Você está na página 1de 4

MITSUBISHI DIESEL ENGINE

TECHNICAL INFORMATION

ITEM NO.

T0217-0009E Rev.2

(1/4)

April, 2010

DATE

Specification Sheets of S16R-F1PTAW2 Engine

Specification Sheets of S16R-F1PTAW2 Engine are enclosed herein.

Revision

First Edition : April, 2010


Rev.1 : August, 2010
Rev.2 : Nov., 2010

Engine Engineering Department


Marine Engine Design Section
Approved by Checked by
T.HASHIGUCHI

K.NAKAMURA

MITSUBISHI HEAVY INDUSTRIES, LTD.


GENERAL MACHINERY & SPECIAL VEHICLE

Drawn by
K.N.

MITSUBISHI

S16R-F1PTAW2

SPECIFICATION SHEET

DIESEL ENGINES

GENERAL ENGINE DATA


Type
Aspiration

4-Cycle, Water Cooled


Turbo-Charged, Inter Cooler
(Fresh water to Cooler)

60oV
16
170
180
65.37
14.0:1
6680
6830

Cylinder Arrangement
No.of Cylinders
Bore mm(in.)
Stroke mm(in.)
Displacement liter(in 3)
Compression Ratio
Dry Weight - Engine only - kg(lb)
Wet Weight - Engine only - kg(lb)

(6.69)
(7.09)
(3989)
(14729)
(15060)

PERFORMANCE DATA
Steady State Speed Stability Band at any Constant Load
Electric Governor - %
Maximum Overspeed Capacity - rpm
Moment of inertia of Rotating Components - kgfm2(lbfft2)
(Includes Std.Flywheel)
Cyclic Speed Variation with Flywheel at 1500rpm

0.25 or better
2100
80.83 (1918.5)
1/138

ENGINE MOUNTING
Maximum Bending Moment at Rear Face of Flywheel Housing - kgfm(lbfft)
AIR INLET SYSTEM
Maximum Intake Air Restriction (Includes piping)
With Clean Filter Element - mm H 2O (in.H2O)
With Dirty Filter Element - mm H 2O (in.H2O)
EXHAUST SYSTEM
Maximum Allowable Back Pressure - mm H2O (in.H2O)
LUBRICATION SYSTEM
Oil Pressure at ldle - kgf/cm2(psi)
at Rate Speed - kgf/cm2(psi)
Maximum Oil Temperature - oC(oF)
Oil Capacity of Standard Pan
High - liter (U.S.gal)
Low - liter (U.S.gal)
Total System Capacity (lncludes Oil Filter) - liter (U.S.gal)
Maximum Angle of lnstallation (Std. Pan)
Front Down
(Engine Only)
Front Up
Side to Side
COOLING SYSTEM
Coolant Capacity of Jacket (Engine only) - liter (U.S.gal)
Coolant Capacity of Air cooler (Engine only) - liter (U.S.gal)
Maximum External Friction Head at Engine Outlet - kgf/cm 2(psi)
(For Jacket and Air Cooler)
Maximum Static Head of Coolant above Crankshaft Center - m(ft)
Standard Thermostat (modulating)Range of Jacket - oC(oF)
o o
Standard Thermostat (modulating)Range of Air Cooler - C( F)
Maximum Coolant Temperature at Engine Outlet of Jacket - oC(oF)
Minimum Coolant Expansion Space - % of System Capacity
(For Jacket and Air Cooler)
o o
Maximum Coolant Temperature at Intercooler lnlet, PTAW type - C( F)
Maximum Air Restriction on Discharge Side of Radiator and Fan - mm H 2O(in.H2O)

450

(3255.6)

400
635

(15.7)
(25.0)

600

(23.6)

23
56.5
110
200
140
230
5o
5o
22.5o

(2943)
(7193)
230
(53)
(37.0)
(60.8)

140
30

(37.0)
(7.9)

0.35
10
7185
4255
98

(5.0)
(32.8)
(160185)
(108131)
(208)

10
45
10

(0.4)
(113)
(0.4)

The specifications are subject to change without notice.

APPLICATION : GENERATOR
Pub. No. T0217-0009E Rev.2
Nov. '10 Printed in Japan

MITSUBISHI

S16R-F1PTAW2

SPECIFICATION SHEET

DIESEL ENGINES

FUEL SYSTEM
Fuel Injector
Maximum Suction Head of Feed Pump - mm Hg (in. Hg)
Maximum Static Head of Return Pipe - mm Hg (in.Hg)

Mitsubishi PS8 Type 2


75
(3.0)
150
(5.9)

STARTING SYSTEM
Battery Charging Alternator - V- Ah
Starting Motor Capacity - V - kW
Maximum Allowable Resistance of Cranking Circuit - m
Recommended Minimum Battery Capacity
At 5oC (41oF) and above - Ah
Below 5oC (41oF) through - 5oC (23oF)

24-30
24-7.5 2
1.5
300
600

Emission Level 100% Load (at STAND-BY POWER)


Values in mg/Nm3, O2 content 5%
Nox : 2000mg/Nm3
CO : 650mg/Nm3
HC : 150mg/Nm3
PM : 50mg/Nm3

Control method of emission level shall be compliant with EPA regulation.


Test Condition
fa

0.96fa1.06

fa: Engine specific parameter considering atmospheric condition


which determined according to the following provisions.
( See EUROMOT 2004 - EC 1997 68 Consolidated - Annex III)
0.7

fa = (99/Ps)

1.5

(Ta/298)

Ps: Dry Atmospheric pressure(kPa)


Ta:Absolute temperature of the intake air(k)
Fuel

JIS K-2204 Type2

Tfi

33Tfi43 Tfi:The fuel temperature at the injection pump inlet.

The specifications are subject to change without notice

APPLICATION : GENERATOR
Pub. No. T0217-0009E Rev.2
Nov. '10 Printed in Japan

MITSUBISHI

S16R-F1PTAW2

SPECIFICATION SHEET DIESEL ENGINES

ENGINE RATING
All data represent net performance with standard accessories such as air cleaner, inlet /exhaust manifolds, fuel oil system,
o
o
L.O. pump, etc. under the condition of 100kPa(29.6inHg) barometric pressure, 77 F(25 C) ambient temperature and 30%
relative humidity.
ITEM
Engine Speed
No. of Cylinders
Bore
Stroke
Displacement
Brake Horse power without Fan
Brake Mean Effective Pressure
without Fan
Mean Piston Speed
Maximum Regenerative Power
Absorption Capacity without Fan
Intake Air flow
Exhaust Gas Flow
Coolant Flow
Coolant Flow to Intercooler
(PTAW only)
Cooling Air Flow
(Std. Fan)
Allowable Fan Loss Horse Power
Radiated Heat to Ambient
Heat Rejection to Coolant
Heat Rejection to Air Cooler
(PTAW Version)
Heat Rejection to Exhaust
Noise Level (1 m height & distance)
(excludes, lntake,Exhaust & Fan)

UNIT
rpm

STAND-BY POWER

PRIME POWER

50Hz

50Hz

1500

1500
16

mm
(in.)
mm
(in.)
liter
3
(in. )
HP
(kW)
2
kgf/cm
(psi)
m/s
(ft/min)
HP
(kW)
3
m /min
(CFM)
3
m /min
(CFM)
liter/min
(U.S. GPM)
liter/min
(U.S. GPM)
3
m /min
(CFM)
HP
(kW)
kcal/hr
(BTU/min)
kcal/hr
(BTU/min)
kcal/hr
(BTU/min)
kcal/hr
(BTU/min)
dB(A)

170
(6.69)
180
(7.09)
65.37
(3989)
2610
(1947)
24.3
(346)
9.0
(1772)
188
(140)
178
(6285)
471
(16631)
1650
(436)
750
(198)

2382
(1777)
22.2
(316)
9.0
(1772)
188
(140)
160
(5650)
424
(14971)
1650
(436)
750
(198)

40
(30)
134051
(8866)
580887
(38419)
491520
(32508)
1587816
(105016)
113

40
(30)
120715
(7984)
523099
(34597)
442622
(29274)
1409483
(93221)
113

The specifications are subject to change without notice.

APPLICATION : GENERATOR
Pub. No. T0217-0009E Rev.2
Nov. '10 Printed in Japan

Você também pode gostar