Escolar Documentos
Profissional Documentos
Cultura Documentos
a. .5 gpm
b. 1 gpm
c. 2 gpm
d. 10 gpm
e. None of the above
2. What is the minimum drain size for a toilet?
a. 1 inch
b. 2 inches
c. 3 inches
d. 4 inches
e. None of the above
3. A lavatory drain tailpiece has what diameter?
a. 1 1/8 inch
b. 1 1/4 inch
c. 1 3/4 inch
d. 2 1/4 inches
4. A ________________is used to stop gases from getting into a building.
a. Ball Valve
b. Gaskett
c. P-Trap
d. Quick Tee Adapter
e. None of the above
5. What type of piping sends water through a hot water heater?
a. Supply
b. Water Transfer
c. Diverter
d. Manometer
e. None of the above
6. A _______ size drain is needed for a shower stall.
a. 1 1/2 inch
b. 2 inches
c. 3 inches
d. 4 inches
e. None of the above
d. 2 inches
e. None of the above
8. A __________________ is used to prevent bends or folds when working with soft
copper piping.
a. chrome support
b. mounting partition
c. bending spring
d. bulkhead fitting
e. None of the above
9. A ________________ is used to connect copper with galvanized pipe.
a. push fit connector
b. dialectric union
c. coupling
d. nipple
e. None of the above
10. The minimum trap size of a bidet is _______________.
a. 1 1/4 inch
b. 1 1/2 inch
c. 1 3/4 inch
d. 2 inches
e. None of the above
11. A kitchen sink needs what size P-trap?
a. 1 1/2 inch
b. 1 3/4 inch
c. 2 inches
d. 2 1/4 inches
e. None of the above
12. A _______________ is used to connect a P-trap to a drain.
a. compression
b. trap adapter
c. coupling
d. valve
e. None of the above
13. The maximum spacing of a horizontal hanger for inch CPVC piping is
________________.
a. 1 foot
b. 2 feet
c. 3 feet
d. 4 feet
e. None of the above
14. A ______________ size drain is needed for a clothes washer.
2
a. 1 inch
b. 1 1/2 inch
c. 2 inches
d. 2 1/2 inches
e. None of the above
15. A four bedroom house should have a septic tank that holds how many gallons?
a. 300
b. 750
c. 900
d. 1200
e. None of the above
16. Water enters a residence at what pressure?
a. 30 - 40 psi
b. 50 - 60 psi
c. 70 - 80 psi
d. 85 - 90 psi
e. None of the above
17. An "A Valve" is a manual ____________________.
a. cold water valve
b. hot water valve
c. air valve
d. septic valve
e. gas valve
18. An air lock is caused by _____________________.
a. an air bubble
b. grease build-up
c. damaged pipe
d. low water pressure
e. None of the above
19. A ___________________ is a sacrificial rod installed in a water heater to protect the
tank from corrosion.
a. dip tube
b. alpha rod
c. anode rod
d. insulation tube
e. None of the above
20. Barlow's Formula is expressed as _________________________.
a. P = D x t
b. P =3t D
c. P = 5St x D
d. P = 2St D
3
Ternary
Combination
Multiple
Sewage pump
Effluent pump
Sump pump
1/2"
3/4"
o
o
1"
4. Polybutylene piping should never come into contact with the following:
o
Caulk
Copper
Water heater
With a union on the inlet and on the outlet, and a shut off valve close to
the inlet
Anti-corrosion rod
Anode rod
Toilets
Sinks, showers, and bathtubs
o
o
Reverse siphonage
Reverse flow
Back siphonage
10. What type of fitting is needed to join copper with galvanized piping?
Dialectric union
o
o
Solder joint
Coupling
o
o
2"
1 3/4"
o
o
P-Trap
Anti-syphon valve
14. What type of piping sends water through a hot water heater?
o
Supply
DWV
15. House water lines can either dump into a ___________ or ___________.
o
o
o
May be unvented
4. Which of the following materials is used to make a threaded joint between galvanized
steel piping and copper tubing?
o
Dresser coupling
5. This is the term for the shutoff valve found between a faucet and water pipe. The outlet
creates a 90 angle with the faucet, and the inlet hooks up to the water supply pipe in the
wall.
Angle stop
o
o
Anode rod
Stop valve
6. This is the term for a decorative metal trim shield or flange located underneath a faucet
handle. It covers the hole in the wall or fixture as well as the faucet stem.
o
Dove tail
Escutcheon
o
o
Fluer
7. You are instructed to cut a triangular opening into a wall. Once cut, he triangular
opening forms one 30-60 right triangle. The longest side of the triangle measures 10' 0".
The shortest side will measure approximately ____ ft.
o
4
5
o
o
8
8
8. 135 cubic ft of water weighs _______ lbs. Choose the closest answer.
o
7,580
7,980.4
8,437.5
9. If there is a pressure of 30 psi at street level, how high will the pressure lift water
contained in a 2 in. vertical water pipe? Choose the closest answer.
o
69.12'
73.10'
68.2'
P= 1675 Kpa
P= 1470 Kpa
P= 1575 Kpa
11. A pressure gauge on a non-pressurized holding tank reads 24.3 Kpa. Find out how many
meters of water are in the tank.
o
Depth= 2.48 m
Depth= 3.48 m
Depth= 1.48 m
12. The specific gravity of a certain type of oil is 0.8. What is the mass of 1 litre of the oil?
o
0.8 Kg
0.16 Kg
0.9 Kg
13. If 600 ft of piping weighs 900 lbs, 140 ft of like piping will weigh _____ lbs. Choose
the closest answer.
o
o
211
217
9
180
14. A 60 gallon water heater weighs 52.5 lbs when it is empty and ________ lbs when it is
full. Choose the closest answer.
o
o
o
585
553
501
15. The inner dimensions of a grease interceptor measure 9' 0" long, 4' 6" wide, 5' 0" deep,
with a 20% free board. What, then, is the liquid capacity of the interceptor in gallons?
Choose the closest answer.
o
1,150.25
1,430.40
1,211.76
10