Escolar Documentos
Profissional Documentos
Cultura Documentos
Reference:
RS05-006
Date:
NTB06-046
IF YOU CONFIRM
An open circuit DTC code (SIDE MODULE
LH [OPEN] / B1134) is stored in the SRS
control unit,
and
The connector for the drivers seat side
impact air bag module is disconnected
(either completely or partially),
NOTE: If CONSULT-II shows the above
code (B1134), and the drivers seat side
air bag connector is not disconnected,
this bulletin does not apply. Return to
ASIST for further diagnostic information.
Figure 1
(View from under the front of the drivers
seat)
ACTION
Change the location of the drivers seat side impact air bag connector by installing the kit
listed in the Parts Information.
IMPORTANT: The purpose of "ACTION" (above) is to give you a quick idea of the work
you will be performing. You MUST closely follow the entire Service Procedure (starting on
page 2) as it contains information that is essential to successfully completing this repair.
Nissan Bulletins are intended for use by qualified technicians, not 'do-it-yourselfers'. Qualified technicians are
properly trained individuals who have the equipment, tools, safety instruction, and know-how to do a job
properly and safely. NOTE: If you believe that a described condition may apply to a particular vehicle, DO
NOT assume that it does. See your Nissan dealer to determine if this applies to your vehicle.
1/4
PARTS INFORMATION
DESCRIPTION
SAB Connector Service Kit.
PART #
87885-EA01E
QUANTITY
1
CLAIMS INFORMATION
Submit a Primary Operation (PO) line claim using the following claims coding:
DESCRIPTION
Install SAB Connector Service Kit
OP CODE
RX35AA
SYM
ZE
DIA
62
FRT
0.6 hrs
SERVICE PROCEDURE
1. Write down all radio station presets.
Presets
AM
FM-1
FM-2
3. Wait at least 3 minutes after the battery cables are disconnected before
disconnecting any air bag connectors.
2/4
4. From under the front of the driver seat, drill 2 holes in the connector bracket as shown in
Figure 2.
The seat does not need to be removed.
Use a inch drill bit.
CAUTION: Make sure to use a rag or other suitable material to catch the metal
shavings from the drilled holes. Dont let the shavings fall into the electrical
connectors, carpet, seat track or other components that are under the seat.
20mm
20mm
24mm
Figure 2
5. Install the new connector holder in the holes you just drilled.
A new connector holder is included in the kit listed in the Parts Information.
Position the connector holder as shown in Figure 3 and snap it in place.
Connector holder
Figure 3
3/4
6. Unsnap the side air bag connector from its original location and snap it into the new
connector holder as shown in Figure 4.
Remove and discard the old connector holder.
Leave the buckle connector in the same location (dont move it).
Edge Guard
Buckle Connector
(Dont Move)
Figure 4
7. Install the edge guard as shown in Figure 4.
Edge Guard is included in the kit listed in the Parts Information.
8. Re-connect the battery cables; positive cable first.
9. Re-set the radio station presets.
10. Using CONSULT-II, erase any DTCs that are stored in the air bag control unit.
4/4