Escolar Documentos
Profissional Documentos
Cultura Documentos
= 0. 0625
Maximum Reinforcement thickness of vertical butt joints of a tank shell plate of 28mm, of an AST
built to API Standard 650 shall be:
5mm
2.4mm
1.6mm
3mm
Vertical joints of a 28mm thick shell of an AST built to API Std. 650 shall be radiographed to the
extent as given below :
Full
Partial
Spot
Nil
8.
In an AST built to API Standard 650, the bottom annular plates have radial weld joints, and
are single butt welded with permanent back-up bar, in which case, the extent of radiographing
radial joints shall be,
One spot on 50% of radial joint
One spot on 10% of radial joints
Full radiography of all radial joints
RT Nil; only MT of 100% joints is adequate.
9.
As per API Std. 650, personnel who perform and evaluate radiographic examinations (RT)
The minimum required shell thickness of a Tank of 60 Meter diameter (200 ft. diameter),
Greater of a, b, c
11.
Determine whether impact testing is required for A516 gr 70 normalised plates 1 inch thick,
Which of the following sets of the Transverse Charpy V-notch Impact Test Values of a fully
killed 0.75 thick plate of ASTM A 516 gr 60 for a design metal temperature of -34 degree C, is
acceptable as per API 650? Plates are not normalized.
20, 11, 12 Joules
18, 24, 12 Joules
24, 22, 10 Joules
20, 10, 27 Joules