Escolar Documentos
Profissional Documentos
Cultura Documentos
Quiz Instructions
Question 11 ptsSkip to question text.
Refer to the exhibit. What destination address will RTB use to advertise LSAs?
224.0.0.5
224.0.0.6
10.1.7.17
172.16.1.1
172.16.2.1
255.255.255.255
Flag this Question
Question 21 pts
What does the Cisco IOS use to calculate the OSPF cost to a destination network?
bandwidth
bandwidth and hop count
bandwidth and reliability
bandwidth, load, and reliability
Flag this Question
Question 31 pts
Which two statements are true about multiarea OSPF? (Choose two.)
A stub area does not accept information from other OSPF areas.
A stub area does not accept information from outside the OSPF autonomous system.
ABRs maintain a separate link-state database for each area to which they are attached.
Internal routers maintain a separate link-state database for each area to which they are
attached.
Flag this Question
Question 41 pts
What are two reasons for creating an OSPF network with multiple areas? (Choose two.)
to provide areas in the network for routers that are not running OSPF
to ensure that an area is used to connect the network to the Internet
to reduce SPF calculations
to reduce use of memory and processor resources
to simplify configuration
Flag this Question
Question 51 pts
For OSPF, which three options must be the same within the hello packet that is
exchanged between two adjacent routers? (Choose three.)
area ID
DR/BDR assignments
hello/dead intervals
router priority
stub flag
Flag this Question
Refer to the diagram. Which state is RTB in if it sees itself in the RTA hello but no
routing information has been exchanged?
attempt state
down state
init state
loading state
two-way state
Flag this Question
Refer to the exhibit. When OSPF is operational and converged, what neighbor
relationship is developed between Router1 and Router2?
A FULL adjacency is formed.
A 2WAY adjacency is formed.
Router2 will become the DR and Router1 will become the BDR.
Both routers will become DROTHERS.
Flag this Question
Question 81 pts
Refer to the exhibit. What does the state "FULL/ -" indicate?
The DR/BDR election is currently taking place.
The router with router ID 10.112.0.34 and RouterA are on a point-to-point network.
RouterA could not form a neighbor relationship with the router with router ID 10.112.0.34.
OSPF hello and dead timers between RouterA and the router with router ID 10.112.0.34 do
not match.
Flag this Question
Type 3 LSA
Type 4 LSA
Type 5 LSA
Flag this Question