Escolar Documentos
Profissional Documentos
Cultura Documentos
Fetal doppler
OPERATE MANUAL
Copyright
2005
Table fo content
Specification...........................................................2
Main configuration..................................................3
Function keys introduction......................................4
Operate manual......................................................5
Stock and transport................................................6
Cleaning.................................................................6
Safety sort..............................................................6
Apply range............................................................6
In case of difficulty..................................................7
Circuitry principium................................................8
Unpacking
Unpacking the unit carefully and make sure that all accessories are
put aside so they will not be lost.Examine the unit for any possibility
of shipping damage.If your unit is damage or fails to operate,notify
our dealer or our company immediately.Please offer the model number,
S/N,date of buying and contact information when you contact us.
Specification
Ultrasound operating frequency
Integrative sensitivity
2.0MHz
3%
17.38mW/cm
1cm2
210bpm
DC 7.2V
240
160
115mm
2
Gel request Density 1.0g/cm
Impedance
1.7
1.7m/s
Attenuation
10 g/cm.s
0.02db/mm
Main structure
Head-on of the mainframe
Adapter
ositio
m this p
Insert fro
10
Switch
Turn up button
Turn down button
Manual calculation start and stop button
12
Loudhailer hole
10
Charge junction
11
Battery storehouse
12
Label
Function introduce
13
13
14
14
MODEL
Press the button can switch the monitor model,when you turn
on the equipment,acquiescence model 1.
Turn down button,press it,the volume reduced until no voice,
when the volume is minimum,press it will without voice.
Turn up button,press it ,the volume increased,when the volume
is maximun,press it will without voice.
Manual calculation start and stop button,the two buttons with
the same function and only valid in model 3.when it is in model
3,press the button and wait until 10 times fetal heart beat,then
press it again,FHR display area will display the manual calculate
result.
Operate manual
Auto measure the HR
1.Turn on
Press
to restart it.
Handmade measure HR
1.Turn on the equipment and press ,choose the model 3--handmade
measure HR
2.Detect the FHR
Put the Gel on the detect position of the pregnant womansabdomen ,then
press the probe ensure it is good connected ,when the probe is on the right
position,you can hear the fetal heart beat,press
or
4.Turn off
When you do not use it, press
will autoturn off if it is no signal,press
--45
9%--45%
The product can be sent by air ,sea and land-carriage,but cant place it
in the open air.
Cleaning
Safety sort
The safety sort of the product is :II Before
Apply range
Suit for fetus more than 16 weeks old
In case of difficulty
Symptom
Audio scream
Remedy
Cause
Battery is exhausted
Audio volume too high
Too much Gel on the
probe surface
Low sensitivity
Insufficient Gel
Battery is exhausted
Insufficient Gel
Add Gel
circuit diagram
Website : www.jumper-med.com