Escolar Documentos
Profissional Documentos
Cultura Documentos
3. HAZARD IDENTIFICATION
RESPIRATORY/INHALATION: Considered to be non-hazardous. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
SKIN IRRITATION: Unlikely to cause irritation. EYE PROTECTION: Wear eye protection if splashing is possible.
EYE CONTACT: May cause temporary irritation.
INGESTION: Considered to be non-hazardous. SKIN PROTECTION: Gloves and protective overalls recommended if
OCCUPATIONAL EXPOSURE LIMITS: prolonged contact is likely.
An exposure limit has been set for Monopropylene Glycol (synonym VENTILATION: Maintain sufficient ventilation to comply with 'Occupational
Propane-1,2-diol). This applies to the UK only. Exposure Standard'.
UK (EH 40) OES
3
Total (vapor & Particulates) 150 ppm ( 10 mg/m )(8hr TWA)
Particulates - ppm ( 10 mg/m3)(8hr TWA) 9. PHYSICAL AND CHEMICAL PROPERTIES (typical values)
ACGIH TLV - TWA No limit assigned. APPEARANCE: Clear green fluid
FRANCE VME No limit assigned. ODOR: None
GERMANY MAK No limit assigned. pH (20°C): 7
BOILING POINT: ~104°C
FLAMMABILITY DATA: See Section 5
4. FIRST AID MEASURES VAPOR PRESSURE (20°C): 15 mm Hg
SPECIFIC GRAVITY (20°C): 1.038
Chemical Emergency: Spill, leak, fire, or accident call VAPOR DENSITY (AIR = 1): 1.0 (estimated)
Chemtrec day or night (800)424-9300; FREEZING POINT:
Outside continental USA call (703)527-3887 100% -37°C
75% v/v -22°C
EYE CONTACT: Flush eyes immediately with fresh water for least 15 minutes 50% v/v -11°C
while holding eyelids open. Consult medical personnel if irritation persists BROOKFIELD LVT VISCOSITY (Spindle No. 1 or 2; 0.3rpm):
SKIN CONTACT: Wash off in flowing water. Launder contaminated 20°C 27,500 mPas
clothing before re-use. -25°C 12,000 mPas
INHALATION: Remove to fresh air if feeling unwell. Consult medical SPECIFIC HEAT:
personnel if symptoms persist. 20°C 3.6 J/g/°C
INGESTION: Give large quantities of water to drink. Consult medical 70°C 3.7 J/g/°C
personnel. SOLUBILITY IN WATER: Completely miscible.
Prepared According to the OSHA Hazard Communication Standard (29 CFR 1910.1200) by Page 1 of 2
MSDS #130 Cryotech Deicing Technology, 6103 Orthoway, Fort Madison, IA 52627 Revised: 3/2008
Kilfrost ABC-S®
MATERIAL SAFETY DATA SHEET
The above information is accurate to the best of our knowledge. However, since data, safety standards, and government regulations are subject to change and the
conditions of handling and use or misuse are beyond our control, Cryotech Deicing Technology, a Division of General Atomics International Services
Corporation makes no warranty, either express or implied, with respect to the completeness or continuing accuracy of the information contained
herein and disclaims all liability for reliance thereon. Cryotech Deicing Technology, a Division of General Atomics International Services Corporation assumes no
responsibility for any injury or loss resulting from the use of the product described herein. User should satisfy himself that he has all current data relevant to his
particular use.
Prepared According to the OSHA Hazard Communication Standard (29 CFR 1910.1200) by Page 2 of 2
MSDS #130 Cryotech Deicing Technology, 6103 Orthoway, Fort Madison, IA 52627 Revised: 3/2008