Escolar Documentos
Profissional Documentos
Cultura Documentos
, LTD
INSTRUCTION ASSEMBLY MANUAL
Specifications
Length
Wing Span
Wing Area
Weight
Radio
Engine Requirements:
1400MM(55.0in)
1520MM(59.8in)
46dm2(713sq.in)
1650g
4channel 5servo
2C- 46 4C- 61
class
Warning!
This model is not a toy.
It is designed for maximum performance. Please seek advice if one is not familiar with this kind
of engine powered precision model. Operating this model without prior preparation may cause
injuries. Remember, safety is the most important thing. Always keep this instruction manual at
hand for quick reference.
MADE IN CHINA
NEPTUNE
INDEX
BEFORE ASSEMBLY --------------------------------------------------------P.1
PARTS LIST
-------------------------------------------------------------P.2
ASSEMBLY
------------------------------------------------------------P.3P.10
SAFETY PRECAUTIONS----------------------------------------------------P.11
BEFORE ASSEMBLY
Read through this instruction manual before assembly , so you will have an overall idea of what to do.
Check all parts. If you find any defective or missing parts, contact your local dealer.
Symbols used throughout this instruction manual comprise of the following.
Must be purchased
separately!
Warning!
Do not overlook this symbol!
Engine
Vent-pipe
Glow plug
Cross Screwdriver
R/C unit
Oil filter
Receiver
Glow starter
Servo
AAA Battery
Scissors
Handy cutter
Flat-end pincers
Pincers
Porpeller
torque Starter
Oil pump
Start battery
Fuel
Carving knife
The above tools and accessories are not included in the kit. Please purchase separately.
Please comply with conventional flying practices when flying this model product. We are not able to
take precautions against all accidents caused by misuse.
P1
P2
1.
Or
Assemble the main wing joiner, glue the three pieces into one, clip and
hold until dry.
2.
Cut the covering film at the wing joining part. Glue the wing joiner to
one piece of the main wing.
3.
4
Glue the main wing float.
Pay attention that float is in alignment with wing
rib end.
Foam sticker is only used at front and back.
Do not use it excessively.
5
Assemble main wing and fuselage connecting bolt.
7
Assemble the main wing.
8.
Install
servo
P4
P5
Insert servo wire through this hole
on fuselage.
P5
Sequence:
P6
Throttle cut-off.
Hole
Install elevator servo, connect pushrod and ca- Ensure the connect pushrod moves smoothly.
bling fixer.
Install rudder.
P9
Cover type
P10
55
40
17
12
12
8
Notice
P11