Escolar Documentos
Profissional Documentos
Cultura Documentos
SKY77573- 12
MAIN_ANT
PCS
DCS
WCDMA_B5
WCDMA_B2
WCDMA_B8
WCDMA_B1
GPS_ANT
SFX836AYA02
Dup lexer
B8607
Dup lexer
SFX897AY502
Dup lexer
SFXG5 0PY702
Dup lexer
B1/ B8 PA
AWT6751
MOTOR
BATT
CONN.
VBAT
VPH_PWR
BAT_ID
R_SENS_M/ P
PM_KYPD_PWR_N
PM_RESIN_N
VPH_PWR_MOTOR
PM_VIB_DRV_N
POWER
KEY
VCAM_FLASH
LNA
RDALN16
FLASH
RF_TX_DA_3
RF_TX_DA_2
FM_ANT
BPF
WL_RFIO_5G
RFCLK1_19. 2M
PM8226
PMI C
GPS_RF_IN
RX_DCS_PCS
B2/ B5 PA
AWT6755
FILTER
SAWFD1G84AM0F0A
RX_B5_G850
OUT_B5
OUT_B2
RX_B2
RX_B8_G900
OUT_B8
OUT_B1
PDET_IN
RF_TX_DA_1
RX_B1
EARJACK
WL_BT_RFIO
DPX165950DT- 8126A1
DUPLEXER
BT/ WIFI_ANT
FI _ V5_ S UBV
VBUS_5V_IF
USB_ID
USB_DP/ DP
I F CONN.
USB_HS_DM/ DP
SSBI
19. 2Mhz
OSC
GPS_BB_RX_IP/ M
GPS_BB_RX_QP/ M
GP_DATA0
GP_DATA1
CH0_BB_TX_IP/ M
CH0_BB_TX_QP/ M
CH0_BB_RX_IP/ M
CH0_BB_RX_QP/ M
CH0_SSBI_TX_GPS
CH0_SSBI_RX
CH1_SSBI_RX
FM_DATA
FM_SSBI
BT_SSBI
BT_DATA
BT_CTL
WLAN_IM/ P
WLAN_QM/ P
WLAN_DATA0
WLAN_DATA1
WLAN_DATA2
WLAN_CLK
TSU6721YFPR
MUI C
MSM8226
AP+CP
POP MEMORY
LPDDR2
MUIC_I2C_SCL / SDA
MUIC_INT_N
19. 2M_OUT
19. 2M_IN
RFCLK1_19.2M
WTR2605
TRANCEIVER
WCN3660A
BT/ FM/ WIFI
WCSS_XO
WLAN_SET
PROXY +
LI GHT
KTD3102EUI
BLI C
8M CAMERA
Mi cr o SI M
Conn.
VOLUME KEY
HOME KEY
KPSNS0
KPSNS1
HOME_GPIO_37
Mi cr o SI M
+
SD Car d
Conn.
WCD9306
CODEC
LCD_PWM_BL
T_FLASH_D(0:3)
T_FLASH_CMD
T_FLASH_CLK
T_FLASH_DETECT_N
UIM1_CLK
UIM1_DATA
UIM1_RESET
UIM2_CLK
UIM2_DATA
UIM2_RESET
AUDIO_REF_CLK
CODEC_INT_N
COEC_RESET_N
SLIMBUS_DATA
SLIMBUS_CLK
LCD_ON
MIPI_DSI0_CLK_P_F
MIPI_DSI0_CLK_M_F
DSI_RST_N
OLED_ID
TS_I2C_SDA
TS_I2C_SCL
TS_INT_N
Magnet i c
1. 9M
VT CAMERA
Accel .
CAMERA
USB I C
MIC_BIAS_2.8V
EAR_MIC_M
EAR_MIC_P
SPK_OUT_P
SPK_OUT_N
EARSPK_L
EARSPK_L
MAIN_MIC_P
RCV_P
RCV_N
MAIN_MIC_M
MIC_BIAS1_1. 8V
LCD MODULE
( HD)
MIPI_DSI0_DATA_4LANES
MIPI_CSI1_CLK_P/ M
MIPI_CSI1_1LANE
CAM2_RST_N
CAM2_STBY_N
CAM_I2C_SCL / SDA
CAM_MCLK0
CAM_MCLK0
CAM_I2C_SCL / SDA
CAM1_RST_N
MIPI_CSI0_CLK_P/ M
MIPI_CSI0_4LANES
PROXY_INT_N
I2C_SCL
I2C_SDA
eMMC DATA( 0: 7)
MSM_RESOUT_N
EMMC_CMD
EMMC_CLK
RCV
EAR MIC
SPEAKER
EAR SPEAKER
MAIN MIC
TSP
8. Level 3 Repair
8-1
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Level 3 Repair
8-2
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-2-2. Bottom
8-3
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3. LOGIC
8-3-1. Power On
Power switch on
NG
Connect the jig box.
Check the current consum
ption
>= 100mA?
NO
Download
Yes
Check the battery
voltage
>= 3.45?
NO
NO
Yes
Check the GPIO_25
of UCP300-1 PS_H
OLD pin is 1.85V?
Yes
Check the clock at
OSC400 = 19.2MHz ?
NO
Resolder OSC400
Yes
C464(VREG_S1)=1.15V?
C465(VREG_S2)=1.15V?
C466(VREG_S3)=1.3V?
C467(VREG_S4)=2.1V?
NO
Yes
check
the initial operation
NO
Resolder or Replace UCP300
Yes
NO
END
8-4
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
AP31
GND
GND
VREG_S1_1P15
GND
AP21
AP27
Level 3 Repair
AA16
VDD_CORE
AA18
AT7
VDD_CORE
MSM_RESOUT_N
MSM_RESIN_N
MSM_PS_HOLD
VDD_CORE
AA30
VDD_CORE
AB21
PMIC_SPMI_DATA
PMIC_SPMI_CLK
RESIN_N
C34
PS_HOLD
D27
G28
GPIO_112
SPI_CS3_N_BLSP2
GPIO_114
SPI_CS2_N_BLSP3
GPIO_111
{ MPM_interrupt }
SPI_CS1_N_BLSP3
GPIO_110
{ MPM_interrupt }
// No-Pull_up //
SPI_CS1_N_BLSP2
GPIO_113
{ MPM_interrupt }
// No-Pull_up //
{ MPM_interrupt }
{ MPM_interrupt }
GPIO_69
{ MPM_interrupt }
{ MPM_interrupt }
GPIO_51
{ MPM_interrupt }
GPIO_52
{ MPM_interrupt }
MI2S_2_WS
VDD_CORE
MI2S_3_D0
AE24
// No-Pull_up //
MI2S_3_D1
R327
VDD_CORE
AE18
// No-Pull_up //
GPIO_50
VDD_CORE
AE16
{ MPM_interrupt }
VDD_CORE
AE14
{ MPM_interrupt }
AD21
MODE_0
{ MPM_interrupt }
VREG_L6_1P8
VDD_CORE
MODE_1
AU32
GPIO_67
AD15
MODE_1
MODE_0
GPIO_49
VDD_CORE
AV31
GPIO_46
AD13
VDD_CORE
MI2S_3_SCLK
VDD_CORE
AC30
GPIO_63
C2
AC24
C311
SPI_CS3_N_BLSP3
MI2S_3_WS
C24
GPIO_48
VDD_CORE
MI2S_4_D0
AC16
D25
GPIO_47
VDD_CORE
F25
C26
MI2S_4_WS
C386
CAM_ANALOG_EN
CAM_IO_EN
MOTOR_EN
VDD_CORE
C310
PMIC_SPMI_DATA
PMIC_SPMI_CLK
C387
VDD_CORE
AC14
C309
GPIO_99
RESOUT_N
D33
MI2S_1_SCLK
VDD_CORE
AB29
C308
GPIO_100
RFFE1_CLK
E32
TP_MSM_RESIN_N
MI2S_1_MCLK
VDD_CORE
AB23
AB27
RFFE1_DATA
AR6
VDD_CORE
AA24
MI2S_4_SCLK
AA22
C303
AD39
VDD_CORE
AE32
AC40
VDD_CORE
AE30
VDD_CORE
C315
C316
C317
C318
AF21
VDD_CORE
AG18
VDD_CORE
AG26
VDD_CORE
AH21
VDD_CORE
AJ14
VDD_CORE
AJ20
VDD_CORE
AJ26
VDD_CORE
AJ30
VDD_CORE
AK11
VREG_S4_2P1
VREG_L25_2P075
VREG_S3_1P3
VPH_PWR
VDD_GR1
VDD_GR2
VDD_GR3
VDD_GR4
VDD_GR5
VDD_GR6
VDD_GR7
C410
C411
C412
C413
C414
C415
C416
8-5
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Power Switch On
LCD Display
On?
LCD FPCB
connector is co
rrectly connecti
ned?
NO
Correctly connected
NO
Yes
Yes
C618
LED_P_26V=26V?
NO
Yes
CHECK
LCD DATALINE
(LCD_SDA,SCL)
NO
Yes
Replace LCD
NO
&
Replace or Resolder
D600,L602,L601,L603
8-6
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
TSP_VDD_1.8V
VCC_1.8V_LCD
VDD_TSP_2.8V
VSN_-5.0V
VSP_5.0V
R600
R601
R602
HDC600
1
3
5
7
9
11
MIPI_DSI0_DATA3_M
MIPI_DSI0_DATA3_P
MIPI_DSI0_DATA0_M
MIPI_DSI0_DATA0_P
13
15
17
19
21
23
25
27
29
31
33
MIPI_DSI0_CLK_M
MIPI_DSI0_CLK_P
MIPI_DSI0_DATA1_M
MIPI_DSI0_DATA1_P
MIPI_DSI0_DATA2_M
MIPI_DSI0_DATA2_P
LCD_PWM_BL
1
2
4
3
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
24
23
25
26
27
28
29
30
31
32
33
34
NC NCNC NC
35 36 37 38
2
4
6
8
10
12
TS_INT_N
TS_I2C_SCL
TS_I2C_SDA
14
16
18
20
22
24
26
28
30
32
34
DSI_RST_N
LED_A_20V
LED_K1
LED_K2
VGH
C604
C605
C606
C607
C647
VPH_PWR_BLU
D600
L604
L603
U608
VOUT
CTRL
C627
C622
C602
LED_K2
LED_K1
NC
NC
C3
A3
B3
R611
S1
S2
R612
B2
GND
PWM
GND
A2
C1
A1
LCD_ON
LCD_PWM_BL
LX
VIN
B1
C2
LED_A_20V
8-7
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-3-3. TSP
Operate TSP
NG
Check
TSP Connecting
NO
Reconnecting TSP
YES
Check
LCD Connecting
NO
Reconnecting LCD
YES
Check
VTOUCH_3.0V
NO
Resolder or Replace
PM400
NO
Resolder or Replace
UCP300
NO
Replace PBA
YES
Check
TSP_SCL,SDA
YES
Replace LCD
8-8
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Signal on in
SPK_OUT_P
& SPK_OUT_N?
NO
Resolder
ZD507,ZD508
C508,C527
YES
Signal on in
L506,L507 ?
NO
Resolder
NO
L506, L507
Replace PM8226
Resolder or
Replace UCP300
YES
Speaker break
down?
YES
Change Speaker
NO
Change main PBA
8-9
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
L506
SPK_OUT_P
VDD_MIC_BIAS2_2.8V
L507
SPK_OUT_N
C545
R518
HDC501
EAR_DETECT_MIC
L509
EAR_DETECT_GND
L510
EAR_MIC_3.5_P
R520
EAR_DETECT_EARLEFT
R514
1
3
5
7
9
C533
C534
R516
1
2
2
3
44
5
66
7
88
9
10 10
NC NCNCNC
11121314
ZD507
R517
FM_ANT
L511
L513
EARSPK_R
EARSPK_L
L514
C515
ZD506
R519
EAR_ADC_3.5
ZD505
L523
ZD504
C530
ZD503
C546
C529
HPH_REF
C522
C537 C538
C535
C536
R502
ZD508
L504
R523
EAR_MIC_3.5_
R513
8-10
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Receiver Working
Operate Receiver
NG
Check
ZD501,ZD502,
C524,C525
NO
Resolder or Replace
ZD501,ZD502,C524,C525
YES
Receiver break
down?
YES
Change Receiver
NO
Check
UCP300
NO
Resolder or Replace
UCP300
YES
Change main PBA
8-11
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
MIC Working
Operate MIC
NG
Pollute
MIC Hole?
YES
Clean up
MIC hole
NO
Signal on in
C501, C503,
C504?
NO
Resoldering
C501, C503, C504
YES
MIC
break down
YES
Resolder or Replace
MIC
NO
Check Voltage
of L500 Voltage
is 1.8V ?
NO
Change UCP300
YES
NO
Crash U502 IC?
YES
Change main PBA
8-12
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VDD_MIC_BIAS1_1.8V
L500
MIC500
POWER
GND1
GND2
OUT
1
2 GND
3 GND
4 OUT
MAIN_MIC_M
L521
C503
C501
ZD510
MAIN_MIC_P
C504
ZD509
R503
VDD_MIC_BIAS2_2.8V
R504
C513
R506
L502
EAR_MIC_3.5_P
EAR_MIC_P
EAR_MIC_3.5_M
EAR_MIC_M
C523
C521
8-13
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Hands-free stereo
headset
NG
YES
Button NG?
Resolder or Replace
U500,U501
NO
YES
MIC NG?
NO
Check
L507
Check U500,U501
YES
NO
Reconnect HDC501
YES
SPK NG?
Signal on
in L511 L513
NO
Resolder or Replace
L511 L513
YES
NO
Resolder or Replace
PM8226
The End
8-14
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
L506
SPK_OUT_P
L507
SPK_OUT_N
VDD_MIC_BIAS2_2.8V
C545
ZD504
C530
ZD503
C546
C529
R518
HDC501
1
3
5
7
9
EAR_DETECT_MIC
EAR_ADC_3.5
L509
EAR_DETECT_GND
L510
EAR_MIC_3.5_P
R520
EAR_DETECT_EARLEFT
R514
1
2
3
4
5
6
7
8
9
10
NC NCNCNC
11 12 13 14
R516
2
4
6
8
10
EARSPK_R
EARSPK_L
L514
C515
C533
C534
R517
FM_ANT
L511
L513
ZD507
C537
ZD506
R519
ZD505
L523
HPH_REF
C522
C538
C535
C536
R502
ZD508
L504
R523
EAR_MIC_3.5_M
R513
VDD_CODEC_BUCK_2.1V
VPH_PWR_SPKDRV
VDD_CODEC_DIG_1.2V
VDD_CODEC_IO_1.8V
VPH_PWR
C502
C506
C509
C507
C540
C541
27
35
VDD_VBAT
VDD_TX_RX
45
19
10
VDD_IO
EAROM
9
DMIC0_CLK
DMIC0_DATA
EAROP
16
21
VPS_L
VPS_R
SPK_OUT_N
SPK_OUT_P
C542
32
15
14
HPH_L
HPH_R
NCP_C1M
17
36
24
DMIC1_CLK
DMIC1_DATA
C511
2
HPH_REF
NCP_C1P
LINE_OUT1
11
NCP_VNEG
VDD_MIC_BIAS2_2.8V
LINE_OUT2
50
49
SPKR_DRVM
BUCK_VOUT1
U502
SPKR_DRVP
C543
44
53
MIC1_INM
6
12
13
C512
L501
BUCK_VSW
WCD9306
39
MAIN_MIC_M
MAIN_MIC_P
EAR_MIC_M
EAR_MIC_P
BUCK_VOUT2
34
LDO_HI_CAP
MIC1_INP
MIC2_INM
47
43
MIC2_INP
MIC_BIAS1
MIC3_INM
MIC_BIAS2
MIC3_INP
MIC_BIAS3
38
41
42
52
37
54
48
51
MIC4_INM
22
CCOMP
MIC4_INP
46
MIC5_INM
MCLK
MIC5_INP
29
MBHC_HSDET
33
MODE
20
CODEC_RESET_N
CODEC_INT_N
C514
NC
NC
TP_CODEC_INT
C516
C517
C518
CODEC_BUCK_GND
57
GND_SPKDRV
GND_SPKDRV
PMIC_AUDIO_REF_CLK
TP_CODEC_RST
INTR
56
40
GND
GND_BUCK
23
GND
GND
GND
CODEC_BUCK_GND
28
25
18
GND_CFILT
SLIMBUS_DATA
TP_SLIMBUS_DATA
55
30
RESET_N
SLIMBUS_CLK
SPKDRV_GND
TP_SLIMBUS_CLK
SLIMBUS_CLK
SLIMBUS_DATA
VDD_MIC_BIAS1_1.8V
CODEC_BUCK_GND
C544
VDD_DIG
26
L503
L508
L515
EARSPK_L
EARSPK_R
HPH_REF
VDD_BUCK
31
RCV_N
RCV_P
VDD_SPKDRV
CODEC_BUCK_GND
SPKDRV_GND
C505
8-15
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Power KEY
NG
Check the P/K
Soldering State
It is OK ?
NO
Resoldering the TAC 500
YES
Check
R510
NO
Resolder or Replace
R510
YES
Check
ON_SW
Resolder or Replace
NO
UCP300
YES
8-16
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Yes
Resolder or Replace TAC501, TAC502
NO
home Key
NG?
Yes
Resolder or Replace
R511,L505,ANT502,ANT503
Yes
NO
Yes
Replace PBA
Yes
Check LED400, LED401 is damaged
NO
Menu&Back Key
NG?
GO TO 8-3-3.TSP
8-17
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
R510
PM_KYPD_PWR_N
TAC500
PM_RESIN_N
VREG_L6_1P8
R511
L505
TAC501
OK_KEY
VOL_UP_KEY
2 2
ANT502
3
C532
C531
1 1
2
ANT503
2
VOL_DOWN_KEY
TAC502
3
C539
8-18
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Operate Vibrator
NO
Check
NO
Vibrator Motor
Yes
Check
No
Resolder or Replace
D500,L519
D500,L519
Yes
NO
VDD_MOTOR_3.3V
(L519) = 3.3V?
8-19
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VDD_FEM/GPS_2.75V
C230
U200
C235
ANT200
F202
C234
GND
EN
F203
C236
1
GPS_EXT_CTRL
IN
L206
OUT 4
GPS_RF_IN
G
G
G
22
L205
GND RFOUT
IN
OUT
RFIN
VDD
C240
C239
2
3
5
G
G
G
C233
2
3
5
C226
C243
C244
L209
C241
C245
L210
8-20
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
NG
YES
SIM601
break down ?
Change SIM601
NO
YES
2nd Pin of
SIM601
= High ?
Change SIM601
NO
1st Pin of
SIM601
= 3.0V ?
NO
Resolder or Replace
PM8226(PMIC)
YES
Check
UCP300
8-21
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VREG_L21_2P95
VDD_UIM1_3.0V
VREG_L6_1P8
VDD_UIM1_NFC
R613
R614
C629
VDD_UIM1_3.0V
VDD_TFLASH_2.95V
R618
R615
R619
R620
R621
R622
R623
SIM601
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
UIM1_RESET
UIM1_CLK
R624
NFC_SWP
UIM1_DATA
T_FLASH_D(2)
T_FLASH_D(3)
T_FLASH_CMD
T_FLASH_CLK
C636
C639
C637
C638
T_FLASH_D(0)
T_FLASH_D(1)
R630
T_FLASH_DETECT_N
C643
C644
VDD_UIM2_3.0V
R629
VDD_UIM2_3.0V
SIM600
UIM2_RESET
UIM2_CLK
S1_VCC
S2_RST
S3_CLK
S4
S5_GND
S6_VPP
S7_IO
S8
T1_DAT2
T2_CD_DAT3
T3_CMD
T4_VDD
T5_CLK
T6_VSS
T7_DAT0
T8_DAT1
G1
G2
G3
G4
G5
G6
G7
G8
DETECT
C1 C1
C5 C5
C2 C2
C6 C6
C3 C3
C7 C7
UIM2_DATA
G G G G
1 2 3 4
C640
C642
C641
U609
C644
U500
R491
R490
R493
R494
C313
HDC300
C311
C308
C316
C484
C312
C304
R608
C464
C310
D601
C354
C619
R623
R622
C303
R615
C314
R630
C317
R305
C315
C309
C318
C350
C333
C353
C332
C335
C334
JTAG_PAD
C386
C387
R619
R620
R621
SIM601
R624
SIM600
C637
TP_SLEEP_CLK
C643
TP_MSM_RESIN_N
R613
R614
C636
8-22
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
NG
NO
SIM Connector
Break down?
Change SIM600,SIM601
YES
No
R618,C639
R629,U609 = 3.0V
Check PM8226(PMIC)
YES
Resolder SIM600,SIM601
Yes
No
Check data,clk,reset line
Resolder or Replace
PM8226
Yes
Change PBA
8-23
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VREG_L21_2P95
VDD_UIM1_3.0V
VREG_L6_1P8
VDD_UIM1_NFC
R613
R614
C629
VDD_UIM1_3.0V
VDD_TFLASH_2.95V
R618
R615
R619
R620
R621
R622
R623
SIM601
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
UIM1_RESET
UIM1_CLK
R624
NFC_SWP
UIM1_DATA
T_FLASH_D(2)
T_FLASH_D(3)
T_FLASH_CMD
T_FLASH_CLK
C636
C639
C637
C638
T_FLASH_D(0)
T_FLASH_D(1)
R630
T_FLASH_DETECT_N
C643
S1_VCC
S2_RST
S3_CLK
S4
S5_GND
S6_VPP
S7_IO
S8
T1_DAT2
T2_CD_DAT3
T3_CMD
T4_VDD
T5_CLK
T6_VSS
T7_DAT0
T8_DAT1
G1
G2
G3
G4
G5
G6
G7
G8
DETECT
C644
C644
U500
R491
R490
R493
R494
C313
HDC300
C311
C308
C316
C484
C312
C304
R608
C464
C310
D601
C354
C619
R623
R622
C303
R615
C314
R630
C317
R305
C315
C309
C318
C350
C333
C353
C332
C335
C334
JTAG_PAD
C386
C387
R619
R620
R621
SIM601
R624
SIM600
C637
TP_SLEEP_CLK
C643
TP_MSM_RESIN_N
R613
R614
C636
8-24
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Camera connector
is connected correct?
NO
Re-connect
Yes
C612 = 2.8V
C613 = 2.8V
C614 = 1.8V
C616 = 1.25V
NO
Check
PM8226(PMIC)
& U600, U604(LDO)
Yes
CAM_MCLK (C605)
= 24 MHz ?
NO
Change UCP300
Yes
8-25
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VDD_CAM_IO_1.8V
VDD_CAM_SENSOR_A2.8V
VDD_CAM_CORE_1.25V
VDD_CAM_AF_2.8V
HDC602
NC 36
1
3
5
7
9
11
CAM1_RST_N
AF_SCL
CAM_I2C_SDA
13
15
17
19
21
23
25
27
29
31
33
35
MIPI_CSI0_DATA3_M
MIPI_CSI0_DATA2_P
MIPI_CSI0_CLK_P
MIPI_CSI0_DATA1_P
MIPI_CSI0_DATA0_M
CIS_SPI_SSN
CIS_SPI_MOSI
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
35
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
2
4
6
8
10
12
AF_SDA
CAM_I2C_SCL
MAIN_CAM_MCLK
MIPI_CSI0_DATA3_P
14
16
18
20
22
24
26
28
30
32
34
MIPI_CSI0_DATA2_M
MIPI_CSI0_CLK_M
MIPI_CSI0_DATA1_M
MIPI_CSI0_DATA0_P
CIS_SPI_MISO
CIS_SPI_SCLK
NC 37
C616
C612
C614
C613
D601
VDD_CAM_SENSOR_A2.8V
VPH_PWR
VDD_LDO_IO_1.8V
U600
VDD_CAM_IO_1.8V
4 VDD
HDC601
MIPI_CSI1_CLK_M
MIPI_CSI1_CLK_P
14 14
16 16
18 18
20 20
13 13
15 15
17 17
19 19
24 NC
23 NC
22 NC
21 NC
MIPI_CSI1_DATA0_M
MIPI_CSI1_DATA0_P
11
33
55
77
99
11 11
VT_CAM_MC
R626
2
GND
GND
3 CE
CAM_IO_EN
22
44
66
88
10 10
12 12
VOUT 1
R606
C632
C633
CAM_I2C_SCL
CAM_I2C_SDA
C651
TP600
CAM2_RST_N
VPH_PWR
VDD_LDO_CAM_A2.8V
U604
4 VDD
C608
VOUT 1
C610
R631
R632
C649
2
GND
3 CE
CAM_ANALOG_EN
GND
5
C648
8-26
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
Yes
Check C106 -65dBm ?
CHECK soldered
RFS100, C105,C106,L103
No
Check the Voltage at
C111 = VBAT_RF ?
No
Resolder or change
U106, C111, C112
No
Resolder or change
L128
Yes
Check L128
-65dBm ?
No
Resolder or change
F105
No
Check component soldering stat
us OK at F105 ?
Resolder or change
F105
No
No
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}& {C50 = 1.8V?}
No
Resolder or change
F105
Resolder or change
F105
Resolder or change
F105
Yes
Change
UCP300
8-27
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
NORMAL CONDITION
catch the channel?
RF INPUT : 3013CH
AMP : -50dBm
NO
Check C106 -65dBm ?
YES
CHECK soldered
RFS100, C105, C106, L103
NO
Check the Voltage at
C111 = VBAT_RF ?
NO
Resolder or change
U106, C111, C112
NO
Resolder or change
C133, C134
NO
Resolder or change
F104
YES
Check C133, C134
-65dBm ?
YES
Check component
soldering status OK at
F104
YES
NO
Resolder or change
F104
YES
Resolder or change
U102
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V ?}
YES
NO
Change or resolder
OSC400
YES
WCDMA band8/GSM900
Receiver is O.K?
NO
Resolder or change
UCP300
END
8-28
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CHECK soldered
RFS100, C105,C106,L103
NO
Check the Voltage at
C111 = VBAT_RF ?
NO
Resolder or change
U106, C111, C112
NO
Resolder or change
L106(DCS),L107(PCS)
NO
Resolder or change
F101
YES
Check L106(DCS),
L107(PCS)
-65dBm ?
YES
Check component
soldering status OK at
F101
YES
Resolder or change
F101
Resolder or change
U102
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V?}
YES
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
END
8-29
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
RFS100
VBAT_PA
1
2
3
4
C
A
G
G
V_BAT
R111
C105
C106
C108
L100
2
C107
VBAT_PA
C110
C109
C103
C111
LB_EN
HB_EN
SPDT
SPDT_IN
SPDT_OUT
19
21
38
NC
NC
SW0
SW1
MODE0
MODE1
24
28
30
40
TXM_CTL4
TXM_CTL3
39
34
33
41
PA_R0
PA_R1
42
58
57
54
55
52
53
50
51
49
56
47
48
45
46
43
23
16
C117
C119
25
17
13
12
14
10
11
22
C116
WCDMA_B2
WCDMA_B5
WCDMA_B1
WCDMA_B8
26
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
37
ANT
U106
G
G
G
G
G
G
G
35
TXM_CTL2
TXM_CTL1
RX1 [ PCS ]
RX2 [ DCS ]
20
TXM_CTL0
ANT_TD_CPL
TD_CPL_OUT
15
32
VCC
VCC
VBATT
TRX1
TRX2
TRX3
TRX4
RF_IN
18
L108
L110
44
L111
36
RF_TX_DA_1
L107
L109
29
IN1 6
10 8 7 5 4 3 2
31
1 OUT
IN2 9
C113
27
L105
L106
ANT101
C112
F101
L104
1
2
C166
L103
C104
Near WTR2605
RX_DCS_PCS
ANT100
1
R118
C114
C118
C115
C120
VDD_WTR_RF2_2.0V
VDD_WTR_RF1_1.3V
C132
C130
VDD_WTR_IO_1.8V
C146
C145
C142
C143
C141
C139
C138
C140
C137
C136
C135
C144
L133
C194
L132
C193
59
52
37
54
VDD_RF3_IO
VDD_RF2_XO
VDD_RF2_T_DA
VDD_RF2_T_PLL
VDD_RF2_R_PLL
VDD_RF2_T_VCO
40
16
19
VDD_RF2_R_BB
46
VDD_RF1_T_LO
VDD_RF1_T_PLL
39
30
20
21
26
VDD_RF1_R_VCO
RX_LB2_IN
VDD_RF1_LNA
RX_LB1_IN
VDD_RF1_R_LO
VDD_RF1_G_LO
5
10
VDD_RF1_G_PLL
RX_B8_G900
RX_B5_G850
VDD_RF1_DIG
48
31
C150
7
TX1_OUT
RF_TX_DA_1
RF_TX_DA_2
RF_TX_DA_3
TX2_OUT
RX_WB1/WB1_WB2
RX_WB2/TD
RX_DCS_PCS
6
RX_MB1_IN
TX3_OUT
9
2
RX_MB3_IN
GPS_RF_IN
GPS_BB_RX_IP
GPS_BB_RX_IM
GPS_BB_RX_QP
GPS_BB_RX_QM
12
61
RX_BB_IP
TX_BB_QP
55
18
23
RX_BB_IM
TX_BB_QM
49
43
GNSS_RF_IN
62
GNSS_BB_IP
51
R105
PDET_RFFB_IN
8
TP_SSBI_RX
56
TP_SSBI_TX_GPS
SSBI_RX
SSBI_TX_GNSS
CH0_SSBI_RX
CH0_SSBI_TX_GPS
C156
GNSS_BB_IM
13
45
RF_ON
GNSS_BB_QP
41
60
GNSS_BB_QM
RFCLK1_19.2M
XO_IN
24
CH0_TXDAC_IREF
53
58
WTR0_PDET_IN
R104
22
U102
WTR2605
RX_BB_QM
11
R103
R102
RX_BB_QP
DAC_REF
GP_DATA0
63
GP_DATA1
NC
GP_DATA2
NC
64
GND
GND
GND
GND
GND
GND
47
38
C159
50
44
42
GND
35
34
GND
GND
33
GND
GND
32
29
GND
28
27
GND
GND
GND
25
17
36
14
15
GND
57
DNC
GP_DATA0
GP_DATA1
TD_CPL_OUT
CH0_BB_TX_IP
CH0_BB_TX_IM
CH0_BB_TX_QP
CH0_BB_TX_QM
TX_BB_IP
TX_BB_IM
CH0_BB_RX_IP
CH0_BB_RX_IM
CH0_BB_RX_QP
CH0_BB_RX_QM
R115
RX_MB2_IN
3
U102
L300
C338
C124
C121
L112
C192
C122
C128
C432
R419
C129
C172
L126
F105
L131
L129
C167
C168
R113
C160
C154
C157
C155
R110
C102
8-30
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
RF INPUT : 10700CH
AMP : -50dBm
NO
Check C106 -65dBm ?
YES
CHECK soldered
RFS100,C105,C106,L103
NO
Check the Voltage at
C111 = VBAT_RF ?
NO
Resolder or change
U106, C111, C112
NO
Resolder or change
C121, C122
NO
Resolder or change
F102
YES
Check C121, C122
-65dBm ?
YES
Check component
soldering status OK at
F102
YES
NO
Resolder or change
F102
YES
Resolder or change
U102
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V ?}
YES
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
END
8-31
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
RF INPUT : 9880CH
AMP : -50dBm
NO
Check C106 -65dBm ?
YES
CHECK soldered
RFS100,C105,C106,L103
NO
Resolder or change
U106, C111, C112
NO
Resolder or change
C102, C154
NO
Resolder or change
U610
NO
Check the Voltage at
C111 = VBAT_RF ?
YES
Check C102, C154
-65dBm ?
YES
Check component
soldering status OK at
U610
YES
NO
Resolder or change
U610
YES
Resolder or change
U102
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V ?}
YES
NO
Change or resolder
OSC400
YES
WCDMA band2
Receiver is O.K?
NO
Resolder or change
UCP300
END
8-32
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VBAT_PA
C121
C122
WCDMA_B1
L112
VBAT_PA
G2
G3
G1
2
C129
C128
RX
G6
TX
C126
RX_B1
F102
7
8
C124
ANT
C127
G5
C123
C192
CPL_PDET_LOOP
14
13
12
11
10
9
WCDMA_B8
L114
C151
L118
ANT
C147
C134
C133
RFOUTHB
GND
VCC
GND
RFOUTLB
GND
TX
RX
F104
B8514
L116
RX_B8_G900
L115
2
G
4
G
5
G
7
G
8
G
GND
C149
C148
VBATT
RFIN
VENHB
VENLB
VMODE
GND
8 CPL_OUT
RF_TX_DA_2
PA_ON_B1
PA_ON_B8
PA_R0
17
GND
16
GND
15
CPLIN
U101
1
2
3
4
5
6
L119
L117
WTR0_PDET_IN
VBAT_PA
C157
C102
C160
C154
VBAT_PA
WCDMA_B2
C155
C101
3 TX
RX 1
RX_B2
2
4
5
7
8
9
G
G
G
G
G
G
R117
ANT 6
U610
C158
GND
U104
RFOUTHB
GND
VCC
GND
RFOUTLB
GND
CPL_OUT
C171
C170
C169
VBATT
RFIN
VENHB
VENLB
VMODE
GND
C161
14
13
12
11
10
9
C167
C168
WCDMA_B5
L126
1
2
3
4
5
6
RF_TX_DA_3
PA_ON_B2
PA_ON_B5
PA_R0
17
GND
16
GND
15
CPLIN
C163
F105
C172
CPL_PDET_LOOP
6
ANT
TX
RX
L128
RX_B5_G850
L127
G1 G2 G3 G5 G6
L129
L131
2 4 5 7 8
L130
U102
L300
C338
C124
C121
L112
C192
C122
C128
C432
R419
C129
L131
C172
L126
L129
C167
F105
C168
R113
C160
C154
C157
C155
R110
C102
8-33
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-4-7. GSM850 TX
YES
CHECK soldered
RFS100, C105, C106, C108,
L100, ANT100
NO
Resolder or change
U106, C111
NO
CONTINOUS TX ON CONDITION
TX POWER DAC:14500 CODE
APPLIED
GSM850 CH : 190
GSM900 CH : 62
RBW : 100KHz
VBW : 100KHz
SPAN : 10MHz
REF LEV. : 10dBm
ATT. : 20dB
YES
Check C151
: About 0dBm ?
YES
Resolder or change
C151
YES
Resolder or change
U102
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V ?}
YES
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
8-34
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-4-8. GSM900 TX
YES
CHECK soldered
RFS100, C105, C106, C108,
L100, ANT100
NO
Resolder or change
U106, C111
NO
CONTINOUS TX ON CONDITION
TX POWER DAC:14500 CODE
APPLIED
GSM850 CH : 190
GSM900 CH : 62
RBW : 100KHz
VBW : 100KHz
SPAN : 10MHz
REF LEV. : 10dBm
ATT. : 20dB
YES
Check C151
: About 0dBm ?
YES
Resolder or change
C151
YES
Resolder or change
U102
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V ?}
YES
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
8-35
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-4-9. DCS/PCS Tx
YES
CHECK soldered
RFS100, C105, C106, C108,
L100, ANT100
NO
Resolder or change
U106, C111, C112
NO
CONTINOUS TX ON CONDITION
TX POWER DAC:14500 CODE
APPLIED
DCS CH : 685
PCS CH : 661
RBW : 100KHz
VBW : 100KHz
SPAN : 10MHz
REF LEV. : 10dBm
ATT. : 20dB
YES
Check U106 PIN36
: About -4dBm ?
Resolder or change
U106
YES
Resolder or change
U102
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V ?}
YES
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
8-36
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CHECK soldered
RFS100, C105, C106, C108,
L100
NO
NO
CONTINOUS TX ON CONDITION
TX POWER DAC:14500 CODE
APPLIED
WCDMA Band1 CH : 10700
RBW : 100KHz
VBW : 100KHz
SPAN : 10MHz
REF LEV. : 10dBm
ATT. : 20dB
Resolder or change
U106, C111, C112
YES
Check C121, C122 :
About 22dBm ?
YES
Resolder or change
C121, C122
NO
Resolder or change
F102
YES
Resolder or change
C124
NO
Resolder or change
U101, C126
YES
Resolder or change
U106
NO
Check component
soldering status OK at
F102
YES
Check C124 :
About 22dBm ?
NO
Check the Voltage at
C126=VOUT_CHARGER?
YES
Check U101 PIN2 :
About 0dBm ?
YES
NO
Resolder or change
U102
YES
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
END
8-37
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CHECK soldered
RFS100, C105, C106, C108,
L100
NO
NO
Resolder or change
U106, C111, C102
YES
Check C102, C154 :
About 22dBm ?
YES
Resolder or change
C102, C154
NO
Resolder or change
U610
YES
Resolder or change
C101, C163, C161
NO
Resolder or change
U104, C158
YES
Resolder or change
U104
NO
Check component
soldering status OK at
U610
YES
Check C101, C163, C161 :
About 22dBm ?
NO
Check the Voltage at
C158=VOUT_CHARGER?
YES
Check U104 PIN2
About 0dBm ?
YES
Resolder or change
U102
NO
{C193,C194,C132 = 1.3V ?}
& {C130 = 2.0V ?}
& {C50 = 1.8V ?}
YES
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
END
8-38
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CHECK soldered
RFS100, C105, C106, C108,
L100
NO
NO
Resolder or change
U106, C111, C102
YES
Check C167, C168 :
About 22dBm ?
YES
Resolder or change
C167, C168
NO
Resolder or change
F105
YES
Resolder or change
C172, L129, L131
NO
Resolder or change
U104, C158
YES
Resolder or change
U104
NO
Check component
soldering status OK at
F105
YES
Check C172, L129, L131 :
About 22dBm ?
NO
Check the Voltage at
C158=VOUT_CHARGER?
YES
Check U104 PIN2 :
About 0dBm ?
YES
NO
Resolder or change
U102
YES
Check the freq. at
OSC400
PIN1,3 : 19.2MHz ?
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
END
8-39
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
YES
CHECK soldered
RFS100, C105, C106, C108,
L100
NO
NO
Resolder or change
U106, C111, C102
YES
Check C133, C134 :
About 22dBm ?
YES
Resolder or change
C133, C134
NO
Resolder or change
F104
YES
Resolder or change
C151
NO
Resolder or change
U101, C126
YES
Resolder or change
U101
NO
Check component
soldering status OK at
F104
YES
Check C151 :
About 22dBm ?
NO
Check the Voltage at
C126=VOUT_CHARGER?
YES
Check U101 PIN2 :
About 0dBm ?
YES
NO
Resolder or change
U102
YES
Check the freq. at
OSC400
PIN1,3 : 19.2MHz ?
NO
Change or resolder
OSC400
YES
NO
Resolder or change
UCP300
END
8-40
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VBAT_PA
C121
C122
WCDMA_B1
L112
VBAT_PA
G3
5
C129
C128
G2
G1
TX
RX
G6
C126
RX_B1
F102
7
8
C124
ANT
C127
G5
C123
C192
CPL_PDET_LOOP
WCDMA_B8
L114
C151
TX
RX
F104
B8514
L116
RX_B8_G900
L115
L118
2
4
5
7
8
G
G
G
G
G
ANT
GND
C149
C148
C147
C134
C133
14
13
12
11
10
9
RFOUTHB
GND
VCC
GND
RFOUTLB
GND
8 CPL_OUT
RF_TX_DA_2
PA_ON_B1
PA_ON_B8
PA_R0
VBATT
RFIN
VENHB
VENLB
VMODE
GND
17
GND
16
GND
15
CPLIN
U101
1
2
3
4
5
6
L119
L117
WTR0_PDET_IN
VBAT_PA
C157
C102
C160
C154
VBAT_PA
WCDMA_B2
C155
C101
ANT 6
U610
C158
3 TX
RX 1
RX_B2
2
4
5
7
8
9
G
G
G
G
G
G
R117
C169
GND
U104
RFOUTHB
GND
VCC
GND
RFOUTLB
GND
CPL_OUT
C171
C170
VBATT
RFIN
VENHB
VENLB
VMODE
GND
C161
14
13
12
11
10
9
C167
C168
WCDMA_B5
L126
1
2
3
4
5
6
RF_TX_DA_3
PA_ON_B2
PA_ON_B5
PA_R0
17
GND
16
GND
15
CPLIN
C163
F105
C172
6
ANT
TX
CPL_PDET_LOOP
RX
L128
RX_B5_G850
L127
G1 G2 G3 G5 G6
L129
L131
2 4 5 7 8
L130
RFS100
VBAT_PA
1
2
3
4
C
A
G
G
V_BAT
R111
C105
C106
C108
L100
R118
C107
VBAT_PA
C110
C103
C111
C104
C109
L104
L105
1 OUT
IN1 6
10 8 7 5 4 3 2
L111
18
L108
20
L109
L110
35
TXM_CTL0
ANT_TD_CPL
TD_CPL_OUT
19
21
38
TXM_CTL2
TXM_CTL1
15
RX1[ PCS ]
RX2[ DCS ]
U106
LB_EN
HB_EN
SPDT
SPDT_IN
SPDT_OUT
NC
NC
SW0
SW1
MODE0
MODE1
24
WCDMA_B2
WCDMA_B5
WCDMA_B1
WCDMA_B8
26
28
30
40
TXM_CTL4
TXM_CTL3
39
34
33
41
PA_R0
PA_R1
42
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
37
TRX1
TRX2
TRX3
TRX4
RF_IN
G
G
G
G
G
G
G
C113
36
RF_TX_DA_1
L107
IN2 9
L106
VCC
VCC
VBATT
F101
ANT
32
C112
Near WTR2605
RX_DCS_PCS
C166
L103
56
58
57
54
55
52
53
50
51
49
47
48
45
46
43
44
31
29
27
25
23
17
13
16
14
11
12
10
22
C117
C116
C119
C114
C118
C115
C120
U102
L300
C338
C124
C432
C128
C121
C122
R419
C129
L112
C192
L131
C172
L126
L129
C167
F105
C168
R113
C160
C154
C157
C155
R110
C102
8-41
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-4-14. Bluetooth
Bluetooth Function ON
Yes
No
No
Check TP_BT
TP_BT_SSBI is ok?
Change UCP300
Yes
No
The voltage of C204 =
about 1.3V
Check U401
Yes
No
Check the .
TP_BT_DATA is ok?
Change UCP300
Yes
No
Check the .
TP_BT_STROBE is ok?
Change UCP300
Yes
End
8-42
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VREG_L6_1P8
VDD_WLAN_1P3
VLDO_1P8
VDD_5GWLAN_3P0
OSC200
FA-128-48MHZ
24
TP_BT_DATA
29
TP_BT_STROBE
19
TP_FM_DATA
41
TP_FM_SSBI
48
U201
BT_STROBE
FM_SSBI
61
68
FM_HS_RX
FM_TXRX
64
51
0603
GND1
GND2
R201
C229
L201
L202
WL_RFIO_5G
TP_WLAN_D0
TP_WLAN_CLK
WLAN_DATA0
WLAN_DATA1
WLAN_DATA2
WLAN_CLK
F201
28
WL_BB_IN
58
N/C
1
G
3
G
5
G
WL_BB_IP
WL_BB_QP
NC
WL_BB_QN
NC
57
80
GND
GND
GND
GND
GND
GND
GND
GND
GND
46
53
55
56
60
62
65
66
67
76
GND
GND
GND
GND
GND
38
39
42
44
23
27
37
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
15
18
20
21
22
1
2
8
10
12
13
GND
81
GND
WLAN_IM
WLAN_IP
WLAN_QP
WLAN_QM
C219
71
WL_CMD_DATA0
70
WL_CMD_DATA1
77
WL_CMD_DATA2
33
WL_CMD_CLK
FM_DATA
OUT
IN
34
47
WL_DA_OUT_5G
72
WL_RFIO_5G
16
WL_PDET_IN
BT_SSBI
BT_DATA
C228
LOW 4
TP_BT_SSBI
R200
WLAN_SET
2
ANT
ANT20
C238
C237
11
2
6 HIGH
R202
TP_WLAN_SET
52
L208
L212
R211
GND
FM_ANT
C222 C223
WL_BT_RFIO
WL_EPA_CTRL0
WL_RFIO_5G
79
BT_SSBI
BT_DATA
BT_CTL
C221
F200
63
WL_CMD_SET
XO_OUT
WL_EPA_CTRL1
FM_DATA
FM_SSBI
C203
0.01NF
C220
XO_IN
43
BT_WIFI_CLK_IN
35
VDD_IO_1P8
9
11
26
30
VDD_XO_1P8
VDD_DIG_1P2
VDD_WL_2GPA_2P9
40
45
50
VDD_WL_BB_1P3
VDD_WL_PLL_1P3
WDD_WL_LO_1P3
VDD_WL_UPC_1P3
VDD_WL_2GPA_1P3
VDD_WL_2GLNA_1P3
69
54
49
32
59
78
73
74
75
VDD_FM_RXFE_1P3
VDD_FM_VCO_1P3
VDD_FM_PLL_1P3
VDD_FM_RXBB_1P3
VDD_FM_TXDA_2P9
VDD_BT_BB_1P3
VDD_BT_PLL_1P3
VDD_BT_VCO_1P3
VDD_WL_5GPA_1P3
VDD_WL_5GLNA_1P3
VDD_WL_5GPA_2P9
31
VDD_BT_FM_DIG_1P3
CLK_OUT
VDD_BT_TXRF_2P9
36
VDD_BT_RXRF_1P3
3
4
7
14
17
25
C225
C218
C207
C206
C204
C205
WCSS_XO
BT_WIFI_CLK_IN
BT_WIFI_CLK_OUT
C272
C224
C215
C217
C216
C212
C214
C213
C209
C210
C211
C208
C202
12PF
25V
1005
BT_WIFI_CLK_OUT
50V
L200
C246
R207
C247
L214
8-43
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-4-15. WiFi
WiFi Function ON
Yes
No
No
Change UCP300
Yes
No
Check the supply voltage of
C221,C200,C201 ?
Check U401
Yes
No
UCP replace
Yes
No
Yes
End
8-44
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VREG_L6_1P8
VDD_WLAN_1P3
VLDO_1P8
VDD_5GWLAN_3P0
OSC200
FA-128-48MHZ
XO_OUT
WL_EPA_CTRL0
29
TP_BT_STROBE
19
BT_SSBI
WL_DA_OUT_5G
TP_FM_DATA
41
48
WL_RFIO_5G
U201
FM_DATA
WL_CMD_DATA0
FM_SSBI
WL_CMD_DATA1
FM_HS_RX
WL_CMD_DATA2
0603
R201
GND2
L202
C219
33
TP_WLAN_D0
TP_WLAN_CLK
WLAN_DATA0
WLAN_DATA1
WLAN_DATA2
WLAN_CLK
F201
28
WL_BB_IN
58
71
70
77
64
51
WL_RFIO_5G
16
WL_CMD_CLK
FM_TXRX
N/C
1
G
3
G
5
G
WL_BB_IP
WL_BB_QP
NC
WL_BB_QN
NC
80
81
WL_RFIO_5G
GND
79
GND
GND
GND
67
76
66
65
62
GND
GND
GND
GND
GND
GND
GND
GND
GND
44
42
56
60
46
53
55
GND
GND
GND
GND
GND
GND
21
22
38
39
37
27
23
GND
GND
GND
GND
GND
GND
GND
20
18
10
12
15
13
GND
GND
57
WLAN_IM
WLAN_IP
WLAN_QP
WLAN_QM
L201
WL_PDET_IN
61
68
OUT
GND1
C229
72
BT_DATA
BT_STROBE
TP_FM_SSBI
C228
34
47
IN
TP_BT_DATA
LOW
FM_DATA
FM_SSBI
24
R200
WLAN_SET
52
ANT
ANT20
2
C238
C237
11
2
HIGH
R202
TP_WLAN_SET
WL_BT_RFIO
FM_ANT
C222 C223
L208
L212
R211
GND
BT_SSBI
BT_DATA
BT_CTL
C221
F200
63
WL_CMD_SET
WL_EPA_CTRL1
TP_BT_SSBI
C203
0.01NF
C220
XO_IN
43
BT_WIFI_CLK_IN
35
VDD_IO_1P8
VDD_DIG_1P2
26
30
VDD_XO_1P8
VDD_WL_2GPA_2P9
40
11
32
45
50
VDD_WL_BB_1P3
VDD_WL_PLL_1P3
VDD_WL_2GPA_1P3
VDD_WL_2GLNA_1P3
VDD_FM_VCO_1P3
WDD_WL_LO_1P3
VDD_WL_UPC_1P3
73
54
74
75
49
69
VDD_FM_PLL_1P3
VDD_FM_RXFE_1P3
VDD_FM_RXBB_1P3
VDD_FM_TXDA_2P9
VDD_WL_5GPA_2P9
25
59
78
14
17
VDD_BT_BB_1P3
VDD_BT_PLL_1P3
VDD_BT_VCO_1P3
VDD_WL_5GPA_1P3
VDD_WL_5GLNA_1P3
31
VDD_BT_FM_DIG_1P3
CLK_OUT
VDD_BT_TXRF_2P9
36
VDD_BT_RXRF_1P3
C225
C218
C207
C206
C204
C205
WCSS_XO
BT_WIFI_CLK_IN
BT_WIFI_CLK_OUT
C272
C224
C215
C217
C216
C214
C212
C213
C211
C209
C210
C208
C202
12PF
25V
1005
BT_WIFI_CLK_OUT
50V
L200
C246
R207
C247
L214
8-45
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
8-4-16. GPS
GPS function on
No
Check U401
Yes
No
Check U200
is ok?
Change U200
Yes
Resolder C226,C209,C234,L205
C230,C241,C245,C235,C236
L206,C240,L210 Resoldering.
Check UCP300
Yes
No
Repair is complete
8-46
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
VDD_FEM/GPS_2.75V
C230
U200
C235
C234
22
C233
IN
OUT
GND
EN
F203
C236
5
GPS_EXT_CTRL
RFIN
VDD
IN
L206
OUT 4
GPS_RF_IN
C240
C239
2
3
5
G
G
G
L205
GND RFOUT
G
G
G
F202
2
3
5
ANT200
C226
C243
C244
L209
C241
C245
L210
8-47
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
- NC Point(Top View)
- UCP300 (
: NC )
8-48
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.
Level 3 Repair
- PM8226 (
: NC )
8-49
Confidential and proprietary-the contents in this service guide subject to change without prior notice.
Distribution, transmission, or infringement of any content or data from this document without Samsungs written authorization is strictly prohibited.