Escolar Documentos
Profissional Documentos
Cultura Documentos
No.
1
2
4
5
6
9
10
11
12
13
14
15
16
The ratio of the resistance of a 100 W, 220 V lamp to that of a 100 W, 110 V lamp
will be nearly
(A) 4
(B)2
(C) 1 / 2
(D) 1 / 4
The resistance of a 100 W, 200 V lamp is
(A) 100 ohm (B) 200 ohm (C) 400 ohm (D) 1600 ohm.
Two 1 kilo ohm, 1/2 W resistors are connected in series. Their combined resistance
C
B
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
b. 18.5 W
c. 135 W
d. 150 W
In a two-branch parallel circuit containing one 30-& resistor in each
branch and
powered from a 10-V source, what is the total current flowing in the
circuit?
a. .33 A
b. .67 A
c. 40 A
d. 60 A
The element of electric heater is made of
(A) copper
(B) steel
(C) carbon
(D) nichrome.
5xl016 electrons pass across the section of a conductor in 1 minute 20 sec. The
current flowing is
(A) 1mA
(B) 0.1 mA
(C) 0.01mA
(D) 10 mA.
If a resistor suddenly decreases in value (resistance decreases), what will
happen to the
Current through the resistor?
a. Increases
b. Remains unchanged
c. Decreases
d. Fluctuates
Three elements having conductance G1, G2 and G3 are connected in parallel. Their
combined conductance will be
(A) 1/( 1/G1 + 1/G2 + 1/G3)
(B) (G1G2 + G2G3 + G3G1)/(G1 + G2 + G3)
(C) 1/(G1 + G2+ G3)
(D) G1 + G2 +G3
How many watts are in 100 microwatts?
a. .01 milliwatts
b. .1 milliwatts
c. 1.0 milliwatts
d. 10 nanowatts
All of the following have negative temperature coefficient EXCEPT
(A) Paper
(B) Gold
(C) Rubber.
Temperature coefficient of resistance is expressed in terms of
(A) ohms / ohms oC
(B) mhos / ohm oC
(C) mhos / oC
(D) ohms / oC.
Resistivity is usually expressed in terms of
(A) mho
(B) ohm / oC
35
36
37
38
39
40
41
42
43
44
45
(C) ohms/cm-square
(D) ohms/cm-cube.
The resistance temperature coefficient is defined as
(A) increase in resistance per degree centigrade
(B) decrease in resistance per degree centigrade
(C) the ratio of increase in resistance per degree centigrade to the resistance at 0oC
(D) the ratio of increases in resistance per degree centigrade to the rate of rise of
resistance at 0oC.
Whats the power loss in watts of a conductor that carries 25A and has a
voltage drop of 7.2 V?
(a) 180W
(b) 350W
(c) 700W
(d) 2,400W
A 120V rated toaster will produce _____ heat when supplied by 115V.
(a) more
(b) less
(c) the same
(d) none of these
The ambient temperature is 250C and R.T.C. at 00C is 0.005 /0C what is R.T.C. at 250C
a) R.T.C. at 250C = 2.22 x 10 -3 / 0C
c) R.T.C. at 250C = 4.44 x 10 -3 / 0C
b) R.T.C. at 250C = 3.33 x 10 -3 / 0C
d) R.T.C. at 250C = 5.55 x 10 -3 / 0C
Two bulbs of 500W & 200W rated at 250 volt will have resistance ratio as
(a) 4:25
(b) 25:4
(c) 2:5
(d) 5:2
Bulbs in street lighting are all connected in
(a) Parallel (b) series
(c) series-parallel(d) end to end
Temperature coefficient of resistance is expressed in terms of
(a) Ohm /0C (b) mho/ohm0C(c)ohm/ohm0C(d) mho/0c
Which resistor will be physically larger in size?
(a) 100, 10W
(b) 10, 50W
(c) 1M. W
(d) 1K, 1W
An electric heater is marked 2000 W, 200 V. The resistance of the coil
is
a) 0.1
b) 20
c) 1/20
d) 200
The current in a circuit having constant resistance is tripled. The power
increases
a) 1/9 times
b) 3 times
c) 9 times
d) 1/3 times
Whats the power consumed by a 9.60 kW heat strip rated 230V connected to a 230V circuit?
a) 7.85 kW
b) 9.60 kW
c) 11.57 kW
d) 25 kW
C
A
A
B
B