Escolar Documentos
Profissional Documentos
Cultura Documentos
(2335278-U)
No 6-3, JalanPuteri 2/4, Bandar PuteriPuchong, 47100 Puchong, Selangor.Website: www.infravera.com
Tel: 03-8063 5733 Fax: 03-8051 4637 Email: sales@infravera.com (Sales) support@infravera.com (Tech. Support)
Table of Contents
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
Page 0
Page 1
4. Drain+ Interface
i.
Program Ribbon
Page 2
Scale
Always ensure your drawing scale 1:1 (meter)
Recommendation:
Instead of working on original drawing, which may contain illegal entities and error less data, we
recommended you to turn off irrelevant layer,
copy the layout with necessary layers and paste to the new CAD, to produce a clean drawing.
Page 3
Using polyline
ii.
To add bend
a. Select polyline
b. Continue draw polyline without stop (mouse click only then continue)
Page 4
3. At General
AutoGradSize
o Gradient and Size
will provide by
application
FixGradSize
o Gradient and size
provide by user
4. Select OK button
Page 5
4. Insert ARI
Page 6
button.
tab
icon
Page 7
.
3. Start to draw catchment area by mouse click (left click)
Page 8
1. Select Integrity
icon
3. Select Run
button
icon
icon
2. Select Save As
tab
3. Select any location to save. Example Desktop (by default it will go to Document)
5. Save
button.
Page 9
2. Drain Section
icon.
3. At Default
4. Select Build
tab.
layout.
tab.
2. Select Pick
button
Page 10
icon.
icon.
button.
3. Select Show
button.
to save calculation.
2. Select Drain+
tab.
Page 11
8. Operation Summary
Setup Input
Paramater
Setup
MSMA
Data
Import
CAD file
Add
catchment
area
Generate
Result
Page 12
icon.
*If user already run once for each Sewer and Drain,
then direct run the Integrity
4. Select Integrity
*Warning icon will appear at layout and info will display in Integration dock panel at bottom if
contain any clashing.
5. Select adjustment
*To automate the minimum depth of closed channels or sewers depth. It will re-calculate all sewers and
drains network.
Page 13
10. FAQ
i.
tab.
iii)
Select PL Read
icon.
iv)
Earth+ Computation Import Levels will pop up. Insert the finished thickness (if
have).
v) Select Accept
button.
vi)
Located the project file.
vii)
Message Import PL will pop up. Select OK
b) Manually insert GL
i) Select Sump.
Page 14
ii.
i) Select Node
icon.
ii) By mouse click, start to draw channel.
Drag it to create
channel.
iii.
icon.
iv.
tab.
Page 15
v.
vi.
vii.
ii) Go to Channel
tab.
*Min D for this channel can be change until 0.3m plus with drop 0.15m, 0.45m only at Depth properties.
iv) Once channel change in yellow colour, the properties for that channel at your left hand
side.
v) Change at Node Start
at Properties
Page 16
By default, MinDepth
read as 0.45m
Change MinDepth to
0.15m
Note:
NodeStart: First node for that channel
NodeEnd : Second node for the same channel
viii.
ix.
Page 17
button
button.
button again.
Page 18