Escolar Documentos
Profissional Documentos
Cultura Documentos
15.00
3.00
3.00
3.00
3.00
3.00
15.00
PLAN
33.00
3.00
3.00
3.00
3.00
3.00
15.00
ELEVATION
Height Y=3.0m
Width Z=15.0m
No. of Bays=5
2.Member Property :
Click General Property Define Rectangle
YD=0.45
ZD=0.30 Add
12
=0.86 sec.
=0.86sec.
12
Max.=30.0m Add
Max.=33.0m Add
Highlight Member load - 12 KN/m Go to Front view Select Beam parallel toX
and Z. Front elevation view. Right click New view Ok.
Select only typical floor beams except roof beam create new view Ok.
Plan view Highlight w1=-12Select the outer portion of beams (9 wall portion )
Assign to selected beams Assign Yes.
Highlight Member weight W=-6KN/m Cut section . Go to Plan view Select inner
portion of the beam Assign to selected beams Assign Yes
Right click New view create a new view OK. Plan view Select outer
portion of the beam Assign to selected beam AssignYes Close.
Click Load case 6 (Live load)Add.
Floor Load pressure :-2 KN/m2
Define Y range Mini.= 3.0m
Max.=30.0m Add
: 4 OK.
Rule No.
1
2
3
4
Dead
1.5
1.5
1.2
0.9
Live
1.5
-1.2
---
Seismic
-1.5
1.2
1.5
the bottom most storey column. If some columns in GF inner are failed, change the
size of the column for inner portion and again run the analysis, verify the result.
Similarly check the beam by double click the particular beam for find the reinforcement.
If all are passed ok. Otherwise revise the beam section if failed.
Report :
Click report set up icon.
Available :
Input
Output
Selected :
1. Sections
2. Supports
3. Loadings
Beam End Forces
Reactions
Beam Max Axial Forces
Beam Max moments
Beam Force Details Summary Ok.
Click Report setup icon Click input from available from left side.
Select sections , Loadings and sent to Right side by clicking > Select output.
From output select Beam end forces, reactions, Reactions, Shear forces, axial forces,
Beam force detail summary.
To Take picture:
Click Take picture icon Enter the title of the sketch. Then Go to report set up. Select
picture Album. If you want to change the sketch title enter the title in caption.
Adjust the picture size by adjusting height & width. Select Full page.
To export Results in word file:
File Export Report MS word file. Click save.