Escolar Documentos
Profissional Documentos
Cultura Documentos
com
RA
[8+8]
D
L
R
O
W
U
T
N
[6+5+5]
(a) Annealing
(b) Nitriding.
[8+8]
cupronickel alloys
Duralumin
Red brasses.
Beryllium Bronzes.
[4 4 = 16]
[5+5+6]
8. (a) Define the term composites. What factors influence the final properties of
composites? Explain.
(b) Explain about Glass Fibre-Reinforced Polymer composites.
[8+8]
?????
1 of 1
www.jntuworld.com
www.jntuworld.com
RA
D
L
R
O
(b) What will happen when a D.C. Series Motor is started without a load connected to it?
(c) A 4 pole, 500V, shunt motor has a total of 720 armature conductors which are
wave wound. The full-load armature current is 60A, and the flux per pole is
0.03Wb. The armature resistance is 0.2. the voltage drop across a brush is
1 volt. Calculate the full-load speed of the motor.
[6+4+6]
W
U
T
N
3. How do you classify the transformers and also discuss the different parts of transformer in detail.
[16]
4. (a) Define voltage regulation of a transformer. Deduce the expression for the
voltage regulation.
(b) The number of turns on the primary and secondary windings of a single phase
transformer are 350 and 35 respectively. If the primary is connected to a 2.2
KV 50 HZ supply determine the secondary voltage.
[8+8]
5. (a) Explain the principle of 3-phase Induction Motor with the help of rotating
magnetic field.
(b) A 3-phase, 6-pole alternator is coupled to an engine running at 1200 r.p.m.
The alternator supplies an Induction Motor which has a full-load speed of
1164 r.p.m. Find the slip and number of poles of the motor.
[10+6]
6. (a) Explain the constructional features of alternator.
(b) How e.m.f is induced in an 3-phase alternator? Derive the expression for e.m.f
induced in an alternator in terms of pitch and distribution factors.
[8+8]
7. Using double field revolving theory for single phase induction motors. Give its
torque speed characteristic. Why this motor does not have starting torque. [16]
8. (a) Discuss the classification of electrical instruments.
1 of 2
www.jntuworld.com
www.jntuworld.com
RA
(b) Explain the significance of controlling torque and damping torque relevant to
the operation of indicating instruments.
[8+8]
?????
D
L
R
O
W
U
T
N
2 of 2
www.jntuworld.com
www.jntuworld.com
RA
D
L
R
O
W
U
[16]
[8]
[8]
4. (a) Perfect competition is only an imaginary situation far from reality ? Do you
agree with the above statement or not? Comment.
(b) What is the role of time factor for price determination?
T
N
[10+6]
(b) Outline the types of partners and comment on the limitations of partnership
business.
[8+8]
[16]
7. Give a brief account on the important records of Accounting under Double entry
system and discuss briefly the scope of each.
[16]
8. (a) From the following information, calculate
i. Debt ? Equity ratio
ii. Current ratio
Rs.
Rs.
Debentures
1,40,000 Bank balance
30,000
Long term loans
70,000 Sundry Debtors 70,000
General reserve
40,000
Creditors
66,000
Bills payable
14,000
Share capital
1,20,000
1 of 2
www.jntuworld.com
[16]
www.jntuworld.com
RA
Rs.
Net profit after deducting interest and taxes 6,00,000
12% Debentures of the face value of
15,00,000
Amount provided towards taxation
1,20,000
?????
D
L
R
O
W
U
T
N
2 of 2
www.jntuworld.com
www.jntuworld.com
RA
D
L
(c) Distinguish between tightly coupled microprocessors and tightly coupled Microprocessors.
[16]
R
O
2. Design register selection circuit to select one of the four 4-bit registers content on
to bus. Give fuller explanation.
[16]
W
U
T
N
[8]
4. (a) How many bits are needed to store the result addition, subtraction, multiplication and division of two n-bit unsigned numbers. Prove.
[8]
(b) What is overflow and underflow. What is the reason?. If the computer is
considered as infinite system do we still have these problems?.
[8]
5. (a) What is Virtual Memory? What are the issues behind the usage of this technique?
(b) What are the advantages and disadvantages of using the technique of Paged
Segmentation
[8+8]
6. Explain the following:
(a) Isolated Vs Memory mapped I/O
(b) I/O Bus Vs Memory Bus
(c) I/O Interface
(d) Peripheral Devices
[4+4+4+4]
www.jntuworld.com
www.jntuworld.com
RA
D
L
R
O
W
U
T
N
2 of 2
www.jntuworld.com
[8+8]
www.jntuworld.com
RA
D
L
2. (a) Illustrate any four functions in the < math.h > header file.
R
O
[8+8]
W
U
[5+6+5]
T
N
5. (a) What are the different types of inheritance? Give an example program for
each.
(b) The private member of a base class is not inheritable, Is it anyway possible
for the objects of a derived class to access the private members of the base
class? If yes, how? Note that the base class cannot be modified.
[6+10]
6. (a) Justify the need of virtual function in C++? What is runtime dispatching?
Explain how C++ handles runtime dispatching.
(b) Write a program to demonstrate the compile time binding of the member
functions of the class. The same message has to be displayed while accessing
the derived class member functions from the array of pointers.
[8+8]
7. (a) What are the disadvantages of using scanf ()/printf () functions? Explain?
(b) Draw a line diagram showing hierarchy of various classes in the iostream
library and explain each?
[8+8]
8. Draw the line diagram of the hierarchy of standard library exceptions thrown by
the C++ language? Explain each one of them briefly?
[16]
?????
1 of 1
www.jntuworld.com