Escolar Documentos
Profissional Documentos
Cultura Documentos
CRT5053
DEH-15UB/XNUC
CD RDS RECEIVER
DEH-15UB
/XNUC
DEH-1500UB
DEH-1500UBA
DEH-1500UBB
DEH-1500UBG
DEH-1550UB
DEH-1590UB
/XNEW5
/XNEW5
/XNEW5
/XNEW5
/XNES
/XNID
This service manual should be used together with the following manual(s):
Model No.
CX-3287
Order No.
CRT4759
Mech. Module
S11.6STD
Remarks
CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
SAFETY INFORMATION
CAUTION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
WARNING
This product may contain a chemical known to the State of California to cause cancer, or birth defects or
other reproductive harm.
Health & Safety Code Section 25249.6 - Proposition 65
Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION:
USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
CAUTION
This product is a class 1 laser product classified under the Safety of laser products, IEC
60825-1:2007, and contains a class 1M laser
module. To ensure continued safety, do not remove any covers or attempt to gain access to
the inside of the product. Refer all servicing to
qualified personnel.
WARNING!
The AEL (accessible emission level )of the laser power output is less than CLASS 1
but the laser component is capable of emitting radiation exceeding the limit for
CLASS 1.
A specially instructed person should do servicing operation of the apparatus.
F
DEH-15UB/XNUC
1
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replaced only with the same or equivalent type recommended by the manufacturer.
Discord used batteries according to the manufacturer's instructions.
C
DEH-15UB/XNUC
5
CONTENTS
SAFETY INFORMATION..................................................................................................................................... 2
1. SERVICE PRECAUTIONS ............................................................................................................................... 5
1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5
1.2 NOTES ON SOLDERING .......................................................................................................................... 6
2. SPECIFICATIONS ............................................................................................................................................ 7
2.1 SPECIFICATIONS ..................................................................................................................................... 7
2.2 DISC/CONTENT FORMAT ........................................................................................................................ 9
3. BASIC ITEMS FOR SERVICE........................................................................................................................ 10
3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 10
3.2 PCB LOCATIONS .................................................................................................................................... 10
3.3 JIGS LIST .................................................................................................................................................11
3.4 CLEANING................................................................................................................................................11
4. BLOCK DIAGRAM.......................................................................................................................................... 12
5. DIAGNOSIS.................................................................................................................................................... 14
5.1 OPERATIONAL FLOWCHART ................................................................................................................ 14
5.2 ERROR CODE LIST ................................................................................................................................ 15
5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 17
6. SERVICE MODE ............................................................................................................................................ 18
6.1 DISPLAY TEST MODE 1 ......................................................................................................................... 18
6.2 DISPLAY TEST MODE 2 ......................................................................................................................... 19
6.3 SOFTWARE VERSION UP METHOD ..................................................................................................... 20
6.4 CD TEST MODE ...................................................................................................................................... 21
7. DISASSEMBLY .............................................................................................................................................. 22
8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 28
8.1 CD ADJUSTMENT................................................................................................................................... 28
8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 29
8.3 PCL OUTPUT CONFIRMATION.............................................................................................................. 31
9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 31
9.1 PACKING ................................................................................................................................................. 32
9.2 EXTERIOR............................................................................................................................................... 36
9.3 CD MECHANISM MODULE..................................................................................................................... 40
10. SCHEMATIC DIAGRAM............................................................................................................................... 42
10.1 TUNER AMP UNIT (GUIDE PAGE) ....................................................................................................... 42
10.2 KEYBOARD UNIT.................................................................................................................................. 48
10.3 CD CORE UNIT (S11.6STD) ................................................................................................................. 50
10.4 WAVEFORMS ........................................................................................................................................ 52
11. PCB CONNECTION DIAGRAM.................................................................................................................... 54
11.1 TUNER AMP UNIT................................................................................................................................. 54
11.2 KEYBOARD UNIT .................................................................................................................................. 58
11.3 CD CORE UNIT (S11.6STD).................................................................................................................. 60
12. ELECTRICAL PARTS LIST .......................................................................................................................... 62
DEH-15UB/XNUC
1
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
1. You should conform to the regulations governing the product (safety, radio and noise, and other
regulations), and should keep the safety during servicing by following the safety instructions
described in this manual.
2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors
during power-on mode may damage the ICs inside the unit.
3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment
(shorting-solder) by referring to "the DISASSEMBLY".
4. After replacing the pickup unit, be sure to check the grating.
5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by
electrostatic induction.
DEH-15UB/XNUC
5
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
DEH-15UB/XNUC
1
2. SPECIFICATIONS
2.1 SPECIFICATIONS
DEH-15UB/XNUC
General
Power source .................. 14.4 V DC (10.8 V to 15.1 V allowable)
Grounding system ........... Negative type
Maximum current consumption
................................ 10.0 A
Backup current.................. 4.0 mA or less
Dimensions (W H D):
DIN
Chassis .............. 178 mm 50 mm
165 mm
(7 in. 2 in. 6-1/2 in.)
Nose .................. 188 mm 58 mm
16 mm
(7-3/8 in. 2-1/4 in. 5/8 in.)
D
Chassis .............. 178 mm 50 mm
165 mm
(7 in. 2 in. 6-1/2 in.)
Nose .................. 170 mm 46 mm
16 mm
(6-3/4 in. 1-3/4 in. 5/8 in.)
Weight ............................. 1 kg (2.2 lbs)
USB
USB standard specification
................................... USB 2.0 full speed
Maximum current supply
................................... 1 A
USB Class ....................... MSC (Mass Storage Class)
File system....................... FAT12, FAT16, FAT32
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
WAV signal format .......... Linear PCM & MS ADPCM
(Non-compressed)
FM tuner
Audio
Maximum power output ... 50 W 4
70 W 1/2 (for subwoofer)
Continuous power output
................................... 22 W 4 (50 Hz to 15 000 Hz,
5 % THD, 4 load, both channels driven)
Load impedance .............. 4 (4 to 8 allowable)
Preout maximum output level
................................... 2.0 V
Loudness contour ............ +10 dB (100 Hz), +6.5 dB
(10 kHz) (volume:30 dB)
Equalizer (5-Band Graphic Equalizer):
Frequency ................. 80 Hz/250 Hz/800 Hz/
2.5 kHz/8 kHz
Equalization range .... 12 dB (2 dB step)
Subwoofer (mono):
Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
125 Hz/160 Hz/200 Hz
Slope ........................ 6 dB/oct,12 dB/oct
Gain ......................... +6 dB to 24 dB
Phase ..................... Normal/Reverse
CD player
AM tuner
Frequency range .............. 530 kHz to 1 710 kHz
Usable sensitivity ............. 25 V (S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (IHF-A network)
CEA2006 Specifications
Note
Specifications and the design are subject to
modifications without notice.
Screw
(BPZ20P060FTC) (UC)
(XXX7020) (EW5, ID, ES)
F
DEH-15UB/XNUC
5
General
Power source .................. 14.4 V DC (10.8 V to 15.1 V allowable)
Grounding system ........... Negative type
Maximum current consumption
................................ 10.0 A
Backup current.................. 4.0 mA or less
Dimensions (W H D):
DIN
Chassis .............. 178 mm 50 mm
165 mm
Nose .................. 188 mm 58 mm
16 mm
D
Chassis .............. 178 mm 50 mm
165 mm
Nose .................. 170 mm 46 mm
16 mm
Weight ............................. 1 kg
Audio
Maximum power output ... 50 W 4
70 W 1/2 (for subwoofer)
Continuous power output
................................... 22 W 4 (50 Hz to 15 000 Hz,
5 % THD, 4 load, both channels driven)
Load impedance .............. 4 (4 to 8 allowable)
Preout maximum output level
................................... 2.0 V
Loudness contour ............ +10 dB (100 Hz), +6.5 dB
(10 kHz) (volume:30 dB)
Equalizer (5-Band Graphic Equalizer):
Frequency ................. 80 Hz/250 Hz/800 Hz/
2.5 kHz/8 kHz
Equalization range .... 12 dB (2 dB step)
Subwoofer (mono):
Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
125 Hz/160 Hz/200 Hz
Slope ........................ 6 dB/oct,12 dB/oct
Gain ......................... +6 dB to 24 dB
Phase ..................... Normal/Reverse
USB
USB standard specification
................................... USB 2.0 full speed
Maximum current supply
................................... 1 A
USB Class ....................... MSC (Mass Storage Class)
File system....................... FAT12, FAT16, FAT32
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
WAV signal format .......... Linear PCM & MS ADPCM
(Non-compressed)
FM tuner
Frequency range ............. 87.5 MHz to 108.0 MHz
Usable sensitivity ............. 9 dBf (0.8 V/75 , mono, S/N:
30 dB)
Signal-to-noise ratio ......... 72 dB (IEC-A network)
MW tuner
Frequency range .............. 531 kHz to 1 602 kHz
Usable sensitivity ............. 25 V (S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)
LW tuner
Frequency range .............. 153 kHz to 281 kHz
Usable sensitivity ............. 28 V (S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)
Note
Specifications and the design are subject to
modifications without notice.
CD player
System .......................... Compact disc audio system
Usable discs ...................Compact disc
Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network)
DEH-15UB/XNUC
1
DEH-1590UB/XNID, DEH-1550UB/XNES
General
USB
USB standard specification
................................... USB 2.0 full speed
Maximum current supply
................................... 1 A
USB Class ....................... MSC (Mass Storage Class)
File system....................... FAT12, FAT16, FAT32
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
WAV signal format .......... Linear PCM & MS ADPCM
(Non-compressed)
FM tuner
Audio
Maximum power output ... 50 W 4
70 W 1/2 (for subwoofer)
Continuous power output
................................... 22 W 4 (50 Hz to 15 000 Hz,
5 % THD, 4 load, both channels driven)
Load impedance .............. 4 (4 to 8 allowable)
Preout maximum output level
................................... 2.0 V
Loudness contour ............ +10 dB (100 Hz), +6.5 dB
(10 kHz) (volume:30 dB)
Equalizer (5-Band Graphic Equalizer):
Frequency ................. 80 Hz/250 Hz/800 Hz/
2.5 kHz/8 kHz
Equalization range .... 12 dB (2 dB step)
Subwoofer (mono):
Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/
125 Hz/160 Hz/200 Hz
Slope ........................ 6 dB/oct,12 dB/oct
Gain ......................... +6 dB to 24 dB
Phase ..................... Normal/Reverse
CD player
System .......................... Compact disc audio system
Usable discs .................. Compact disc
Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network)
Number of channels ........ 2 (stereo)
MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch
audio)
(Windows Media Player)
MW tuner
Frequency range .............. 531 kHz to 1 602 kHz (9 kHz)
530 kHz to 1 640 kHz (10 kHz)
Usable sensitivity ............. 25 V (S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)
SW tuner
Frequency range .............. 2 300 kHz to 7 735 kHz
(2 300 kHz to 2 495 kHz,
2 940 kHz to 4 215 kHz,
4 540 kHz to 5 175 kHz,
5 820 kHz to 6 455 kHz,
7 100 kHz to 7 735 kHz)
9 500 kHz to 21 975 kHz
(9 500 kHz to 10 135 kHz,
11 580 kHz to 12 215 kHz,
13 570 kHz to 13 870 kHz,
15 100 kHz to 15 735 kHz,
17 500 kHz to 17 985 kHz,
18 015 kHz to 18 135 kHz,
21 340 kHz to 21 975 kHz)
Usable sensitivity ............. 28 V (S/N: 20 dB)
Signal-to-noise ratio ......... 62 dB (IEC-A network)
Note
Specifications and the design are subject to
modifications without notice.
DEH-15UB/XNUC
5
To keep the product quality after servicing, please confirm following check points.
No.
1
Procedures
Confirm whether the customer complain has
been solved.
If the customer complain occurs with the
specific media, use it for the operation check.
Play back a CD.
(Track search)
Check FM/AM tuner action.
(Seek, Preset)
Switch band to check both FM and AM.
Check whether no disc is inside the product.
Appearance check
2 CD
3 FM/AM tuner
B
Item to be confirmed
The customer complain must not be
reappeared.
Display, audio and operations must be
normal.
No malfunction on display, audio and
operation.
Display, audio and operations must be
normal.
The media used for the operating check must
be ejected.
No scratches or dirt on its appearance after
receiving it for service.
See the table below for the items to be checked regarding audio:
Item to be checked regarding audio
Distortion
Noise
Volume too low
Volume too high
Volume fluctuating
Sound interrupted
Unit Number
Unit Number
Unit Number
Unit Number
Unit Number
Unit Number
Unit Name
Unit Number
Unit Number
Unit Number
Unit Number
Unit Number
Unit Name
Unit Number
Unit Name
B Keyboard Unit
A:DEH-15UB/XNUC
B:DEH-1500UB/XNEW5
C:DEH-1500UBA/XNEW5
D:DEH-1500UBB/XNEW5
E:DEH-1500UBG/XNEW5
F:DEH-1550UB/XNES
H:DEH-1590UB/XNID
10
: QWM3468(A)
: QWM3465(B,D)
: QWM3467(C)
: QWM3466(E)
: QWM3469(F)
: QWM3471(H)
: Tuner Amp Unit
: (A,F,H)
: (B)
: (C)
: (D)
: (E)
: Keyboard Unit
: CWX4023
: CD Core Unit (S11.6STD)
DEH-15UB/XNUC
1
Jig No.
GGD1310
TCD-782
GYH1026
GEM1017
Remarks
Tuner Amp Unit - CD Core Unit
Checking the grating
Checking the grating (Two pieces)
Capacitor Bond Lock
Capacitor Bond Lock
Grease No.
GEM1024
GEM1038
GEM1043
GEM1045
Remarks
CD Mechanism Module
CD Mechanism Module
CD Mechanism Module
CD Mechanism Module
- Grease List
Name
Grease
Grease
Grease
Grease
3.4 CLEANING
Cleaning tools
Cleaning liquid : GEM1004
Cleaning paper : GED-008
DEH-15UB/XNUC
5
11
4. BLOCK DIAGRAM
A
JA401
1
ANTENNA
5
16
2,3
18
57
DACOUTL
FMMIXIN1
PINDIN
LNAIN
RF FRONT END IC
IC401
TDA7706
I2CSCL
I2CSDA
RSTN
34
93
33
94
31
88
TUN_SCL
TUN_SDA
39
RES
TUNRES
RESET
IC671
S-80827CNMC-B8M
EVOL_MC
EVOL_LRC
EVOL_BC
SYSTEM MICRO
COMPUTER
IC601
(1/2)
R5S726A0D216FP
EVOL_DAT
ILMPW
EVOL_D
Q873
B.UP
EVOL_C
ILM+B
EVOL_C
JA891
56
2 KEYAD
WIRED
REMOTE
EVOL_RS
Q874
KEYAD
105
3 KEYD
KEYD
1 GND
19
ILMPW
B D E F H
SYSTEM MICRO
COMPUTER
IC601
(2/2)
R5S726A0D216FP
Q875
21
RGBDT/DIMMER
MUT
FLASH ROM
IC681
A :PEB047A8
ANTP
USB5V REGULATOR
IC551
BD9876EFJ
B C D
:PEB046A8
E F
B.UP
IC552
BD2232G-G
A :DEH-15UB/XNUC
B :DEH-1500UB/XNEW5
C :DEH-1500UBA/XNEW5
D :DEH-1500UBB/XNEW5
E :DEH-1500UBG/XNEW5
F :DEH-1550UB/XNES
H :DEH-1590UB/XNID
USB5V
VOUT VIN
SYNC
1
OC
118
SYNC
Q601
1
EN
TEL
VCC
EN
LX
ASEN
98
DDON
FB
BST
119
120
USBCTL
USBFLG
SSEN
PICKUP UNIT
(P10.6)(SERVICE)
CN101
12
VCC
LD
LD-
15
12
15
REGULATOR IC
IC911
BA49183-V12
V+3A
RF AMP, CD DECODER
DIGITAL SERVO/DATA PROCESSOR
CPU
VDD
GND
Q101
SWVDD
VDD3.3V
VDD1.2V
Q102
LD
V+3A
SYS+B
VDD
6
9
7
8
5
SW5V
SWVDD
VDD
VDDCONT
BSENS
SYSPW
SW5VCNT
MD 5
PD
PD
PUEN
113
90
SWVDD
BSENS
ROT
ROT
SYSPW
VDD12
+B
SYS+B
+BUP
MD
11
B.UP
10
54
REFO
VREF
93
REFO
FOM
TRACKING ACT.
FOP
IC201
PE5791A
FOM
TD,FD
14 LD+
SD,MD
8
7
SOP
VDD
DPD
VDD3.3V
5
4
DSEN
VD
VDSENS
VD
Q751
B.UP
Q752
FCO85
23
40
22
41
MUTE 21
39
CNT
SLLDO+
SLLDO-
CLCONT
35
CONT
RESET
29
RESET
33
CDRST
DSCSNS
HOME
CD DATA (CDSRQ,CDSTBY,SKIP,
SCL,SDA,DATA,BCLK,LRCK,WAIT)
S901
HOME
VDCONT
LOEJ
RESET
S903
DSCSNS
VD
FCO+
38
55
TKO-
3
SPO+
2
SPO-
SOM
LCOP
LCOM
MECHA VD
TKO+
LDIN
LOADING/CARRIAGE
MOTOR
VDD
CN701
IC301
BD8223EFV
1 TOP
4 TOM
10
VDD
TOP 1
14
CN701
ACTUATOR/
MOTOR DRIVER
FOP
TOM 4
LD+
SPINDLE
MOTOR
KYD
AC,BD,E,F
HOLOGRAM
UNIT
FOCUS ACT.
REFOUT
CD DATA (CDSRQ,CDSTBY,SKIP,
SCL,SDA,DATA,BCLK,LRCK,WAIT)
D
D
12
DEH-15UB/XNUC
1
JA251
ELECTRONIC VOLUME/
SOURCE SELECTOR
IC201
PM9013A
OUTPL
INAN1L
RCA OUT
1
Q252
P251
40
TUNL
PL
35
A B C D E F
JA251
RCA OUT
PL 3
RCAG 1
FL
EVOL_LRCK
EVOL_BCK
EVOL_DATA
EVOL_DT
EVOL_CK
EVOL_CS
EVOL_RST
81
19
104
20
103
21
106
22
110
23
108
24
111
25
87
26
FL 6
MCLK
RCAG 4
Q251
LRCLK
BCLK
DIN
DATA
CLK
JA901
STB
OUTFL
RESETB
OUTRL
33
11
34
12
FUSE 10A
FLIn
FL+
Q301
(1/2)
AUXL
37
AMP
IC301
PAL011A
INBP4L
FLRL+
RL-
FL+
FL-
RL+
RL-
1
3
117
22
MUTE
B.UP
VDD
OUT
BREM
(10A)
5
7
B.REM&A.ANT
IC961
TPD1052F
Q301
(2/2)
MUTE
18
17
15 B.UP
B.UP
RLIn
MUTE
SYSTEM MICRO
COMPUTER
IC601
(2/2)
R5S726A0D216FP
P251
EVOL_MCK
POWER
CONNECTOR
14
Q302
ANTPW
17
25
B.REM
SYS+B
TELIN
IN
Q951
TELIN
26
TEL
ASENS
Q941
SYNC
ASENS
B D E
89
ACC
13
DDON
USBCTL
KEYBOARD UNIT
USBFLG
CN801
AUXL
JA1921
CN1931
19
19
18
18
AUXL
S1841
SSENS
SOURCE
35
FRONT AUX
AUXR 3
AUXL 2
AUXGND 1
SOURCE
S1842
MULTI-CONTROL
S1830
SWVDD
BSENS
ROT0
ROT1
53
ROT0
54
ROT1
ROT0
ROT1
SYSPW
KDT2
KST1
SWVDD
SWVDD
KDT0
KDT1
KDT2
KDT3
KYDT
22
KYDT
KYDT
IC801
TC7SET08FUS1
DPDT
DSENS
23
34
DPDT
DSENS
10
10
20
20
DPDT
KST0
KYDT
DPDT
KST1
LCD DRIVER/
KEY CONTROLLER
IC1801
PD6583A8
KST2
KST3
21
22
23
24
3
KEY MATRIX
5
7
15
DSENS
REM
REMOTE CONTROL
SENSOR
1
VDCONT
ILM+B
LCD
V1801
VDSENS
IC1941
GP1UXC14RK
ILM+B
D1952,D1953,
D1954,D1955,
D1956,D1957,
D1958,D1959,
D1960,D1961,
D1962,D1963,
D1964,D1965
D1966
D1951
CDRST
D1967,D1968,
D1969,D1970,
D1971,D1972,
D1973,D1974,
D1975,D1976,
D1977,D1978,
D1979,D1980
D1981
B C D E
A F H
A B C D F H
CN1911
11
USB5V
DM
DP
49
DM
50
DP
11
13
13
15
15
USB5V
USB5V
DM
DM
DP
DP
DEH-15UB/XNUC
5
2
3
USB
13
5. DIAGNOSIS
Power ON
Vcc = 1.2 V
PVcc = 3.3 V
BSENS
B
Pin 90
BSENS = L
ASENS
Pin 89
ASENS = L
DSENS
Pin 34
DSENS = L
Starts
communication
with Grille
microcomputer.
D
300 ms
SWVDD <- H
Pin 113
300 ms
Source keys
operative
Source ON
SYSPW <- H
Pin 8
14
DEH-15UB/XNUC
1
If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a
cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from
customers and facilitate failure analysis and repair work in servicing.
6-digit display
ERROR-xx
ERR-xx
4-digit display
E-xx
07
Servo
TOC reading NG
10
Servo
Carriage Home NG
11
Servo
Focus NG
12
Servo
Spindle Lock NG
Subcode NG
RF-amp NG
15
Servo
RF NG
17
Servo
Setup NG
30
Servo
50
Mechanism
Load NG
Eject NG
51
Mechanism
Failure in retried
turning for ejection
Disc could not be ejected even after disc turning had been retried.
--> A foreign object inserted in the mechanism; Disc jammed.
NOTES
Indications of error codes are available only during disc operations, because CD operations are unavailable if a mechanical error is
generated.
If the TOC cannot be read, It stops because of error 07.
If you design a new head unit, be sure to use one of the display formats indicated in Display example of the head unit.
The 2 high-order digits of an error code denote the main classification, shown below.
code
classification
0x
1x
Servo-related errors
3x
5x
Mechanism-related errors
F
DEH-15UB/XNUC
5
15
Message
Cause
Action
Message
Cause
FORMAT
READ
Sometimes
there is a delay
between the
start of playback
and when you
start to hear any
sound.
ERROR-19
NO AUDIO
There are no
songs.
The connected
USB storage device has security enabled.
ERROR-23
The connected
USB storage device contains
files embedded
with Windows
MediaDRM 9/
10.
USB storage de- USB storage device was not for- vice should be formatted with
matted with
FAT12, FAT16 or FAT12, FAT16 or
FAT32.
FAT32.
STOP
There are no
songs in the
current list.
PROTECT
Transfer audio
files not embedded with
Windows Media
DRM 9/10 to the
USB storage device and connect.
N/A USB
Connect a USB
Mass Storage
Class compliant
device.
Disconnect
your device and
replace it with a
compatible USB
storage device.
The connected
USB storage device consumes
more than maximum allowable
current.
Disconnect the
USB storage device and do not
use it. Turn the
ignition switch to
OFF, then to ACC
or ON and then
connect only
compliant USB
storage devices.
SKIPPED
16
Action
DEH-15UB/XNUC
1
DEH-15UB/XNUC, DEH-1500UBA/XNEW5,
DEH-1500UB/XNEW5, DEH-1500UBB/XNEW5, DEH-1500UBG/XNEW5, DEH-1550UB/XNES
REAR OUTPUT
ANTENNA
15 13 11 9 7 5 3 1
16 14 12 10 8 6 4 2
1
2
3
4
5
6
7
8
FL+
FR+
FLFRRL+
RR+
RLRR-
9 NC
(DEH-15UB/XNUC,
DEH-1500UBA/XNEW5,
DEH-1550UB/XNES,
CELLULAR MUTE
(DEH-1500UB/XNEW5,
DEH-1500UBB/XNEW5,
DEH-1500UBG/XNEW5)
10
11
12
13
14
15
16
NC
NC
NC
ACC
B.REM
B.UP
GND
DEH-1590UB/XNID
WIRED
REMOTE
CONTROL
ANTENNA
15 13 11 9 7 5 3 1
FRONT
OUTPUT
16 14 12 10 8 6 4 2
1
2
3
4
5
6
7
8
FL+
FR+
FLFRRL+
RR+
RLRR-
9
10
11
12
13
14
15
16
DEH-15UB/XNUC
5
REAR OUTPUT or
SUBWOOFER OUTPUT
NC
NC
NC
NC
ACC
B.REM
B.UP
GND
17
6. SERVICE MODE
LIST
EQ
BAND
ROTARY
Grille condition
Conf. item
All light up
All light off
Conf. LCD pattern 1
(* And change ILM color)
Conf. LCD pattern 2
Operate
EQ + LIST
SOURCE
Show LCD
Draw 1
No light Draw2
BAND
Draw 3
ROTARY center
Draw 4
ILM
ILM(1)
No light
ILM(2)
(If not have, ILM(1) light on)
ILM(1)
Drawings Style
Draw1 ALL light up
Draw2 ALL light off
Draw3
Draw4
18
DEH-15UB/XNUC
1
[Operation key]
Operation key
Processing
1+3
Remarks
[Test items]
Start display test mode.
Press and hold "1" and "3" buttons together, and turn
BUP and ACC on.
Key Illumination
Icon
Off
All off
All off
* Initial
condition
$ $ $ $
# # #
$ PD number
# System
microcomputer
version
All off
On (lighting condition
of normal times)
E
On (state when
entering test mode)
DEH-15UB/XNUC
5
19
Overview
This mode is used for upgrading the MCU software of system using USB memory.
How to enter in USB rewriting mode
Press and hold "1" and "2" buttons together, and turn BUP and ACC on.
USB rewriting operation flow
Explanatory note
Screen display and ON/OFF of illumination
Characters displayed on the screen
USB
B
START UPDT
Press LIST button
* After connecting USB memory in which upgrading file is stored, press LIST button.
C
Retry rewriting
CHECK FILE
First time
After retry
Rewriting is started
If the power supply is turned OFF
during rewriting, retry the rewriting.
DON'T STOP
D
Switched every
5 seconds
PRG **/100
CAN'T UPDT
COMPLETE
FILE ERROR
ERR->RETRY
In 5 seconds, rewriting
is retried
ERR->RETRY
In 5 seconds, rewriting
is retried
Result of rewriting
20
Displayed when there is no upgrading file in USB memory or the data of upgrading file is different.
In 5 seconds, usual operation (OFF SOURCE) is started.
If the upgrading file error is detected or the upgrading file is not detected after the rewriting is retried, the rewriting is failed.
In 5 seconds, rewriting is retried.
Displayed when the writing of upgrading file in serial Flash is not normally terminated.
Or, displayed if the upgrading file error is detected or the upgrading file is not detected after the rewriting is retried.
In 5 seconds, rewriting is retried.
Displayed when the retry becomes unavailable because the retry count is exceeded.
The display is continued until the power supply is turned OFF. If the power supply is turned ON again, the display is not changed.
The upgrading using USB is disabled, so it is necessary to write programs in serial Flash using E10A.
DEH-15UB/XNUC
1
A
[Key]
[CD] or [SOURCE]
Source ON
TRK
Contents
MIN
Display
[BAND]
[2]
RF AMP *1
Gain switching
TRK MIN SEC
Power On
(T.Offset is adjusted)
TRK MIN SEC
00
[BAND]
MIN
SEC
[BAND]
91
91
SEC
TRK
MIN
*2
TRK
MIN
SEC
0X
0X
0X
TRK
MIN
SEC
[>]
00 00 00
or 99 99 99
[3]
??
??
??
[3]
F,T,RF AGC*5
F.Bias display switching
TRK MIN SEC
??
??
??
[<]
[2]
CRG +
CRG -
*6
00 00 00
or 99 99 99
*6
00 00 00
or 99 99 99
[>]
RF AGC /
RF AGC coefficient display
TRK MIN SEC
SEC
[1]
Power Off
GG
Tracking Servo
Close
[BAND]
GG
[1]
[1]
T.Close & AGC
Applicable servomechanism
Power Off
MIN
GG
[6]
Focus Close
S curve check
TRK MIN SEC
91
TRK
00
[3]
Power Off
TRK
00
Self-adjusting
switching *3
MIN SEC
??
[<]
CRG -
8X 8X 8X
or 9X 9X 9X
8X 8X 8X
or 9X 9X 9X
[>]
[<]
CRG/TR Jump -
*4
*4
MIN
SEC
TRK
??
T.Balance adjustment /
T.BAL coefficient display
TRK MIN SEC
??
??
??
[2]
CRG/TR Jump +
TRK
??
[2]
CRG +
TRK
MIN
Tracking Open
SEC
8X 8X 8X
or 9X 9X 9X
*6
[BAND]
[2]
Power Off
TRK
*1)
MIN
Tracking Open
TYP
TRK
8X 8X 8X
or 9X 9X 9X
SEC
MIN
SEC
+ 6 dB
t
TRK
06MIN06SEC06
S. Curve
t
01MIN01SEC01
TRK
+ 12 dB
TRK
12MIN12SEC12
F EQ measurement setting
TRK
02MIN02SEC02
[Key]
[BAND]
[>]
[<]
[1]
[2]
[3]
[6]
Operation
Test Mode
Power On/Off
CRG + / TR Jump +
(Direction of the external surface)
CRG - / TR Jump (Direction of the internal surface)
T. CLS & AGC & Applicable servomechanism /
AGC,AGC display setting
RF Gain switching / Offset adjustment display /
T.Balance adjustment / T. Open
F. Close,S. Curve / Rough Servo and RF AGC /
F,T,RF AGC
F. Mode switching / Tracking Close
After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete.
When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks
to Wall, causing the actuator to be damaged).
In the case of 100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released.
When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the
default setting.
Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows)
DEH-15UB/XNUC
5
21
7. DISASSEMBLY
While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same.
A
Panel Assy
B
Fig.1
CD Mechanism Module
Lift off the Tuner Amp Assy from the Heat Sink side.
6
5
CD Mechanism Module
F
Fig.2
22
DEH-15UB/XNUC
1
Fig.3
CD Mechanism Module
Fig.4
F
DEH-15UB/XNUC
5
23
Fig.5
B
2. Press the upside hook and the bottom side hook of the
button at the same time, and pull out the button.
Fig.6
Fig.7
24
Fig.8
DEH-15UB/XNUC
1
3. Fit the spring in the groove at the position shown in the figure.
4. Fit the boss on the lower side of the arm in the lower hole of
the panel, and then warp the rib on the panel in the direction
shown in the figure and fit the boss of the arm in the panel.
Fig.9
DEH-15UB/XNUC
5
25
Handling OK
Handling NG
26
DEH-15UB/XNUC
1
Fig 2a
Fig 2b
B
Fig 1
Fully-hooked state
Tentatively-hooked state
C
Fig 3
Fig 4
Outer holder
Rear end of feeding screw
DEH-15UB/XNUC
5
27
1) Cautions on adjustments
In this product the single voltage (3.3 V) is used for the
regulator. The reference voltage is the REFO1 (1.65 V)
instead of the GND.
If you should mistakenly short the REFO1 with the GND
during adjustment, accurate voltage will not be obtained,
and the servos misoperation will apply excessive shock
to the pickup. To avoid such problems:
a. Do not mix up the REFO1 with the GND when
connecting the (-) probe of measuring instruments.
Especially on an oscilloscope, avoid connecting the (-)
probe for CH1 to the GND.
b. In many cases, measuring instruments have the same
potential as that for the (-) probe. Be sure to set the
measuring instruments to the floating state.
c. If you have mistakenly connected the REFO1 to the GND,
turn off the regulator or the power immediately.
2) Test mode
This mode is used to adjust the CD mechanism module.
To enter the test mode.
[4] + [6] -> BUP + ACC ON
To exit from the test mode.
Turn off the ACC and back up.
Notes:
a. During ejection, do not press any other keys than the
EJECT key until the loaded disc is ejected.
b. If you have pressed the () key or () key during focus
search, turn off the power immediately to protect the
actuator from damage caused by the lens stuck.
c. For the TR jump modes except 100TR, the track jump
operation will continue even if the key is released.
d. For the CRG move and 100TR jump modes, the tracking
loop will be closed at the same time when the key is
released.
e. When the power is turned off and on, the jump mode
is reset to the single TR (91), the RF amp gain is set to 0 dB,
and the auto-adjustment values are reset to the default
settings.
28
DEH-15UB/XNUC
1
Note :
The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism
module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU
unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the
PU unit must be changed, the grating should be checked using the procedure below.
Purpose :
To check that the grating is within an acceptable range when the PU unit is changed.
Symptoms of Mal-adjustment :
If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform
track search operations, or taking a long time for track searching.
Method :
Measuring Equipment
Measuring Points
Disc
Mode
L.P.F.
F
E
E
VREF
REFO1
Xch
100 kohm
Ych
Oscilloscope
390 pF
100 kohm
VREF
390 pF
D
L.P.F.
Checking Procedure
1. In test mode, load the disc and switch the 3 V regulator on.
2. Using the right and left buttons, move the PU unit to the innermost track.
3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking
balance adjustment the display should now read "81". Press key 3. The display will change,
returning to "81" on the fourth press.
4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase
difference is within 75 . Refer to the photographs supplied to determine the phase angle.
5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any
improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the
mechanism should be judged to be at fault.
Note
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be
seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the
average angle.
Hint
Reloading the disc changes the clamp position and may decrease the "wobble".
DEH-15UB/XNUC
5
29
Grating waveform
0 degrees
30 degrees
45 degrees
60 degrees
75 degrees
90 degrees
30
DEH-15UB/XNUC
1
- PCL Output
In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode
cancelled), shift the TESTIN IC601(Pin 99) terminal to H.
The clock signal is output from the PCL terminal IC601(Pin115).
The frequency of the clock signal is 600 kHz that is divided by 20th of the oscillation frequency of X601 (12MHz).
The clock signal should be 600 kHz(- 25 Hz, + 25 Hz).
If the clock signal is out of the range, the X'tal (X601) should be replaced with new one.
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screw adjacent to mark on the product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions,apply as you think it appropriate.)
"
DEH-15UB/XNUC
5
31
9.1 PACKING
A
1500UB/XNEW5
1500UBA/XNEW5
1500UBB/XNEW5
1500UBG/XNEW5
1550UB/XNES
1590UB/XNID
15UB/XNUC
1500UB/XNEW5
1500UBA/XNEW5
1500UBB/XNEW5
1500UBG/XNEW5
1550UB/XNES
1590UB/XNID
1500UB/XNEW5
1500UBA/XNEW5
1500UBB/XNEW5
1500UBG/XNEW5
1500UB/XNEW5
1500UBA/XNEW5
1500UBB/XNEW5
1500UBG/XNEW5
1550UB/XNES
1590UB/XNID
15UB/XNUC
1550UB/XNES
1590UB/XNID
1500UB/XNEW5
1500UBA/XNEW5
1500UBB/XNEW5
1500UBG/XNEW5
A
15UB/XNUC
1550UB/XNES
1590UB/XNID
15UB/XNUC
1500UB/XNEW5
1500UBA/XNEW5
1500UBB/XNEW5
1500UBG/XNEW5
1550UB/XNES
1590UB/XNID
15UB/XNUC
15UB/XNUC
1550UB/XNES
1590UB/XNID
32
DEH-15UB/XNUC
1
Description
Mark No.
Part No.
Description
Part No.
10
Screw
11
Unit Box
Protector
12
Contain Box
Protector
13
14
6
Screw
Polyethylene Bag
Screw
Handle
QNC3021
Cord Assy
Polyethylene Bag
Protector
4
5
Case Assy
No.
Description
DEH-15UB/
XNUC
DEH-1500UB/
XNEW5
1
2
3
4
5
Cord Assy
Polyethylene Bag
Protector
Protector
Protector
CDP1480
CEG1173
CHP4103
CHP4104
Not used
QDP3012
QEG3001
Not used
Not used
CHP4594
QDP3014
QEG3001
Not used
Not used
CHP4594
QDP3012
QEG3001
Not used
Not used
CHP4594
QDP3012
QEG3001
Not used
Not used
CHP4594
6
7
8
10
11
Screw
Polyethylene Bag
Screw
Screw
Unit Box
BPZ20P060FTC
CEG1160
CRZ50P090FTC
TRZ50P080FTC
QHG3320
Not used
Not used
Not used
Not used
QHG3316
Not used
Not used
Not used
Not used
QHG3318
Not used
Not used
Not used
Not used
QHG3319
Not used
Not used
Not used
Not used
QHG3317
12
13
QHL3320
QXE1047
QHL3316
Not used
QHL3318
Not used
QHL3319
Not used
QHL3317
Not used
14
15-1
15-2
Contain Box
Card Remote
Control Unit
Case Assy
Owner's Manual
Warranty Card
Not used
QRD3131
QRY3001
QXA3129
QRD3130
CRY1376
QXA3129
QRD3130
CRY1376
QXA3129
QRD3130
CRY1376
QXA3129
QRD3130
CRY1376
15-3
Service Network
Not used
Not used
Not used
Not used
Not used
Mark
No.
Description
DEH-1550UB/
XNES
DEH-1590UB/
XNID
1
2
3
4
5
Cord Assy
Polyethylene Bag
Protector
Protector
Protector
CDP1480
QEG3001
Not used
Not used
CHP4594
CDP1480
QEG3001
Not used
Not used
CHP4594
6
7
8
10
11
Screw
Polyethylene Bag
Screw
Screw
Unit Box
Not used
CEG1160
Not used
TRZ50P080FTC
QHG3322
Not used
CEG1160
Not used
TRZ50P080FTC
QHG3328
12
13
QHL3322
QXE1047
QHL3328
QXE1047
14
15-1
15-2
Contain Box
Card Remote
Control Unit
Case Assy
Owner's Manual
Warranty Card
QXA3129
QRD3132
Not used
QXA3129
QRB3250
CRY1304
15-3
Service Network
Not used
CRY1305
DEH-15UB/XNUC
5
33
Language
QRD3130
QRD3131
QRD3132
QRB3250
English
34
DEH-15UB/XNUC
1
DEH-15UB/XNUC
5
35
9.2 EXTERIOR
A
B
15UB/XNUC
1550UB/XNES
1590UB/XNID
1500UBB/XNEW5
1590UB/XNID
15UB/XNUC
15UB/XNUC
1550UB/XNES
1590UB/XNID
1500UB/XNEW5
1500UBA/XNEW5
1500UBB/XNEW5
1500UBG/XNEW5
36
DEH-15UB/XNUC
1
Description
Part No.
Screw
ASZ26P050FTC
Screw
BSZ26P060FTC
Screw
BSZ26P080FTC
Screw
BSZ26P120FTC
Cord Assy
Spring
QBH3001
Cover
QNM3029
Panel
QNS3126
Arm
QNV3025
10
Button
QNV3026
11
12
FFC
QDE3029
13
Case
QNB3005
14
Holder
QNC3020
15
Panel
QNS3387
16
17
Screw
BPZ26P080FTC
18
Screw
BSZ26P060FTC
19
Screw
BSZ26P120FTC
20
Holder
>
21
Heat Sink
22
Fuse (10 A)
23
24
Screw
BPZ20P100FTC
25
Spring
CBH2210
26
Button (EJECT)
QAC3075
27
QAC3078
28
Button (DISP)
QAC3080
29
QAC3081
30
Button (DETACH)
QAC3082
31
Cover
QNS3326
32
33
Holder
QNC3045
34
Lighting Conductor
QNV3051
35
Contact Rubber
QNV3052
36
Rubber Connector
QNV3056
37
Grille Unit
38
Door
QAT3006
39
Knob Unit
QXA3670
40
Spring
YBL5010
41
42
Cover
43
Sheet
44
Seal
45
Label
DEH-15UB/XNUC
5
37
Mark
No.
CDP1480
QWM3468
QNC3051
QNR3010
QXA3570
QDP3012
QWM3465
QNC3050
QNR3010
QXA3566
QDP3014
QWM3467
QNC3051
QNR3010
QXA3568
QDP3012
QWM3465
QNC3050
QNR3010
QXA3569
QDP3012
QWM3466
QNC3050
QNR3010
QXA3567
32
CAW2024
CAW2024
CAW2024
CAW2027
CAW2024
QXA3626
QXE1047
QXA3622
Not used
QXA3624
Not used
QXA3625
Not used
QXA3623
Not used
42
43
Segment LCD
(V1801)
Grille Unit
Card Remote
Control Unit
Cover
Sheet
CNS7068
Not used
Not used
Not used
Not used
Not used
Not used
QNM3074
Not used
Not used
44
45
Seal
Label
CAN3984
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
No.
Description
DEH-1550UB/
XNES
DEH-1590UB/
XNID
5
16
20
21
23
Cord Assy
Tuner Amp Unit
Holder
Heat Sink
Detachable Grille
Assy
CDP1480
QWM3469
QNC3050
QNR3002
QXA3571
CDP1480
QWM3471
QNC3049
QNR3002
QXA3575
32
CAW2024
CAW2024
QXA3628
QXE1047
QXA3631
QXE1047
42
43
Segment LCD
(V1801)
Grille Unit
Card Remote
Control Unit
Cover
Sheet
CNS7068
Not used
CNS7068
Not used
44
45
Seal
Label
Not used
Not used
Not used
CNN3533
37
41
DEH-1500UB/
XNEW5
Cord Assy
Tuner Amp Unit
Holder
Heat Sink
Detachable Grille
Assy
Mark
DEH-15UB/
XNUC
5
16
20
21
23
37
41
Description
38
DEH-15UB/XNUC
1
DEH-15UB/XNUC
5
39
(A)
(B)
(A)
(B)
(A)
(A)
(A)
D
(A)
(A)
(A)
(B)
(A)
(B)
(A)
(A) : GEM1024
(A)
40
(B) : GEM1043
DEH-15UB/XNUC
1
Description
Mark No.
Part No.
Description
Part No.
50
Damper
CNW1198
CBA1835
51
Arm
CNW1726
Washer
CBF1038
52
Motor Unit(M2)(LOAD/CRG)
CXC4026
Spring
CBH3010
53
Screw Unit
CXC8894
54
Arm Assy
CXE5027
55
Washer
CBF1037
CBF1038
.....
Screw
BSZ20P040FTC
Screw(M2 x 4)
4
5
6
Spring
CBH2855
Spring
CBH2856
Spring
CBH2860
56
Washer
Screw
BSZ26P060FTC
57
Arm
CND6242
10
Spring
CBH3011
58
Collar
CNW2444
59
Roller
CNW1196
11
Coil Spring
CBH3095
60
Gear Unit
CXC8893
12
Spring
CBH3014
13
Spring
CBH3015
61
Washer
YE15FTC
14
Spring
CBH3016
62
Chassis Unit
CXE4528
15
Spring
CBH3017
63
Motor Unit(M1)(SPDL)
CXE2273
64
Screw
JFZ20P025FTC
65
Screw
JGZ17P022FTC
16
Spring
CBH3086
CBH3019
17
Spring
18
.....
66
Screw
EBA1028
19
Leaf Spring
CBL1824
67
CWX4023
20
Pickup Unit(P10.6)(Service)
CXX3556
68
Chassis
CNA3181
21
Bracket
CND4553
22
Arm
CND4555
23
Bracket
CND6127
24
Bracket
CND5710
25
Lever
CND5398
26
Sheet
CNN3678
27
Rack
CNV8342
28
Guide
CNW2240
29
Roller
CNW1172
30
Holder
CNW1195
31
Arm
CNW2241
32
Roller
CNW1175
33
.....
34
Arm
CNW1177
35
Arm
CNW1178
36
Gear
CNW1180
37
Gear
CNW1181
38
.....
39
Gear
CNW1183
40
Rack
CNW1184
41
Gear
CNW1185
42
Gear
CNW1186
43
Gear
CNW1187
44
Gear
CNW2287
45
Clamper
CNW1190
46
Arm
CNW1192
47
Holder
CNW1193
48
Holder
CNW1194
49
Damper
CNW1197
DEH-15UB/XNUC
5
41
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST".
A-a
7 SDA
6 SKIP
5 SCL
VD
VD
/CDSRQ
3
SDA
SCL
SKIP
100
R708
CDSRQ
CDSTBY
220
820
MCLK
220
100
R709
R710
CDSKIP
220
R706
CDSTBY
CDSRQ
47k
R684
47k
R681
CDWAIT
VDCONT
ASENS
RESETB
TUN_RST
NM
47k
100
100
100
R628
R627
R626
100
100
R629
R633
R630
100
R632
47k
47k
81
R631
C623 0.1u/10
82
C621 0.1u/10
85
R682
C682
22p/50
0.1u/10
0.1u/10
86
C622
C625
C624
87
47k
R634 1k
GND
108
C629
109
Vcc
1k
0.1u/10
110
EVOL_DT
1k
111
112
PVcc
0.1u/10
113
SWVDD
VC
BST
VC
EN
FIN
FB
SYNC
6
5
1u/16
C551
220u/16
119
120
3.3V
B.UP
FLG
R653
GND
VCC
only H
10k
BST
DDON
EN
only B - F
GND
IC552
only B - F
17
AUXGND
16
DP
RGBST/ILMCLR2
15
11
DPDT
10
USBGND
MD_CLK 79
78
Vcc
77
QIO3
76
Vss
75
QIO2
74
QIO1
73
QIO0
72
QSSL
83
80
MD_BOOT
EVOL_MCK
RGBST/ILMCLR2
RGBCK/ILMCLR1
SYSPW
BTDATA
R805
10
R806
R807
10
1
DSENS
22k
DEH-15UB/XNUC
4
D809 NM
0.1u/16
D807 DZ2S068C
D808 NM
C808
1u/10
C807
D805 DZ2S068C
ILMG
D804 DZ2S068C
C803
NM
USGND C804
NM
NM
DGND
C805
C806 0.1u/16
DGND
D802 DZ2S068C
SWVDD 3
2
ILMGND
22k
R804
US5V
C802 NM
ROT1
GRILLE
R803
14
USB5V
8
KYDT
RGBDT 7
6
ROT0
GND
DM 13
RGBCK/ILMCLR1
12
ILM+B
NM : No Mount
2.2k
CN1931
18
NM
19
AUXR
D801
DEH-15UB/XNUC
DEH-1500UB/XNEW5
DEH-1500UBA/XNEW5
DEH-1500UBB/XNEW5
DEH-1500UBG/XNEW5
DEH-1550UB/XNES
DEH-1590UB/XNID
AUXL
SOURCE
R801
R818
A
B
C
D
E
F
H
20
ILMPW
220p/50
DSENS
OFFSET
C801
CKS6452-A
NM
VBUS
CN801
RGBDT/DIMMER
R802
BT_RST
BT_BCK
GND
BT_LRCK
USBCTL
BTTX
only H
USBCLT
BTRX
FLG
D806 DZ2S068C
4
NM
BD2232G-G
5
FLG
OC
C559
EN
R662
47k
DGND
VOUT
GND
R663
47k
VIN
C560
NM
C561
1u/10
C562
1u/10
1
2
84
GND
GND
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
/BSENS
/ASENS
TUNRES
EVOL_RST
Vcc
VDCONT
Vss
/CDWAIT
PVcc
BTTESTIN
SYNC
SYNC
C563
FB
118
SYNC
2.2k
USBCTL
PCL
RAM_MON
MUTE
SYNC
USBCTL
/USBFLG
117
R661
47k
GND 9
R652
SYNC
Vss
PCL 115
RAM_MON 116
R601
47k
GND
VCC
MUTE
C633
NM
Lx
EVOL_CS
C630
114
CMS03
89
1k
R650
NM
NM
C555
6800p/25
LX
C554
R551
GND
C552
C565
CCG1222-A
4.7u
D551
IC551
BD9876EFJ
6.8k
C564 CCG1201-A
4.7u D552
RB056L-40
220u/6.3
1u/10
C557
C556
180k D
C553
0.01u/16
EVOL_CK
R648
SWVDD5
IC601
R5S726A0D216FP
D803 DZ2S068C
GND
USB&USB5V
43k D
NM
470
R554
iPod CP@(2.0C)
C558
NC3
Vss
CP_SDA
L551
CTH1524-A
TP1
R552 0
SCL
R555
RST
R553
VCC
R535 4.7k
C532
0.1u/10
NC2
R534 2.7k
8
PAD
9
EVOL_DATA
107
R649
47k
USB5V
106
100
R664 10k
CP_SCL
R539
KEYD
R651 47k
100
100
EVOL_LRCK
105
R603 NM
47k
R537
R538
104
C603 0.1u/10
STB
EVOL_BCK
R645 100
0.1u/10
CPPWR
103
ROM
4.7k
BT_TESTMD
R644 100
C602
DATA
R707
0.1u/10
90
R647
102
R602
KEYD
DIN
CLK
PVcc
0.1u/10
47k
C628 22p/50
Q531
LSAR523UB
IC531
NM
42
WP/S
4
BTRST
5 PVcc
6 BT_BCK
Vss
7 BT_LRCK
BTDATA
8
SYSPW
9
ROM
10
Vss
11
RGBCK/ILMCLR1
12
Vcc
13
BTRX
14
BTTX
15
RGBCS/ILMCLR2
16
PVcc
17
ANTPW
18
Vss
19
ILMPW
1k
Vss
101
0.1u/10
R892
CPRST
CS
SO/SI
BT_TESTIN
W.REM
KEYAD2
BCLK
LRCLK
TESTIN
100
KEYAD
KEYD
KEYAD
DDON
99
KEYD2
1k
/CDSRQ
98
R891
CD_SDA
97
C601
1
3
2
BT_TESTMD
96
100k
C626
10k
JA891
CKS6437-A
R540
D751
VDCONT
BSENS
KEYD
GND
GND
RKZ8.2KG(B2)
C752
LTC014YEB
Q601
C627 22p/50
R646
except A, C
TESTIN
R643
R668 47k
DDON
47k
R669
CDSRQ
R536
NC1
R752
R753
47k
4.7k
CD_SDA
NM
C893
VA891
NM
NM
NM
CD_SCL
GND
GND
R532
2.2k
92 CP_SCL
CP_SDA
93 TUN_SCL
94
TUN_SDA
95 CD_SCL
R641
R642
TUN_SDA
MIC1P
MIC1N
R893
NM
91
CP_SDA
TUN_SCL
GND
R533
2.2k
R639
CP_SCL
4.7k
R972 NM
R640
BTRX
R973
6
5
4
3
2
1
47k
CCG1192-A
C751 NM
VDSENS
47k
NM
NM
SDA
CD_SDA
L413
CTF1786-A
C440
C439
0.1u
C438
NM
1000p/50
47k
R637
BT_RST
D602
R636
BT_BCK
C631
22p/50
GND
IC
1
2
KN1
0.1u/16
FLAS
C459
M2R6TP_GND
C891
MIC1N
PEB047A8
PEB046A8
A
except A
NM
NM
DGND AGND RF GND DGND AGND
0.1u/16
C892
L531
R531
C753
49
32
31
0.1u
C436
NM
C435
0.47u/10
82p
C434
RF GND
C458
1u
*4
R414
NM
NM
GND
BTTX
W.REM&MIC
C531
R705
0.01u/16
BTDATA
R971
(W/R)
0.1u/10
10u/10
NM
C445
0.1u/10
C446
C449
9p/50
C448 0.1u
NM
R417
29
VDIG
28
27
30
GNDSLINK
AMMIXIN2
AMMIXIN1
LNADEC2
VCCREG1V2
REG1V2
VREG3V3
RSTN
RDSINT
8.2
L411 NM
NM
GND
R704 100k
BT_LRCK
C972
GND
3.3V
100
C894
1000p/50
GND
MIC1P
R703
4.7k
C701
*1
100
1000p/50
VA892 NM
L971
MIC1P
MIC1N
BTTOSYS
SW5V
R976 100
SYSTOBT
6
6
R638
R974
R975
BTBCK 11
BTLRCK 10
5
RN4983
C973
47p/50
GND 13
BTDATA 12
NRST_CPU
2
1
100k
R635 1k
GND 14
CD:0.0 dBs
88
VCC 15
47k
R702
VDCONT Q752
NM
C971
VCC 16
R701
GND
BT Connector
NM
NM
C433
RFGND
VD1
NM
CN971
JA892(RMIC)
C432
R411 680
*1
GND
26
25
NM 24
R409
0
R410 0
C426
C460
33
47uH
*1
C429 L410
Q751
2SD2396(K)
B.UP
DGND
0.01u/16
TUN_SDA
VD2
TUN_RST
1u
RFGND
C431 NM
RF GND
*1
TUN_SCL
F, H
10p
*1
GND
C441
*1
NM
B-E
7.4V
NM
15p/50
NM
NM
0.01u/16
0.01u/16
NM
NM
3p/50
8p/50
NM
NM
100p/50
22p/50
100p/50
DCH1246-A
NM
NM
2p/50
82p/50
82p/50
NM
DCH1246-A
NM
0.1u/10
NM
NM
NM
NM
0.1u/16
10p/50
NM
NM
NM
CCG1218-A
NM
0.1u/10
0.1u/10
NM
NM
68n
NM
CTF1389-A CTF1389-A
NM
NM
0.27uH
NM
1.5uH
4.7uH
4.7uH
NM
NM
0.39uH
47uH
47uH
2.2uH
CTF1786-A
NM
NM
330
390
390
470
470
360
0
NM
NM
680
390
680
0
NM
0
C419
C420
C421
C423
C428
C430
C432
C433
C436
C439
C441
C447
C448
L405
L406
L407
L408
L409
L410
L414
R403
R408
R409
R411
R415
L415
48
*1
C430
100p
NM
L409 C423
0.39uH 8pF
C425
CCG1192-A
10u
NM
R405
C421
3p
R406
C422
1M
L407
0.27uH
0.01u/16
4.7uH
R407
CTF1389
L405
68n
C424
R404
1M
L406
LNAOUT2
C418
0.022u/16
C419
C420
0.01u
C428
RFGND
GND
RFGND
23
16
22
CCG1192-A
10u
C427
0.1u/10
15
LNAIN2
14
C415
PINDDEC
PINDIN
LNAOUT
C414 0.01u/16
LFREF
LF1
VCCVCO
TCAM2
21
13
GNDLNA
C416
0.1u/10
NM
12
TDA7706
17
C413
0.1u/10
A GND
L404
CTF1786-A RFGND
C411
0.01u/16
CK_SEL
GNDVCO
11
C412
0.1u/10
IC401
L416 NM
R415 0
L414
*1
NM
VCCRF
20
AGND
orRFGND C404 NM
TCAM
0.1u/10
LNADEC
1u/10
GNDRF
LNAIN
19
C403
FMPINDRV
FMPINDDEC
R408
470
C406
0.01u/16
C405
C408
0.01u/16
C407
NM
6p/50
C409
L402
0.15u
CTF1786-A
C461
C417
FMMIXIN1
10
RF GND
L403
0.1u/10
FMMIXIN2
R416 NM
CTF1786
47 2.2u C444
CCG1205-A
46
C443
TEST
VDD_CORE 45
NM
GND1V2 44
GPIO0
GPIO1 43
GPIO2 42
GPIO3
41
GPIO4
40
GPIO5
39
GPIO6
38
GPIO7
37
GPIO8
36
GND3V3
C442
35
VDD3V3
0.1u/10
34
I2CSCL
DGND
I2CSDA 33
FMMIXDEC
0.01u/16
0.01u/16
0.27uH
33p/50
C401 NM
C402
VKN1192-A
MECHA VD
*1
DGND
L418 NM
L417 NM
C437
3
RFGND
CN701
AGND
*1
64
TVDAC
63
TCFM
62
PLLTEST
61
GND-PLL
60
VCC-PLL
59
VCC-ADC_DAC
58
DACOUTR
57
DACOUTL
56
GND-ADC_DAC
55
VREFDEC
54
GND-REF
53
OSCOUT
52
OSCIN
VCC-REF 51
VDDIO1V2
VDDPLL1V2 50
L401
18
750
R402
220
C410
D402
RN731VN
R401
D401
Detailed page
A-b
RN731VN
NM
A-a
GND1
X1
CSS1848-A
C451
C454
RFGND
X2
C450
9p/50
1
0.1u/10
L420
C453
0.1u/10
C452
C455
0.22u/16
X401
36.48MHz
4 GND2
1u/10
M2R6TP_GND
NM
KN2
Guide page
P402
A-b
HSPC16701B02
P401
A-a
CTF1756-A
L419
JA401
TUNGND YKS5041-A
1
2
CD
TUNL
4700p/25
4 /CDSTBY
TUNR
C456
C457 4700p/25
AGND
10k
TUNER
R754
Large size
SCH diagram
A-b
CTF1786-A
A-a
A-b
C708
CCG1201-A
4.7u
820
100p/50
22k
R258
C258
100p/50
22k
1000p/50
1000p/50
C912
1000u/16
C913
0.1u/16
C914
CCG1201-A 1
C915
NM
C917
1000p/50
C916 R911
C328
100p/50
NM
NM
C261
C326
NM
FL1
RLRR+
RL+
FR-
FL-
FR+
FL+
C930
NM
RFGND
GND
TELIN
D951
L951
15k BTH1101-A
1SS301
only B, D, E
C941
4.7k
R943
A GND
C962
C963 NM
ROT0
GND
NC2
D302
CRG03
6
MASK
TPD1052F
C322
0.1u/16
4 GND
10k
Dim off 12.13 V
Dim on 8.03 V
ILM GND
OUT
DIAG
CRG03
3 IN
RGBDT/DIMMER
C330
0.1u/16
1 VDD
D301
IC961
GND
ILMPW
1M
GND
2 NC1
Q875
LTC043EEB
DPDT
RR-
GND
C966
RN4983
ROT1
NM
AGND
GND
B.REM&A.ANT
SWVDD
L851
2
3
INB
Vcc
INA
GND
OUTY
TC7SET08FUS1
4
C811
NM
IC801
1
DPDT
0.1u/10
NM
C851
4.7k
R851
NM
C852
C810 220p/50
VA802 EZJP0V270RM
C809 220p/50
VA801 EZJP0V270RM
D811
NM
NM
D810
D809 NM
0.1u/16
D808 NM
C808
D807 DZ2S068C
C325
FR1
TEL
22u
DCH1256-A
C969
ILMPW
D806 DZ2S068C
C323
FL2
R952
0.033u/16
C961
R879
1.2k
R873
NM
5
R961
KYDT
R817 2.2k
NM
FR2
GND
R963
RKZ7.5KG(B2)
D871
R874
390
NM
NM
0.1u/16
2.2k
3
2
R962 10k
2.2k
R816
C319
RL1
RR1
R951
C965
R814
NM
12 GND
4.7u
47k
R943
D941
NM
2.2k
D872
RGBCK/ILMCLR1
C320
NM
NM
C327
1u/16
C335 NM
RL2
1k
TELIN
47k
RGBST/ILMCLR2
R875
NM
NM
R876
R813
R811
R812
C873
DM
22
0.1u/16
R810
8.2k
3 3
CTF1713-A
R815
44
NM
C321
C332 NM
C334 NM
C331 NM
C333 NM
C311 NM
C310 NM
C312 NM
CCG1201-A
C918
4.7u
NM
C919
4.7u
NM
C921
CCG1201-A
C920
SYS+B
SWVDD
NM
10 +BUP
11 VDDCONT
1k
Q874
DP
22
C871
R809
NM
2 2
C872
L801
47k
11
R878
22k
10
RR2
R953
LED Supply
13 ACC
11
8 VDD12
9 SWVDD
22k
Q951
LSAR523UB
14 BREM
12 A.ANT
TELIN
YEK5001
15 B.UP
R944
A, F, H HZU7L(A1) 4.7k
B, C, D, E HZU7L(C3) 47k
Q873
2SD1767(QR)
R877
0.1u/16
R804
AUXR
AUXG
>
FUSE
ASENS
D941
Q872
LTC143EUB
22k
ACC
CRG03
*3
HZU7L(A1)
R942
Q941
LSCR523UB
ASENS1
22k
17
(10A)
16 GND
AANT
RFGND
10k
R872
R941
B.UP1
BREM
D912
SSENS
100
100
NM
1608
47k
R311
NM
C329
470
R304
470
GND
*3
3.3k
(1/10W)
R871
ASENS2
B.UP3
D911
CRG03
ASENS
CDSCKIN
CDSTBY
TELIN
CPPWR
CPRST
CCG1201-A
C922
NM
4.7u
1u/10
RESET
DGND
NM
C925
4.7u
NC1
R912
VSS
NM
C923
VDD
NM
S-80827CNMC-B8M
C672
NM
NC2
1000p/50
C926
OUT
VDDCNT
SWVDD5
CCG1201-A 1
C924
D671
C671
B.UP2
CDLRCKIN
1SR154-400 GND
NM
NM
C929
NM
R671
SWVDD
CDDATAIN
2SA1577(QR)
DPDT
470
C309 NM
NM
D901
L901
6 SW5V
7 VDD
1.2V
470
SYS+B
SW5V
B.UP
3.3V
15k
VDD
GND2
0.1u/16
47k
R610
47k
R609
SW5V
IC671
RST
0.1u/10
C605
SSENS
DSENS
GND1
2
1
1SR154-400
CTH1432-A
D902
4 +B
5 SYS+B
SYSB
R606
R806
R807
IC301
PAL011A
18
600uH
2 SYSPW
3 SW5VCNT
+B
USB GND
100k
only B, D, E
SYSPW
SYSPW
R605
RGBDT
RGBDT/DIMMER
ILMPW
OFFSET
RGBST/ILMCLR2
BTTX
BTRX
R604 47k
TELIN1
0.1u/10
C604
R664 10k
C603 0.1u/10
0.1u/10
R603 NM
C602
47k
RGBCK/ILMCLR1
BSENS
BSENS
C607
C928
7 BT_LRCK
BTDATA
8
SYSPW
9
ROM
10
Vss
11
RGBCK/ILMCLR1
12
Vcc
13
BTRX
14
BTTX
15
RGBCS/ILMCLR2
16
PVcc
17
ANTPW
18
Vss
19
ILMPW
20
Vcc
21
RGBDT/DIMMER
22
KYDT
23
DPDT
24
CPRST
25
CPPWR
26
TELIN
27
CDSTBY
28
PVcc
29
CDSCKIN
30
Vss
IC911
BA49183-V12
1 BSENS
GND
R803
10k
CKM1613-A
31
AUXL
GND
JA901
R607
100
FLP-GND1
GND
CDRST
R805
VCC
GND
IC REGULATOR
NM
2.2k
RL+
POWER SUPPLY
ROM
MUTE
GND
STBY
24 P-GND4
R312 25
B.REM
Q302
LTC014YEB
12p/50
C606
0.1u/10
DSENS1 R608
R808
C911
38
CKIO 37
PVcc
36
SSENS
/DSENS 35
/CDRST 34
CDDADATIN
33
CDLRCKIN
32
15k
R660
R659
4
RES 39
Vss
GNDTP2
1k
B.UP
CCH2040-A
GND 2200u/16
RN4983
C927
Vss 40
X601
R611
C609 0.1u/10
AC_GND
OFFSET
GND
12MHz
0.1u/10
NC1 2
47k
1 X1
NMI 42
AGND
C901
RL-
FL+
10 SVR
11
FLIn
12
RLIn
13
AGND
14
RRIn
15
FRIn
16
AC-GND
17
FR+
18
P-GND3
19
FR20
VCC
21
RR+
22
MUTE
23 RR-
GND
1u/16
GND
C314 0.1u/16
P-GND2
12p/50
X2 3
C610
41
C608
1.5k
NM
CSS1847-A
C611
R613
R612
GND
TAB
C313
R306
R307
NM
NM
C615
C614
10k
DM
Vcc 43
PLLVcc
MUTE
DP
NC2
XTAL 45
Q301
47k
EXTAL 44
0.22u/16
10k
CDSKIP
47k
ASEMDR614
0.1u/10
Vss 46
R5S726A0D216FP
0.22u/16
C303
R305
ROT1
ROT0
R615
47
NM
MU1
VDSENS
PVcc
Vss
0.22u/16
GND
KEYAD
AGND
ASEMD 51
10u/16
C318
0.22u/16
C307
NM
R616 47k
CDSKIP 52
GND
AGND
R620
GND
D601
R617
47k
VDD1.2V
NM
47k
R619
NM
MODEL
ROT0 53
IC601
R303
R301
R302
NM
NM
C617
C616
47k
R622
R618
0.1u/10
ROT1 54
C260
C259
100p/50
100p/50
22k
R254
C254
22k
R253
3
STBY
C317
C301
TRST
*2
C612
PVcc 48
1u/10
R309
C305
L602
61
5
R623
ASEBRK 47k
TDI 3
65
TMS
TDI 64
TDO
63
ASEBRK
TRST 62
66
TDO 4
TMS 2
8
AUDIO_X2
TCK
67
TCK 1
0.1u/10
AUDIO_X1
PVcc
68
C620
69
100
R625
QSPCLK
70
R626
100
R627
72
100
100
R628
73
71
74
Vss
QIO1
QSSL
QIO0
100
R629
75
100
R630
77
76
Vss
Vcc
QIO2
QIO3
R631
C621 0.1u/10
78
100
R632
47k
47k
R633
NM
1.2V
C622
VDD3.3V
DM 49
C807
C253
RN1910
Q251
6
SYS+B 5.78 V
10k
C613 0.1u/10
AMP
12p/50
NM
R621
100p/50
A, F
B - E, G, H 1000p/50
NM
4
CSS1794-A
GND
KEYAD 56
VDSENS 55
R618 R619
47k
10k
NM
47k
47k
22k
NM
47k
*5
GND
GNDTP1
L601
60
*5
C324
X2
5
4
FR
GND
2.2k
AVref 59
AVcc
AVss 58
MODELAD 57
2
1
6
FL
GND2 C618
C619
DP 50
D805 DZ2S068C
C257
R257
R251
JA251
3
MCLK
LRCLK
BCLK
DIN
DATA
CLK
STB
RESETB
AUXR
TUNL
TUNR
AUXL
AUXG
C681
47k
X1
1
DGND
A, E
B, D, H
C
F
R602
C251
CKB1056 (A,B,C,D,E,F
CKB1099 (H)
PR
R624 16.9344MHz
Vcc 84
VDCONT
Vss 83
/CDWAIT
82
PVcc
81
EVOL_MCK
80
MD_BOOT
MD_CLK 79
C623 0.1u/10
PL
NM
NM
X603
GND1
12p/50 3
*2
SYSPW
820
RCAG
only H
X602
CSS1603-A
16.9344MHz
1
R683 47k
C683 3p/50
22p/50
C682
R682
P251
R259
NM
NM
*4
CCG1201-A
4.7u
FRch
0.1u/10
47k
8
CS
VCC
NC/SIO3 7
SO/SIO1
SCLK 6
WP/SIO2
4
5
GND SI/SIO0
1
1
C252
FR
820
R252
CDLRCKIN
CDWAIT
CDSCKIN
CDDATAIN
CDSKIP
CDRST
CD_SDA
IC681
NM
R685
MCLK
CDSTBY
CDSRQ
47k
R684
47k
R681
CDWAIT
L681
Q252
4.7u
FLch
FLASH ROM
6
RR
PR
GND
R255
FL
RR
>
3A
CEK1386-A
2
1
PRch
RL
PREOUT
C255
CCG1201-A
FR
ROR
BTDATA
820
MUTE
AGND
NM
USB GND
AGND
USBGND
PEB047A8
PEB046A8
R256
CCG1201-A
4.7u
GND
A
except A
971 - 990
NM
C225
C256
PLch
RFGND
RCA
FM/AM(A, F, H): -6.0 dBs
FM/AM(B, C, D, E): -2.0 dBs
AUX:+10.2 dBs
CD/USB:+10.2 dBs
RN1910
10u
0.1u/10
CCG1192-A
C224
22
23
0.1u/10
24
0.1u/10
C215
25
0.1u/10
C214
27
26
28
NM
C213
29 C211
32
33
34
35
36
21
ucomD
GND
BT MOD
C227
NM
GND
NM
NM
C201
C234
10p/50
DGND
1u/10
C703
NM
L701
NM
0.01u/16
DGND
NM
C702
RCA
251 - 300
AMP
301 - 400
TUNER
401 - 460
iPod CP 531 - 550
USB&USB5V 551 - 600
UCOM
601 - 670
RESET
671 - 680
FLASH ROM 681 - 690
DSENS
691 - 700
CD MECHA 701 - 750
L201
C218 47u/16
IC201
PM9013A
150
10p/50
C706
R711
R705
DGND
AGND
C219
220
100
R709
R710
R704 100k
1u/10
C221
NM
C223
1000p/50
INAN1R
INAN1L
2 INAP2R
INAP2L
1u/10
3 INBN3R
C205
INBN3L
1u/10
C203
4 INBP4R
INBP4L
5 IN5R
C226
IN5L
6 OUTPR
NM
OUTPL
7 OUTRR
C232
OUTRL
8 OUTFR
NM
OUTFL
C207 0.1u/10
9 AVDDR1
AGNDL1
C208 0.1u/10
10 AVDDR2
AGNDL2
C210
11 VREFR
10u C209
VREFL
150p/50
CCG1192-A
12 AGNDR1
AVDDL1
13 AGNDR2
AVDDL2
14 DGND
C229
DVDD2
10u
1000p/50
15 TEST
L202
C216
RESETB
CCG1192-A CTF1793-A16 REG
C228
STB
NM
C217
17 DVDD1
CLK
0.1u/10
NM 18 DOUT
C220
DATA
C235 19 MCLK
CCG1192-A
DIN
10u
20 LRCLK
BCLK
100
R708
R717
220
R707
C704
10p/50
C705
1k
220
R706
1
R703
4.7k
150
2
R716
150
R715
C236
AGND
GND
5
37
40
100k
38
NM
39
100k
C701
C233
1u/10
C202
R719
CD:0.0 dBs
C231
1u/10
10u
C212 CCG1192-A
1u/10
C206
30
C204
31 150p/50
DGND
220
R718
47k
R702
NM
PGND
R701
RL
FL
16 WAIT
15 PGND
14 GND
ROL
C707
NM
PGND
WAIT
GND
13 LRCK
PL
LRCK
9 VDD
12 BCLK
11 DATA
BCLK
8 RESET
7 SDA
6 SKIP
10
DATA
DGND1
VDD4
SDA
5 SCL
CN701
RESET
D1
CDSTBY
CDSRQ
VKN1192-A
SCL
SKIP
VD
VD
/CDSRQ
CN701
4 /CDSTBY
CD
GND
GND
SWVDD
GND
DEH-15UB/XNUC
5
43
9 VDD
VDD4
GND
10
SIO0
*4
CLK 6
VCC
SIO3 7
NM
C703
NM
C702
GND
ROM
L701
100
A, E
, D, H
C
F
DGND
220
R718
DGND1
70
R625
Vss
R685
NM
C620
69
QSPCLK
DATA
150
R715
0.1u/10
68
NM
L681
14 GND
R618 R619
47k
10k
NM
47k
47k
22k
NM
47k
X602
CSS1603-A
GND
60
46
Vss 47
PVcc 48
DM 49
DP 50
ASEMD 51
CDSKIP 52
ROT0 53
ROT1 54
KEYAD 56
VDSENS 55
AVref 59
AVcc
AVss 58
MODELAD 57
1u/10
1u/10
CSS1794-A
X603
2.2k
47k
47k
ASEMDR614
R615
R616 47k
AGND
MODEL
0.1u/10
C612
47k
R618
*2
R624 16.9344MHz
X2
12p/50 3
C619
GND1
C613 0.1u/10
16.9344MHz
10p/50
10p/50
C706
10p/50
C705
C704
100k
C202
C206
TUNL
11 DATA
BCLK
150
CDDATAIN
R716
PVcc
IC201
PM9013A
12 BCLK
LRCK
150
47k
TCK 1
NM
C233
26
37
38
NM
12p/50
GND2 C618
X1
1
USBGND
AGND
GND
GND
ROR
NM
R620
L602
NM
NM
NM
R621
L601
DGND
VDD3.3V
VDD1.2V
NM
USB GND
C227
23
13 LRCK
CDSCKIN
R683 47k
C683 3p/50
39
NM
16 WAIT
CDWAIT
TMS 2
6
NM
21
15 PGND
PGND
WAIT
CDLRCKIN
40
1u/10
C201
TUNR
R619
C234
1u/10
C203
AUXR
47k
R717
AUDIO_X1
47k
34
7
C232
D601
R617
1u/10
C205
5
C226
NM
0.1u/10
TDI 3
C681
TDO 4
67
AUDIO_X2
66
TCK
65
TMS
TDI 64
TDO
63
ASEBRK
TRST 62
R623
ASEBRK 47k
61
C231
33
8
10k
R719
R622
36
NM
32
9
NM
C207 0.1u/10
C614
11
C210
NM
C617
NM
C615
DGND
NM
10
C208 0.1u/10
C616
12
150p/50
10u C209
CCG1192-A
NM
PGND
R659
TRST
35
10u
C212 CCG1192-A
31 150p/50
0.1u/10
C213
30
29 C211
0.1u/10
C214
28
0.1u/10
C215
27
13
INAN1R
INAN1L
INAP2R
INAP2L
INBN3R
INBN3L
INBP4R
INBP4L
IN5R
IN5L
OUTPR
OUTPL
OUTRR
OUTRL
OUTFR
OUTFL
AVDDR1
AGNDL1
AVDDR2
AGNDL2
VREFR
VREFL
AGNDR1
AVDDL1
AGNDR2
AVDDL2
DGND
DVDD2
TEST
RESETB
C229
1000p/50
24
NM
22
DIN
25
STB
DVDD1
CLK
17
DATA
DOUT
18
NM
MCLK
19
BCLK
LRCLK
20
C235
CCG1192-A
10u
DM
DP
CDSKIP
ROT1
ROT0
VDSENS
KEYAD
MCLK
LRCLK
BCLK
DIN
DATA
CLK
STB
RESETB
REG
14
10u
15
L202
C216
CCG1192-A CTF1793-A
16
C228
15k
R660
MUTE
1u/10
C221
NM
AGND
AGND
NM
L201
DGND
C223
1000p/50
DGND
C236
AGND
C218 47u/16
1u/10
RR
PR
FR
ucomD
GND
B.UP
C204
SW5V
RFGND
0.1u/10
FL
SYS+B 5.78 V
MUTE
1
RN4983
Q301
10k
R305
C303
1k
R306
0.22u/16
C307
GND
0.22u/16
0.22u/16
C305
0.22u/16
C301
CCG1201-A
4.7u
C251
CCG1201-A
4.7u
C252
4.7u
C255
CCG1201-A
CCG1201-A
4.7u
MU1
AGND
971 - 990
1u/16
C313
GND
CCH2040-A
GND 2200u/16
C901
GND
C314 0.1u/16
10k
R309
820
R251
820
820
R252
R255
820
MUTE
R256
BT MOD
C256
only H
FRch
FLch
PRch
PLch
RCA
251 - 300
AMP
301 - 400
TUNER
401 - 460
iPod CP 531 - 550
USB&USB5V 551 - 600
UCOM
601 - 670
RESET
671 - 680
FLASH ROM 681 - 690
DSENS
691 - 700
CD MECHA 701 - 750
C309 NM
C310 NM
10u
CCG1192-A
C219
1.2V
NM
C225
C224
SYS+B
C217
0.1u/10
C220
15k
AUXL
AUXG
C611
C311 NM
NM
0.1u/10
C312 NM
RL
470
Q252
Q251
C708
R301
Q302
LTC014YEB
GNDTP2
NM
10u/16
C318
C317
GND
AMP
GND
GND
>
NM
R259
B.UP
GND
FR
FL
PR
PL
RCAG
*5
*5
GND
A, F
JA251
100p/50
P-GND1
FL-
VCC
RL+
STBY
RL-
P-GND2
TAB
FL+
10 SVR
11
FLIn
12
RLIn
13
AGND
14
RRIn
15
FRIn
16
AC-GND
17
FR+
18
P-GND3
19
FR20
VCC
21
RR+
22
MUTE
23 RR-
B - E, G, H 1000p/50
5
4
2
1
6
CKB1056 (A,B,C,D,E,F)
CKB1099 (H)
10k
IC301
PAL011A
24 P-GND4
R312 25
B.REM
AC_GND
GND
GNDTP1
AGND
STBY
P251
CEK1386-A
2
1
3A
FR
RR
FL
RL
RCA
1
6
R311
PL
R302
ROL
470
4
3
5
C707
NM
3.3V
C332 NM
3
RN1910
RN1910
4
47k
22k
R257
R254
R253
R258
22k
22k
22k
C258
C257
C254
CN701
R307
A-a A-b
C333 NM
NM
R304
470
R303
470
A-b
NM
C331 NM
C327
1u/16
C335 NM
NM
C259
100p/50
100p/50
100p/50
C253
C319
C329
C334 NM
C328
100p/50
NM
1608
NM
NM
NM
C320
C321
C323
DEH-15UB/XNUC
NM
C260
1
C324
44
NM
F
NM
C261
E
100p/50
D
C325
C
3
NM
PREOUT
C326
B
2
NM
1
4
RGBDT
RGBDT/DIMMER
21
0.1u/10
L801
CTF1713-A
RGBDT/DIMMER
KYDT
22
DPDT
23
DPDT
CPPWR
25
3 3
2 2
CPRST
24
R817 2.2k
R816 2.2k
2.2k
2.2k
R814
R812
R811
31
GND
NM
NM
0.1u/10
NM
47k
GND
D671
100k
DM
DP
AUXR
AUXG
AUXL
SSENS
SWVDD
NM
ROT1
ROT0
KYDT
RGBCK/ILMCLR1
L851
1.5k
R613
NM
R671
47k
RGBST/ILMCLR2
NM
0.1u/10
DSENS1 R608
C606
R611
C609 0.1u/10
C610
R612
47k
47k
ASEMDR614
RST
DPDT
DGND
SWVDD
VSS
VDD
OUT
IC671
NC1
NC2
R606
R607
USB GND
12p/50
C607
RESET
S-80827CNMC-B8M
C608
12p/50
ILM GND
15k
DPDT
CDLRCKIN
CDDATAIN
CDRST
DSENS
SSENS
RGB Supply
2SA1577(QR)
NM Q871
NM
R877
R659
NM
GND
Q873
2SD1767(QR)
Q872
LTC143EUB
GND
GND
INA
INB
3
2
1
MUTE
OUTY
Vcc
1.2V
SW5V
RN4983
Q874
LED Supply
ASENS
SWVDD5
SYSPW
BSENS
OFFSET
Q875
LTC043EEB
TC7SET08FUS1
IC801
ILMPW
GND
DM
DP
CDSKIP
ROT1
ROT0
C927
SYS+B
C929
RGBDT/DIMMER
ILMPW
C925
TELIN
*3
22k
R941
A-a A-b
ASENS2
MUTE
RN4983
Q301
IC REGULATOR
GND
10k
R305
GND
ASENS1
D941
GND
R943
A GND
10k
R961
GND
GND
22u
DCH1256-A
C969
GND
NC2
OUT
MASK
TPD1052F
4 GND
3 IN
2 NC1
DIAG
IC961
1 VDD
A, F, H HZU7L(A1) 4.7k
B, C, D, E HZU7L(C3) 47k
D941
HZU7L(A1)
*3
GND
1k
R306
MU1
VDDCNT
B.UP2
R952
1k
R951
RFGND
1k
D302
TELIN
L951
only B, D, E
15k BTH1101-A
GND
B.REM&A.ANT
NM
C330
CRG03
D901
1SR154-400 GND
C930
R953
GND
GND1 GND2
2
1
1SR154-400
CTH1432-A
D902
L901
600uH
GND
Q302
LTC014YEB
GNDTP2
NM
RFGND
GND
1SS301
AGND
GND
D951
ASENS
R944
22k
Q951
LSAR523UB
GND
D912
D911
CRG03
12 GND
10 +BUP
11 VDDCONT
8 VDD12
9 SWVDD
6 SW5V
7 VDD
4 +B
5 SYS+B
2 SYSPW
3 SW5VCNT
CRG03
SWVDD
1.2V
VDD
SW5V
SYSB
+B
SYSPW
BSENS
IC911
BA49183-V12
1 BSENS
CCH2040-A
GND 2200u/16
B.UP
FL1
FR1
FL2
FR2
RL1
RR1
RL2
RR2
TELIN
AANT
ACC
BREM
B.UP1
(10A)
RLRR+
RL+
FRFLFR+
FL+
7
6
5
4
3
2
1
RR-
TEL
8
10
11
12 A.ANT
13 ACC
14 BREM
15 B.UP
YEK5001
FUSE
>
CKM1613-A
JA901
16 GND
17
18
B.UP3
B.REM
IC301
PAL011A
R312 25
10k
VCC
RR+
MUTE
23 RR24 P-GND4
22
21
20
A-b
Vss 38
RES 39
2.2k
R813
22
R810
22
R809
R808
41
Vss 40
PLLVcc
NMI 42
Vcc 43
EXTAL 44
XTAL 45
Vss 46
Vss 47
PVcc 48
DM 49
DP 50
C611
ASEMD 51
0.1u/10
CDSKIP 52
R610
R615
NM
NC2
R616 47k
C851
NC1 2
1 X1
KEYAD
B.UP
R879
1.2k
ROT0 53
Vss
CKIO 37
PVcc
36
SSENS
/DSENS 35
/CDRST 34
CDDADATIN
33
CDLRCKIN
32
PVcc
28
CDSTBY
27
CDSTBY
TELIN
26
TELIN1
TELIN
only B, D, E
R604 47k
CPPWR
C810 220p/50
1000u/16
C913
ROT1 54
8.2k
CDSCKIN
29
C605
NM
R605
CDSCKIN
NM
X2 3
X601
47k
1u/10
30
0.1u/10
R815
PVcc
R851
R609
C671
C852
C672
CSS1847-A
0.1u/16
C873
NM
C923
A, E
, D, H
C
F
C872
12MHz
47k
R878
KYDT
VA801 EZJP0V270RM
D811
NM
NM
CCG1201-A
C922
15k
R660
0.1u/16
C871
10k
R875
CPRST
VA802 EZJP0V270RM
C809 220p/50
RKZ7.5KG(B2)
R871
NM
R876
R872
3.3k
(1/10W)
NM
D872
D871
R874
390
47k
NM
NM
C928
R912
1000p/50
C926
1
4.7u
CCG1201-A
C924
Q941
LSCR523UB
SWVDD
NM
C921
C324
NM
VDSENS
C811
4.7u
3.3V
0.1u/10
47k
C325
NM
AGND
C963 NM
NM
NM
R962 10k
4.7u
SYS+B
NM
C919
NM
C965
R873
NM
CCG1201-A
C920
R942
CCG1201-A
C918
4.7u
NM
1
4.7u
CCG1201-A
C915
C327
R943
R307
C962
1000p/50
C912
C941
1u/16
C335 NM
0.1u/16
C914
4.7k
NM
C323
NM
C326
NM
KEYAD 56
VDSENS 55
C966
NM
C917
1000p/50
C916 R911
0.1u/16
1000p/50
0.1u/16
1M
R963
C911
R618 R619
47k
10k
NM
47k
47k
22k
NM
47k
0.1u/16
DEH-15UB/XNUC
0.033u/16
C961
D301
5
C322
0.1u/16
CRG03
5
8
POWER SUPPLY
A
45
4.7k
C410
RFGND
L405
68n
SYSTOBT
BTTOSYS
GND
MIC1P
GND
MIC1N
GND
(W/R)
6
5
4
3
2
1
GND
NRST_CPU
BTLRCK 10
BTBCK 11
BTDATA 12
GND 13
GND 14
VCC 15
VCC 16
NM
GND
C420
0.01u
CN971
JA892(RMIC)
NM
0.27uH
L401
L404
CTF1786-A RFGND
CTF1786-A
RF GND
L403
33p/50
0.1u/10
RFGND
M2R6TP_GND
R401
D401
NM
P402
750
KN2
220
RN731VN
L402
0.15u
1M
C416
L406
C419
C411
0.01u/16
C418
0.022u/16
L407
0.27uH
GND
C973
47p/50
100
MIC1P
MIC1N
GND
R973
R972 NM
R971
NM
L971
36.48MHz
X401
X2
3
2
*1
GND1
X1
CSS1848-A
4 GND2
1
TDA7706
CK_SEL
LFREF
LF1
VCCVCO
TCAM2
GNDVCO
IC401
PINDDEC
PINDIN
FMPINDRV
FMPINDDEC
VCCRF
TCAM
GNDRF
FMMIXIN1
FMMIXIN2
C425
NM
L420
0.1u/10
C452
FMMIXDEC
DGND
NM
0.01u/16
GND
*1
47uH
C429 L410
JA891
CKS6437-A
except A, C
*1
CCG1192-A
10u
16
15
14
13
12
11
10
RF GND
0.01u/16
100
R976 100
R975
R974
BT Connector
*1
4.7uH
C424
CCG1192-A
10u
C415
C414 0.01u/16
C412
0.1u/10
CTF1389
8
9
C403
1u/10
AGND
orRFGND C404 NM
RFGND
A GND
C401 NM
0.01u/16
C402
RFGND
NM
C454
C455
0.22u/16
1u/10
TUNGND YKS5041-A
1
2
C413
C409
C461
C417
R406
GNDLNA
17
6p/50
C421
3p
C453
LNAIN
R402
C422
CTF1756-A
L419
LNAIN2
21
20
LNAOUT
22
C427
C426
R407
0.1u/10
33
100p
C428
D402
RN731VN
CTF1786-A
LNAOUT2
C408
0.01u/16
C407
NM
C450
C430
*1
GND
1u
RFGND
C431 NM
AMMIXIN1
0.1u/10
23
NM 24
LNADEC2
C460
AMMIXIN2
25
1
3
2
RFGND
R411 680
0.1u/10
9p/50
C451
26
GNDSLINK
1u
C433
82p
0.1u/10
0.1u/10
4700p/25
*1
C434
HSPC16701B02
P401
R405
R417
28
VDIG
27
R409
0
R410 0
C432
AGND
DGND
48
*1
L416 NM
R415 0
L414
L418 NM
L417 NM
R416 NM
8.2
*1
C459
RF GND
KEYD
KEYAD
R892
R891
NM
NM
DGND AGND RF GND DGND AGND
C458
R414
L411 NM
8.2
*1
CTF1786
47 2.2u C444
CCG1205-A
46
C443
TEST
VDD_CORE 45
NM
GND1V2 44
GPIO0
GPIO1 43
GPIO2 42
GPIO3
41
GPIO4
40
GPIO5
39
GPIO6
38
GPIO7
37
GPIO8
36
GND3V3
C442
35
VDD3V3
0.1u/10
34
I2CSCL
DGND
I2CSDA 33
30
0.1u
0.01u/16
L409 C423
0.39uH 8pF
C449
31
LNADEC
2.2u CCG1205-A
C447
C438
NM
NM
29
C436
NM
18
C446
NM
C445
L413
C439
VCCREG1V2
REG1V2
VREG3V3
RSTN
RDSINT
91
19
9p/50
C448 0.1u
49
32
NM
/16
92
R408
470
C972
1000p/50
AGND
L415
1k
1k
TUN_RST
TUN_SDA
TUN_SCL
NM
KEYAD2
KEYD2
C419
C420
C421
C423
C428
C430
C432
C433
C436
C439
C441
C447
C448
L405
L406
L407
L408
L409
L410
L414
R403
R408
R409
R411
R415
*1
KEYD
KEYAD
BTRX
BTTX
BT_RST
BT_LRCK
BT_BCK
BTDATA
B.UP
NM
0.01u/16
NM
NM
100p/50
NM
82p/50
B-E
F, H
3.3V
NM
R642
LTC014YEB
Q601
C627 22p/50
C628 22p/50
BCLK
LRCLK
DDON
CDSRQ
CD_SDA
CD_SCL
TUN_SDA
TUN_SCL
CP_SDA
CP_SCL
SW5V
15p/50
0.01u/16
NM
3p/50
8p/50
NM
22p/50
100p/50
DCH1246-A
NM
2p/50
82p/50
NM
DCH1246-A
NM
0.1u/10
NM
NM
NM
NM
0.1u/16
10p/50
NM
NM
CCG1218-A
NM
NM
0.1u/10
0.1u/10
NM
NM
NM
68n
CTF1389-A CTF1389-A
NM
0.27uH
NM
NM
1.5uH
4.7uH
4.7uH
NM
0.39uH
NM
47uH
2.2uH
47uH
NM
CTF1786-A
NM
330
390
390
470
470
360
0
NM
NM
390
680
680
0
NM
0
NM
NM
MECHA VD
VD2
7.4V
KN1
104
105
102
103
0.1u/10
R644 100
R645 100
101
100
99
98
97
96
100k
C626
TESTIN
R643
820
KEYD
EVOL_LRCK
EVOL_BCK
BT_TESTMD
PVcc
Vss
TESTIN
DDON
/CDSRQ
CD_SDA
92 CP_SCL
CP_SDA
93 TUN_SCL
94
TUN_SDA
95 CD_SCL
91
47k
47k
R637
R636
2
1
RN4983
VDCONT Q752
Q751
2SD2396(K)
M2R6TP_GND
GND
BT_TESTMD
NM
R641
R754
0.1u/10
CTF1786-A
0.1u
C441
C437
C435
0.47u/10
C440
10p
CCG1192-A
C751 NM
JA401
R640
10u/10
4.7k
64
TVDAC
63
TCFM
62
PLLTEST
61
GND-PLL
60
VCC-PLL
59
VCC-ADC_DAC
58
DACOUTR
57
DACOUTL
56
GND-ADC_DAC
55
VREFDEC
54
GND-REF
53
OSCOUT
52
OSCIN
VCC-REF 51
VDDIO1V2
VDDPLL1V2 50
NM
D751
TUNL
4.7k
R753
47k
VDSENS
47k
C753
10k
R668 47k
0.1u/10
C752
TUNR
R638
C456
47k
C457 4700p/25
BSENS
90
RKZ8.2KG(B2)
VDCONT
R752
ASENS
89
C406
NM
*4
C701
A
except A
GND
0.01u/16
NM
R705
R704 100k
R703
4.7k
PEB047A8
PEB046A8
CD:0.0 dBs
100k
47k
R702
R701
VKN1192-A
CN701
CD
VD1
VDCONT
TUNER
RESETB
R635 1k
88
TUN_RST
R634 1k
87
/CDSTBY
4
/CDSRQ
3
A-a A-b
C625
C624
86
NM
C971
R893
NM
84
0.01u/16
C405
VA891
NM
83
NM
MIC1P
MIC1N
C893
CDWAIT
NM
1000p/50
VA892 NM
80
R404
1M
C894
1000p/50
4
16
DEH-15UB/XNUC
R669
IC601
CN701
CS
IC681
FLASH ROM
NM
C703
NM
C702
GND
A, E
B, D, H
C
F
*2
*4
8
VCC
2
NC/SIO3 7
SO/SIO1
3
SCLK 6
WP/SIO2
4
5
GND SI/SIO0
1
C
14 GND
A-b
DGND
L68
10
10
C
10
C
R618 R619
47k
10k
NM
47k
47k
22k
NM
47k
MO
R631
MD_CLK 79
0.1u/10
0.1u/10
85
MCLK
22p/50
C622
R633
81
EVOL_MCK
47k
NM
C682
C621 0.1u/10
78
R681
100
R632
47k
47k
MD_BOOT
C623 0.1u/10
VD
1
R682
100
R630
77
Vcc
82
/BSENS
/ASENS
TUNRES
EVOL_RST
Vcc
VDCONT
Vss
/CDWAIT
PVcc
VD
2
CDSRQ
220
R706
CDSRQ
R684
47k
76
QIO3
5 SCL
CDSTBY
CDSTBY
47k
Vss
R629
100
75
100
100
R708
SDA
R628
QIO1
74
100
R627
100
R626
QSSL
73
QIO0
71
R707
220
6 SKIP
SCL
SKIP
GND
10
100
70
R625
Vss
72
QIO2
VDD4
L701
7 SDA
RESET
1k
R711
220
R709
CDSKIP
100
R710
CD_SDA
8 RESET
CDRST
9 VDD
DGND1
QSPCLK
11 DATA
DATA
150
R715
0.1u/10
68
15 PGND
8
CDDATAIN
R685
16 WAIT
7
NM
C620
12 BCLK
BCLK
150
R716
PVcc
69
13 LRCK
LRCK
150
R717
AUDIO_X1
CDSCKIN
47k
PGND
WAIT
CDLRCKIN
TCK 1
TMS 2
R683 47k
C683 3p/50
220
CDWAIT
46
0.1u/10
A-a
C681
F
6
E
5
D
TDI 3
C
TDO 4
B
R623
A
2
67
AUDIO_X2
66
TCK
65
TMS
TDI 64
TDO
63
ASEBRK
TRST 62
1
4
R639
0.1u/10
C531
R531
PAD
9
R532
2.2k
MIC1P
MIC1N
NC3
SCL
RST
VCC
iPod CP@(2.0C)
NC2
NC1
SDA
R893
NM
IC531
NM
VA891
NM
C893
4.7k
100
100
R536
R537
R538
Q531
LSAR523UB
C894
1000p/50
GND
USB5V
GND
1
3
2
47k
R539
47k
R540
L551
CTH1524-A
W.REM
JA891
CKS6437-A
GND
NM : No Mount
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
GND
47k
GND
NM
R533
2.2k
1000p/50
VA892 NM
R534 2.7k
C532
0.1u/10
L531
R535 4.7k
W.REM&MIC
NM
C558
(W/R)
470
R555
except A, C
1u/10
C557
220u/6.3
C556
C891
GND
A
B
C
D
E
F
H
FB
VC
EN
BST
VCC
OC
VOUT
4
SYNC
BD2232G-G
EN
GND
FIN
GND 9
Lx
IC552
VIN
IC551
BD9876EFJ
SYNC
EN
BST
VCC
R892
R891
1k
1k
GND
1u/16
C551
220u/16
B.UP
3.3V
CN1931
CMS03
D551
KEYAD2
KEYD2
A-a A-b
USBCLT
FLG
GND
DEH-15UB/XNUC
DEH-1500UB/XNEW5
DEH-1500UBA/XNEW5
DEH-1500UBB/XNEW5
DEH-1500UBG/XNEW5
DEH-1550UB/XNES
DEH-1590UB/XNID
GND
FB
VC
GND
LX
USB&USB5V
GND
KEYAD
C553
0.01u/16
KEYD
0.1u/16
MIC1P
MIC1N
TP1
R552 0
R553
R554
180k D
43k D
6800p/25
6.8k
NM
C554
NM
C561
6
5
4
3
2
1
C564 CCG1201-A
4.7u D552
RB056L-40
0.1u/16
C892
1u/10
NM
C560
JA892(RMIC)
1u/10
C552
NM
C555
R551
C562
NM
C565
CCG1222-A
4.7u
C563
C559
14
15
16
17
18
19
10
11
GRILLE
DGND
ILMGND
SWVDD 3
2
ROT1
ILM+B
RGBDT 7
6
ROT0
KYDT
USBGND
DPDT
USB5V
DM 13
RGBCK/ILMCLR1
12
DP
RGBST/ILMCLR2
AUXGND
AUXR
SOURCE
AUXL
DSENS
CKS6452-A
20
FLG
C801
R801
2.2k
220p/50
USBCTL
SYNC
MUTE
SWVDD5
STB
DATA
KEYD
DIN
CLK
GND
R668 47k
BT_TESTMD
100
10k
R653
2.2k
R652
R650
R649
R648
R647
LTC014YEB
Q601
C627 22p/50
R669
C628 22p/50
BCLK
LRCLK
CN801
USBCTL
FLG
SYNC
DDON
CPRST
CP_SDA
CP_SCL
CPPWR
KEYD
KEYAD
DDON
47k
D602
RGBDT/DIMMER
R802
CDSRQ
C633
NM
0
SYNC
120
119
118
117
BTTESTIN
PCL
RAM_MON
MUTE
SYNC
USBCTL
/USBFLG
Vss
SWVDD
PVcc
EVOL_CS
EVOL_DT
Vcc
EVOL_CK
Vss
EVOL_DATA
KEYD
EVOL_LRCK
EVOL_BCK
BT_TESTMD
PVcc
Vss
TESTIN
DDON
/CDSRQ
CD_SDA
CD_SCL
DGND
ILMG
only H
only B - F
IC601
R5S726A0D216FP
R806
R807
22k
22k
R803
R804
R805
A, E
B, D, H
C
F
2
R618 R619
47k
10k
NM
47k
47k
22k
NM
47k
44
11
100
100
100
CTF1713-A
L801
3 3
2 2
/
/
CDD
CD
R814
A-b
R817 2.2k
R816 2.2
2
2.2
R813
22
R810
22
R809
R808
USGND C804
NM
C803
NM
US5V
DGND
115
only B - F
only H
PCL
114
113
112
111
110
109
108
107
106
105
104
103
102
101
100
99
98
97
96
95
RAM_MON 116
0.1u/10
C630
0.1u/10
1k
1k
C629
R645 100
R644 100
0.1u/10
100k
C626
TESTIN
R643
1k
10k
NM
NM
R651 47k
CD_SDA
R818
R661
47k
CD_SCL
C601
C806 0.1u/16
1
R601
47k
D802 DZ2S068C
R662
47k
R663
47k
CPPWR
GND
BT_LRCK
GND
BTDATA
NM
NM
C631
22p/50
VBUS
D801
15
R646
DSENS
C802 NM
ROM
CDSTBY
27
NM
C805
0.1u/10
BT_BCK
D803 DZ2S068C
2
BT_RST
3
BT_TESTIN
4
BTRST
5 PVcc
6 BT_BCK
Vss
7 BT_LRCK
BTDATA
SYSPW
D804 DZ2S068C
11
ROM
9
R602
PVcc
28
GND
D807 DZ2S068C
Vss
10
47k
1u/10
C807
SYSPW
D805 DZ2S068C
Vcc
12
0.1u/10
C602
RGBCS/ILMCLR2
C603 0.1u/10
BTRX
13
R603 NM
BTRX
PVcc
16
C808
RGBST/ILMCLR2
BTTX
14
BTTX
RGBCK/ILMCLR1
RGBCK/ILMCLR1
D806 DZ2S068C
17
OFFSET
ILMPW
19
ILMPW
ANTPW
R664 10k
D808 NM
0.1u/16
RGBDT
Vss
18
D809 NM
RGBDT/DIMMER
20
C604
KYDT
21
0.1u/10
RGBDT/DIMMER
Vcc
22
KYDT
NM
26
R604 47k
only B, D, E
DPDT
23
DPDT
TELIN
TELIN
25
TELIN1
CPPWR
CPRST
24
CPRST
D810
VA801 EZJP0V270RM
D811
NM
DEH-15UB/XNUC
C810 220p/50
VA802 EZJP0V270RM
C809 220p/50
29
C605
NM
R605
CDSTBY
CDSCKIN
5
8
A-a
47
48
1
except D
only D
CAW2024
CAW2027
SEGMENT LCD
2
ILMGND
only E
A
B
C
D
E
F
H
DEH-15UB/XNUC
GREEN
D1952-D1966 : SML-D12P8W(KL)
DEH-15UB/XNUC
DEH-1500UB/XNEW5
DEH-1500UBA/XNEW5
DEH-1500UBB/XNEW5
DEH-1500UBG/XNEW5
DEH-1550UB/XNES
DEH-1590UB/XNID
NM
R1961
BAND
NM
EQ/PHONE
D1958
C1957
390
R1960
1.8k
1/4W
1/10W
1/4W
only A, F, H
R1962
S1837
MN
S1836
NM
R1963
R1964
KDT2
KYDT
DPDT
SOURCE
KDT3
S1824
1
2
DISP/BACK
D1965
LIST
NM
D1959
S1829
D1966
C1958
6
NM
D1960
1/4W
EJECT RIGHT
1/10W
KST0
C1959
COLOR2
680
R1970
NM
S1840
NM
S1839
MN
KDT1
S1823
R1969
3
4
C1964
D1963
D1964
1/4W
1/10W
S1835
1
2
680
R1968
KDT0
C1965
NM
DGND
NM
R1967
C1962
S1838
C1963
DISP
1/10W
MN
S1834
only B - E
EQ
680
S1828
R1966
NM
S1822
D1961
KST1
NM
R1942
D1962
S1827
1
2
NM
IC1941
GP1UXC14RK
NM
5 MHz
1/4W
L1801
S1826
1
2
R1965
LEFT
C1960
SOURCE
C1961
VCC
KDT2
R1943
KST3
1/10W
COM0
MN
S1821
D1956
LEFT
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
SEG29
SEG30
SEG31
GRILLE uCON
D1957
RIGTH
GND
COM1
COM2
CCG1192-A
KST2
680
R1959
NM
SEG0
REM
SEG2
SEG1
NM
C1941
SEG3
1/4W
SEG4
R1958
SEG6
D1954
SEG7
TA/CLK
SEG8
C1955
SEG9
D1955
SEG10
EJECT
41
SEG14 43
42
C1956
NM
1/4W
21
1/10W
KDT0
680
22
R1957
DGND
KDT3
NM
26
COM0
25
KDT3
24
KDT2
23
NM
COM1
47k
X1801
CSS1547-A
COM3
R1956
DGND
27
C1953
KDT0
28
C1954
SEG49
R1941
KDT1
29
1.8k
SEG46
SEG5
SOURCE
COM2
SEG11
LIST
COM3
SEG45
1/4W
SEG44
30
1/10W
SEG0
31
560
SEG43
32
R1954
SEG1
33
NM
D1952
SEG42
34
NM
SEG2
35
D1953
C
SEG12
SEG13
SEG16 45
SEG15 44
SEG18 47
SEG17 46
SEG20 49
SEG19 48
SEG22 51
SEG21 50
SEG24 53
SEG23 52
SEG26 55
SEG25 54
SEG28 57
SEG27 56
60
SEG31
SEG30 59
SEG29 58
NM
V1801
SEG3
36
47k
IC1801
PD6583A
37
R1953
SEG4
38
C1951
SEG40
47k
R1808
SEG5
SEG39
47k
R1807
SEG38
39
C1952
80
SEG6
220
1/4W
SEG48
SEG51
SEG7
R1951
79
SEG50
SEG8
47k
R1806
SEG47
SEG9
40
R1955
D
78
SEG37
SEG11
SWBA05(FI231718)
V1801
77
SEG33
SEG10
220
1/4W
SEG51
76
SEG32
R1805
SEG50
75
SEG36
18 X0
19
X1
20
VSS
SEG49
74
SEG35
0.1u/10
SEG48
73
C1806
SEG47
72
16 NC
17 C
SEG46
71
SEG41
KST3
SEG45
70
1u/10
C1807
SEG44
69
8 RST
R1802
9
BTPW
10
NC
11
V2
0 R1804 12
V3
R1803 13
VLCD
2.2k
14 VCC
15 KST3
SEG43
68
47k
SEG42
67
KST2
SEG41
66
SEG34
6 REM
7 KST2
SEG40
62
KST1
SEG39
65
3 KST0
4
DPDT
5 KST1
SEG38
64
DPDT
SEG37
DBG
KYDT
SEG36
B
63
47k
R1801
SEG35
61
KST0
KYDT
SEG34
R1952
COM3
COM2
COM1
COM0
SEG51
SEG50
SEG49
SEG48
SEG47
SEG46
SEG45
SEG44
SEG43
SEG42
SEG41
SEG40
SEG39
SEG38
SEG37
SEG36
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
SEG20
SEG19
SEG18
SEG17
SEG16
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
SEG0
SEG32
D1951
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
SEG33
COM3
COM2
COM1
COM0
SEG51
SEG50
SEG49
SEG48
SEG47
SEG46
SEG45
SEG44
SEG43
SEG42
SEG41
SEG40
SEG39
SEG38
SEG37
SEG36
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
SEG20
SEG19
SEG18
SEG17
SEG16
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
SEG0
1
4
KEY MATRIX
S1825
1
2
BAND/ESC
1
2
S1832
S1831
BACK
S1833
2
5
2
1
2
KDT1
S1842
2
1
S1841
2
SRCDGND
REMOTE
R1944
100
ILLUMINATION
N
Q
KYDT
4
2
DPDT
KDT3
SOURCE
GRILLE uCON&LCD
1801-1820
KEY MATRIX
& ROTARY
1821-1850
USB
1911-1920
ND/ESC
31
KEYBOARD UNIT
1921-1930
AUX
CONNECTOR 1931-1940
REMOTE
1941-1950
LED
1951-2000
2
32
2
AUX
S1830
CK
CKN1094-A
NM
R1922
3
2
1
37
CSD1168-A
L1802
CTF1389-A
JA1921
L1803
CTF1389-A
R1921
R1923
MULTI-CONTROL
CN1931
CKS6451-A
NM
NM
1
L1804
CTF1389-A
DGND
DGND
2 ILMGND
DGND
3 SWVDD
4
ROT1
R1931
R1932
2.2k
27k
R1822
NM
R1823
5 ILM+B
USBGND
KYDT
9 USBGND
5V
2.2k
ROT0
10 DPDT
CN801
11 USB5V
12 ILMCLR1
14 ILMCLR2
NM
NM
D1932
D1931
13 DM
15 DP
16 AUXGND
17 AUXR
ILM+B
DGND
18 SOURCE
19 AUXL
2
1
1/10W
DGND
USB
CN1911
NM
L1911
CKS6443-A
NM
1/4W
NM
R1982
*1
R1983
1/4W
1/10W
*1
R1981
NM
R1980
*1
R1979
1/4W
1/10W
1/10W
NM
R1978
*1
R1977
1/4W
1/10W
NM
R1976
*1
R1975
R1973
1/4W
1/10W
NM
R1971
*1
R1972
1/4W
1/4W
R1990
1/4W
390
1
2
NM
D1912
C1911
NM
D1911
C1912
0.1u/16
0.1u/16
2
3
4
D1976
D1977
D1978
D1979
RIGTH
LEFT
1
D1980
D1973
D1974
D1975
D1971
BAND
D1972
DISP/BACK
TA/CLK
EJECT
D1969
NM
D1970
R1974
D1967
SOURCE
D1968
LIST
D1981
R1993
NM
Q1953
NM
Q1952
EQ/PHONE
EQ/PHONE
R1960
D1958
NM
R1961
1/4W
1/10W
1.8k
NM
0
*1
DISP/BACK
BAND
C1957
R1962
MN
NM
R1963
R1964
5
NM
D1959
NM
D1960
D1965
D1966
C1958
6
C1959
20 DSENS
AUX:+2.2 dBs
ILLUMINATION
ILMGND
DGND
COLOR1
USBGND
RED/AMBER
USB:0.0 dBs
820
R1978
820
1.8k
R1980
1k
1.8k
R1982
1k
2.2k
R1990
820
1.2k
1
NM
ILMCLR
ILMGND
NM
2.2k
1k
680
R1987
R1973
R1976
only E
NM
820
R1988
680
Q1951
4
R1989
R1971
NM
AMBER
SML-D12D8W(RS)
RED
SML-D12V8W(PQ)
NM
A, B, D, F, H
COLOR
D1967 - D1981
R1986
W5
EW5
EW5
NEW5
S
D
R1984
*1
R1985
except E
except E
B
DEH-15UB/XNUC
5
49
CXX3556
V3R3
2.4
4.7u/6.3
(2125)
C104
2.4
2.7
(1/10W)
(1/10SR,1608)
R101 R102 R103
LD1
Q102
LTA123JUB
VCC
TOP
TRK ACT
D101
NM
TOM
C220
FOM
0.1u/10
RFI
TOP
82
R229
83
470
84
C217
R216
85
56p/50
1.2k
86
EQ1
RF2RFA.GND2
88
A.VDD2
89
A
BD
90
91
92
B
F
E
93
REFO
C229
0.1u/10
TE
C225
TEC
C223
94
68p/50
95
FEO
96
ADCIN
C236
REFOUT
FE-
FE
0.1u/10
ADCIN
C224
97
47p/50
98
TETEO
99
0.01u/16
100
C239
C104
CXE2273
TE2
TEC
2125:PARTS
M1 SPDL MOTOR
EQ2
C222
0.1u/10
NM
AC
RFO
87
C204
CKS4808-A
27p/50
BD
AC
TOP
FOP
FOM
TOM
81
RFO
C228
NM
CN101
1608:PARTS
C205 C209 C238
C240 C307 C308
C708
C3T
C219
0.1u/10
AGCI
FOP
REFO2
AGCO
80
REFO1
A.GND1
79
1800p/50
RFAGC
C205
74
75
ATEST
f
PD
LD
FOP
78
FOM
A.VDD1
77
C216
TOM
PD
NM
MD
AC
0.1u/10
5.6k
A+C
76
C221
4.7k
4p/50
F
REFO
C218
VR
R218 R217
VREF
NM
P1+P6
C201
10
NM
11
10
EFM
ATEST
NM
11
V+3A
BD
V+3A
1M
12
R108
13
12
C101
GND
14
13
39
ASY
NM
P5+P10
14
R2
C110
VCC
15
C111
B+D
15
NM
C102
LD+
FOCUS ACT
LD
2SA1577(QR) 2.2k
LD-
HOLOGRAM UNIT
R109
C214
Q101
LD
R
R
R
R
PUEN
0.047u/16
E:P5+P10
F:P1+P6
LD
PD
BLK
SOM
RED
SOP
VDD
C202
C301
GND
BL
LCOM
YW
CN702
CXC4026
C312
LCOP
NM
CSN1080-A
8SNS
S905 NM
FOP
FOM
TOM
8SNS
DSCSNS
S903
DSCSNS
10
TOP
CSN1081-A
DSCSNS
SWITCHES:
CD CORE UNIT (S11.6STD)
S901:HOME SWITCH.........ON-OFF
S903:DSCSNS SWITCH.....ON-OFF
C308
11
1u/10
(1608)
12
13
CLCONT
LOEJ
CONT
EJ
PLAY
OFF
H
H
L
H
L
L
VD
CLCONT
LOEJ
CONT
DEH-15UB/XNUC
1
LOAD
PGND
C
50
TD
VDD 1
FD
C301
C306
14
SD
a9
NM
LCOM
NM
C313
SOP
MD
NM
SOM
NM
SIN
SPIN 28
POWVCC
CIN
SLIN 27
SPOC315
BIAS 26
SPO+
FIN
NM
25
TKIN
SLLDOTIN
FCIN 24
SLLDO+
CNT 23
POWGND
LDIN 22
TKO- 29 GND
21
MUTE
TKO+
PRTOUT 20
FCOPREGND 19
FCO+
47k
PRTLIM 18 R309
TKRNF
PRTF 17
FCRNF
16
PRTT
TKCDET
PREVCC 15
FCCDET
C314
HOME
431
431
43 1
HOME
0.1u/10
HOME 3
S901
IC301
BD8223EFV
C307
1u/10
(1608)
LCOP
M2 LOAD/CRG MOTOR
PUEN
12k
12k
R303
R304
SKIP
/CDSRQ
10k
Mask
51
LRCK0
/CDSRQ
/TESTIN
52
SKIP
53
55
54
/PUEN
/ADENA
VDCONT
56
57
VDSENS
58
TEMP
59
MONITOR_0
MONITOR_1
60
62
61
MONITOR_2
63
SD2
MONITOR_3
50
PC3
A.GND1
SDA
RFI
SCL
78
AGCO
8
0
7
0
81
82
R229
83
470
84
R216
85
86
TX/EMPH
SCKO
EQ2
DOUT
EQ1
PA7
LOEJ
CLCONT
87
A.GND2
IC201
A.VDD2
PE5791A
88
CONT
DSCSNS
89
NC
A
90
EJSW
E
93
/CDSTBY
REFOUT
C223
94
ICECK
FE95
68p/50
FEO
IO.VDD1
ADCIN
IO.GND1
96
C224
97
47p/50
TE-
RESET
TEO
C.GND
98
99
C.VDD
TE2
NM
NM
C235
SCL
C283
NM
R283
44 R281
56
43 R282
56
LRCK
56
R292
BCLK
C281
C282
NM
NM
R293
DATA
42
C284
41
NM
R202
LOEJ
40
R201
CLCONT
39
R264
1k
CONT
38
DSCSNS
37
8SNS
35
HOME
EJSW
34
33
R245
R253
100k
NM
100k
R240
47k
/CDSTBY
ICECK
32
ICECK
R297
31
C211
30
NM
0.1u/10
29
R237
C233
28
27
C210
26
0.1u/10
RESET
220
0.01u/16
R232
XTAL
VPP
X.GND
VPP
CVDD
CVDD
VDD2
C299 0.1u/10
VDD
VD2
RESET
VD1
SCL
SDA
SKIP
CDSRQ
CN701
CKS6146-A
I/O
VPP 9
SCK 7
ICECK 5
VD
/CDSRQ
VDD 1
CDSTBY
GND
NM
CVDD 3
VDD1
(1608)
NM
C240
ICEMD
0.1u/10
0.1u/16 (1608)
0.1u/16 (1608)
CVDD
ICECK
VPP
X201
CSS1603-A
16.934 MHz
C209
10 GND
SCK
C238
SCK
NM
8 SI
6 SO
CN702
RESET
C202
C203
A0
STB
RST
INTQ
25
/XTAL
24
470
ICEMD
X.VDD
23
R294
22
DA.VDD
SDA
R291
21
20
LOUT
19
REGC
DA.GND1
ROUT
DA.VDD1
DA.GND
18
17
16
15
14
REG16
REGS
13
D.GND
12
D.VDD
SI
9
SI
11
10
SO
SO
8
SCK
/SCK
A0
/STB
VPP
INTQ(INT1)
/RST
PD
LD
NM
C239
TEC
100
/WAIT
R254
HOME
F
92
36
12SNS
B
91
22
ADENA
BSCK0
45
LRCK
RFO
RF-
56
470
ADENA
46
AGCI
RF2-
1.2k
22
47
/WAIT
C3T
C219
56
48
80
0.1u/10
Flash
10k
22
49
79
1800p/50
0
56
C216
IO.GND2
IO.VDD2
A.VDD1
77
64
65
66
67
TD
FD
SD
68
70
71
69
MD
TEST
AD.GND
72
73
EFM
AD.VDD
75
74
ASY
ATEST
76
R232
R281
R282
R291
R294
GND
TESTIN
TEMP
TH201
NM
Q201
NM
ATEST
TEMP
R296
R260
C16M
MONI0
MONI2
MONI1
MDX
0.1u/10
(1608)
R246
VDD
MDY
10k
C215
R214
39k
EFM
ADENA
TEMP
C212
C213
0.1u/10
GND
R215
ASY
4.7k
R306
4.7k
4.7k
4.7k
4.7k
3300p/50
C214
R308
4.7k
0.1u/10
PUEN
C305 0.022u/16
R310
R311
R312
R313
1000p/50
1000p/50
C304
0.047u/16
R307
1k
R305 SD
1k
R302 TD
C302
C303
0
R301 FD
MD
/CDSTBY
R709
0
R706
SCL
R702
220
SKIP
100
R701
R708
SDA
100
RESET
VD
7.5V
VD
7.5V
/CDSRQ
/CDSTBY
SCL
SKIP
SDA
RESET
VDD
10 GND
DATA
NM
(1608)
C708
NM
C707
NM
C705
C710
1000p/50
GND
15 PGND
GND
16 WAIT
IIC-BUS
Digital
GND3
GND2
GND1
LRCK
WAIT
DATA
BCLK
NM
NM
C701
NM
NM
C702
PGND
C703
NM
R710
R711
H
L
L
14 GND
i h g
F
PGND2
OFF
13 LRCK
/WAIT
PGND1
PLAY
CN701
12 BCLK
LRCK
GND
11 DATA
BCLK
LOGIC TABLE
3.3V
C
DEH-15UB/XNUC
5
51
10.4 WAVEFORMS
- CD CORE UNIT(S11.6STD)
A
1DSCSNS
3HOME
4LOEJ
5 V/div
5 V/div
5 V/div
Note : 1. The encircled numbers denote measuring points in the circuit diagram.
2. Reference voltage REFO1(1.65 V)
500 ms/div
1DSCSNS
5CLCONT
4LOEJ
6VD1
5 V/div
5 V/div
5 V/div
10 V/div
12 cm CD Loading operation
12 cm CD Loading operation
Ref.:
GND
Ref.:
GND
Mode:
Normal
Mode:
Normal
500 ms/div
7SIN
8CIN
9TIN
aFIN
200 mV/div 500 ms/div
bRFOK(MONI_2) 2 V/div
7SIN
2 V/div
cTE
dFE
Ref.:
REFO
Ref.:
REFO
Ref.:
REFO
Mode:
Normal
Mode:
Normal
Mode:
Normal
1 V/div
500 mV/div
500 mV/div
1 s/div
dFE
aFIN
cTE
9TIN
500 mV/div
500 mV/div
500 mV/div
500 mV/div
52
eMDX
7SIN
2 V/div
50 ms/div
500 mV/div
eMDX
7SIN
5 s/div
2 V/div
500 mV/div
Ref.:
REFO
Ref.:
REFO
Ref.:
REFO
Mode:
Normal
Mode:
Normal
Mode:
Normal
aFIN
dFE
20 ms/div
cTE
fRFAGC
500 mV/div
500 mV/div
2 ms/div
fRFAGC
cTE
9TIN
1 V/div
500 s/div
500 mV/div
500 mV/div
Ref.:
REFO
Ref.:
REFO
Ref.:
REFO
Mode:
TEST
Mode:
TEST
Mode:
TEST
DEH-15UB/XNUC
1
fRFAGC
cTE
9TIN
1 V/div
500 mV/div
500 mV/div
2 ms/div
fRFAGC
cTE
8CIN
7SIN
1 V/div
200 ms/div
1 V/div
500 mV/div
2 V/div
gLRCK
2 V/div
hBCLK
2 V/div
iDOUT(DATA) 2 V/div
Ref.:
REFO
Ref.:
REFO
Ref.:
GND
Mode:
TEST
Mode:
Normal
Mode:
Normal
10 us/div
1DSCSNS
5CLCONT
4LOEJ
5 V/div
5 V/div
5 V/div
1DSCSNS
3HOME
4LOEJ
500 ms/div
5 V/div
5 V/div
5 V/div
12 cm CD Eject operation
12 cm CD Eject operation
Ref.:
GND
Ref.:
GND
Mode:
Normal
Mode:
Normal
fRFAGC
9TIN
cTE
aFIN
1 V/div
1 V/div
1 V/div
1 V/div
500 ms/div
500 s/div
Ref.:
REFO
Mode:
Normal
DEH-15UB/XNUC
5
53
W.REM
JA891
1
PREOUT
140
Capacitor
Connector
130
R252
R259
C261
C254
R254
SIDE A
P251
Q251
JA251 3
R253
C253
R251
R256
C258
R258
VA891
C260
Q252
JA892
C892
C891
3
4
C893
R891
R892
R893
R255
C331
C317
R555
D551
C313
C305
C301
C252
C332
C307 C303
C309
R301
Chip Part
P.C.Board
C333 C334
C318
C251
C259
IC301
15
C320
C894
VA892
C256
SIDE B
C328
C255
10
C319
C311
R303
C257
R257
R304
C312
C321
C310
R302
C562
C96
R307
R311
C551
C556
R309
120
C557
C563
C558
C555
5
1
IC551
C552
C554
R551
C553
110
C564
R553
R554
R552
1
C565
L551
D552
100
C
90
80
70
D
60
50
40
E
30
20
10
Y
A
54
FRONT
X
10
20
30
40
50
60
70
DEH-15UB/XNUC
1
80
SIDE A
CEK1386
POWER SUPPLY
C326
20
IC301
15
L901
Q751
JA901
E
D751 C752
25
C332
11
13
16
18
15
Q752
C751
C322
C901
JA401
P402
P401
C421
R406
L401
C413
L403
C403
C414
C416
C412
C453
C415
C404
C458
L420
60
55
C450
R417
1
X401
45
L417
R416
L414
R415
L415
D911
C446 C448
C449
C459 C447
L418
C445
C443
C444
C442
C457
C456
C452
C451
50
R403
C424
R617
D601
C671
R402
D912
35
R610
C422
C419
R961
R612
1 X601
L416
R412
R413
C607
D671
R611
30
Q873
Q874
L601
R621
R871
D871
CN971
C914
15
Q871
R875
R664
C614
C615
R659
R660
R604
R872
D872
R876
L602
R609
R879
E
R873
C616
C617
Q872
C871
C672
R671
R616
R620
R605
R607
R606
C604
R663 R602
R603
R662
R615
IC671
C609
40
C440
C437
C455
C963
C966
R963
R962
R953
R951
R618
R619
60
C612
C613
C608
R608
25
35
R874
R625
20
C601
R414
C435
C401 D402
IC401
C436
55
50
45
R613
C610
40
R614
C611
R410
C431
C434
L411
L413
R633
R631
R629
R682
R630
R628
R627
R626
C620
C623
C441
R623
C606
C605
R653
C621
R537
R540
R635
R634
C624
R536
R639
R640
R636
R601
15
C603
R532
R533
R646
R669
10
C602
C971
C618
R622
C460
C438
C439
R685
C681
E
R535
90
1
R661
R973
85
C633
R652
IC601
120
80
R668
C630
R651
R624
R401
C408
L402
30
100
C629
X602
C432
C433
R411
R754
R753
R683
R539
C627 R643
C628
C626
R645
R644
C631 R647
X603
D401
C409
L419
25
R642
R641
C619
C417
C411
R409
C410
20
R637
R538
Q601
R632
C625
L404
C426 R404
R408
C427
R407
C429
C428
L410
L681
C420
L406
C461
C425
C683
IC681
95
D602
C225
5
1
C622
R638
R684
L405
L407
C423
C962
IC531
R648
R649
R650
L201
C224
C236
L202
C216
20
C223
25
C219
C682
Q531
R531
C532
C531
R534
L409
30
15
C215
R681
L531
R405
C220
KN2
C969
IC961
C961
Q302
C211
C213
C214
C235
C217
E
Q951
C231
C930
35
C210
C221
R952
40
10
C208
C232
C209
D951
C218
C212
C226
C207
C206
IC201
C227
L951
C228
C229
C234
C202
C204
C233
C205
C203
C201
Q941
C454
C911
L408
R943
E
C418
D302
R942
R941
ANTENNA
75
R309
C329
Q301
C941
D941
R307
C314
C323
C324
C430
C335
R305
D901
D902
R944
C330
D301
R306
C965
R311
R752
C753
17
R312
70
10
R974
R975
C973
R976
E
Q875
C928
C918
C972
L971
C929
C925
R718
R719 C704
C706
R716
C705
R717
R715
R707
R708
R709
R710
CN701
C920
C924
C919
C912
R911
5
10
C708
C707
C923
1
IC911
R912
C916
C921
10
C926
C927
R711
R704
C701
R701
15
C922
C703
R702
R706
C913
L701
C915
C917
R705
C702
R971
R972
CN701
R703
1
R877
R878
C873
IC552
R807
R805
C807
D805
R804 R803
D804
1
D806
D809
D807
CN801
D808
R818
5
VA801
D801
VA802
C810
L801
R813
D810
D811
C802
R801
R808
C808
IC801
C809
R802
R816
C560
C559
5
1
R814
C805
D802
R815
C811
R810
L851
C851
R809
R811
R806
R812
C561
R851
C803
C872
C852
KN1
R817
C311
R303
14
65
R302
12
C327
R304
C312
C321
C310
10
15
C305
10
C313
C307 C303
C333 C334
FUSE
C325
10
D803
C804
15
C806
10
20
CN1931
C801
FRONT
80
90
100
110
120
130
140
150
DEH-15UB/XNUC
5
160
A
8
55
TESTIN
PCL
160
A
56
150
140
130
120
110
100
DEH-15UB/XNUC
1
90
80
SIDE B
A
150
140
1
130
B
120
110
100
90
80
70
60
50
40
30
20
10
Y
90
80
70
60
50
40
30
20
10
A
DEH-15UB/XNUC
5
57
10
R1971
S1825
40
30
S1830
20
50
S1831
S1834
C1959
LEFT
S1821
C1955
D1951
DISP
D1969
70
RIGHT
C1956
S1823
60
BACKS1832
D1954
R1987
R1972
S1840
45
C1960
40
V1801
25
C1961
S1837 C1964
25
30
35
40
10
20
130
15
C1963
120
S1836
10
110
C1962
15
100
S1839
20
90
D1975
80
S1838
30
SEGMENT LCD
35
140
S1835
150
C1965
160
JA1921
AUX
CN1911
USB
IC1941
40
30
20
10
10
BAND/ESC
S1824
S1827
R1954
Q1952
20
D1981
D1958
C1957
S1833 C1952
50
15
R1955
R1974
EQ
MULTI-CONTROL
R1805
R1990
R1993
10
R1806
R1975
R1957
S1826
55
R1807 R1808
R1981
R1823
R1960
Q1953
R1962
R1961
R1977
30
S1829
60
LIST
X1801
S1828
R1822
S1842
R1982
R1803
SRC
IC1801
D1956
C1806
R1963
R1965
C1954
R1969
R1942
R1941
C1807
R1952
S1841
D1976
R1951
R1968 R1966
R1976
D1970
R1970
R1983
L1911
R1804
L1801
S1822
D1980
D1911
80
R1980
R1967
C1958
D1959
D1971
75
R1988
R1985
R1978
R1964
10
40
D1966
D1912
70
R1801
20
R1958 R1959
30
R1979
40
3
Q1951
D1931 D1932
50
CN1931
D1960
D1972
L1803
C1953
R1921
D1974
60
EJECT
C1912 1
65
D1973
C1911
D1961
L1802
D1962
70
D1967
D1963
80
1
D1977
90
D1964
100
58
C1951
D1952
D1978
110
D
D1965
R1923 R1922
D1979
L1804
120
B
1
1
130
D1955
D1968
D1953
5
140
E
4
150
C
3
55
1
2
SIDE A
160
KEYBOARD UNIT
50
45
1
4
2
1
1
R1943
C1941
R1944
D1957
20
R1802
R1989
R1973
R1984
R1932
R1986
R1931
R1956
R1953
DEH-15UB/XNUC
CN801
DEH-15UB/XNUC
5
59
SIDE A
60
B
CN101
15
10
R246
R232
M2
LOADING/CARRIAGE
MOTOR
R254
TH201
C235
HOME
C102
S901
C201
50
D101
CN702
R253
R245
1 5
10
F
E
C238
R706
C240
C205
C710
R297
C299
40
C707
R701
C220
C705
R702
M1
SPINDLE
MOTOR
30
D
CN701
15
10
CN701
C702
20
C307
R710
C701
C308
C312
R306
R303
R304
R201
R308
REFO1
10
IC301
10
R307
R305
R301
R302
R264
R202
15
20
25
C306
R309
0
F
10
20
30
40
50
C
60
DEH-15UB/XNUC
1
SIDE B
A
60
R101
R103
R102
C104
Q102
R108
Q101
E
C202
E
X201
1
50
R109
R294
C203
C239
C209
15
20
25
R240
90
85
R291
C218
R218
R216
R229
C219
45
C283
R292
C204
C222
IC201
40
C281
C282
C301
40
R293 R282
R283 R281
35
C284
95
C223
80
Q201
30
C211
C101
C111
C236
C229
R296
C110
C224
100
10
C210
C233
R237
C225
1
C217
C228
R217
C216
C221
50
55
60
65
70
75
30
R215
R214
C215
C212
R709
R708
R260
D
S905
C708
C214
C213
20
R711
C703
1
C305
C304
C302
C303
C313
C314
C315
R313
R312
R311
R310
DSCSNS
10
S903
0
50
40
30
20
10
C
DEH-15UB/XNUC
5
61
NOTE:
Parts whose parts numbers are omitted are subject to being not supplied.
The part numbers shown below indicate chip components.
Chip Resistor
RS1/_S___J,RS1/__S___J
Chip Capacitor (except for CQS.....)
CKS....., CCS....., CSZS.....
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Meaning of the figures and others in the parentheses in the parts list.
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding
PC board.
IC 301 (A, 91, 111) IC NJM2068V
The expression of the unit in this manual is shown by u instead of . Please do not make a mistake.
Circuit Symbol and No.
Part No.
A:DEH-15UB/XNUC
B:DEH-1500UB/XNEW5
C:DEH-1500UBA/XNEW5
D:DEH-1500UBB/XNEW5
E:DEH-1500UBG/XNEW5
F:DEH-1550UB/XNES
H:DEH-1590UB/XNID
Unit Number : QWM3468(A)
Unit Number : QWM3465(B,D)
Unit Number : QWM3467(C)
Unit Number : QWM3466(E)
Unit Number : QWM3469(F)
Unit Number : QWM3471(H)
Unit Name : Tuner Amp Unit
Unit Number : (A,F,H)
Unit Number : (B)
Unit Number : (C)
Unit Number : (D)
Unit Number : (E)
Unit Name : Keyboard Unit
Unit Number : CWX4023
Unit Name : CD Core Unit (S11.6STD)
A
Unit Number : QWM3468(A)
Unit Number :
Unit Number :
Unit Number :
Unit Name :
Part No.
QWM3466(E)
QWM3469(F)
QWM3471(H)
Tuner Amp Unit
MISCELLANEOUS
IC 201
IC 301
IC 401
IC 551
IC 552
(A,101,107) LSI
(A,78,142) IC
(A,150,91) IC
(A,19,111) IC
(A,106,24) IC
PM9013A
PAL011A
TDA7706
BD9876EFJ
BD2232G-G
IC 601
IC 671
IC 681
IC 801
IC 911
(A,110,77) IC
R5S726A0D216FP
(A,131,75) IC
S-80827CNMC-B8M
(A,114,94) Flash ROM Unit(A)
PEB047A8
(A,114,94) Flash ROM Unit(B,C,D,E,F,H) PEB046A8
(A,104,18) L-MOS And Gate TC7SET08FUS1
(A,145,28) IC
BA49183-V12
IC 961
Q 251
Q 252
Q 301
Q 302
Q 601
Q 751
(A,131,110) IC
TPD1052F
(A,13,130) Chip Transistor(H) RN1910
(A,23,131) Chip Transistor RN1910
(A,87,125) Chip Transistor RN4983
(A,127,104) Transistor
LTC014YEB
(A,93,68) Transistor
LTC014YEB
(A,142,139) Transistor
2SD2396
Q
Q
Q
Q
Q
Q
752
873
874
875
941
951
D
D
D
D
D
301
302
401
402
551
(A,102,125) Diode
(A,90,121) Diode
(A,158,107) Diode
(A,158,100) Diode
(A,22,124) Diode
CRG03
CRG03
RN731VN
RN731VN
CMS03
D
D
D
D
D
552
751
802
803
804
(A,22,104) Diode
(A,138,135) Diode
(A,92,17) Diode
(A,126,15) Diode
(A,119,14) Diode
RB056L-40
RKZ8.2KG(B2)
DZ2S068C
DZ2S068C
DZ2S068C
DEH-15UB/XNUC
1
Part No.
D
D
D
D
D
805
806
807
871
901
(A,120,14) Diode
(A,116,13) Diode
(A,113,13) Diode
(A,148,61) Diode
(A,141,127) Diode
DZ2S068C
DZ2S068C
DZ2S068C
RKZ7.5KG(B2)
1SR154-400
D
D
D
D
902
911
912
941
(A,137,127) Diode
(A,158,66) Diode
(A,161,66) Diode
(A,93,125) Diode(A,F,H)
(A,93,125) Diode(B,C,D,E)
1SR154-400
CRG03
CRG03
HZU7L(A1)
HZU7L(C3)
D
L
L
L
L
951
202
401
402
403
(A,123,113) Diode(B,D,E)
(A,94,102) Inductor
(A,155,104) Chip Coil
(A,159,104) Chip Coil
(A,151,102) Inductor
1SS301
CTF1793
LCTAWR27J2520
LCTAWR15J2520
CTF1786
L
L
L
L
L
404
405
406
407
408
(A,146,102)
(A,151,108)
(A,147,105)
(A,147,107)
(A,141,104)
(A,141,104)
302
303
304
305
306
(A,82,125)
(A,73,127)
(A,78,126)
(A,88,127)
(A,89,129)
RS1/16SS471J
RS1/16SS471J
RS1/16SS471J
RS1/16SS103J
RS1/16SS102J
R
R
R
R
R
309
311
312
401
402
(A,86,121)
(A,86,123)
(A,99,129)
(A,161,106)
(A,161,100)
RS1/16SS103J
RS1/16SS473J
RS1/16SS103J
RS1/16SS221J
RS1/16SS751J
(A,139,104) (A,B,C,D,E)
(A,139,104) (F,H)
(A,142,99)
(A,154,108)
(A,139,96)
RS1/16SS391J
RS1/16SS331J
RS1/16SS105J
RS1/16SS105J
RS1/16SS330J
(A,137,97)
(A,137,97)
(A,144,98)
(A,141,91)
(A,138,91)
(A,138,91)
RS1/16SS471J
RS1/16SS361J
RS1/16SS0R0J
RS1/16SS0R0J
RS1/16SS681J
RS1/16SS391J
R 404
R 406
R 407
R 408
Inductor
CTF1786
Inductor(A)
LCYB68NJ1608
Inductor(A,B,C,D,E) CTF1389
Chip Coil(F,H)
LCTAWR27J2520
Inductor(A,B,C,D,E) LCTAW4R7J2520
Chip Coil(F,H)
LCTAW1R5J2520
L
L
L
L
413
414
419
420
L
L
L
L
X
X
551
801
901
951
401
601
(A,30,107) Inductor
CTH1524
(A,115,17) Inductor
CTF1713
(A,112,141) Choke Coil 600 uH CTH1432
(A,122,116) Chip Coil(B,D,E) BTH1101
(A,161,88) Crystal Resonator 36.48 MHz CSS1848
(A,126,76) Crystal Resonator 12 MHz
CSS1847
X 602
> P251
P 402
VA801
VA802
CN701
CN801
JA251
JA401
JA891
JA901
>
(A,114,32) Connector
VKN1192
(A,109,4) Connector
CKS6452
(A,19,138) Pin Jack(A,B,C,D,E,F) CKB1056
(A,19,138) Pin Jack(H)
CKB1099
(A,158,129) Antenna Jack YKS5041
(A,42,138) Jack(B,D,E,F,H)
CKS6437
(A,113,141) Connector
CKM1613
Fuse 10 A
YEK5001
RESISTORS
R
R
R
R
251
252
253
254
(A,18,131) (H)
(A,9,132) (H)
(A,15,131) (H)
(A,11,131) (H)
RS1/16SS821J
RS1/16SS821J
RS1/16SS223J
RS1/16SS223J
R
R
R
R
R
255
256
257
258
301
(A,29,132)
(A,19,131)
(A,28,131)
(A,21,131)
(A,68,127)
RS1/16SS821J
RS1/16SS821J
RS1/16SS223J
RS1/16SS223J
RS1/16SS471J
R 409
R 410
R 411
(A,B,C,D,E)
(F,H)
(F,H)
(A,B,C,D,E)
(F,H)
R
R
R
R
R
412
413
414
415
539
(A,152,78)
(A,158,78)
(A,139,87)
(A,152,80) (A,F,H)
(A,97,83)
RS1/4SA8R2J
RS1/4SA8R2J
RS1/16SS0R0J
RS1/16SS0R0J
RS1/16SS473J
R
R
R
R
R
540
551
552
553
554
(A,97,85)
(A,25,111)
(A,30,112)
(A,27,112)
(A,27,110)
RS1/16SS473J
RS1/16SS682J
RS1/16SS0R0J
RS1/16SS1803D
RS1/16SS4302D
R
R
R
R
R
555
601
602
604
609
(A,39,124)
(A,101,66) (B,C,D,E,F)
(A,107,63)
(A,116,59) (B,D,E)
(A,122,64)
RS1/10SR471J
RS1/16SS473J
RS1/16SS473J
RS1/16SS473J
RS1/16SS473J
R
R
R
R
R
610
611
613
614
615
(A,122,70)
(A,124,72)
(A,121,76)
(A,122,78)
(A,130,79)
RS1/16SS473J
RS1/16SS473J
RS1/16SS152J
RS1/16SS473J
RS1/16SS473J
R 616
R 617
R 618
(A,125,68)
(A,131,81)
(A,125,82) (A,E)
(A,125,82) (B,C,D,H)
RS1/16SS473J
RS1/16SS103J
RS1/16SS103J
RS1/16SS473J
R 619
R 622
R 623
(A,126,82) (A,E,F)
(A,126,82) (C)
(A,125,87)
(A,130,85)
RS1/16SS473J
RS1/16SS223J
RS1/16SS473J
RAB4CQ473J
R
R
R
R
625
626
627
628
(A,114,90)
(A,113,90)
(A,112,88)
(A,111,90)
RS1/16SS101J
RS1/16SS101J
RS1/16SS101J
RS1/16SS101J
R
R
R
R
R
629
630
631
632
633
(A,109,92)
(A,110,89)
(A,107,92)
(A,105,91)
(A,107,90)
RS1/16SS101J
RS1/16SS101J
RS1/16SS473J
RS1/16SS473J
RS1/16SS101J
R 634
R 635
(A,103,88)
(A,102,88)
RS1/16SS102J
RS1/16SS102J
DEH-15UB/XNUC
5
Part No.
R
R
R
R
R
R 403
L 409
L 410
63
Part No.
R 636
R 637
R 638
(A,100,91)
(A,100,90)
(A,104,92)
RS1/16SS473J
RS1/16SS473J
RS1/16SS473J
R
R
R
R
R
639
640
643
644
645
(A,97,91)
(A,98,91)
(A,99,82)
(A,98,79)
(A,95,79)
RS1/16SS472J
RS1/16SS472J
RS1/16SS104J
RS1/16SS101J
RS1/16SS101J
R
R
R
R
R
646
647
648
649
650
(A,92,75)
(A,98,78)
(A,95,76)
(A,95,75)
(A,95,74)
RS1/16SS103J
RS1/16SS101J
RS1/16SS102J
RS1/16SS102J
RS1/16SS102J
R
R
R
R
R
R
R
R
651
652
653
659
660
661
662
663
(A,97,71)
(A,98,69)
(A,100,66)
(A,123,61)
(A,123,60)
(A,100,65) (H)
(A,102,61) (B,C,D,E,F)
(A,102,62) (H)
RS1/16SS473J
RS1/16SS222J
RS1/16SS103J
RS1/16SS153J
RS1/16SS153J
RS1/16SS473J
RS1/16SS473J
RS1/16SS473J
R
R
R
R
R
R
R
664
668
669
671
681
682
683
(A,133,62)
(A,93,71)
(A,95,69)
(A,128,70)
(A,109,97)
(A,110,91)
(A,120,92)
RS1/16SS103J
RS1/16SS473J
RS1/16SS473J
RS1/16SS104J
RS1/16SS473J
RS1/16SS473J
RS1/16SS473J
R
R
R
R
R
684
685
701
702
703
(A,109,94)
(A,120,96)
(A,108,38)
(A,115,37)
(A,118,28)
RS1/16SS473J
RS1/16SS473J
RS1/16SS473J
RS1/16SS104J
RAB4CQ472J
R
R
R
R
R
704
706
707
708
709
(A,110,41)
(A,108,36)
(A,109,38)
(A,110,38)
(A,111,38)
RS1/16SS104J
RS1/16SS221J
RS1/16SS221J
RS1/16SS101J
RS1/16SS221J
R
R
R
R
R
710
711
715
716
717
(A,112,38)
(A,114,39)
(A,116,36)
(A,117,36)
(A,119,36)
RS1/16SS101J
RS1/16SS102J
RS1/16SS151J
RS1/16SS151J
RS1/16SS151J
R
R
R
R
R
718
719
752
753
754
(A,122,36)
(A,121,36)
(A,145,135)
(A,127,91)
(A,127,92)
RS1/16SS221J
RS1/16SS104J
RS1/10SR821J
RS1/16SS473J
RS1/16SS103J
R
R
R
R
R
801
803
804
805
806
(A,124,22)
(A,121,17)
(A,118,17)
(A,121,19)
(A,118,20)
RS1/10SR222J
RS1/16SS223J
RS1/16SS223J
RS1/10SR101J
RS1/10SR101J
R
R
R
R
R
807
808
809
810
813
(A,119,20)
(A,124,20)
(A,115,21)
(A,114,21)
(A,107,16)
RS1/10SR101J
RS1/10SR222J
RS1/10SR220J
RS1/10SR220J
RS1/10SR222J
R 814
R 815
R 816
(A,101,19)
(A,100,19)
(A,96,19)
RS1/10SR222J
RS1/16SS822J
RS1/10SR222J
64
Part No.
R 817
R 818
(A,95,19)
(A,104,13)
RS1/10SR222J
RS1/10SR0R0J
R
R
R
R
851
874
875
877
(A,93,20)
(A,147,58)
(A,149,58)
(A,121,27)
RS1/16SS472J
RS1/10SR391J
RS1/10SR473J
RS1/16SS1R0J
R
R
R
R
R
R
878
879
891
892
911
912
(A,124,26)
(A,156,67)
(A,58,138) (B,D,E,F,H)
(A,58,136) (B,D,E,F,H)
(A,145,40)
(A,141,41)
RS1/10SR473J
RS1/10SR122J
RS1/16SS102J
RS1/16SS102J
RS1/10SR1R0J
RS1/10SR1R0J
R 944
(A,94,121)
(A,94,122)
(A,95,125) (A,F,H)
(A,95,125) (B,C,D,E)
(A,98,123)
RS1/16SS223J
RS1/16SS473J
RS1/16SS472J
RS1/16SS473J
RS1/4SA102J
R
R
R
R
R
(A,126,115) (B,D,E)
(A,121,111) (B,D,E)
(A,125,115) (B,D,E)
(A,127,112)
(A,130,113)
RS1/16SS102J
RS1/16SS223J
RS1/16SS153J
RS1/16SS103J
RS1/16SS103J
(A,129,112)
RS1/16SS105J
R 941
R 942
R 943
951
952
953
961
962
R 963
CAPACITORS
C
C
C
C
C
201
202
203
204
205
(A,96,115)
(A,104,116)
(A,92,116)
(A,107,115)
(A,94,116)
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
C
C
C
C
C
206
207
208
209
212
(A,107,114)
(A,94,108)
(A,94,106)
(A,93,104) 10 uF
(A,108,109) 10 uF
CKSRYB105K10
CKSSYB104K10
CKSSYB104K10
CCG1192
CCG1192
C
C
C
C
C
213
214
215
216
217
(A,108,106)
(A,108,104)
(A,108,102)
(A,92,101) 10 uF
(A,95,100)
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CCG1192
CKSSYB104K10
C
C
C
C
C
218
219
220
223
224
(A,114,109)
(A,112,103) 10 uF
(A,106,98) 10 uF
(A,91,101)
(A,115,103)
XCEVW470M16
CCG1192
CCG1192
CKSSYB102K50
CKSSYB104K10
C
C
C
C
229
236
251
252
(A,110,112)
(A,110,104)
(A,35,128) 4.7 uF(H)
(A,17,127) 4.7 uF(H)
CKSSYB102K50
CKSRYB105K10
CCG1201
CCG1201
C
C
C
C
253
254
255
256
(A,17,130)
(A,10,130)
(A,35,132)
(A,30,130)
CCSSCH101J50
CCSSCH101J50
CCG1201
CCG1201
C 257
C 258
C 261
(H)
(H)
4.7 uF
4.7 uF
(A,26,131)
(A,20,131)
(A,6,133) (A,F)
(A,6,133) (B,C,D,E,H)
(A,69,129)
(A,80,129)
C 301
C 303
CCSSCH101J50
CCSSCH101J50
CCSSCH101J50
CKSSYB102K50
CKSRYB224K16
CKSRYB224K16
DEH-15UB/XNUC
1
305
307
313
314
317
(A,72,129)
(A,77,129)
(A,83,130)
(A,135,126)
(A,60,129)
CKSRYB224K16
CKSRYB224K16
CKSRYB105K16
CKSRYB104K16
XCEVW100M16
C
C
C
C
C
322
327
402
403
405
(A,104,126)
(A,87,129)
(A,155,101)
(A,152,102)
(A,162,101)
CKSRYB104K16
CKSRYB105K16
CKSSYB103K16
CKSRYB105K10
CKSSYB103K16
C
C
C
C
C
406
408
409
410
411
(A,160,101)
(A,161,105)
(A,156,105)
(A,155,107)
(A,148,99)
CKSSYB103K16
CKSSYB103K16
CCSSCH6R0D50
CCSSCH330J50
CKSSYB103K16
C
C
C
C
C
412
413
414
415
416
(A,148,101)
(A,150,101)
(A,145,100)
(A,144,101) 10 uF
(A,147,100)
CKSSYB104K10
CKSSYB104K10
CKSSYB103K16
CCG1192
CKSSYB104K10
C
C
C
C
C
418
419
420
421
423
(A,142,101)
(A,146,110)
(A,150,106)
(A,154,111)
(A,144,106)
CKSSYB223K16
CCSSCH150J50
CKSSYB103K16
CCSSCJ3R0C50
CCSSCH8R0D50
C
C
C
C
C
424
425
426
427
428
(A,140,101)
(A,138,99) 10 uF
(A,139,97)
(A,144,97)
(A,137,96) (A,B,C,D,E)
(A,137,96) (F,H)
CKSSYB103K16
CCG1192
CKSSYB104K10
CKSSYB104K10
CCSSCH101J50
CCSSCH220J50
C 433
(A,136,96)
(A,139,90)
(A,138,92)
(A,138,92)
(A,136,91)
CKSSYB103K16
DCH1246
CCSSCH820J50
CCSSCK2R0C50
DCH1246
C
C
C
C
C
C
435
436
439
440
441
442
(A,139,86)
(A,140,84) (F,H)
(A,145,80) (F,H)
(A,142,86)
(A,137,89) (A)
(A,146,83)
CKSRYB474K10
CKSSYB104K10
CKSRYB104K16
CKSSYB102K50
CCSSCH100D50
CKSSYB104K10
C
C
C
C
C
C
444
445
447
448
449
450
(A,152,82) 2.2 uF
(A,156,82)
(A,157,83) 2.2 uF(F,H)
(A,158,85) (A,B,C,D,E)
(A,161,85)
(A,161,90)
CCG1218
CKSSYB104K10
CCG1218
CKSSYB104K10
CCSSCH9R0D50
CCSSCH9R0D50
C
C
C
C
C
451
452
453
455
456
(A,158,91)
(A,158,94)
(A,160,96)
(A,158,97)
(A,161,92)
CKSSYB104K10
CKSRYB105K10
CKSSYB104K10
CKSRYB224K16
CKSSYB472K25
C
C
C
C
C
C
457
461
551
552
553
555
(A,161,93)
(A,145,104)
(A,13,121)
(A,13,107)
(A,15,110)
(A,25,112)
CKSSYB472K25
CKSSYB104K16
XCEVW221M16
CKSRYB105K16
CKSSYB103K16
CKSSYB682K25
(A,32,120)
CEVQW221M6R3
C 429
C 430
C 432
C 556
(F,H)
(B,C,D,E,F,H)
(A)
(F,H)
1 uF(A)
(A,B,C,D,E)
(F,H)
1 uF(A)
Part No.
Part No.
C
C
C
C
557
560
561
564
(A,32,116)
(A,108,21)
(A,102,23)
(A,32,114) 4.7 uF
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CCG1201
C
C
C
C
C
565
601
602
603
604
(A,15,107) 4.7 uF
(A,104,66)
(A,109,65)
(A,111,65)
(A,112,65)
CCG1222
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
C
C
C
C
C
605
606
607
608
609
(A,116,65)
(A,122,71)
(A,126,73)
(A,126,78)
(A,121,73)
CKSSYB104K10
CKSSYB104K10
CCSSCH120J50
CCSSCH120J50
CKSSYB104K10
C
C
C
C
C
610
611
612
613
620
(A,121,75)
(A,122,77)
(A,122,82)
(A,123,82)
(A,114,88)
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
C
C
C
C
C
621
622
623
624
625
(A,108,88)
(A,105,93)
(A,106,88)
(A,105,88)
(A,104,90)
CKSSYB104K10
CCSSCH220J50
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
C
C
C
C
C
626
627
628
629
630
(A,100,80)
(A,97,81)
(A,95,81)
(A,99,75)
(A,99,73)
CKSSYB104K10
CCSSCH220J50
CCSSCH220J50
CKSSYB104K10
CKSSYB104K10
C
C
C
C
C
631
672
681
683
701
(A,96,77)
(A,132,71)
(A,121,96)
(A,120,94)
(A,111,41)
CCSSCH220J50
CKSRYB105K10
CKSSYB104K10
CCSSCJ3R0C50
CKSSYB103K16
C
C
C
C
C
704
705
706
752
753
(A,120,39)
(A,118,38)
(A,116,38)
(A,141,135)
(A,147,131) 10 uF
CCSSCH100D50
CCSSCH100D50
CCSSCH100D50
CKSSYB104K10
CCG1192
C
C
C
C
C
801
806
807
808
809
(A,124,6)
(A,125,8)
(A,122,14)
(A,108,19)
(A,96,16)
CKSRYB221K50
CKSRYB104K16
CKSRYB105K10
CKSRYB104K16
CCSRCH221J50
C
C
C
C
C
C
C
810
811
871
873
891
892
901
(A,96,13)
(A,104,20)
(A,153,62)
(A,124,24)
(A,52,138) (B,D,E,F,H)
(A,34,139) (B,D,E,F,H)
(A,133,124) 2 200 uF/16 V
CCSRCH221J50
CKSSYB104K10
CKSSYB104K16
CKSRYB104K16
CKSRYB104K16
CKSRYB104K16
CCH2040
C
C
C
C
C
912
913
914
915
916
(A,152,40)
(A,131,43)
(A,156,56) 1 000 uF/16 V
(A,132,42)
(A,146,43) 4.7 uF
CKSSYB102K50
CKSSYB102K50
CCH2024
CKSRYB104K16
CCG1201
C
C
C
C
C
917
919
921
923
926
(A,145,46)
(A,151,42)
(A,135,42)
(A,159,41)
(A,140,44)
CKSSYB102K50
CCG1201
CCG1201
CCG1201
CCG1201
DEH-15UB/XNUC
5
4.7 uF
4.7 uF
4.7 uF
4.7 uF
65
Part No.
C
C
C
C
C
C
927
941
961
962
966
969
(A,139,42)
(A,96,124)
(A,126,107)
(A,132,107)
(A,128,112)
(A,135,113) 22 uF
CKSSYB102K50
CKSRYB104K16
CKSSYB104K16
CKSSYB104K16
CKSSYB333K16
DCH1256
B
Unit Number : (A,F,H)
B
Unit Number :
Unit Number :
Unit Number :
Unit Number :
Unit Name :
(B)
(C)
(D)
(E)
Keyboard Unit
L 1802
L 1803
L 1804
X 1801
S 1830
CN1911
CN1931
(B,139,6) Inductor
CTF1389
(B,70,25) Ceramic Resonator 5.00 MHz CSS1547
(A,37,20) Encoder(MULTI-CONTROL) CSD1168
(A,156,25) Connector
CKS6443
(B,109,10) Connector
CKS6451
JA1921
V 1801
(A,155,9) Jack
CKN1094
(A,142,32) Segment LCD(A,B,C,E,F,H) CAW2024
(A,142,32) Segment LCD(D) CAW2027
D 1981
IC 1801
IC 1941
D 1951
D 1952
D 1953
(B,85,23) IC
PD6583A8
(A,157,39) Remote IC(A,F,H) GP1UXC14RK
(A,65,22) White LED
SWBA05(FI231718)
(A,18,32) LED(E)
SML-D12P8W(KL)
(A,53,31) LED(E)
SML-D12P8W(KL)
R
R
R
R
R
1801
1802
1803
1804
1805
(B,82,13)
(B,73,20)
(B,75,24)
(B,75,22)
(B,58,29)
RS1/10SR473J
RS1/10SR473J
RS1/10SR222J
RS1/10SR0R0J
RS1/10SR473J
D
D
D
D
D
1954
1955
1956
1957
1958
(A,55,20) LED(E)
(A,5,38) LED(E)
(A,68,6) LED(E)
(A,79,6) LED(E)
(A,12,21) LED(E)
SML-D12P8W(KL)
SML-D12P8W(KL)
SML-D12P8W(KL)
SML-D12P8W(KL)
SML-D12P8W(KL)
D
D
D
D
D
1959
1960
1961
1962
1963
(A,18,9) LED(E)
(A,54,8) LED(E)
(A,90,6) LED(E)
(A,101,6) LED(E)
(A,112,6) LED(E)
SML-D12P8W(KL)
SML-D12P8W(KL)
SML-D12P8W(KL)
SML-D12P8W(KL)
SML-D12P8W(KL)
R
R
R
R
R
R
R
1806
1807
1808
1823
1931
1932
1941
(B,60,30)
(B,60,31)
(B,58,32)
(B,50,23)
(B,43,11)
(B,45,11)
(B,128,25) (B,C,D,E)
RS1/10SR473J
RS1/10SR473J
RS1/10SR473J
RS1/10SR273J
RS1/10SR222J
RS1/10SR222J
RS1/10SR473J
D
D
D
D
1964
1965
1966
1967
(A,123,6) LED(E)
SML-D12P8W(KL)
(A,133,6) LED(E)
SML-D12P8W(KL)
(A,144,6) LED(E)
SML-D12P8W(KL)
(A,17,31) LED(Red) (A,B,D,F,H) SML-D12V8W(PQ)
(A,17,31) LED(C)
SML-D12D8W(RS)
R
R
R
R
R
R
1944
1951
1952
1953
1954
1956
(B,133,27) (A,F,H)
(B,56,16)
(B,56,18)
(B,17,27) (E)
(B,12,34) (E)
(B,19,26) (E)
RS1/10SR101J
RS1/4SA221J
RS1/4SA221J
RS1/4SA561J
RS1/10SR182J
RS1/4SA681J
D 1968
R
R
R
R
R
R
1958
1960
1962
1963
1965
1967
(B,24,7) (E)
(B,20,20) (E)
(B,11,10) (E)
(B,19,18) (E)
(B,22,16) (E)
(B,21,12) (E)
RS1/4SA681J
RS1/4SA391J
RS1/10SR0R0J
RS1/10SR182J
RS1/4SA681J
RS1/4SA681J
(B,145,19) (E)
(B,11,32) (A,B,D,F,H)
(B,11,32) (C)
(B,52,16) (A,B,D,F,H)
(B,52,16) (C)
RS1/4SA681J
RS1/4SA681J
RS1/4SA821J
RS1/4SA102J
RS1/4SA222J
(B,16,13)
(B,16,13)
(B,24,10)
(B,24,10)
(B,56,13)
(B,56,13)
RS1/4SA681J
RS1/4SA821J
RS1/4SA821J
RS1/4SA182J
RS1/4SA102J
RS1/4SA182J
D 1969
D 1970
D 1971
E
SML-D12D8W(RS)
RESISTORS
MISCELLANEOUS
D 1980
Part No.
D 1972
D 1973
D 1974
D 1975
D 1976
D 1977
F
D 1978
D 1979
66
R 1969
R 1971
R 1973
R 1980
R 1976
R 1978
R 1982
R 1984
R 1989
R 1990
R 1993
(A,B,D,F,H)
(C)
(A,B,D,F,H)
(C)
(A,B,D,F,H)
(C)
(B,143,19) (A,B,D,F,H)
(B,143,19) (C)
(B,47,10) (E)
(B,54,9) (A,B,C,D,F,H)
(B,19,22) (A,B,D,F,H)
(B,19,22) (C)
RS1/4SA102J
RS1/4SA222J
RS1/10SR0R0J
RS1/10SR0R0J
RS1/4SA821J
RS1/4SA122J
(B,14,18) (A,B,C,D,F,H)
RS1/10SR0R0J
DEH-15UB/XNUC
1
1806
1807
1911
1912
1941
(B,66,23)
(B,71,20)
(B,148,21)
(B,144,23)
(B,137,30) 10 uF(A,F,H)
Part No.
CKSRYB104K16
CKSRYB105K10
CKSRYB104K16
CKSRYB104K16
CCG1192
C
Unit Number : CWX4023
Unit Name
MISCELLANEOUS
Part No.
R
R
R
R
R
308
309
310
311
312
(A,25,11)
(A,35,6)
(B,30,9)
(B,30,10)
(B,30,11)
RS1/16SS472J
RS1/16SS473J
RS1/16SS472J
RS1/16SS472J
RS1/16SS472J
R
R
R
R
R
313
701
702
706
708
(B,30,12)
(A,21,38)
(A,23,38)
(A,32,42)
(B,28,26)
RS1/16SS472J
RS1/16SS101J
RS1/16SS101J
RS1/16SS221J
RS1/16SS0R0J
R 709
(B,29,28)
RS1/16SS0R0J
CAPACITORS
B
IC 201
IC 301
Q 101
Q 102
X 201
(B,23,37) IC
PE5791A
(A,37,11) IC
BD8223EFV
(B,11,53) Transistor
2SA1577
(B,15,54) Transistor
LTA123JUB
(B,25,49) Ceramic Resonator 16.934 MHz CSS1603
C
C
C
C
C
104
203
209
210
211
(B,12,57)
(B,22,47)
(B,28,47)
(B,33,43)
(B,33,41)
CKSQYB475K6R3
CKSSYB104K10
CKSRYB104K16
CKSSYB104K10
CKSSYB104K10
S 901
S 903
CN101
CN701
(A,42,53)
(B,21,12)
(A,16,58)
(A,25,29)
C
C
C
C
C
212
213
214
215
216
(B,22,28)
(B,18,26)
(B,17,26)
(B,19,28)
(B,12,33)
CKSSYB104K10
CKSSYB332K50
CKSSYB473K16
CKSSYB104K10
CKSSYB182K50
C
C
C
C
C
217
218
219
220
221
(B,10,34)
(B,10,36)
(B,14,34)
(A,18,38)
(B,14,32)
CCSSCH560J50
CCSSCH4R0C50
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
C
C
C
C
C
222
223
224
225
228
(B,13,37)
(B,12,42)
(B,13,45)
(B,13,46)
(B,10,33)
CKSSYB104K10
CCSSCH680J50
CCSSCH470J50
CKSSYB103K16
CCSSCH270J50
C
C
C
C
C
229
233
236
238
299
(B,9,40)
(B,32,46)
(B,8,40)
(A,25,44)
(A,26,41)
CKSSYB104K10
CKSSYB103K16
CKSSYB104K10
CKSRYB104K16
CKSSYB104K10
C
C
C
C
C
302
303
304
305
306
(B,28,12)
(B,29,12)
(B,27,12)
(B,26,12)
(A,31,7)
CKSSYB102K50
CKSSYB102K50
CKSSYB223K16
CKSSYB104K10
CKSSYB104K10
C 307
C 308
C 710
(A,41,19)
(A,31,15)
(A,34,42)
CKSRYB105K10
CKSRYB105K10
CKSSYB102K50
RESISTORS
R
R
R
R
R
101
102
103
108
109
(B,6,57)
(B,8,57)
(B,9,57)
(B,18,55)
(B,12,50)
RS1/10SR2R4J
RS1/10SR2R4J
RS1/10SR2R7J
RS1/16SS105J
RS1/16SS222J
R
R
R
R
R
201
202
214
215
216
(A,24,11)
(A,23,9)
(B,18,28)
(B,17,28)
(B,12,35)
RS1/16SS0R0J
RS1/16SS0R0J
RS1/16SS103J
RS1/16SS393J
RS1/16SS122J
R
R
R
R
R
217
218
229
232
237
(B,10,32)
(B,10,35)
(B,12,34)
(A,31,54)
(B,33,45)
RS1/16SS562J
RS1/16SS472J
RS1/16SS471J
RS1/16SS0R0J
RS1/16SS221J
R
R
R
R
R
240
245
254
260
264
(B,34,40)
(A,34,46)
(A,37,56)
(B,30,27)
(A,22,9)
RS1/16SS473J
RS1/16SS104J
RS1/16SS104J
RS1/16SS103J
RS1/16SS102J
R
R
R
R
R
281
282
283
291
292
(B,33,38)
(B,33,39)
(B,35,38)
(B,33,34)
(B,33,36)
RS1/16SS560J
RS1/16SS560J
RS1/16SS0R0J
RS1/16SS560J
RS1/16SS0R0J
R
R
R
R
R
293
294
296
301
302
(B,35,39)
(B,27,48)
(B,34,43)
(A,27,9)
(A,28,9)
RS1/16SS0R0J
RS1/16SS471J
RS1/16SS0R0J
RS1/16SS0R0J
RS1/16SS0R0J
R
R
R
R
R
303
304
305
306
307
(A,27,11)
(A,28,11)
(A,26,9)
(A,26,11)
(A,25,9)
RS1/16SS123J
RS1/16SS123J
RS1/16SS102J
RS1/16SS472J
RS1/16SS102J
Pickup Unit(P10.6)(Service)
CXX3556
Motor Unit(SPDL)
CXE2273
Motor Unit(LOAD/CRG)
CXC4026
DEH-15UB/XNUC
5
67