) and to Albay (at the southern part, which
approximately accounts for nearly a third of the Basin).
The Bicol River commences at the outlet of Lake Bato and follows a meandering
course to the sea at San Miguel Bay. The three (3) main tributaries of the Quinale
river; Nasisi, Cabilogan and Ogsong River carry most of the sediments from Mt.
Mayon. Some 1,000,000 metric tons of materials are deposited in the lake annually
and become a threat to the fishing industry and inhabitants around the lake.
Downstream of Lake Bato, the Bicol river flows in a confined but meandering
channel past Sto. Domingo and opens up some four (4) kms. downstream into the
lake Baao area. During wet season, these areas expand into a shallow lake which
fluctuates in size according to rainfall conditions. The inundation is amplified by the
contracting of the valley downstream where the Pawili River runs together with the
Bicol River. The Pawili River brings down large volumes of suspended materials
during floods that cause the riverbed to aggravate downstream. The downstream
left bank has an extensive flood plain between Baliwag Nuevo and the Libmanan
River flows which is subject to deep inundation, particularly when the floods coincide
with high tide or typhoons cause tidal surges in San Miguel Bay. This event causes
deep flooding in Naga City and other towns and habitation in the floodplain area.
The last 60 kilometers of the Bicol River are characterized by increasingly large river
meanders as the river approach the tidal estuary. However, the three (3) short cut
channels between the meanders built in 1988 had considerably shortened the river
reach to the sea.
Important Bird areas. Diamante, Prieto Diaz, Sorsogon was identified as
important bird areas with the following species: White-collared Kingfisher,
Philippine Mallard, Swifter, Sunbird. Similarly, Balumbon island, Prieto Diaz,
Sorsogon was also identified, with the following species: White-Collared
Kingfisher, Waders, Egret, Sunbird, Swallow, Sandpiper, Rails, Tems
Whimbel/Sand snipes.
Second growth forests (>50% slopes and >1000m elevation). Based on
LANDSAT survey, the Bicol region has a total of 530,301 forestland with
Camarines Sur having the biggest forestland of 164,203 hectares followed by
Masbate with 144,743 hectares. The smallest forestland (31,116 hectares) is
in the province of Sorsogon. Of the total forestland, 33.6 percent are within
the protection forests with 100,424 hectares forest cover consisting of 48,298
has. closed canopy, 54,710 has. open canopy, 6,698 has. Mangrove, and 718
hectares forest plantations.
Mangroves are defined in PD 705 as a type of forest occurring in tidal flats
along the seacoast extending along the streams where the water is brackish.
As of 1999, the Bicol region had a total of 6,698 hectares of mangrove forest.
Mangroves serve as nursery and feeding areas that support coastal fisheries
and as a buffer for coastal settlements that minimizes damages in times of
typhoons and strong waves.
Environmentally Critical Areas (ECAs)
Environmentally Critical Areas are areas prone to natural hazards (weather,
hydrologic, and geologic).
Bicols environmentally-critical areas include areas that are subject to seismic
hazards, prolonged flooding, tsunamis, volcanic eruption fallouts, and severe
erosion. (Figure 3.22).
Flooding
The area mostly flooded is the Bicol River Basin in the provinces of Albay and
Camarines Sur. It has a drainage area of about 3,156 square kilometers, of which
some 2,000 sq. km. are agricultural, and the rest are forests, wetlands, rivers and
lakes.
The Quinale riverbed of the River Basin area ebbs and flows with the material
erupted from the Mt. Mayon that flood events had washed into the river system.
Sand quarrying, a common practice along the river, probably ameliorates the
situation with some 100,000 sq. m. of sand taken annually. The increasing
backwater effect of the lake during floods also causes the upstream bed level to rise.
Settlements, as well as livelihood, are threatened by extensive flooding and
inundation.
The low lying areas in the Bicol River Basin are generally associated with deep and
prolonged flooding, which destroys rice and other crops. Recent urbanization and
other human activities have accelerated flooding and caused permanent loss of
prime agricultural lands. The pattern of land use conversion for housing and other
urban uses fragments irrigated ricelands and causes more areas to become more
prone to flooding. Sedimentation and soil erosion likewise aggravate flooding in the
entire basin areas including the rapid changes in the brackish water and morphology
of the estuaries and riparian landscapes of the Bicol River.
Volcanic Hazards
The Bicol region has two active volcanoes: Mt. Mayon and Mt. Bulusan. Two other
volcanoes in the region are inactive, namely, Mt. Isarog and Mt. Iriga.
Materials ejected during eruptions pose danger to people, infrastructures,
farmlands, properties at the base and midslope of the volcano. The most common
hazards are lava flows and base surges. Other dangers are earthquake, tsunamis
and seiche and edifice failure.
Because of its height, steep slopes and very deep gullies, Mayon volcano is
potentially susceptible to creating an avalanche. It could be triggered by
earthquakes, eruptions, intense rainfall and magma intrusion. A famous avalanche
occurred in 1868 when Mt. Iriga erupted. It covered about 70 sq. km. (reaching 11
km. from the old summit), dammed the Barit River, and created Lake Buhi.
Erosion
Erosion is a destructive geologic process that wears down land masses and
ultimately lowers their surfaces as close as possible to base level the extension of
sea level inland. With time, mountain ranges are destined to become hilly lands and
then as rolling plains through river erosion. Rivers erode by down cutting
streambeds, scouring banks, transporting detached soil, mineral and rock fragments
and depositing these detached fragments on floodplains, lakebeds and seabeds.
Ultimately, everything washes down into the sea.
The Bicol region has a total of 664,776 hectares affected by erosion, of which
511,197 were classified as moderate erosion and 153,579 hectares were severe
erosion.
1,763,249
511,197
153,579
664,776
37.70
30,004,802
8,478,513
5,080,979
13,559,492
45.19
Others
Geothermal Reservations
The Bicol Region has three (3) Geothermal Reservation areas: (1) Tiwi
Geothermal Reservation in AlbayProclamation No. 739 dated February 1982; (2)
Bacon-Manito Geothermal Reservation in Albay Proclamation No. 2036 A dated
November 11, 1980; and (3) Barit River-Lake Buhi Forest Reservation in Camarines
Sur Proclamation No. 573 dated June 26, 1969.
Proclamation No. 2036 prohibited all logging activities within the reservation area
and all permits and revoked all previously issued licenses for logging operations in
the area. Further, Proclamation No. 573 declared that the improvement and
development of pertinent portions of the watershed shall be undertaken as specific
or cooperative projects by the Bureau of Forestry, with the cooperation of the
Reforestation Administration, National Waterworks and Sewerage Authority, National
Irrigation Administration, Bureau of Public Works, National Power Corporation and
Bureau of Soils.
DEMOGRAPHIC PROFILE AND ECONOMIC TRENDS
Population Profile and Projections
Size and Distribution and Growth Rates
Bicol regions population of 3.9 million shared 6.44 percent of the Philippines total
in 1990. Camarines Sur province accounted for one-third of the regions overall
population or 33 percent (Table 3.41). The regions population distribution among all
other Bicol provinces was maintained through CY 2000.
Table 3.41 Population Distribution and Rank, by Province and Municipality, Bicol Region
2000, 1990, 1980, 1970
2000
1990
1980
1970
Region/Province/
Municipality
Distribution Rank Distribution Rank Distribution Rank Distribution Rank
Bicol Region
4674855
3910001
3476982
2966881
Camarines Sur
33.19
1
33.40
1
31.62
1
31.97
1
Albay
23.34
2
23.11
2
23.27
2
22.72
2
Masbate
15.14
3
15.33
3
16.81
3
16.61
3
Sorsogon
13.92
4
13.37
4
14.40
4
14.39
4
Camarines Norte
9.82
5
10.00
5
8.86
5
8.84
5
Catanduanes
4.61
6
4.78
6
5.04
6
5.47
6
The regions CY 2000 population reached 4.67 million. This was 6.11 percent of
the countrys total and 7th in rank among the 16 regions of the country. Among
provinces, Albay and Sorsogon increased their respective shares while those of the
rest of the provinces decreased, albeit maintaining their 1990 ranking. In terms of
land area, the region ranked 9th with 17,632.5 square kilometers or 5.88% of the
countrys land area.
Distributed among municipalities/cities, Legazpi Citys population ranked first for
four consecutive census periods (1970 2000) as its growth rate also steadily
increased. Naga City, Tabaco and Daraga consistently maintained their 2nd, 3rd and
4th positions, respectively. The municipality of Sorsogon exhibited very fast and
high incremental growth. From rank 13th in 1970, it rose to 5th in the 2000 Census
of Population. The opening of ports in the province led to the development of
business and tourism sites in the area. Subsequently, its growth resulted to the
merging of the municipalities of Sorsogon and Bacon and to the eventual conversion
of Sorsogon into a city in the year 2000.
The population sizes and growth rates of the region for census years 1970, 1980,
1990 and 2000 by province and municipalities are presented in Annex 3.16. In
1970, Camarines Sur was the only province with close to a million population. Albay,
which was next in rank, reached the 1970 population level of Camarines Sur only 20
years later. Masbate and Sorsogon were in the same level every census year from
1970 to 1980. It is noteworthy that distribution and growth of the 1970 population
were towards areas that were sparsely populated but agriculturally rich and/or
endowed with fishery resources. The island province of Catanduanes and its
municipalities have exhibited very low population growth from 1970 to 1980.
In 1980, the pattern was towards urbanization. This was due to the pull of newlyinstalled infrastructures, particularly roads, and the sporadic growth of trade in
strategically situated municipalities that have better economic opportunities. The
1990 growth originated from the strong attraction of employment opportunities in
established urban centers, which have become a source of growth of adjacent
municipalities. This situation was highly evident in Naga and Legazpi areas, whose
surrounding municipalities exhibited high growth rates. Unmistakably, the spill-over
effects of development permeated those initial high growth areas.
Looking at the growth rates, all of the five provinces registered positive increases
except for the province of Camarines Norte. Most evident were those for the
provinces of Catanduanes, Masbate and Sorsogon, all of whom registered more than
50% increments in the 1980-1990 and 1990-2000 periods. The positive increase in
the growth rate of Catanduanes was attributed to the improved sea transport
facilities for ferrying people and cargo to and from the port of Tabaco. The opening
of the port of San Andres and the rehabilitation of Virac Port likewise provided better
access to goods and services in the province.
Population Density
With the countrys total land area of 300,000 square kilometers and total
population of 76 million in 2000, the crude density index of the Philippines was
estimated at 255 persons per square kilometers, more than twice that of the 1970
level of 122 persons per square kilometer.
During the year 2000, the population density of the region reached 265 persons
per square kilometer. This was 10 points more than the national figure of 255. In
terms of its share to the total population, the regions 4,674,855 accounted for 6.11
percent. The region had an increasing growth rate as seen from the 1970, 1980,
1990 & 2000 data.
Population density levels in all the provinces grew as all the provinces became
increasingly populated over time (Table 3.42 and Figures 3.22A 3.22B). The most
densely settled province was Albay, whose 427 persons per square kilometer was
way above the regions density of 265 persons per square kilometer. Sorsogon
followed with a density level of 304 persons per square kilometer and Camarines
Sur, with a density level of 295 persons per square kilometer. On the other hand,
the provinces of Camarines Norte, Masbate, and Catanduanes had density levels
lower than the regions level at 203, 175 and 142 persons per square kilometer,
respectively.
In 1970, about half of the 114 municipalities/cities of the region had densities
ranging from 100 to 199 persons per square kilometer
(Annex 3.17). The other
half fell under the 300-699 classification. No municipality was classified under the
700-999 density class while only one city reached the 1000-above density level. In
1980, the municipality of Camaligan showed a very rapid growth by attaining a
density level of 845, second to Naga City. Its growth was attributed to the spillover
effect of the development in Naga City, being so proximate to the area. Other
municipalities whose growths were also traced to the development in Naga City were
Canaman and Milaor. Conversely, Iriga City decelerated from its second most
populous ranking in 1970 down to the 10th rank in 1980. This was due to the high
out-migration behavior of its population and/or the rapid increases in the population
of the other municipalities owing to the developments taking place in their localities.
Another municipality that decelerated during the decade was Presentacion, also in
Camarines Sur, from rank 18 in 1970 to rank 78 in 1980.
In 1990, the municipality of Camaligan attained a density level of 1,476 persons
per square kilometer. After several census periods, it was the only municipality that
reached the 1000-above density level, excluding Naga City. Legazpi also grew
substantially during this period as more people relocated to the city following its
proclamation as the administrative seat of the region.
The municipality of Canaman and the city of Legazpi reached the 1000-above
density level in the 2000 census with 1,122 and 1022 persons per sq. kilometer,
respectively. This brought 4 municipalities/cities into the 1000-above density
position. Seven municipalities/cities joined the 700-999 density level while only nine
municipalities remained below the 100 density class. The municipality of Gigmoto in
Catanduanes consistently ranked last among the 107 municipalities with a density
range of only between 25-38 persons per square kilometers during the four-censal
periods.
Table 3.42 Population Density, by Municipality, by Province Bicol Region
2000, 1990, 1980 and 1970
Total
2000
1990
1980
1970
Land
Municipality
Pop'n
Pop'n
Pop'n
Pop'n
Area
Rank
Rank
Rank
Rank
Density
Density
Density
Density
(in has.)
Albay
255,260
427
354
317
264
Camarines Norte
211,250
203
185
146
124
Camarines Sur
526,682
295
248
209
180
Catanduanes
151,151
142
124
116
107
Masbate
404,771
175
148
144
122
Sorsogon
214,140
304
244
234
199
1.
a town hall, church or chapel with religious
services at least once a month;
2.
a public plaza, park or cemetery;
3.
a market place or building where trading activities
are carried on at least once a week; and
4. a public building like school, hospital, puericulture and
health center or library
Barangays having at least 1,000 inhabitants which meet the conditions set forth in
above, and where the operation of the inhabitants is predominantly non-farming or
fishing.
Urban areas are classified based on population density, the presence of facilities
and utilities that cater to the socio-economic needs of the population, and on the
predominance of secondary and/or tertiary economic activities.
Urban and Rural Distribution of Population
The distribution of municipalities in the Bicol Region with urban agglomerations
during the census years 1970, 1980, 1990 and 2000 is presented in Table 3.44. In
1970, only 58 out of the 114 municipalities, or barely 51 percent were with urban
conglomerations. This number increased to 111 municipalities in 1980 and remained
static until 1990, with only 4 municipalities in Camarines Sur province having an
entirely rural population (Bombon, Gainza, Presentacion, and Sangay). In 2000,
only two municipalities in the region remained in the entirely rural category: Jovellar
in Albay and Presentation in Camarines Sur. During the current census year, 4
cities/municipalities qualified in the entirely urban category, namely: the cities of
Naga and Legazpi; and the municipalities of Camaligan in Camarines Sur and Daet
in Camarines Norte.
Within each province, the concentration of the urban population can easily be
detected. Logically and not surprisingly, all the cities and/or capital towns showed
the highest urban concentration of their respective provincial population. Their
prominence can be closely associated to the functions or roles they play vis--vis the
other municipalities. Such centers served as service points and seat of the provincial
government, thus, enjoying the bulk of the flow of capital funds for developmental
projects.
Evidently, only 32 municipalities had at least 1 percent share in urban
agglomeration in 1970. Throughout the 30-year census period, only 6
municipalities/cities figured consistently at the top among the 32 areas of
concentration of urban population. These were Naga City, Legazpi City, Daet, Iriga
City, and Tabaco. Unlike their contemporaries, however, Legazpi City and Tabaco,
both in Albay, had been increasing their share progressively while Naga City, Daet
and Iriga City were on the reverse trend.
Together with the impressive urban growth manifested by Legazpi City and
Tabaco, Daraga emerged to occupy the seventh spot in 1980. It retained its rank in
1990 by increasing further its share to 2.40 percent. Significantly, this development
pinpointed to the socio-economic progress in Albay.
While most of the old places decreased their urban share during the 25-year
intercensal period, five municipalities that were classified as rural in 1970 overtook
32 other municipalities in the rankings. In contrast, five municipalities which had
higher than one percent urban share were eliminated from the list as they failed to
register a share of one percent and above during the next two decades.
Noteworthy, four of the five municipalities with new urban districts shared the
same qualities and resource potentials and were strategically located. They served
as service points or jumping boards for other municipalities. These municipalities
were Mercedes and Paracale in Camarines Norte, Pasacao in Camarines Sur and
Pioduran in Albay. Except for Paracale, all were coastal towns and fishlanding areas
equipped with good ports. Pasacao and Pioduran both face the China Sea. Pasacao,
having a national port, served as a transit point of people from San Pascual in Burias
Island, Masbate, as well as those from the coastal barangays along Bondoc
Peninsula and from the barangays of railroad municipalities of Camarines Sur. The
port played a significant role in the water transport system towards the National
Capital Region and other northern parts of Luzon. Pioduran, aside from serving as a
transit point of the population of Claveria, Burias Island, is a fish and livestock
landing port. Equipped with an ice plant, the town abounds with fish dealers who
transport their goods straight to Navotas and Manila. Likewise for Mercedes in
Camarines Norte. On the other hand, Paracale was historically a gold mining town
since pre-war years. These situations indicated clearly that the presence of
economic opportunities and utilities/facilities in the said areas tended to attract
population and promote fast urbanization.
The phenomenon of new urban districts seemingly occurred when prominent
settlement centers of the Spanish era and pre-war years, such as Camalig,
Guinobatan and Libon in Albay; Labo and Vinzons in Camarines Norte; Tigaon and
Nabua in Camarines Sur, failed to expand economic activities and job opportunities
for their swelling population. People would rather be attracted to areas with
potentials for exploitation and where their economic needs can be easily met and
satisfied. Frontier areas such as Pasacao, Pioduran and Mercedes predictably
became magnets/absorbers of the venturesome segment of the regions population.
FIgure 3.23A Urbanity Index CY 1990
Census year 2000 saw the emergence of municipalities with new urban
agglomerations. Surprisingly, those municipalities were at the bottom of the 19701990 urban listing but were able to gain more than one percent urban population in
2000. One was the municipality of Donsol, Sorsogon, which ranked 69th in 1990 but
was elevated to 12th in 2000. Its economic development was attributed to a
booming tourism industry sparked by the rare presence of whale sharks locally
known as butanding in Donsol Bay. Another municipality that rapidly urbanized was
San Lorenzo Ruiz in Camarines Norte. Being adjacent to Daet, some people from
the capital town chose to relocate to San Lorenzo Ruiz for their residential area. The
site also attracted people from other neighboring municipalities and eventually
stirred up the sprouting of subdivisions and housing projects in the area. San
Lorenzo Ruiz ranked 90th in 1990 but advanced to 15th in 2000. Three
municipalities in Camarines Sur were not in the 1990 list but were now categorized
as big shareholders in the regions urban population. These included Calabanga,
Camaligan and Canaman. The growth of the municipality of Calabanga from 31st in
1990 to 10th place in 2000, was attributed to the operation of the Tamban Port and
the rehabilitation/concreting of corresponding access roads. Being very proximate to
Naga City, the municipalities of Camaligan and Canaman enjoyed the fruits of
development in the city. In fact, Camaligan is now categorized as a 100 percent
urban municipality. In the province of Masbate, the municipality of Aroroy was
classified in the top one percent. From rank 66th in 1990, Aroroy now ranks 19th.
A mining boom in the early part of the 90s has led to its progress.
For the past 30 years, Naga City led the list of urbanized cities in the region but
was overtaken by Legazpi City in year 2000. The two cities have been growing
inversely. Legazpi City has increased its share in the regions urban population,
which is now the biggest share as per the 2000 census.
Centrality of Functions and Hierarchy of Settlements
An analysis of central places was performed by subjecting the 114 cities /
municipalities of the Bicol Region to a manual scalogram technique of analysis
(Annex 3.20) introduced by Rondinelli and Ruddle _a / in their book Urbanization and
Rural Development.
Among the many uses of the scalogram in regional planning is the categorization
of settlements of the region into levels of functional complexity and the
determination of the types of diversity of services and facility located in central
places at various levels of hierarchy. In so doing, it identifies the gaps in terms of
absence of the necessary utilities in a particular but strategically significant area
which can be addressed to by the infrastructure support in the next twenty five
years.
For greater practicality and use, the scalogram in this RPFP document included not
only the common items but also the items that were most likely not present in all
municipalities and those that has greater effect on the peoples movement over
geographical locations or space. The RLUC-Technical Working Group identified 100
functions (institutions and services) and each city/municipality in the six provinces of
the region were asked to identify which among the functions are present in their
respective locality.
Limitations of this analysis, however, are many. Worth mentioning is that the
number and size of facilities and utilities present were not given, nor the quality of
the services catered. Second, the specific settlements within the municipality where
the specific function is located are likewise not pinpointed which may give rise to
doubts on the effectivity of the function and their potential linkages.
By scaling the resulting centrality indices, the 114 cities / municipalities were
categorized into six levels. The first level, with centrality indices ranging from 283.5
to 335.8 is composed of highly-urbanized areas (cities and capital towns), namely:
Sorsogon City, Legaspi City, Daet, Daraga and Pili. These areas possessed the most
number of functions and the presence of functions that are rare in the region. For
example, in the case of Pili, the presence of an airport and a mental hospital gave
the municipality a high centrality index. The second level, with centrality indices
ranging from 232 to 283.4 is composed of the following: Virac, Naga City and
Masbate City. In the case of Naga City, what pulled down its centrality index was the
absence of a port and airport, two functions which, because of their rarity usually
give high weighted score. The third level, with centrality indices ranging from 178.7
to 231, is composed of the following: Iriga City, Tabaco City and Camalig. Camalig, a
third class municipality, was categorized under the third level due to the presence of
the cement factory, the only cement factory in the region. The fourth level, with
centrality indices ranging from 126.3 to 178.6, is composed of Labo, Libmanan, Goa,
Ligao City, Guinobatan and Bulan. The fifth level, with centrality indices ranging from
73.9 to 126.2, is composed of 26 municipalities (Figure 3.24)
And the last level, with centrality indices ranging from 21.4 to 73.8 is composed of
71 municipalities. These are areas with a scarcity of facilities and utilities and highly
dependent on urbanized areas for their socio-economic needs and services.
Table 3.45. GRDP Growth Rates, by Sector, Bicol Region, 1985-2001 (At Constant 1985 Prices)
Year
Sector
1986 1987 1988 1989 1990 1991 1992 1993 1994 1995 1996 1997 1998 1999 2000 2001 Ave.
GRDP
0.9 (3.2) 6.3 4.7 3.1 0.2 0.8 2.4 3.0 1.9 4.7 5.7 (1.6) 1.6 1.5 4.5 2.3
AFF
(2.9) (2.8) 5.5 2.2 (0.9) 2.7 (2.7) 1.0 2.4 (0.7) 2.8 6.0 (10.1) 3.9 (4.1) 7.4 0.6
Industry 6.8 (14.8) 7.8 9.3 10.3 (4.2) 7.8 2.2 1.0 5.7 6.4 6.8 0.8 (3.0) 6.1 3.5 3.3
Services 2.3 2.8 6.5 5.1 3.7 0.0 0.9 3.8 4.5 2.4 5.5 5.0 4.7 2.1 3.8 3.0 3.5
From a negative 3.2 percent in 1987, GRDP growth peaked to 6.3 percent in 1988
when the political turmoil settled down and prospects for the economy were
optimistic, resulting to the robust performances of all the three sectors
simultaneously. National policies on agrarian reform, countryside development, and
economic zones development perked up the economy, both at the national and
regional levels.
Beginning in 1989, however, growth rates decelerated, sliding down to 0.2 percent
in 1991. This was the period when the country faced a power crisis that proved
detrimental to nationwide economic growth and pulled down the growth of the
regions industry and services sectors despite the relatively strong performance of
the agriculture sector.
From 1992 to 1997, GRDP growth again accelerated, dipping only once in 1995
and peaking at 5.7 percent in 1997. The liberalization policies of the Ramos
Administration resulted to the fast growth of the services sector during this period,
particularly the transport/communication/storage, finance, government and private
services, and trade subsectors. The decelerated growth of the GRDP in 1995 was
due to the negative growth of the agriculture sector brought about by Typhoon
Rosing that hit the region.
The year 1997 was the year of the Asian currency crisis, which drastically affected
regional, as well as national economic growth. Aside from this, the El Nio
phenomenon and two typhoons (Monang and Naning) also hit the region towards
the latter part of the year. All these resulted to a year of negative GRDP growth in
1998, with agriculture as the most affected sector, hitting negative 10.1 percent.
The industry sector grew by only 0.6 percent while the services sector decelerated
slightly to 4.7 percent.
The period from 1999 to 2001 was a period of recovery for the region as the
GRDP posted positive, though fluctuating, growth rates. The negative growth in the
agriculture sector in 2000 due to strong and prolonged monsoon rains, caused the
slight deceleration of the GRDP growth in 2000 despite the strong performances of
the industry and services sectors.
The preceding discussion shows the vulnerability of the regional economy,
particularly the agriculture and industry sectors, to natural, political, and external
disturbances. The services sector, on the other hand showed resiliency and
managed to prop up the economy during critical periods.
Source: N SCB
Ave. Contribution
(%)
38.3
37.6
0.1
20.6
3.8
1.4
7.1
8.2
41.1
4.7
10.4
1.2
10.9
7.8
6.6
Year
1985
1986
1987
1988
1989
1990
1991
1992
1993
1994
1995
1996
1997
1998
1999
2000
Sources: Com pendium of P hilippine Social Statistics, NSCB 1990 and P hilippine
Statistical Y earbook 1986-2001, NSO
The number of unemployed and the Unemployment Rate was at its lowest in
1990. Contrary to that in 1998, when the number of unemployed as well as the
unemployment rate hit the highest mark at 205 persons and 9.6 percent,
respectively. Relatedly, economic growth dipped to a negative 1.6 percent. This
was a repercussion of the Asian Financial Crisis experienced in 1997.
The employment situation seem to set a three to four-year period pattern from
1991 to 2000. The employment rate was on an upward movement from 1991 to
1994, that is, from 94.1 to 95.8 percent, but made a dip in 1995 to 93.4 only to
increase again in the next three years.
The employment situation was erratic from 1985 to 1990. This behavior could be
attributed to the combined effects of crisis due to changes in the national leadership
and the typhoons that hit the country during this period. Figure 3.26 illustrates this
pattern.
Sectoral Employment
Employment distribution in Region V remains to be heavily concentrated in the
Agriculture sector as it absorbs the most number of jobs in the region. Although the
Agriculture sector maintains the status of being the number one job provider, its
percent share to employment is decreasing. This movement is more pronounced in
the years 1995 to 1997 and abruptly again in 1999 to 2000. (Table 3.48 and Figure
3.27).
The performance of the services sector, on the other hand, has been slowly
picking up, steadily increasing in number and its percent share to total employment
is getting bigger.
The industry sector has more or less remained unvarying in number and its
percent share has always been the least among the sectors.
The biggest shift noticeable in employment is in 1999 where the share in
employment of the services sector was at its highest at 46.78 percent.
In 1993 and 1994, the Agriculture, Fishery and Forestry (AFF) sector was at its
peak in terms of number of employed with 1014 and 1069 thousand workers,
respectively. There are two notable declines in employment in this sector and these
are in 1994 to 1995 and 1999 to 2000.
Year
1985
1986
1987
1988
1989
1990
1991
1992
1993
1994
1995
1996
1997
1998
1999
2000
2001
2002
During these same years (1993 & 1994), the Industry sector had the least number
of employed persons with 219 and 215. The employment in this sector is pretty
much the same in number all throughout the 16-year period except in 1988 and
1989.
At any point in time, the services sector, has been increasing in number except in
1988 and from 1996 to 1997, then again in 1999 to 2000 where it experienced a
decline in employment.
The trend lines shown below in Figure 3.27 clearly illustrate the upward and the
downward movement of each major industry group. Despite the downward trend
from 1985 to 1987, the AFF sector gave a very encouraging performance from 1989
through1994. But this has not been sustained as thereafter it continued to decline.
Countering the performance of the AFF sector, the industry sector started low in
1985 to increase substantially in 1986 until 1989. But it dropped considerably in
1990 and continued on a downward trend until 1994. Since then the sector has
been exhibiting an almost passive behavior, though from 1986 to 1989 it had
employed more than it ever had in any given year in the series.
The services sector steadily increases, although at some points it retracts. It can
be noted that the decrease in employment in agriculture, although not
proportionally, has a counter effect in employment in the services sector.
1922
2792
870
45.3
73
689
2611
931
116
1430
4587
2028
43
741
1976
1097
58.9
107.5
75.7
117.8
342
678
336
98.2
3408
19801
924
3
165
3
28
171
49
5636
4
27778
815
9
146
8
71
288
82
2228
4
7977
-109
6
-19
5
43
117
33
65.4
40.3
-11.8
200.0
-3.6
166.7
153.6
68.4
67.3
11
15
36.4
179
1534
302
1736
123
-1
202
68.7
13.2
several sectors like Mining and Quarrying, Electricity, Gas and Water, Construction
and Community/Social and Personal Services had growth increases more than the
Philippines.
National Growth Effect on Employment in the Region
Table 3.50 National Growth Effect on Employment in Bicol Region: 1985-2000
National
Net
Growth
Actual
Regional
Total
Effect
Regional
Change
Employment 1991Employment
to be
Sector
in Bicol
2000
Growth Accounted
1985
N = (1) x
(R)
for(3) (1)
NGR
(3)
(2)
(.403)
(4)
(2)
Agriculture, Fishery and Forestry
924
372.37
-109
482.37
Mining/Quarrying
3
1.21
6
4.79
Manufacturing
165
66.50
-19
-85.50
Electricity/Gas and Water
3
1.21
5
3.79
Construction
28
11.28
43
31.72
Wholesale/Retail Trade
171
68.91
117
48.09
Transportation/Storage/Communication
49
19.75
33
13.25
Finance and Housing
11
4.43
4
-0.43
Community/Social and Personal
179
72.14
123
50.86
Services
Others
-1
-1.00
Total
1534 618.20
202
-416.20
The preceding table (Table 3.49) attempts to answer the question on how much
would employment in the region grown if it each sector had expanded as much as
the national growth.
As observed in the data, had employment in each sector in the region grown at
the same rate as the national, the total employment of the region would have
increased by 618,200 jobs while in reality it increased only by 202,000. Employment
in the agriculture sector would have grown by 372,370 jobs and manufacturing
would have 66,500 jobs more instead of the negative 109,000 jobs in the AFF and
the negative 19,000 for manufacturing.
Wholesale/Retail Trade, on the other hand, gained 117,000 jobs and
Community/Social and Personal Services with 123,000 additional jobs which were
greater than the national which was able to grow only an additional 68,910 and
72,140 jobs for Wholesale/Retail Trade and Community/Social and Personal Services,
respectively.
Mining and Quarrying, Electricity Gas and Water, Construction and
Transportation/Storage/ Communication, too, were able to generate more jobs than
the national.
The shortfall of 416,200 jobs in the region may be brought about mainly by the
immense discrepancy in the AFF and by poor economy due to slow economic activity
and various other reasons like calamities and national crisis brought about by the
change in the administration that somehow affected the regions performance.
Table 3.51 Industry Effect on Employment in the Bicol Region: 1985-2000
Percent
Deviation:
Distribution of Industry
Industry
Employment
Growth
Regional
Mix
1985 in
Rate
Employment
Sector
M = (3)
Minus
1991
x (4)
(4)
Philippines Bicol National
(5)
Growth
(1)
(2)
Rate(3)
Agriculture, Fishery and Forestry
49 60.2 7.2 - 40.3
924 -30584.4
= -33.1
Mining/Quarrying
0.6 0.20 -17.2 3
-172.5
40.3 = 57.5
Manufacturing
0.7 10.8 45.3 - 40.3
165
825.0
= 5.0
Electricity,Gas and Water
0.4
0.2 58.9 - 40.3
3
55.8
= 18.6
Construction
3.5
1.8 107.5 28 1881.6
40.3 =
67.2
Wholesale and Retail Trade
13.2 11.1 75.7 - 40.3
171 6053.4
= 35.4
Transporation/Storage/Communication
4.7
3.2 117.8 49 3797.5
40.3 =
77.5
Finance and Housing
1.7
1.7 98.2 - 40.3
11
636.9
= 57.9
Community/Social & Personal Services
17.2 11.7 65.4 - 40.3
179 4492.9
= 25.1
Others
0.1
Total
100.0 100.0
13013.8
sectors. Neither can the positive growth rate in other sectors like wholesale and
retail trade, transportation/storage/communication, community/social and personal
services, and the rest of the sectors that performed positively, counteract the effect
of the comparatively slow growth of the agriculture sector.
The percentage of experienced or gainful workers in Agriculture in the region at
60.2 is higher than the national that is 49, but employment in the national grew by
7.20 percent, the decline in the region is -11.8 percent.
Regional Share Effect of the Components of Employment Change in the
Region
Table 3.52 Employment and Components of Employment Change in Bicol Region,
1985-2000 (Thousands of Persons Employed)
Employment
Regional
Regional National Industry
by
Shares
Mix
Industry in Employment Growth
Effect
Sector
Change ( R Effect
Effect
Bicol
S=R-N)1985-2000
N
M
M
1985 2000
(3)
(4)
(5)
(6)
(1)
(2)
Agriculture, Fishery and Forestry
924
815
-109 372.37 -30584.4 30103.0
Mining/Quarrying
3
9
6
1.21
-172.5
177.3
Manufacturing
165
146
-19
66.5
825.0
-910.5
Electricity, Gas and Water
3
8
5
1.21
55.8
-52.0
Construction
28
71
43
11.28 1881.6 -1849.9
Wholesale/Retail Trade
171
288
-143
68.91 6053.4 -6265.3
Transportation/Storage/Communication
49
82
33
19.75 3797.5 -3784.3
Finance and Housing
11
15
4
4.43
636.9
-637.3
Community/Social/Personal Services
179
302
123
72.14 4492.9 -4442.0
Others
Total
1534 1736
202
618.2 13013.8 12597.6
Location Quotient
0.90
15.67
0.83
0.81
5.03
Location Quotient
1.27
0.94
0.77
Location Quotient
1.27
1.25
0.80
1.25
0.80
1.00
0.71
0.45
0.90
-
The way we manage ecological balance and biodiversity shall have a great impact
on the state of the life support system of the Bicolanos as well as the state of
ecotourism in the Region.
Transportation and digital communication infrastructure shall play a major role in
making these effective development drivers that will ultimately lead to poverty
reduction. Physical and digital infrastructure support shall be strategically located to
effect:
economic integration of production (agriculture, mineral and industrial
areas) with consumption areas;
greater access to basic social services especially by rural areas, the
island provinces and the islands of Masbate, and of other
municipalities with island barangays;
greater accessibility of ecotourism destinations and
integration of Bicol Region with the rest of the country through
intermodal transportation
Intra-regional Economic Integration
Intra-regional economic integration shall be achieved through the improvement in
physical access and access to information in all areas.
Physical access shall be improved through an intermodal transport network among
cities and municipalities that will:
Reduce cash and non-cash hauling/transport cost of farmers/fisherfolks
in bringing their produce/catch to trading centers;
Reduce cash and non-cash hauling/transport cost of middlemen in the
performance of their assembling function;
Facilitate access of rural population to basic social services, i.e. schools
and hospitals
Information related to marketing, basic social services, employment, government
services and requirements and the like shall be made available by allowing digital
infrastructure to cover the whole region. Partnership with the private sector,
especially the telecommunication service providers need to be forged in establishing
landline telecommunication lines in the rural areas.
Interregional Economic Integration
The Bicol Region shall have interregional economic relations with most of the
regions in Luzon and some regions in Visayas and Mindanao. Major areas of
interregional relations are agriculture, agri-industry, trade and tourism.
Transportation and information infrastructure shall play a critical role in making
effective and efficient interregional linkages in these areas. Intemodal transportation
shall be improved. Regular routes along the Philippine nautical highway shall include
the Bicol Region. The following shall be the major transport strategies:
Mining operations in the forestlands shall have been strictly regulated and
conducted with due regard to protection, development and utilization of other
surface resources. Mining laws, rules and regulations of the DENR shall have
governed the location, prospecting, exploration, utilization or exploitation of mineral
resources in forest reservations.
Local Government Units (LGU) instead of the DENR shall have maintained its
responsibility of identifying areas suitable for sand and gravel extraction and limiting
issuance of permits considering impact assessment of the area.
Watersheds shall have been well-managed and protected. Denuded areas
existing proclaimed watersheds shall have been immediately reforested.
of
Environmental Management
Land Management
Boundaries of proclaimed watersheds in the region shall be welldefined on the ground by the DENR. Watersheds shall be wellmanaged and protected in order to regulate water in the area.
Denuded areas of existing proclaimed watersheds shall be
immediately reforested.
Integrated Water Resources Management shall be adopted in
watershed areas to improve the water supply, quality, and
forest cover of watersheds. A River Basin management
approach shall be adopted in the Bicol River Basin area.
reforestation,
captive
b.
Local land suitability analysis should be pursued to identify lands
suited for specific industrial requirements, including required expansion
areas. Marginal agricultural lands should be prime candidates for
industrial expansion.
c.
Industrial activities must be banned in SAFDZs, NIPAS areas,
and other similarly protected areas, and hazard-prone areas that have
been identified to be too risky for industrial activities to take place (e.g.
fault lines, erosion-prone areas, permanent volcanic eruption danger
zones).
d.
There should be sufficient infrastructure support facilities
(power, water, and waste disposal), especially those that allow,
accessibility to markets, sources of production inputs (including labor),
and to key transportation facilities such as ports, airports, and
highways; and
e.
Social and environmental impacts must be considered.
Industrial activities shoud also be treated as catalysts to industrial development in
an area, rather than as exclusive sites for production activities. While RAIC, PICs, or
ecozones enjoy scale and agglomeration economies from the collective presence of
several industries, industries can locate in other parts of a settlement, as a group or
individually, provided that they conform to the aforementioned considerations.
Solicit the inputs and participation of the private sector and other stakeholders in
planning for industrial sites.
Whether at the regional or local level, land suitability must complement market
compatibility in order to ascertain the viability of a proposed industrial site. Although
the feasibility of a specific industrial activity is best determined by its proponent-
coconut-based agri-industries of the region like geo-textile making, virgin coconut oil
production, coconut wine, vinegar and coco-based handicrafts making.
The strategy of implementation will center on the establishment and promotion of
coconut model farms. A "model coconut farm" is a cluster of small but contiguous
farms owned and/or operated by small coconut farmers totaling 15 to 20 hectares,
within the Strategic Agriculture and Fishery Development Zone (SAFDZs). It will have
the following features:
Fully intercropped with cash and commercial crops such as corn,
legumes, bananas, root crops, fruit trees and agro-forest products;
The model coconut farmer shall be provided with the necessary knowledge, values
and skills to develop his farm not only as a producer but also as an entrepreneur
through actual experience and training.
Other High Value Commercial Crops Development Program
The overall objective of the high value commercial crops program is to increase
production of the following crops in the region: sugar cane, banana and pineapple.
Intensive cropping of sugar cane in Camarines Sur would be needed to meet the
needs of its sugar mill. Banana and pineapple shall be produced for desserts.
Model farms for the above commodities will be established in strategic locations.
Technical assistance to farmers will be provided through extension and training.
Production inputs, loan assistance and credit facilities shall also be given.
Agro-Forestry Program
The agro-forestry program intends to increase the production of selected fruit
trees and fast-growing timber species in the region. The long-term objective of the
program is to increase the plant density and to cover the open production lands. Pili
as the flagship commodity of the region will be promoted for planting as intercrop to
coconut areas with slopes within the 18 to 30 percent. Forest tree species will be
recommended in lands having slopes greater than 30 percent. The program will
require the full cooperation of national government agencies that are concerned with
crops and the local government units. Seedlings will be mass-produced and
distributed to farmers. Nurseries will be established in strategic areas to provide
upland farmers with quality planting materials. Private land owners in upland areas
will be encouraged to go into agro-forestry.
Pasture Development Program
The pasture development program intends to improve the carrying capacity of the
regions pasture lands from the present one animal head per hectare to 2.5 animal
heads per hectare. This will be carried out through the planting of improved grasses
and legumes. The program shall provide technical assistance to pasture lease
agreement holders through the provision of planting materials like grass cuttings and
legume seeds. Credit facility for the development of pasture lands shall also be
provided.
Fishponds Development Program
The program intends to increase fresh water fish production through the
improvement of fishpond management. New technologies on fishpond culture will
be provided to fishpond lease agreement holders. Provision of loan assistance for
fishpond development will be provided to fishpond owners.
Regional Growth Center Program
The program aims to disperse industrial activities to
thereby, encouraging investments in the countryside.
the establishment of the Bicol Regional Agri-Industrial
Industrial Centers in the different provinces of
implementation of infrastructure to ensure that firms
competitive vis-avis those located in Metro Manila and in
Settlements Development
Scenario by Year 2030
Based on the assessment of the prevailing situations in the region, it is envisioned
that by the end of the planning period, 2000-2030, the following objectives would
have been achieved:
To effect a rational distribution of the population
This can be realized through the provision of services and economic facilities
especially in identified growth areas so as to encourage and spur the movement of
people in still less-habited areas.
It is also proposed that an aggressive and responsive population management
program be implemented in all sectors of society.
To achieve equitable distribution of the fruits of development
among sub-regional areas
The highly polarized growth of the cities of Naga and Legazpi, although proved to
have served its purpose, provided negative effect to neighboring areas. Some areas
no longer grew, were highly dependent on these cities for most of its economic
activities. Some areas have been merged and/or have grouped/organized together
to achieve a common purpose.
With the classification of Masbate and Camarines Norte provinces as one of the
poorest provinces in the country, efforts must be done in order to alleviate these
conditions. Emphasis should be made on the following: ensure provision of and
access to employment opportunities; enhance revenue generation and promote the
efficient use of resources; and develop agri-industry systems that are suited to the
areas.
In terms of delineation of areas in the region, the definitions used during the past
RPFP were adopted. These are listed below:
Politico-administrative
boundaries.
The smallest political unit
considered is the barangay. Each province was considered as a single
IAD;
Natural boundaries and resource homogeneity.
Where natural
boundaries do not conflict with No. 1, the same were used considering
further the physical resource homogeneity of the area;
Commonality of dominant socio-economic activities. Municipalities
whose dominant socio-economic activities are common or are interrelated were grouped together in sub-integrated area development
(SIAD) unit;
Functionality. In terms of spatial linkages, i.e., urban-rural linkages,
the neighboring municipality, the province, the region;
Flow analysis. Population movement and commodity flow;
Hierarchy of municipalities within each province or the centrality
function of each municipality relative to the province/region;
Infrastructure Development
Basically, the infrastructure plan is based on the development challenges, issues
and concerns confronting the development of the region. These could be achieved
through spatial development strategies and supporting policies and with
corresponding programs and projects. The spatial development strategies and
policies are categorized into general and specific.
General Development Strategies and Policies
The national level spatial development strategies and policies are also deemed
appropriate at the regional level. These are broadly categorized as follows: a)
three other plans within the planning horizon of 310 years period. The required
interregional linkages, particularly those among urban centers shall be maintained in
order to increase access to alternative product sources and markets, allowing for
increased competition and greater economic integration.
To achieve these objectives, the regional priorities resulting from the various
workshops are: (1) Railways; (2) Power, Electrification and Irrigation; (3) Roads and
Bridges, Airports, Ports, Water Supply; and (4) Communication.
General Strategies and Policies
The order of priority of physical development shall be:
maintenance of existing infrastructure facilities to extend the life span
of the project and thereby generate more productive use of assets;
construction of additional and/or new structures.
The type and scale of new infrastructure facilities shall be consistent with or in
support of the desired spatial pattern for a specific plan period. Likewise,
infrastructure shall be used to induce or effect the realization of the desired spatial
pattern.
The location of new infrastructure shall as much as possible, avoid disturbing
critical ecosystems. In cases where this does not apply, appropriate mitigation
measures shall be incorporated in the project design.
Existing infrastructure facilities found to be improperly located .i.e. threatened by
environmental hazard or impinge upon critical ecosystems shall be made to conform
to the policies established under Protection Land Use.
The provision of infrastructure facilities in environmentally critical areas will have
to be studied closely. Any proposed project in any of these areas as defined in the
Protection Land Use Plan shall be subjected to environmental impact assessment.
The construction of roads and bridges, communications and other infrastructure
and installations within the identified environmentally-critical areas by government
and private institutions shall be undertaken with the least impairment of the
resource values therein. The objective is to avoid or reduce damage or injury to the
resource value. The Department of Environment and Natural Resources shall
likewise be involved in the planning and establishment of these infrastructure
facilities.
Maintain and/or rehabilitate existing infrastructure facilities in production and
settlement areas to facilitate socio-economic activities.
Upgrade and/or provide new infrastructure facilities in the identified expansion
areas for production and settlement.
Sea Transport
On water transport development, priority shall be given to national ports and other
seaports identified in the nautical highway. To achieve more efficient port services,
other port appurtenances and facilities shall be based on the type of cargo handled
and the projected volume of passengers and cargoes. The traffic flow and influence
areas shall also serve as the bases for ports development in particular on the
establishment of RORO facilities for the identified ports included in the nautical
highway (Figure 4.05).
Air Transport
The strategic framework is based on having effective and efficient airport runways
and facilities within international standards. The physical infrastructures would
require: Construction of the New Legazpi Airport, upgrading of the existing airports
to serve as gateways to regional centers and major tourist destinations and a
Feasibility study of the Pamplona Airport in Camarines Sur. The policies that need to
be in place are: a) Ensuring compliance with international security standard; b)
Promoting the integration with global markets and considering the need to develop
more international gateways; and c) encouraging airline industry to restore domestic
flights for the inter-provincial and inter-regional flights as shown in Figure 4.05.
Water Resources
The strategy shall incorporate the fundamental elements of integrated water
resources managements. These elements involve: 1) strong coordination among
water users, 2) water conservation, 3) social, economic and environmental value of
water, and 4) demand management.
Water Supply
The provision of safe, potable and sufficient water supply for domestic,
commercial and industrial use shall taken into account the following: (a) the
targeted human settlements/cluster of households, number of population served; (b)
and willingness and ability of water associations to share in the responsibility of
installing and maintaining a system.
Level I, a point source, usually a protected well (shallow/deep well drilled driven)
or developed spring, with one water outlet but without any distribution system and
has a coverage of 250 meters radius from source and has effective serviceability of
15 to 25 households. These are adopted in rural areas where houses are thinly
scattered. Generally, there are no water treatment provided, in some areas however,
disinfections are conducted periodically.
Level II water supply is communal faucet system consisting of a point source, a
reservoir, a piped distribution network and communal faucets. The water sources are
usually drilled/driven wells or spring. Water treatments are not also provided except
for periodic disinfections by local authorities. A simple communal piped water system
Irrigation
It shall focus on the maintenance, rehabilitation of aged and damaged irrigation
facilities and appurtenant structures and on the construction of new irrigation
facilities targeting the 50% of the total potentially irrigable areas. Moreover, it shall
implement the volumetric water pricing system.
The construction of irrigation projects shall be in full support of Republic Act No.
6978 (AFMA) thus ensuring the promotion of rural development for an accelerated
program within ten-year period.
Flood Mitigation
Flood mitigation structures are important to safeguard the population, settlement
and agricultural areas. But because of the huge investments required, an integrated
flood mitigation and drainage program throughout the region should be prepared
coupled with disaster management programs. The structures shall be so designed to
give importance to the upstream and downstream impacts.
Power/Energy
The power/energy policies shall initiate institutional reforms to ensure
transparency and accountability, if not eradicate administrative impropriety. Such
reforms should: a) pursue the streamlining of the ECs to reduce system losses to
single digit, b) allow the private sector through investment management contract
(IMC); c) address NPC losses by loan restructuring d) privatize Transco and NPC
generation plants in an optimal manner; e) privatization of existing NPC-SPUG
areas. The other energy/power policies shall focus on: ensuring sufficient and
reliable power supply and system efficiency improvement; prioritizing projects that
address energy generation for sufficient power supply; exploring the use of new and
renewable energy sources; 100% electrification of all the barangays; and resolving
water allocation issues on hydropower.
Communication
The strategies for the development of the digital infrastructure includes regulatory
and legal reforms outlined as follows:
Promoting and strengthening the independence of regulatory powers
of the NTC;
Promoting price settings to balance cost recovery, externalities and
consumers willingness and capacity to pay. Adoption of cost-based
pricing for telecom sector- lower national/international charges;
Setting/clarifying legal regime on voice over the internet protocol
(VOIP) Executive Order on VOIP;
Continuing work with mobile phone producers to disperse cell sites to
un-served areas to connect the region and the entire country.
Social Infrastructures
School Building
The school building program shall provide adequate and convenient classrooms
through the following strategies: (a) rehabilitation and/or improvement of partly
damaged or not well maintained but economically repairable classrooms to maximize
the use of existing structures; (b) replacement of aged or severely dilapidated
classrooms; (c) construction of new classrooms to accommodate the annual
increment in enrollment, maintain an average occupancy rate of about 40 to 50
pupils per room, and provide accessible educational facilities to small and isolated
barangays, and (d) provision of non-academic school buildings.
Health Facilities
The planning design for the location and bed capacities of hospitals shalll follow a
hierarchal order consisting of 10 beds for municipal hospital, 25 beds for district
hospitals, 50 beds for regional hospitals and 250 beds for medical centers. The
health centers and equipment shall be upgraded to conform within standards and/or
minimum requirements.
To balance the distribution of health facilities, the primary health care facilities and
services shall be provided in the rural areas. These facilities shall be based on
accessibility to the users, number of population served, health practices in the rural
communities, health status of the population and socio-economic situation.
Government Buildings Facilities
The maintenance, improvement and new construction of buildings will be the
responsibility of the respective concerned entities. RA 7160 or the Local
Government Code of 1991 tasks LGUs with the responsibility of developing their
respective areas through their own resources, national government buildings from
the generated savings of the agency.
Solid Waste Management Facilities
DENR Administrative Order 98-49 and 98-50, encourage LGUs to adopt the
sanitary landfill method as the proper means of waste disposal. It requires LGUs to
put up or upgrade their existing open dumping sites to specified levels taking into
account their technical feasibilities. A 2.60 hectare of land per 100,000 population is
recommended for sanitary landfill projects.
Long-Term Infrastructure Projects
The proposed infrastructure projects shall put into operation the desired spatial
pattern. The major proposals, categorized according to sub-sector, are presented
as follows:
a.
a. Ocampo-Tigaon-Goa-Lagonoy-Presentacion-GarchitorenaCaramoan-Guijalo
b. Tinambac Siruma Road
Sangay (Nato) Port, Sangay, Camarines Sur (RORO)
Cataingan Port, Cataingan, Masbate (RORO)
a.
Mabolo Bridge
Ocampo-Tigaon-Goa-Lagonoy-Presentacion-Garchitorena-CaramoanGuijalo Road, Camarines Sur,
Tinambac-Siruma Road, Camarines Sur,
Cam. Sur-Tiwi-Legaspi-Manito-Sorsogon Road,
Ligao-Pio Duran Road, Albay,
Pilar-Donsol Road, Sorsogn
Libon-Marocmoc-Pantao Road
Ligao-Pioduran Road
Catanduanes Circumferential Road
Lagonoy-Presentacion-Caramoan-Garchitoren-Guijalo Road
Masbate-Milagros Road
Sorsogon-Bacon-Manito Road
Putiao-Pilar-Donsol Road
Daang-Maharlika via Abuyog-Gubat-Ariman Road
Ariman-Casiguran Road
Juban-Magallanes Road
Gubat-Prieto Diaz Road
Railways
Water Transport
1.
2.
3.
4.
5.
6.
7.
1.
2.
3.
4.
5.
Air Transport
Communications
Power / Energy
Projects that are geared to sufficient energy generation and effective power supply
are presented below with their respective locations indicated on Figure 4.07 and
Figure 4.08.
Rehabilitation of generating units to their original efficiency
Development of other geothermal energy sources through promotion
of geothermal exploration
Development of new and renewable energy sources,
Implementation of the Luzon-Catanduanes interconnection project,
Regional industrial center transmission lines,
40 MW Tanawon Geothermal Power Plant, and
Rapu-Rapu Diesel Power Plant.
Social Infrastructure
The region proposes the social infrastructure programs and projects as follows:
Schools
School Classrooms
Health Facilities
Government Buildings
PLAN IMPLEMENTATION
Review, Approval and Adoption
The RPFP acquired legitimacy as the result of a formal process of endorsement
and adoption. As such, government agencies, local government and the private
sector acknowledge its significance. It becomes an integrating factor in various
development activities in the Region.
The RPFP will guide detailed land use planning and development at the
provincial, city and municipal levels through the various legal and political
controls operating at those levels. Under present conditions, the main leverage
of the national and regional agencies relate to their public investment functions.
The LGUs through their planning and zoning powers, as well as their capital
improvement programs, will carry out the RPFP provisions which pertain to
them. At both levels, through positive and negative measures, government
seeks to influence private investment.
The plan implementation process started with the official endorsement by the
Regional Land Use Committee (RLUC) of the draft RPFP after the completion of
the first draft RPFP by the RLUC. It was submitted to the RDC for approval and
adoption as the final RPFP.
The steps in this process were as follows:
Interregional Consultations. Two interregional consultations were attended
by NEDA personne. The first inter-regional consultation group was with the
Visayas and Mindanao regions, i.e. regions IV-B, V, VI, VII, VIII, IX, X and XIII.
The second group was composed of Regions III, IV-A, IV-B and V. These
consultations aimed to identify and resolve inter-regional issues; to agree on
possible areas for integration and complementation of development strategies,
especially among regions with strong trade and transportation linkages and those
sharing common boundaries; and to establish substantive linkages among
regions.
Review of the draft RPFP by the Regional Land Use committee, which is
composed of agencies concerned with the plan components, i.e. settlements,
production, protection and infrastructure. The overall responsibility for
orchestrating the review process was with NEDA.
Provincial Consultations. The RLUC-TWG presented the draft RPFP to the
Provincial Development Councils (PDCs)/ Provincial Land Use Committees
(PLUCs) for their comments and suggestions. This also familiarized them with
those provisions of the RPFP that affect the province.
Revision of Draft. The RLUC-TWG made revisions on the draft RPFP based on
results of the inter-regional consultations and the provincial consultations.
Review and Endorsement by the RLUC. The RLUC reviewed again the RPFP,
the revised draft incorporated results of the series of consultation meetings. The
revised draft was endorsed for presentation to the RDC for approval and
adoption.
RDC Approval and Adoption. The RDC approved and adopted the RPFP
during its meeting on April 25, 2006 through an appropriate resolution.
Plan Phasing
The 30-year period programs and projects is divided into three phases, Phase 1
from 2000-2010, Phase 2 from 2011-2020 and Phase 3 from 2021-2030. To have
a disagregation of financial costing and to synchronize the RPFP with the tenure
of political officials and the medium term and short-term planning cycles at the
different levels.
Organizational Structure for Plan Implementation
The Regional Development Council, through its Regional Land Use Committee
(RLUC) is the over-all lead in the implementation of this plan. This entity is the
counterpart of the National Land Use Committee (NLUC) which is responsible for
the coordinative functions tasked to oversee physical planning activities in the
region. The RLUC shall likewise perform deliberative functions on purely land use
policy issues and conflicts. Policy recommendations shall be elevated to the
Regional Development Council for final deliberation and decision. Operational and
technical issues/conflicts shall be decided upon by the RLUC and based on the
nature of the concern may no longer be raised to the RDC.
The RLUC shall be backstopped by a Regional Core Group with NEDA V staff as
the lead. The RCG shall be supervised by the RLUC and supported by lead staff
on concerns related to production land use, protection land use, settlements and
infrastructure. These lead sector staff shall provide the necessary
sector/technical inputs and give preliminary recommendations on issues related
to their particular sector. The Regional Core Group shall serve as the integrating
body of the sector inputs and shall likewise act as the technical secretariat of the
RLUC.
The existing structure of the Regional Land Use Committee (RLUC) as a
special/affiliate committee under the Regional Development Council (RDC) shall
be maintained. It is chaired by the Regional Director of NEDA and Co-chaired by
the Regional Coordinator of the Housing and Urban Development Coordinating
Council; and the members are the Regional Directors of the following agencies:
Department of Agriculture, Agrarian Reform, Tourism, Interior and Local
Government, Environment and Natural Resources, Transportation and
Communication, Public Works and Highways, Trade and Industry, Science and
Technology and the Regional Administrator of the Housing and Land Use
Regulatory Board and three regular RDC members representing the Private
Sector.
The Regional Core Group (RCG) shall be composed of senior technical staff
from the selected RLUC member agencies, namely: DENR, DAR, DA, DPWH,
HLURB, DOT, DOST, HUDCC, DILG, DOTC and NEDA. Overall coordination of all
physical planning activities shall be the responsibility of the NEDA Regional Office
specifically the Macro Intersectoral Coordination and Assistance Division
(MICAD).
programs and projects. For example, the regional production land use strategy can
influence the formulation of programs and projects in the economic or productive
sectors. The regional settlements strategy for its part, provides guidelines for the
social programs and projects and the location and allocation of support
infrastructure. The regional infrastructure strategy serves as a basis for the
infrastructure support component of the MTRDP which in turn is translated into the
Regional Development Investment Program (RDIP). The RDIP is finally broken
down into the Annual Investment Program (AIP) which becomes part of the annual
budget.
The environmental management or protection land use strategy can be a source
of sectoral programs and projects having to do with preservation, conservation,
rehabilitation and protection of vital natural resources. This will help operationalize
the Philippine Agenda 21, which seeks among other things to achieve economic
growth with adequate protection of the countrys biological resources and its
diversity, vital ecosystems functions and over-all environmental quality.
Beyond the requirement that all sectoral development programs and projects
impinging on the natural ecosystems must incorporate environmental conservation
measures, the environmental management strategy of the RPFP demands that active
conservation and rehabilitation projects in severely degraded areas be regarded as
development projects in their own right. It is time that more projects of this latter
type find their way into the RDP.
Another aspect of horizontal integration pertains to sectoral plans. Sectoral
agencies dealing with land and other natural resources may formulate and adopt
their own long-term and medium-term plans. Such sectoral plans must be prepared
within the framework of the RPFP. The sectoral agencies plans must be linked to
the RPFP process in two ways: First, the sectoral agencies provide data and
information as input to the formulation or refinement of regional development goals
and objectives in the RPFP. Second, sectoral agencies implement those particular
components of the RPFP that are within their functional responsibility through their
sectoral programs and projects. The latter role includes monitoring of environmental
change to furnish feedback information into an inter-agency resource information
system. This resource information system provides monitoring and feedback data
for future revisions of the RPFP and the formulation of other development plans.
Replanning and Updating
The Regional Land Use Committee (RLUC) shall monitor changes in land use and
other physical resources. The NEDA shall be responsible for the monitoring of
changes in the socioeconomic environment.
The Provincial Land Use Committee (PLUC) and the Provincial Planning (PPDO),
City and the Municipal Development Planning Offices (MPDO) shall serve as the
counterparts at the province, city and the municipality. The PLUC together with the
Provincial and City Environment and Natural Resources Office (PENRO/CENRO) shall
monitor environmental change at the provincial level. Private Organizations and
Peoples Organizations are encouraged to participate. Any revision of the mediumterm plan that has spatial or land use implications should be reflected in the revision
of the RPFP.
Executive Order NO. 72 identifies the composition of the PLUC. It is Chaired by
the Provincial Planning and Development Coordinator (PPDC), Provincial
Agriculturist, a representative of non-government organization that are represented
in the Provincial Development Council (PDC) and representatives from the following
national government agencies as members: Housing and Land Use Regulatory Board
(HLURB), Department of Environment and Natural Resources (DENR), Department of
Agrarian Reform (DAR), Department of Trade and Industry (DTI), Department of
Public Works and Highways (DPWH)< Department of Tourism (DOT) and
Department of Interior and Local Government (DILG).
Plan implementation shall be monitored to facilitate its updating. The monitoring
shall be done on a yearly basis. The Regional Project Monitoring and Evaluation
System (RPMES) shall be used as the official monitoring report.
Policy review shall be hand-in-hand with the monitoring to be able to improve the
program implementation. Based on the results of the monitoring, policies needing
refinement or revision can be raised to the proper authorities.
It is targeted that the RLUC shall perform periodic review of the physical plans and
conduct revision and updating every three years to coincide with the term of the
local government officials.
IMPLEMENTATION SUPPORT SERVICES
There shall be support activities that will ensure the efficient and effective
implementation of the programs and projects. Likewise, capability building
programs shall be proposed to enhance the planners on the aspect of updating,
monitoring and evaluation of the project being implemented. Advocacy on the 30year plan shall be performed for a wider dissemination of the proposed land use,
protection, settlements and infrastructure plans to achieve the goals and objectives
of the plan. Included in the promotion will be the potential of the region to attract
more investors
Public Information Programs. A prcis of the plan in non-technical language
will be written and disseminated through the different media of communication. It
will be translated into a primer to enable ordinary citizens to understand what it is all
about and how it affects them.
Capability Building Program. Efforts shall be exerted for training and
retraining programs on various aspects of physical and land use planning to enable
TWG members to keep abreast of recent developments in physical planning
concepts and techniques. Training is needed on gender analysis and planning to
better analyze and plan for gender concerns that influence sectoral policies and
plans. Scholarships, both locally and abroad may be sourced from time to time to
help facilitate this process.
existing land use and other thematic maps using a series of satellite imageries
that will show changes in land use over time;
map overlay analysis showing relationships among themes, i.e. land tenure
vs. land use.