Escolar Documentos
Profissional Documentos
Cultura Documentos
Contents
Before it drives
It explains the operation and the attention that will be needed by driving.
It explains the method of running and the stop and the methods of the safe driving.
Maintained method
Vehicle specification
The specification of the car and information on the customizing function are
described.
It is of sparing
It is possible to look for information described in this book by the method of the order
of the Japanese syllabary etc.
Please read "Audio manual with 5.8 type display" and "Navigation system manual" of
the separate volume also if you take audio or the navigation system installation car.
Ant on _ KA
TABLE OF CONTENTS
Contents
68 1-6 anti-theft systems
Before it drives
k e y
Engine immobilizer68
s y s t e m
restraint system
airbag..child seat..install.
t r u n k
Seat..steering
wheel..mirror..adjustment..method.
5
5
d
9 0 .
d r i v e
7
o
m i r r o r
..installation.
.car..automatic..transmiss
ion..direction..instructio
n..lever..parking brake.
Ant on _ KA
1 1 5
m u l t i
information
d i s p l a y
129
s y s t e m
driving
f l o o r
at 168 cold
Maintained method
[furontowaipa-deaisa-]
t i r e s
a r e 2 1 8 .
Ant on _ KA
TABLE OF CONTENTS
Contents
cleaning
2 4 7
Vehicle specification
of
a i r
conditioner
f i l t e r
a n d
e x c h a n g e
It is of sparing
.data..recorder.
Syndrome ..307..
260 action method in 5-2 emergencies
267 engines
d o
start.
2
9
1
a
2
t
8
s t a c k s .
Ant on _ KA
another is not
n o t
regretted.
317.
Ant on _ KA
Illustration contents
Externals
Bonnet P. 221
Wiper P. 127
Door mirror P. 58
Ant on _ KA
[Riyauindou;defogga-] P. 189
Fill opening P. 64
Door P. 34
Taillight P. 121
[Riyawaipa-] P. 129
Trunk P. 38
Tire
- Rotation P. 218
- Exchange
P. 267
*:Different equipment and option equipment in vehicle model etc.
Ant on _ KA
Illustration contents
Room
Headrest P. 47
Seat belt P. 49
Console side
pocket P. 200
Power window
switch P. 61
Rear centerArmrest
P . 2 0 7
Cup holder P. 197
SRS side air bag * P. 71
Reception desk seat P. 41
Glove box P. 195
Departure flame cylinder P. 252
8
Ant on _ KA
Ant on _ KA
Illustration contents
Room
Lock lever P. 35
Power window switch P. 61
Door lock switch P. 34
Window lock
switch P. 61
10
Ant on _ KA
11
Ant on _ KA
Illustration contents
Instrument panel
Ant on _ KA
[Riyauindou;]
Defogger switch P. 189
13
Ant on _ KA
Illustration contents
Instrument panel
Toque switch **
Cruise control
lever * P. 136
Telephone switch **
MODE switch switch **
Reception desk
wiper[Deaisa-suicchi] * P. 190
Backing & clearance sonar
switch * P. 140
14
Ant on _ KA
15
Ant on _ KA
16
Ant on _ KA
Attention of driving
Please always take account to surrounding circumstances such as other cars and pedestrians, and bear the safe
driving in mind.
Please never do the driving under the influence of liquor. Powers of attention and the judgment become duller
when sake is drunk, and the unforeseen accident might be caused. Moreover, please refrain from driving
when you take the medicine that holds drowsiness.
Please do not use the cellular phone while driving, and do not adjust the device. The attention
of surrounding circumstances etc. becomes insufficient, and it is very dangerous. It is prohibited to use the car
telephone and cellular phones other than hands-free while driving by the law.
17
Ant on _ KA
Attention
Fear that leads to the breakdown and the damage of the car and the fixture and a correct
performance might not be able to be secured if it doesn't guard described in here.
Knowledge
Function..explanation..manner of operation..explanation..excluding..know..would
like..know..convenient..explain.
18
Ant on _ KA
Before it drives
k e y
1
64 method of 1-5 refueling
64 how to open fill opening
t r u n k s
Seat..steering
wheel..mirror..adjustment..method.
5
5
d
installation of
7 1
child seats
8
7
o
m i r r o r
19
Ant on _ KA
Key
We will pass the following keys to the customer.
Smart entry & start system installation car
electronic key
Smart entry & star
Operation of Toshi stem ( P. 22)
Operation of wireless function
( P. 31)
Mechanical
keyKeenan bar plate
Smart entry & start system non-installation car key
(wireless function installation)
Operation of wireless
function ( P. 31)
20
Ant on _ KA
Knowledge
- Keenan bar plate
Please keep it in safe places (in the purse etc.) other than in the car. When the key is
lost by any chance, a new key can be made from the Keenan bar in the Toyota shop.
( P. 281)
Before it drives
Attention
- To prevent the key from breaking down
- It doesn't strike close to home to the key, and please do not expose, and do not wet it to the place the high temperature
into which direct sunshine strikes.
- Please do not bring the key close to the one with magnetism, and do not put the one to intercept the electromagnetic
radiation on the surface of the key.
21
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
22
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Lock and unlocking of door (Only the reception desk door steering wheel :).
The lock switch is locked pushing.
1
Before it drives
Unlocking of trunk
The trunk opening switch is unlocked
pushing.
23
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
- Position of antenna
Antenna in car of
antenna outside car
Antenna outside
antenna trunk in trunk
:Unlocking of trunk
About ..surroundings.. 70 from
the trunk opening switch An electronic
key is operated within the cm
when portable.
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Knowledge
- Signal of operation
It informs them of it by blinking the buzzer and the emergency blinking light (Unlocking : the lock twice once)(It is
excluded to unlock the trunk).
Before it drives
The buzzer rings when the door is locked with the door completely not
closed. Please lock again after completely closing the door.
- 2 Smart entry & start system was not used longer than the week.
- About ..outside.. 1 of the vehicles An electronic key was left for ten minutes or more within m.
Smart entry & start system returns when either the following
is done.
To prevent remarkable consumption of the battery, about one of the electrical appliances that generate the following
magnetisms Please do not put an electronic key within m.
TV
Personal computer
Cellular phone and cordless phone under charge
Desk lamp
25
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
- If an electronic key is in the range of operation, it is possible to lock and to unlock it excluding the person who is
carrying an electronic key.
- The engine start might become possible also outside the car when there is an electronic key
in a position near the door glass.
- The door might unlock it when an electronic key is in the range of operation when volumes of water hang to the door
handle because of the carwash and the heavy rain, etc. (It will be locked automatically in about 30 seconds if there
is no opening and shutting operation of the door).
- Even if the door handle is gripped, it is likely not to be unlocked when gloves are installed.
- It becomes impossible for smart entry & start system to unlock when locking
in a wireless function etc. when there is an electronic key in a position near
the vehicle (Return when unlocking it by using a wireless function).
- When a sudden approach to range ( P. 24) of operation and a sudden door steering wheel control
are done, the door might not be unlocked. In that case, please return the door handle
to former position once, and do the unlocking operation again.
26
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
because of anti-theft.
Before it drives
Might it sound, and the warning light light to warning outside in the car and the car to prevent the accident
and the theft by the operational error etc. not anticipated. Please deal appropriately according to the
situation when the warning light lights. ( P. 265)
The situation and the coping process when only the warning sound rings are as follows.
Warning sound
Situation
Coping process
in the car.
electronic key had been put in the trunk trunk after taking out
with all doors locked.
an electronic key in
the trunk.
after turning
27
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Warning sound
It rings in the car once ,
Situation
Coping process
stop" switch with the driver's seat driver's seat door after
door open (The driver's seat
It keeps ringing in the car , door was opened at the accessories start stop" switch.
saying that "Feep and feep". mode). accessories mode
"Engine start stop" switch
was turned off with the driver's
28
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Warning
- Warning of influence that electric wave exerts
- It is about 22 from antenna ( P. 24) outside the car of the indoor antenna that the
implanted cardiac pacemaker and the planting type defibrillator are installed Please
do not approach within the cm. It might influence the operation of the implanted cardiac
Before it drives
- Please confirm the influence by the electric wave to an electric equipment manufacturers for the medical
treatment etc. beforehand when an electric equipment for medical treatments other than the implanted cardiac pacemaker
and the planting type defibrillator is used. It might influence the movement of an electric equipment for the
medical treatment by the electric wave.
Smart entry & start system can be non-operated.
Please inquire of the Toyota shop in detail.
29
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Attention
- Situation in which function might not work normally
Smart entry & start system is using a slight electric wave. The
communication between an electronic key and the vehicle might be disturbed in the following
cases, and smart entry neither & start system nor wireless remote control operate normally.
(coping process: P. 282)
- When you carry wireless telecommunications equipments such as the wireless machine, cellular phones, and the cordless type telephones
- When an electronic key touches the metallic object or is covered
- When is to be near two or more electronic keys
- An electronic key simultaneously with the product that sends the following electric waves when carrying
or using it
Electronic key to other cars
Electric wave type wireless remote control
Personal computer
30
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
door unlocking
Trunk unlocking (Keep pushing).
Before it drives
31
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Knowledge
- Signal of operation
Smart entry & start system installation car
door
: It informs them of it by blinking the buzzer and the emergency blinking light. (Unlocking : the lock twice once. )
- Half door warning buzzer (smart entry & start system installation car)
P. 25
32
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Attention
Before it drives
- When is in the place where high-intensity radio waves and the noise such as there are a television tower, a power plant,
a gas station, a broadcasting station, and a large-scale display and an airport to be near are generated
- When you carry wireless telecommunications equipments such as the wireless machine, cellular phones, and the cordless type
telephones
33
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
- Wireless function
P. 31
- Key
Smart entry & start system installation car
The door can be locked and be unlocked with a mechanical key. ( P. 282)
Smart entry & start system non-installation car all
door lock all
door unlocking
34
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
- Lock lever
Lock
unlocking
1
Before it drives
When you lock the reception desk seat door from the outside without using the key
When the time of the accessories mode
or ignition ON mode and an electronic key
has been left in the car, smart entry & start
system installation car "Engine start stop" switch that closes the door
with the door handle that adjusted the lock lever of all doors to the
lock side pulled is not locked.
The key might be locked without being correctly detected according to the position of an
electronic key.
35
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Child protector
The [riya] seat door doesn't open from the
inside when making it to the lock side.
The child can be prevented from opening the
[riya] seat door from the inside. Please adjust the
[riya] seat door on both sides to the lock side.
Knowledge
- How to open door of child protector use
When the door handle outside the car is pulled unlocking the door, it opens. Please lower the door glass,
put out the hand, and pull the door handle outside the car when the emergency opening it in the car.
36
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Warning
- To prevent the accident
Please guard the following while driving.
The desire doesn't depend if it doesn't guard, either the door opens, and it reaches important injury
37
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Trunk
It is possible to open it by the trunk opener, smart entering, and
using & start system * and a wireless function.
- Trunk opener
The lock of the trunk is released.
- Wireless function
P. 31
38
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Knowledge
- Luggage room light
The luggage room light lights when
opening a trunk.
1
Before it drives
39
Ant on _ KA
1-2. How to open and shut door trunk and method of lock
Warning
- Warning of running
Please close the trunk while running.
Luggage might be thrown out, and the vehicle exhaust emission enter in the car when
leaving open.
- It might become difficult to open and shut the trunk from a smooth place uphill.
Moreover, the trunk might open and shut suddenly. Please do not
place the finger etc. enough.
- Please note the opening and shutting at the strong wind enough.
It is flapped the trunk by the wind and might mightily open, shut, and be
dangerous.
40
Ant on _ KA
1
Before it drives
Warning
- About the reclining adjustment
- Please note that seats are not regrettably in the crew and luggage.
- Please do not knock down the drip to the back more than the necessity.
The important injury related to the life as the body receives strong pressure from the seat belt under
to diving and the abdomen, etc. at the accident might be received and it is dangerous.
- Please confirm the seat is surely fixed after adjusting the seat.
41
Ant on _ KA
Rear seat
Reclining adjustment
42
Ant on _ KA
- When folding
The region of the lateral zone of the seat cushion
in the forward end is lifted, and the lock is released.
43
Ant on _ KA
44
Ant on _ KA
Warning
- When you operate the rear seat
Please guard the following.
In the worst case, it reaches important injury if it doesn't guard or, it is likely
45
Ant on _ KA
Warning
- After the back also returns the drip to former position
Please guard the following.
In the worst case, it reaches important injury if it doesn't guard or, it is likely
to lead to the death.
- The seat is lightly shaken back and forth, and it fixes surely.
- It is whether placed by the seat belt between seats and crowded are confirmed.
Guide
46
Ant on _ KA
Headrest
Upper and lower adjustment
When lowering, it operates it while
pushing the release button.
1
Detaching
It detaches it while pushing the
Release button
Before it drives
release button.
Knowledge
- About the height of the headrest
The center of the headrest must adjust it
so that both ears may become it near on.
47
Ant on _ KA
Warning
- About the headrest
Please guard the following.
In the worst case, it reaches important injury if it doesn't guard or, it is likely
to lead to the death.
48
Ant on _ KA
Seat belt
All crew must wear the seat belt correctly before it
runs.
- To wear it correctly
1
Before it drives
Release
The release button is pushed.
49
Ant on _ KA
Release
The release button of buckle A is pushed.
[Masu].
Release button
Plate A
Buckle A
Plate B
Button
Buckle B
50
Ant on _ KA
Guide
guide.
Before it drives
Plate B
Plate A
..lowering...
Please move it to the place in which "[Kachi]"
and the sound are heard and it is fixed.
51
Ant on _ KA
Knowledge
- Seat belt fixation mechanism in emergency
The belt is locked when there are a sudden stop and an impact. The body might be suddenly
knocked down to previous, and even if the belt is quickly drawn out, it lock. The belt can be drawn
out if it loosens after the belt is strongly pulled, and it moves it slowly once.
52
Ant on _ KA
Knowledge
- For the woman during pregnancy and the disease's there
Please wear it correctly after confirming notes
to the doctor. ( P. 49)
The waist belt must wear the pregnancy of the
hipbone under the swelling of the stomach just like
the method of a usual wearing to hang to a low
position as much as possible. Moreover, please surely
avoid the swelling of the stomach through the shoulder and
wear the shoulder department belt to hang to the chest.
1
Before it drives
- Please use the child seat to fit the child for a small child who cannot
wear it at the position where the seat belt is correct. ( P. 80)
Please follow how to wear the seat belt for the child who can wear it at the
position where the seat belt is correct. ( P. 49)
53
Ant on _ KA
Warning
Please guard the following to avoid the injury at the sudden braking and the accident.
Important injury might be received, and, in the worst case, it lead to the death if
it doesn't guard.
- The child makes it sit on the rear seat, makes the seat belt worn or
uses the child seat.
- The shoulder department belt is passed under the arm and it doesn't wear it.
- They are made to stick to a low position as much as possible and the waist belt is worn.
- Please confirm the seat belt goes to guide ( P. 51) when you
use the rear seat belt.
Plate B
Buckle B
54
Ant on _ KA
Warning
- About damage and the breakdown of the seat belt
- Please damage the belt or neither plate nor the buckle, etc. by placing it between
the seat and the door.
- Please do not use the seat until the seat belt is repaired when you
Before it drives
- Please confirm whether the seat belt has twisted. whether ..ensuring.. [**]
is done to the buckle the platePlease contact the Toyota shop at once when
[umaku] [**] cannot do.
- Please exchange the seat and the seat belt even when clear damage is
not seen when is in a serious accident.
- Please do the installation of the seat belt with the pretensioner, detaching, and neither
resolution nor abandonment, etc. excluding the Toyota shop.
Might it not operate normally when inadequately treating, important injury be received,
and, in the worst case, it lead to the death.
- About the seat belt with the child seat fixation mechanism
Please do not let the child play with the child seat fixation mechanism addition
seat belt.
Attention
- About the rear seat central seat seat belt
Please do not separate the belt, except when the back in the driver's seat side rear seat also
moves up the drip.
55
Ant on _ KA
Steering wheel
It can be adjusted that the handle position is driven easily.
It has the steering wheel, and the lever
is lowered.
The steering wheel is raised, and back and forth
and it moves up and down, and the located
appropriate lever is raised.
Warning
- Warning of running
Please do not adjust the handle position while running.
Driving is mistaken, and it is likely to become an accident that causes a death and important injury.
56
Ant on _ KA
Inner mirror
When the light of the following car is dazzled, the reflected light can be decreased by
operating the lever ([fusemabayu]).
At [fusemabayu] when
1
using it usually
Before it drives
Warning
- Warning while driving
Please do not adjust the mirror while driving.
Driving is mistaken, and it is likely to lead to important injury and the death.
57
Ant on _ KA
Door mirror
The angle of the specular can be adjusted with the switch.
The mirror is chosen.
L:The left
R:The right
58
Ant on _ KA
Knowledge
- Operation condition
Smart entry & start system installation car
1
Before it drives
- In the following cases, when sunlight is appropriated for 1.2 days at fine weather, it recovers though the effect of
the hydrophilicity is temporarily lost.
When you wipe the dirt of the mirror off
When the mirror becomes cloudy
When you wash wax with the automatic car-washing machine
A long term, when parking to the place without the day such as the basement car parks regrettably
59
Ant on _ KA
Warning
- When you run
Please guard the following while running.
Driving is mistaken if it doesn't guard, it causes an unexpected accident, and it is likely
to lead to important injury and the death.
Attention
- When the mirror specular freezes (cold-weather model car)
The frozen part of the mirror specular must be operated the mirror heater or thaw
without scraping it with a plastic board etc. by putting the warm water to continue the
effect of [oyamizumaku].
60
Ant on _ KA
Power window
The door glass can be opened and shut with the switch.
It closes (The switch is maintained on the way).
The door glass closes until the
1
switch is separated.
Before it drives
61
Ant on _ KA
Knowledge
- Operation condition
Smart entry & start system installation car
When smart entry & start system non-installation car engine
switch is . ON " when "Engine start stop"
switch is ignition ON mode
62
Ant on _ KA
Warning
- When you open and shut the door glass
Please guard the following.
In the worst case, it reaches important injury if it doesn't guard or, it is likely
- The prevention function might not operate including scissors when the foreign body is placed immediately before
the door glass closes completely. Moreover, the prevention function doesn't operate the switch in the state that was able
to continue including scissors. Please do not place the finger etc.Important injury
might be received and it is dangerous.
Attention
- When you open and shut the door glass
Please guard the following.
- The switch of the driver's seat switch and other doors is not moved in the opposite direction at the same time.
- After opening completely the door glass closed, all it doesn't keep pushing the switch in the same direction.
63
Ant on _ KA
- Before it refuels
Smart entry & start system installation car
Please close the door and the door glass, and turn off
"Engine start stop" switch.
Please close the smart entry & start system
non-installation car door and glass of the door, and make the engine
switch . LOCK ".
64
Ant on _ KA
1
Before it drives
Knowledge
- Kind of fuel
Nonlead regular gasoline
65
Ant on _ KA
Warning
- About refueling
Please guard the following before it refuels.
In the worst case, it reaches important injury if it doesn't guard or, it is likely
to lead to the death.
- It is likely to ignite to the fuel by the spark by the electrical discharge that
removes the static electricity of the body touching the metallic portion such as bodies.
- Please open it slowly after the sound stops when the sound "Hiss" is
heard when the cap is loosened.
It has the switch part of the cap when the cap is opened, and it opens it slowly.
The fuel blows from the fill opening when the temperature is high if it doesn't slowly open it, it
returns, and it is likely to injure.
- The person who has not removed static electricity is not brought close to the fill opening.
- The evaporating fuel is not breathed in.
In the element of the fuel, there is a thing that contains the poisonous substance, too.
- It doesn't smoke.
It ignites and a fire might be caused.
66
Ant on _ KA
Attention
- When refueling
Please do not use neither gasoline nor other fuels (inferior gasoline, light oil, kerosene,
and alcohol system fuel) except specification, and spill the fuel.
67
Ant on _ KA
Knowledge
- When the system doesn't operate normally
- When the key touches the metallic one or it is covered
- When the key is a key (key with built-in the signal transmitter) for the security system of
other vehicles and comes in succession or approaches
- In the state of the electric steering wheel lock's being locked by caught etc.
Attention
- To operate the engine immobilizer system normally
Please do not remodel of invalidating the system etc. and do not detach it.
The system might not operate normally if it doesn't guard.
68
Ant on _ KA
Before it drives
can be depressed
enough easily also makes the seat the angle
of the drip ( P. 41) either.
The ( P. 47) seat belt that makes
the center of the ( P. 56) headrest
where the steering wheel that the
supplemental restraint system airbag
turns to my chest is located the
rear side of the ear can be correctly
worn ( P. 49).
69
Ant on _ KA
Warning
- While running
- Please do not adjust the driver's seat while running.
Driving might be mistaken.
- Please do not put the cushion of the back etc. between the drip and the back.
The effects such as seat belts and headrests might not be demonstrated enough when cannot
not only take correct driving posture but also colliding and it is dangerous.
- Please do not put the thing under the reception desk seat.
Important injury that is not fixed the seat when the thing narrows, causes an unexpected accident, and
is related to the life might be received and it is dangerous. Moreover, it causes the breakdown of the
adjustment mechanism.
70
Ant on _ KA
71
Ant on _ KA
Knowledge
- When the supplemental restraint system airbag develops
- The bruise file wound etc. might be received by contact with the supplemental restraint system airbag.
- A white gas is generated with the operation sound.
- Not only a part etc. of the reception desk seat, the reception desk pillar, and the
roof side rail but also each part of the air bag module (hub, air bag cover, and inflator of
the steering wheel) might become hot for several minutes. The air bag becomes
hot, too.
- The reception desk in case of the collision from forward at strength of the impact near a set
value Neither the supplemental restraint system airbag nor the seatbelt pretensioner might operate
at the same time.
72
Ant on _ KA
- When knocking against a hard thing like the edge etc. of the curb
- When it falls in the deep hole and the ditch or it gets it over
Before it drives
- When the supplemental restraint system airbag doesn't operate (reception desk supplemental restraint system airbag)
To operate by the impact from the impact from the side and the rear side, turning sideways or low speeds
forward, the reception desk supplemental restraint system airbag is not designed. However, the reception
desk supplemental restraint system airbag might operate when those impacts cause the
deceleration forward enough.
73
Ant on _ KA
To operate by the impact from the side at the impact from forward and the rear side,
turning sideways or low speeds, neither the SRS side air bag nor the SRS curtain shield air
bag are designed.
74
Ant on _ KA
Before it drives
75
Ant on _ KA
Warning
- About the supplemental restraint system airbag
Please guard the following.
In the worst case, it reaches important injury if it doesn't guard or, it is likely
to lead to the death.
- Those who drive and all crew must wear the seat belt correctly.
The supplemental restraint system airbag is a thing to assist the seat belt.
- In the worst case, it reaches important injury because the passenger's seat supplemental restraint system
airbag swells in strong power or, it is likely to lead to the death. It is especially dangerous when the crew is near
the place where the supplemental restraint system airbag swells. Please the back of the seat also must adjust the drip,
separate the seat from the supplemental restraint system airbag as much as possible, and sit straight.
- In the worst case, it reaches important injury if the child is not firmly sitting on the seat by
the impact that the supplemental restraint system airbag swells or, it is likely to lead to the death.
Please fix with the child seat firmly when you cannot use the seat belt
because the child is small. I
will encourage the child seat or the seat belt to put on the [riya] seat,
and to be worn by the child. ( P. 80)
- Neither those who drive nor the passenger's seat crew have
anything on the knee.
76
Ant on _ KA
Warning
- About the supplemental restraint system airbag
- It doesn't lean against the door, the reception
1
Before it drives
77
Ant on _ KA
Warning
- About the supplemental restraint system airbag
- Please do not use the seat accessories with which the place where the SRS side
air bag swells is covered.
- Please do not put a hard thing such as suspenders on the coat hook.
It is thrown out when the SRS curtain shield air bag operates and it is
likely to lead to an important injury or death.
- The supplemental restraint system airbag system configuration part surrounding must not be overpowered
as the strong beating etc.
The supplemental restraint system airbag might not operate normally.
- It is not necessary to touch immediately after the supplemental restraint system airbag's having swollen so
that complete parts are hot.
- Please confirm safety and whether the door and the door glass are opened and put some air when feeling
that breath is painful after the supplemental restraint system airbag swells go out outside the car.
Please flush traces to prevent the inflammation of the skin as soon as possible.
- Please do not use as it is, and exchange it in the Toyota shop when the wound has placed to
the pad and the reception desk pillar garnish where the supplemental restraint system airbag is
stored or there is a crack.
78
Ant on _ KA
Warning
- About remodeling and abandonment
Please do not remodel as follows and abandon it without the consultation to the Toyota shop.
The supplemental restraint system airbag might not operate normally, and it reaches important
injury or, in the worst case, it lead to the death by swelling by mistake.
Before it drives
- Detaching, installation, taking apart, and repair of supplemental restraint system airbag
- Improper repair around steering wheel, Instrument panel, dashboard, seat,
seat epidermal, reception desk side rear pillar, and roof side rail, detaching,
and remodeling
- Improper repair and remodeling of reception desk fender, reception desk bumper, and vehicle guest room side part
- Installations such as grill guard ([buruba-] kangaroo bar etc.) and devices of clearing
snow and winches
- Remodeling of suspension
- Installation of electrical appliances such as CD players and wireless machines
79
Ant on _ KA
[Topputeza-anka-]
When [teza-beruto] is fixed, it
uses it.
[Topputeza-anka-] is equipped
with the package tray behind
the rear seat.
80
Ant on _ KA
It fixes with the child seat fixation mechanism addition seat belt.
The back also adjusts the angle of the drip.
After it pulls a lever, and the back also knocks
1
Before it drives
81
Ant on _ KA
82
Ant on _ KA
It fixes with bar & [topputeza-anka-] only for the child seat fixation for ISOFIX.
The back also adjusts the angle of the drip.
After it pulls a lever, and the back also knocks
1
Before it drives
83
Ant on _ KA
Knowledge
- About bar & [topputeza-anka-] only for the child seat fixation for ISOFIX
We will recommend bar & [topputeza-anka-] only for the child seat fixation for this
ISOFIX to install the seat (Toyota pure child seat for bar & [topputeza-anka-]
only for the child seat fixation for ISOFIX) only for the child who suits the security
standard of the road transportation vehicle. Please consult the Toyota shop
when you select the child seat.
84
Ant on _ KA
Warning
- About the child seat
- Please use the seat belt or the child seat according to the age of the child and the
size of the body to protect it effectively when the accident and you stop suddenly. Instead,
embracing the child in the arm doesn't become it about the child seat. The child
Before it drives
might be faced with a windshield, crew, and indoor equipment during the accident.
- Please use the child seat suitable for the age of the child and the size of the body
and install it in the rear seat.
- Do not start leaning in the vicinity of the door, the seat, the reception desk
pillar, and the roof side rail even if make them sit on the child seat any part of
child's head and body. It is very dangerous, and important injury might be received, and, in
the worst case, it lead to the death when the supplemental restraint system airbag swells.
- About the seat belt with the child seat fixation mechanism
Please do not let the child play with the child seat fixation mechanism addition seat
belt. It becomes impossible to draw out the belt when it operates by mistake, and the belt coils
around the neck by any chance and it reaches important injury like suffocation etc. or, in the worst case,
it is likely to lead to the death.
Please cut the seat belt with scissors etc. when it enters such a state by any
chance by mistake, and the buckle cannot be removed.
- Please move the child seat right and left, and confirm whether to be fixed
firmly.
85
Ant on _ KA
Warning
- When you install the child seat
- Please install it in the [riya] seat on the
passenger side when the driver's seat and the
child seat interfere, and the child seat is not
installed correctly.
- Please do not draw out the shoulder department belt fully to prevent the child
seat fixation mechanism from operating when you install the junior seat in [riya] outside
seat.
- The shoulder department belt must come to the center of child's shoulder always
when you use the junior seat. Please do not separate the belt from the neck and do not
fall from the shoulder. It might lead to important injury and the death and is dangerous in the
accident and the sudden braking if it doesn't guard.
- When you use the bar only for the child seat fixation for ISOFIX, please confirm
whether there is no in the surrounding the obstacle the seat belt doesn't narrow.
86
Ant on _ KA
Warning
- When you do not use the child seat
- When the child seat is installed in the vehicle, ( P. 81, 83) ..the installation on the
seat surely by the proper procedure... Please avoid putting it in the guest
room while not fixed firmly to the seat even when the child seat is not
Before it drives
used.
- Please unload from the vehicle, keep when detaching the child
seat is necessary or store in the trunk, and fix firmly.
Attention
- About [topputeza-anka-]
Please close the cap surely when you do not use it. The cap might be damaged
when leaving open.
87
Ant on _ KA
88
Ant on _ KA
drive
2
2-4. Other crane travel mechanisms
How to use131
1
s y s t e m
1 1 5
m u l t i
information
d i s p l a y
129
89
Ant on _ KA
It starts.
The gear-shift is made D with stepping on the brake pedal
( P. 106).
The parking brake is released.
( P. 109)
The foot is gradually separated from the brake pedal, it steps on the gas pedal
slowly, and it starts.
- It stops.
The parking brake is put if necessary ..stepping
on the brake pedal.. like ..gear-shift.. D.
The gear-shift is made P or N when stopping for a long time.
( P. 106)
It parks.
The gear-shift puts the parking brake that steps
on the brake pedal like D.
( P. 109)
( P. 106)
90
Ant on _ KA
- View worsens, the glass becomes cloudy, the road becomes slippery on the
day of rain, and run carefully, please.
- Please run carefully in beginning get off about rain so that the road is slipperier.
- The water film is generated between the tire and the road, neither the steering wheel nor the brake
might work in the high speed operation on the day of rain etc. , and do the speed, please with
unassuming modesty.
91
Ant on _ KA
Warning
- When starting
Please operate the gear-shift with the brake pedal firmly depressed.
The car is prevented from beginning to move by the creep phenomenon.
- Please do not run on a combustible thing, and stop the car to the vicinity of the
combustible. The exhaust tube and the vehicle exhaust emission might become fires when is becoming the high temperature, and near the
combustible and are dangerous.
- Never do the retreat by inertia with the gear-shift put in the shift position on
the advancement side, and advancement by inertia while put in R.
The engine might stop, working of the brake worsen, the steering wheel become
heavy, and it cause an unexpected accident and the breakdown.
- Please confirm the door glass is opened, and the trunk is closed when the vehicle exhaust
emission smell is noticed in the car. A large amount of vehicle exhaust emission causes drowsiness, there is fear to another
who becomes a cause of the accident and important health problems and the death, and it is dangerous. Please receive
maintenance promptly in the Toyota shop.
92
Ant on _ KA
Warning
- When you drive
- Please do not make the gear-shift N while running.
Because the engine brake doesn't work at all when making it to N, it might
cause an unexpected accident.
not rotating.
- In the sharp incline, please drop one's speed with an engine brake.
The brake overheats when the service brake is continuously used too much and it
doesn't function normally. ( P. 106)
Please adjust the steering wheel, the seat or neither door mirror nor the inner mirror.
Driving is mistaken, it causes an unexpected accident, there is fear of important injury and the death, and it
is dangerous.
- There must not be fear of important injury and the death, and all of those who multiply this must not
put out a part of the head, the hand, and other bodies from the car.
- Please do not run putting luggage on on the seat and the vicinity.
It dashes out and it hits the crew, it damages luggage, and the nature is taken in
luggage by luggage, and when time that slammed on the brakes and turning, it might connect
and is dangerous in an unexpected accident.
93
Ant on _ KA
Warning
- When you drive a slippery road
- The sudden braking, the rapid acceleration, and the abrupt steering become impossible for the tire to slip, and
to control the vehicle it, might cause an unexpected accident, and are dangerous.
- A sudden change in the engine rotational speed such as engine brakes by the shift
up and the shift down might cause an unexpected accident by sideslipping by the car and
is dangerous.
- Please confirm the brake works normally lightly stepping on the brake pedal after
it runs of the puddle. It worsens working of the brake, is effective only of one that
has not been wet, taken the steering wheel when the brake pad is wet, might cause an
unexpected accident, and is dangerous.
- When stopping
- Please do not rev.
It starts rapidly by the car when there is a gear-shift besides P or N, might cause
an unexpected accident, and is dangerous.
- Please do not leave a long time starting up an engine. Please confirm the car is stopped
to the opened place, and the vehicle exhaust emission doesn't enter in the car when it is necessary by
all means.
- Please always put the foot on the brake pedal to prevent the accident because the car begins to
move while the engine is rotating.
- Please use the brake pedal and the parking brake to prevent it from beginning
to move when about stopping on the slope and causing the accident.
94
Ant on _ KA
Warning
- When parking
- Please leave glasses or neither spray can nor the can etc. of the carbonated drink in the car under
hot weather. The following things might happen when having left it and it is
dangerous.
The gas leaks from the spray can, and it breaks out.
Glasses of a plastic lens plastic material are transformed or crack.
2
[Wo] is caused.
To the cause to which the can of the carbonated drink explodes and it makes dirty in the car, and electric parts are short
It becomes it.
- Please do not leave the writer left in the car. The final controlling element
of the writer mis-operates when luggage is pushed or the seat is moved when it puts in
the glove box of the writer etc. or it is left to drop in the car, and it might connect
with a fire and is dangerous.
- Please do not put the sucker on the window glass etc.Moreover, please do
not put the container of the aromatic substance etc. on the Instrument panel and the
dashboard.
It works the lens by the sucker and the container, might cause the vehicle fire, and is dangerous.
- Please leave neither door nor the window when you paste the metallic deposition film of the
silver color etc. to the curved surface glass while opened. It reflects in the curved surface glass
direct sunshine, works the lens, might connect with a fire, and is dangerous.
- Please put the parking brake, make the gear-shift P, stop the
engine, and lock.
Please do not part from the car while it engines starts.
- It is not necessary to touch the exhaust tube immediately after the stop while the engine is rotating.
The burn might be done.
- Please do not leave starting up an engine in the place where the snow and the snow pile.
The vehicle exhaust emission stays because of the snow that piles in the circumference, it enters in the car, there is fear to
important health problems and the death, and it is dangerous.
95
Ant on _ KA
Warning
- About the vehicle exhaust emission
- There is fear to important health problems and the death when the vehicle exhaust emission is inhaled because deadly
carbon monoxide (CO) is contained in the vehicle exhaust emission in colorlessness and scentless and it is dangerous.
- Please sometimes check the exhaust tube. Please receive maintenance in the Toyota shop
when you notice abnormality etc. of the damage of the hole, the crack such as the corrosion such as the exhaust
tubes, and the joint and the exhaust sounds. The vehicle exhaust emission invades in the car when using it
as it is, there is fear to important health problems and the death, and it is dangerous.
- Please do not step on the brake pedal repeatedly when the engine stops by any
chance. Whenever pedaling, savings of the assistance power of the brake are used completely.
- The brake system is composed of two independent systems, and the other operates
even if the other oil pressure system breaks down. In this case, it is necessary to step on the
brake pedals harder than usually, and the slip distance for brake becomes long. Please do not run
with only the other brake system operating. Please receive the repair
of the brake at once.
96
Ant on _ KA
Warning
- Escape circle [shitatoki] (4WD car) : by any chance.
It is not necessary to run idle it excessively when either of tire is pending.
It might cause damage of the drive and the system parts and an unexpected accident because of dashing out of
the vehicle.
Attention
- While driving
When you drive
Please do not use the gas pedal to stop on the slope, and step on neither
gas pedal nor the brake pedal at the same time.
- When parking
Please make the gear-shift P. When the car begins to move or the gas
pedal is depressed by mistake, it is likely to start rapidly if it doesn't make it to P.
- Please run as slowly as possible when you pass the difference etc. to prevent
the disc wheel etc. being damaged.
- When hearing of the creak and the scratch sound (brake pad indicator)
Please receive the check in the Toyota shop, and exchange the brake pads as soon as possible.
If pads are not exchanged when it is necessary, it is likely to connect with the damage of
the rotor.
Parts such as the brake pads and the disk rotors function and
are worn out. The breakdown might not only be caused when running exceeding the limit of
wear-out but also it causes the accident.
97
Ant on _ KA
Attention
- When it has tire punctured while running
The tire blowout and damage are thought when it is the following. Please apply the brakes
gradually with the steering wheel firmly, and give to me at reduced speed.
- It stalls.
- Electrical equipment is short.
- Engine damage that inhales water
Please check in the Toyota shop as follows when running on the water-covered road
by any chance, and soaked in water.
- Lubrication is defective in the propeller shaft (4WD car) and each bear and collaborate each.
98
Ant on _ KA
Engine (ignition) switch (smart entry & start system installation car)
The mode can be switched by pushing "Engine start stop"
switch carrying an electronic key. (The engine can be started
from any mode by operating the switch while stepping on the brake
pedal. )
Accessories mode
The electrical equipment such as audio
can be used.
The indicator on the switch lights
to the orange color.
Ignition ON mode
All electrical equipments can be used.
The indicator on the switch lights
to the orange color.
99
Ant on _ KA
Knowledge
- To release the steering wheel lock
Please push "Engine start stop" switch
while moving the steering wheel right and
left.
The indicator of "Engine start stop"
switch blinks to green when the steering
wheel lock has not been released.
100
Ant on _ KA
- When the indicator on "Engine start stop" switch blinks to the orange
color
Abnormality might be found in the system. Please receive the check at once in
the Toyota shop.
The rotation of the starter is maintained for 20 seconds or less until the engine starts when the engine start
When you drive
- Situation that smart entry & start system might not work normally
P. 30
101
Ant on _ KA
Warning
- When you start the engine
Please get under the wheel. At this time, never step on the
gas pedal. It causes an unexpected accident, and it reaches important injury or, in the
worst case, it is likely to lead to the death.
- Warning of running
Please do not touch "Engine start stop" switch while running.
The engine stops when keeping pushing, it causes an unexpected accident, and it reaches important
injury or, in the worst case, it is likely to lead to the death.
Attention
- To prevent the battery rising
Please do not leave it for a long time when not engining starts
with "Engine start stop" switch made the accessories mode or
ignition ON mode.
102
Ant on _ KA
Engine (ignition) switch (smart entry & start system non-installation car)
- Position of engine switch
. LOCK "(OFF)
The key can do pulling out [**].
. ACC "
The electrical equipment such as audio
can be used.
. ON "
. START "
The engine can be started.
103
Ant on _ KA
Knowledge
- To spend the key from . ACC " in . LOCK "
It is confirmed that the gear-shift is
at the position of P.
It spends in . LOCK " while pushing
the key.
104
Ant on _ KA
Warning
- When you start the engine
Please get under the wheel. At this time, never step on the
gas pedal. It causes an unexpected accident, and it reaches important injury or, in the
worst case, it is likely to lead to the death.
Attention
Please do not leave it for a long time when not engining starts with the
engine switch made . ACC " or . ON ".
105
Ant on _ KA
Automatic transmission
Please choose the shift position according to the situation.
Purpose
Parking or engine start
Retreat
Running * usually
Running on slope
- Please usually use D position for the fuel cost improvement and the decrease of the noise.
106
Ant on _ KA
Knowledge
- Reverse warning buzzer
It is informed that the buzzer rings when the gear-shift is put in R, and it exists in R those
who drive.
The function of an advanced automatic changing the speed control to have used the function of the navigation system.
When you drive
Warning
- On a slippery road
Please note that a sudden accelerator operation and a rapid change in the engine
brake power cause the sideslip and spin.
107
Ant on _ KA
Knowledge
- Operation condition
Smart entry & start system installation car
When smart entry & start system non-installation car engine
switch is . ON " when "Engine start stop"
switch is ignition ON mode
108
Ant on _ KA
Parking brake
The parking brake is put.
The parking brake pedal is fully
depressed with the left leg while stepping
on the brake pedal by the right leg.
released.
The parking brake pedal
is depressed again with the
parking brake hangs.
Knowledge
- Warning buzzer when running unreleasing parking brake
P. 260
Attention
- Attention before it runs
Please release the parking brake completely.
Working of the brake might overheat when running with the parking
brake put the brake parts, worsen, and be worn-out early.
109
Ant on _ KA
Meters
[Oputei;toronme-ta-]/[supo-tsuoputei;toronme-ta-]
Fuel gauge
The amount of the fuel remainder is shown.
When the residual quantity becomes it below constancy, the amount of the detailed remainder can be displayed. ( P. 120)
Speed meter
The transport speed of the vehicle is shown.
110
Ant on _ KA
- Trip meter
The mileage after it resets it is displayed.
Two kinds of (trip A and trip B) section distances can be used properly.
P. 118
DISP button
The display of the multi information display is switched. ( P. 118)
111
Ant on _ KA
Analog meter
Tachometer
The engine rotational speed of per minute is shown.
Fuel gauge
The amount of the fuel remainder is shown.
When the residual quantity becomes it below constancy, the amount of the detailed remainder can be displayed. ( P. 120)
Speed meter
The transport speed of the vehicle is shown.
112
Ant on _ KA
Odometer/trip meter
- Odometer
A total distance where it runs is displayed.
- Trip meter
The mileage after it resets it is displayed.
Two kinds of (trip A and trip B) section distances can be used properly.
P. 118
DISP button
113
Ant on _ KA
Attention
- To prevent damage to the engine and complete parts
- The needle of the tachometer must not enter Red Zone (range to exceed a permissible
rotational speed of the engine).
- Please stop in the place of safety at once so that there is fear of overheating when the display
of the water temperature meter reaches the top and you blink. ( P. 289)
114
Ant on _ KA
2
When you drive
Analog meter
115
Ant on _ KA
Central panel
- Pilot light
The operation situation of the system is displayed.
Direction instruction
pilot light ( P. 108)
Ecodrive
Indicator * ( P. 91)
Headlight
Upward pilot light ( P. 122)
Reception desk Fogra Ito
pilot light * ( P. 126)
- Ignition ON mode (smart entry & start system installation car) or the
engine switch is lit in case of . ON " (smart entry & start system
non-installation car), and when after a few seconds or the engine starts,
"Engine start stop" switch is turned off for the operation confirmation.
There is fear of the system malfunction do not light and in the state of lighting.
Please receive the check in the Toyota shop.
* :Different equipment and option equipment in vehicle model etc.
116
Ant on _ KA
- Warning light
It warns of an emergency system malfunction etc.( P. 260)
1
*-
- 1
- 1
- 1
- 1
- 1
- 1
- 2
1 Ignition ON mode (smart entry & start system installation car) or the
engine switch is lit in case of . ON " (smart entry & start system
non-installation car), and when after a few seconds or the engine starts,
"Engine start stop" switch is turned off for the operation confirmation.
There is fear of the system malfunction do not light and in the state of lighting.
Please receive the check in the Toyota shop.
- Two "Engine start stop" switch unifies to lighting the half door warning
light when ignition ON mode (smart entry & start system installation
car) or the engine switch is . ON " (smart entry & start system
non-installation car), and the half door warning display is displayed
in the multi information display. ( P. 120) -
Warning
- When the warning light of the safety device doesn't light
Supplemental restraint system airbag..safety device..warning
light..engine..start..stop..switch..ignition..mode..smart..entry..start..syste
m..installation..car..engine..switch..smart..entry..start..system..instal
lation..car..light..light..in the state of..accident..provide..correc
117
Ant on _ KA
Display switch
To switch the display, the DISP
button is pushed.
118
Ant on _ KA
119
Ant on _ KA
Knowledge
- About the fuel detailed remainder amount display
When the residual quantity display of the fuel gauge is two or less, a detailed residual quantity can be confirmed.
When confirming it, the DISP button (Or,
DISP switch *) is pushed while displayed
for the distance that can cruise on the
multi information display.
It returns to the display of the distance that can cruise after
it is displayed for about six seconds.
- Navigation system installation car of
manufacturer option
120
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
Light switch
The headlight etc. can be lit by hand power ..automatic operation *...
*
switch is ignition ON
mode, two [konraito] can
be used.
121
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
122
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
2
When you drive
Dial position
Crew
Luggage
1.5L FF car
(front-wheel drive car)
None
None
All crew
None
1.5
1.5
All crew
1.5
123
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
Knowledge
- Light sensor ([konraito] installation car)
Please paste to the window glass neither
putting the thing on the sensor nor
closing the sensor. Neither an automatic lighting nor
the turning off function work normally when light from surroundings
is shut out.
- When "Engine start stop" switch is made the accessories mode or to turn off without turning
off the light switch and the driver's seat door is opened, the lighting front position
light etc. are turned off by the automatic operation.
124
Ant on _ KA
Or,
2-3. How to use of how to apply it and the wiper of the light.
Or,
It drinks and [aruto] and the driver's seat door are opened to the location.
Or,
It drinks and [aruto] and the driver's seat door are opened to the location.
Attention
- To prevent the battery rising
Please do not light the light for a long time with the engine stopped.
125
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
Knowledge
- Lighting condition
When the headlight or the front position light lights, it is possible to use it.
126
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
127
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
Knowledge
- Operation condition
Smart entry & start system installation car
When smart entry & start system non-installation car engine
switch is . ON " when "Engine start stop"
switch is ignition ON mode
Attention
- When the reception desk window glass is dry
Please do not use the wiper.
The glass might be damaged.
128
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
2
When you drive
Knowledge
- Operation condition
Smart entry & start system installation car
When smart entry & start system non-installation car engine
switch is . ON " when "Engine start stop"
switch is ignition ON mode
129
Ant on _ KA
2-3. How to use of how to apply it and the wiper of the light.
Attention
- When [riyauindou;garasu] is dry
Please do not use the wiper.
The glass might be damaged.
130
Ant on _ KA
- Brake assistance
2
- VSC *([bi-kurusutabiritei;kontoro-ru])
The system that tries to control the output of the brake and the engine automatically to control
the sideslip on a rapid steering wheel control and a slippery road etc. when turning, and to secure
the direction stability of the vehicle.
131
Ant on _ KA
- To stop TRC
To stop TRC, the switch is
pushed.
The slipping pilot light lights.
It returns to the state that the system can
operate when the switch is pushed again.
132
Ant on _ KA
Knowledge
- About an automatic return of TRC and VSC
TRC and VSC automatically return to the state that can be operated when "Engine
start stop" switch is turned off after TRC and VSC stop operating.
- Operation sound of ABS, brake assistance, and VSC and TRC and vibrations
- It is not abnormal though it is likely to hear of the operation sound from the engine room
immediately after the engine start and the start when repeatedly stepping on the brake.
133
Ant on _ KA
Warning
In the following situations, the accident might happen, important as a result injury be received, and,
in the worst case, it lead to the death.
- When the slip distance for brake becomes longer than usually because ABS operates
ABS is not a device that shortens the slip distance for brake. Please always do the speed with unassuming modesty
and take a preceding vehicle and a safe distance between two cars in the following situations.
- When you run on the road and the snowfall road of mud and gravel
- When you install the tire chain
- When you exceed the difference such as the tie eyes of the road
- When you run in the bad road of the road and stone [dataminado] with ruggedness
- When you cannot demonstrate the effect of TRC
Even if TRC operates, neither the direction stability nor the driving performance of the vehicle
might be obtained on a slippery road. In the situation in which the direction stability and the driving performance
of the vehicle are lost, please drive especially carefully.
- When the slipping pilot light blinks, and the operation warning buzzer rings
It is informed that VSC is operating them. Please always bear the safe driving in mind.
The aggressive driving might cause an unexpected accident and is dangerous. Please drive especially
carefully when the pilot light blinks, and the buzzer rings.
134
Ant on _ KA
Warning
- When you exchange tires
4 Please make it to the recommended air pressure with a tire of the same manufacturer and
the brand and the tread pattern (ditch pattern) by the size specified the circle. ( P. 298)
Neither ABS nor VSC operate normally when a different tire is installed.
Please consult the Toyota shop when you exchange the tire or wheels.
2
When you drive
135
Ant on _ KA
Cruise control *
It is possible to run a constant speed even if not stepping on the gas pedal.
136
Ant on _ KA
Return
It returns to former constant speed running
when the lever is raised. However, the velocity
of the car is about 40 It doesn't return at the time
of km/h or less.
137
Ant on _ KA
Knowledge
- About the setting condition
- When the gear-shift is D or S, it is possible to set it.
- The velocity of the car is about 40 It is possible to set it from km/h within the range at 100 km/h.
- Accelerator operation
It is possible to accelerate with the accelerator as well as running usually. It returns to the velocity of a set car after it accelerates.
- An actual speed is about 16 from the setting speed When km/h or more decreases
- The velocity of the car is about 40 When becoming km/h or less
- When the car slips sideways and VSC * works
- When the pilot light blinks in the constant speed running
Please turn off the main switch once, and set it again.
There is fear of the system malfunction when it is not possible to set or it is released
at once. Please receive the check in the Toyota shop.
138
Ant on _ KA
Warning
- To prevent the operational error
Please turn off the main switch when you do not use the cruise
control.
139
Ant on _ KA
- When using it
The switch is pushed.
Backing & clearance sonar pilot
light lights, and the buzzer rings.
It is released when pushing again, and the pilot
light is turned off.
140
Ant on _ KA
Knowledge
- Operation condition
Backing & clearance sonar switch operates when all the following requirements
are met with turning on respectively.
141
Ant on _ KA
At approach to
driver side
[Pippippi]
(discontinuous sounds)
About 50 - 37.5cm
(blinking)
(blinking)
[Pipipipi]
(fast discontinuous sounds)
About 37.5-25
cm (fast blinking)
(fast blinking)
About 25 Cm or less
Feep(continuous sound)
(lighting)
142
Ant on _ KA
Buzzer sound
(lighting)
- [Riyako-na-sona-]
Rough distance
to obstacle
At approach to
driver side
Buzzer sound
[Pippippi]
(discontinuous sounds)
About 50 - 37.5cm
(blinking)
(blinking)
[Pipipipi]
(fast discontinuous sounds)
About 37.5-25
cm (fast blinking)
(fast blinking)
About 25 Cm or less
Feep(continuous sound)
(lighting)
(lighting)
143
Ant on _ KA
- Backing sonar
Rough distance
to obstacle
Buzzer sound
[Pippippi] (slow
discontinuous sounds)
[Pippippi]
(discontinuous sounds)
About 60-45 Cm
(blinking)
[Pipipipi]
(fast discontinuous sounds)
About 45-35 Cm
(fast blinking)
About 35 Cm or less
Feep(continuous sound)
(lighting)
144
Ant on _ KA
When you perceive the obstacle in two or more places at the same time
The buzzer sound changes as follows when the obstacle is perceived in two or more places
at the same time.
When you perceive the obstacle with the reception desk corner clearance warning system
or [riyako-na-sona-]
- The obstacle is about 25 When the obstacle is newly perceived
by other parts while perceived within the cm, the buzzer sound
repeats "[Pipipipipipipipi-]".
145
Ant on _ KA
146
Ant on _ KA
. -
Knowledge
Abnormal display and warning of backing & clearance sonar
The buzzer that informs them of abnormality rings for about seven seconds at the same time as the pilot
light's in the meter blinking when abnormality of the sonar occurs when the obstacle is not perceived.
( P. 262)
"Engine start stop" switch comes to remain always being being abnormally displayed
until abnormality is canceled when ignition ON mode and backing &
clearance sonar switch ( P. 140) is turned on if abnormality is detected once.
The buzzer volume of the clearance sonar and the perception beginning distance of the backing sonar
can be changed. (customizing list P. 301)
Warning
- Attention when using it
- There are limits at the detectable area and the operation speed of the sonar. Please confirm safety outside the
perception of the sonar around the vehicle (especially, vehicle side etc.) range without fail, control the velocity of
the car enough with the brake, and drive the car slowly when it advances and you retreat (Moreover, please note the
slip distance for brake to change depending on the road surface conditions such as rain and gravel).
The detectable area of the sonar is limited around a vehicle corner part and back bumper.
In shortening of the distance that can be perceived according to shape and the condition of the obstacle, and perception
Coming [naiko] and [gaarimasu].
It somewhat takes time from the perception of the obstacle to ringing of the display and the buzzer.
Even the obstacle is about 25 before the display and the buzzer ring when ultra low-speed
running It is likely to approach within the cm (The backing sonar is about 35 within the cm).
147
Ant on _ KA
Warning
- Attention when using it
- Please do not install the accessories articles etc. within the range that the sonar perceives.
It doesn't operate normally the clearance sonar, be likely to cause an unexpected accident, and
is dangerous.
- First of all, please confirm the state of the sensor when abnormal display ( P. 263)
appears. Abnormality of the sensor is thought and receive the check in the Toyota shop, please when
an abnormal display appears to there are neither ice, a snow nor mud.
- It might not operate normally at the following the clearance sonar, might cause an
unexpected accident, and is dangerous. Please drive carefully.
When ice, the snow, and mud, etc. adhere to the sensor (Return normally if it removes)
When the sensor assembly freezes (Return normally if it melts)
Especially, an abnormal display might not appear, and it perceive it by freezing even if there
is an obstacle at the low temperature.
When you close the sensor with the hand etc.
When the vehicle posture inclines greatly
At the hot weather under and the cold
At irregularity road, slope, gravel walk, and grassy place running etc.
Engine sound of another car horn and motorcycle, airbrake sounds of large-sized car, and another cars
When drinking and generating the supersonic wave such as [ku] rear rance sonars approach
When downpour and the spray hang
When you attach fender Paul on the market and the wireless machine antenna to the car
When you advance toward a tall curb and the curb of the right angle
The perception distance shortens according to the object of the sign etc.
The vicinity right under the bumper is not perceived.
No neither object that is lower than the sensor nor a thin paling, etc. might be suddenly perceived
when approaching even if it perceives it once.
When the obstacle approaches the sensor too much
148
Ant on _ KA
Warning
- Obstacle that might not be able to be perceived accurately
The following things might not be perceived. Please drive carefully.
Detailed things such as wire, fences, and ropes
Thing to absorb sound waves such as cotton and snows easily
Thing of acute angle shape
It is tall and a thing that the part projects.
2
Short thing
Attention
- Attention when using it
- The device of the sonar might not operate normally due to abnormality etc.
at the following. Please receive the check in the Toyota shop.
The switch when the buzzer of turning on doesn't ring
The operation display of the clearance sonar blinks with the obstacle not perceived.
When it does, and the buzzer rings
When the thing was thrown at the vicinity of the sensor and when a strong impact of the beating etc. is given
When you throw the bumper
In the state of the display's lighting so as not to hear the buzzer sound
149
Ant on _ KA
ETC system *
The ETC(Electronic Toll Collection) system is a system that adjusts the
charge by the automatic operation to pass the tollway smoothly.
It communicates between ETC units of a road side wireless device and the vehicle, and the
charge is pulled down from the pulling down account of the ETC card to which the customer is
registered later.
150
Ant on _ KA
ETC unit
It is installed in the vehicle.
The equipment to communicate data necessary for the charge adjustment stored on the ETC card with
a road side wireless device.
ETC card
The card for the ETC unit installed in the ETC unit equipped with the integrated circuit chip.
Data necessary for the charge adjustment is maintained in the integrated circuit chip.
2
Knowledge
Warning
- Ahead of the use
Those who drive must operate neither pulling out [**] doing of the ETC card nor the ETC unit as
much as possible for safety while running.
The operation under running might cause an unexpected accident as the steering wheel control is mistaken
and is dangerous. Please operate it after stopping the car.
Attention
- When other service (smart IC etc.) is used
Additionally, there are various restrictions in service (smart IC etc.)
with ETC unit. Please confirm use that the service provider guides.
151
Ant on _ KA
Attention
- Before inserting the ETC card
Please note cutting of the expiration date of the ETC card. The opening and shutting bar doesn't
open when the ETC card is expired. Please confirm the expiration date described
in ETC card on hand beforehand.
- The insertion of the ETC card in this side of the toll gate might cause the error by the
time the ETC unit attests the ETC card because it borrows for a few seconds.
- Please it is likely not to open in the opening and shutting bar set up in the ETC
lane when the communication between the communication or the ETC unit and the ETC card
between ETC unit and road side wireless device is not normally done.
- Please pass after confirming it decelerates enough to stop safely in this side of the opening and shutting
bar after the distance between two cars with the preceding vehicle is maintained, and the opening and shutting
bar opened when you pass in the ETC lane.
152
Ant on _ KA
- Installation position
It is while center boxing
( P. 200).
Smart entry & start system
installation car
The power supply of the ETC
2
153
Ant on _ KA
Knowledge
- Before using ETC
When the ETC system is used for the first time, the setup procedure of the ETC
unit is necessary beforehand.
- When dirt and the snowfall of the reception desk window glass are awful
Please remove them.
154
Ant on _ KA
Attention
- Attention in handling
- Road..side..wireless..device..communication..disturb..unit
..antenna..Instrument panel..center..near..build into..upper
side..thing..put.
- Please do not put the foreign body etc. in the ETC unit. The ETC unit
might break down.
2
- Please do not strike close to home to the ETC unit. The ETC unit might break
down, and be damaged.
- Please do not touch the ETC unit by a wet hand, and put water (liquid
etc.). Water enters in the ETC unit, and it is likely to break down and to damage it.
- Please wipe dirt off with a soft, dry cloth when becoming dirty. Please
never use wax, thinner, and alcohol, etc.The ETC unit
might be transformed and break down.
- The opening and shutting bar at the gate might not open when two or more ETC units
are installed in one vehicle.
155
Ant on _ KA
Attention
- Attention in handling
- Please follow notes that the ETC card issuer presents about the handling
of the ETC card.
- Please do not use the ETC card with which the ETC card and the terminal of the metal (integrated
circuit chip) where the Scotch tape seal etc. are pasted are dirty.
The ETC unit might not operate normally, and it cause the breakdown as it
becomes impossible to take out the ETC card.
156
Ant on _ KA
A green lamp and the bitter orange lamp of the ETC unit light at the same time, and it turns it off
after a while.
voice guide when the ETC card is inserted at once after the engine starts, and the
display guide not be done.
Ant on _ KA
Knowledge
- When the bitter orange lamp lights
It is not possible to use it because it sets up and the ETC unit is not followed a procedure.
- When you insert the ETC card that the expiration date cutting and was canceled
The opening and shutting bar doesn't open though the error display is not done.
Attention
- When a green lamp has blinked
Please do not pull out the ETC card.
Data in the ETC card might be damaged.
158
Ant on _ KA
is stopped.
We will inform you by "Forgetting to pull out the card warning" that the engine is stopped before
the ETC card is extracted.
Knowledge
When you drive
- We will inform you only because of the buzzer sound "Feep" when the volume is set to 0.
- It is possible ..this function.. not to work (Turn it off).
- Setting change of forgetting to pull out card warning
The ETC card is inserted, and a green lamp lights.
[Wo] is simultaneous.
- "[Pippi]" and the sound are heard whenever operating it, and ON/OFF of the function changes.
- Please operate it after it stops in the place of safety.
Attention
- When parting from the car
Please do not leave the ETC card left in the car. The ETC card might be
transformed by the rise in heat in the car, and data in the ETC card be damaged.
159
Ant on _ KA
About the lamp display and the notification sound using ETC
The vehicle is notified the lamp display of the ETC unit changing according to the situation, and also while
running because of the sound.
- When you pass the ETC gate (entrance) and the examination of tickets place, previous notice
antenna, and ETC card uninsertion information antenna
Previous notice antenna/ETC
card uninsertion information antenna
Notification sound *
Vehicle
Vehicle
Traveling direction
Lamp
display
Notification sound
Voice guide
Vehicle
Traveling direction
160
Ant on _ KA
Knowledge
- About the notification sound
It is likely to be notified two times at one ETC gate when the communication is normally
done by the road side system.
- When it is set up forward, and it communicates with the ETC unit, and the ETC card of the
toll gate has not been inserted in the ETC unit correctly, the ETC card uninsertion information
antenna is an antenna to notify those who drive beforehand through the ETC unit.
- Neither the previous notice antenna nor the ETC card uninsertion information antenna
might be being set up by the system on the road side in the case to be set up.
becomes a voice "Porn ETC gate cannot be passed" or "Porn ETC card has not been
inserted".
161
Ant on _ KA
Attention
- Attention when running
- Those who drive must not look at the lamp display of the ETC unit while running.
- Please decelerate enough when the ETC gate goes into it.
- Please run according to the guide displayed in the vicinity of the ETC gate when you
pass the ETC gate.
- Please follow the toll gate clerk in charge's instruction when the opening and shutting bar at the ETC gate doesn't open.
- Additionally, please follow use that the road entrepreneur issues.
- Please pass over the ETC gate (for exit/adjustment) or the examination of tickets place
with the ETC card used at the ETC gate (entrance).
- Please do not pull out the ETC card in the vicinity of the ETC card uninsertion of the information antenna, the ETC
gate, the examination of tickets place, and the previous notice antenna. Data in the ETC card
might be damaged.
162
Ant on _ KA
is pushed.
The following of the most past history return to the latest history.
After about one second or more after the guide ends
Knowledge
- About the use history
- Because the use history is recorded on the ETC card, the record number is different according
to the ETC card used. (100 or less)
- When the maximum record number of use histories is exceeded, the oldest use history is deleted.
- It is guided , saying that "There is no use history" when there is no use history.
- When information on the use day is not correct, it is guided , saying that "The use date is uncertain".
- When information on the toll fee is not correct, it is guided , saying that "The charge is uncertain".
Attention
- Attention when using it
Please do not confirm the use history in the vicinity of the ETC gate. It becomes impossible
to communicate with a road side wireless device.
163
Ant on _ KA
Volume adjustment
Volume large
volume smallness
The adjustment result is guided by the voice.
Volume
1. 8
0
Voice guide
"Volume **. "
"The voice guide is
discontinued. "
Knowledge
- About the volume adjustment
- The volume adjustment is effective for the following guides.
Notification unset up
Buzzer sound when error occurs
Forgetting to pull out card warning
Confirmation of use history
Guide when volume is adjusted
- When the error occurs even if the voice guide is set to discontinuance (volume 0), it is
output by volume 1.
164
Ant on _ KA
01
Content of abnormality
Cause of abnormality
02
Coping process
Data processing is
abnormal.
2
When you drive
165
Ant on _ KA
Union error
code
03
04
05
Content of abnormality
Cause of abnormality
Coping process
ETC unit
breakdown
Abnormality of
ETC card information
166
Ant on _ KA
06
07
Communication abnormality
Knowledge
- In this case, it is not abnormally.
- No breakdown of the ETC unit though might notified union error code (07)
when communicating with the ETC card uninsertion information antenna etc.
- A wireless communication of the ETC unit is used, and the parking management system etc.
are operated. No breakdown of the ETC unit though might notified union error
code (01) or (07) when a communication different from the charge payment
2
The error sound stops when the ETC card is pulled out. Again, when the ETC card is
inserted, the stop of the vehicle might simultaneously be guided with the voice of "Porn
ETC card was inserted" in the following toll gate though a green lamp lit.
167
Ant on _ KA
Warning
- Thing not piled up
It might ignite if the following things are piled up and is dangerous.
- Please stabilize all the luggage with which it indoors loads firmly.
It is thrown out, and the crew might be damaged during the sudden braking and the
accident if not steady.
168
Ant on _ KA
Warning
- About how to apply weight and the load of luggage
- Please do not load with luggage too much.
- Start always be being even the load.
This not only is put a strain in the tire but also is caused an unexpected accident due to the decrease
in the steering wheel control and the brake control, and is received important injury or, in the
worst case, might lead to the death.
2
When you drive
169
Ant on _ KA
- Please check liquid measure and the specific gravity of the battery.
- Please prepare the tire (four wheels) for winter and the tire chains
(for front tire).
The tire must prepare the thing of the same brand in four wheels and specified sizes
( P. 298) and the tire chain must prepare the thing suitable for the size of the tire.
Before it drives
Please do the following according to the situation.
- Please melt ice by not forcibly opening, not moving, and putting
lukewarm water, and wipe moisture off enough at once when the
door and the wiper freeze.
- Please remove the snow to operate the fan of the air conditioner
normally when the snow has piled in the air intake in front of the
reception desk window glass.
- Please deice when ice has adhered to the underside.
- Please remove when the snow and ice have placed to the fender part
and the brake equipment.
- When parking
It becomes impossible for the brake equipment to freeze when the parking
brake is put and to release. The gear-shift is put in P without
putting the parking brake, it parks, and trig *.
- The trig can be bought in the Toyota shop.
170
Ant on _ KA
Knowledge
- About the wiper blade for the cold district
- To prevent the snow from adhering, the wiper blade for the cold district used for the snow
period has covered the metallic portion with rubber. Please buy the braid of each car specification
in the Toyota shop.
- When high-speed running, it might become difficult to wipe the glass off from a
usual wiper blade. Please reduce velocity in that case.
2
171
Ant on _ KA
Warning
- Warning when tire for winter is installed
Please guard the following.
The control of the vehicle might become impossible if it doesn't guard, important injury
be received, and, in the worst case, it cause the fatal accident.
- The speed limit or 30 provided to the chain that installs it It doesn't run the speed
that exceeds low one either at km/h.
172
Ant on _ KA
Attention
- About the use of the tire chain
Please use the Toyota pure tire chain.
(195/65R 15 and 195/55R 16 tire installation car must use a Toyota
pure alloy steel special chain of the ant on specification. )If
the tire chains other than a Toyota pure goods are used, it is likely to become a body with
the obstruction of around and running.
Please consult the Toyota shop in detail.
- When you remove the ice that places to the reception desk window glass
When you drive
173
Ant on _ KA
174
Ant on _ KA
3
3-4. Other indoor equipment
How to use202
2
[furontowaipa-deaisa-]
floor
175
Ant on _ KA
Auto setting
Windshield cloudy removing
Display switch
Ventilation stop
Preset temperature/outside
temperature display
Pollen removal
[Suwo] is
pushed pushing.
ON. OFF of the air conditioner changes whenever the switch is pushed.
- The navigation system installation car of the manufacturer option can be operated
176
Ant on _ KA
Howtouseoftheindo requipment.
[Wo] is pushed.
177
Ant on _ KA
The cloudy weather of ventilation and the glass is taken in one's feet.
178
Ant on _ KA
[Wo] is pushed.
The air conditioner operates.
Again when cloudy weather can be taken.
[Wo] is pushed.
[Wo] is pushed.
Howtouseoftheindo requipment.
Pollen is removed by changing into a shy circulation, and ventilating it to the upper-body. In about
three minutes usually
Plasma cluster *
The plasma cluster operates automatically
while operating the fan (Be
ventilating it).
- It changes into the plasma cluster ion
mode and the negative air ion mode
while operating every about 15 minutes.
- CLEAN( ) and it subtracts it
at the plasma cluster ion mode.
Mark ( ) of ION is displayed
at the ion mode.
* :Different equipment and option equipment in vehicle model etc.
179
Ant on _ KA
[Wo] is operated.
180
Ant on _ KA
Knowledge
- About the operation of an auto setting
The following controls might be done. Please use it by setting the favorite when
you want to release the control.
- It changes into a shy circulation if the preset temperature is lowered when the outside temperature is high.
-
- The cold wind is turned to the upper-body when heating it and it sends it.
- About a shy circulation
- It is effective when shyly circulating around the inside and outside nature switch switch to improve the
effect of air-conditioning when the outside temperature is high in time when to be put dirty air in the car due to
3
Howtouseoftheindo requipment.
181
Ant on _ KA
- At time that has stopped and low-speed running (About 20 km/h or less)
- When the outside temperature changes rapidly (vicinity etc. of the gateway of the garage and the tunnel)
- About plasma cluster *
The plus ion and the negative air ion of tales doses are discharged, and the activity of the
mold bacterium that floats in the car is controlled while operating in the plasma cluster ion mode
(CLEAN is displaying it).
- The ratio of negative air ions is discharged high, and the ion balance in air is straightened
while operating in the negative air ion mode (ION is displaying it).
- Static electricity is felt in the vicinity of the driver's seat side balloon entrance it is not abnormal
though it is likely to hear of a small operation sound while operating.
- The plasma cluster, the plasma cluster ion, and Plasmacluster are
trademarks of Sharp Corp..
[Nishitatoki]
The wind sent to one's feet is warmed from the wind sent to the upper-body and ventilated depending on the preset
temperature because of the balloon to aim at keeping one's head cool and feet warm.
182
Ant on _ KA
Warning
- To prevent the cloudy weather of the windshield
Please ..[wo].. do not push when you operate when humidity is very high by the preset temperature
with a low air conditioner. It is cloudy outside of the glass in the temperatures fluctuate
of air and the glass, and might disturb view.
- Please do not jet the spray to the vicinity of the driver's seat side balloon entrance, and do not insert
3
the foreign body such as sticks. It causes the breakdown and the electric shock.
Howtouseoftheindo requipment.
Attention
- To prevent the battery rising
Please do not use the air conditioner while the engine is stopping.
183
Ant on _ KA
- When using it
. decrease..) . drinking.. . . (.. . increase.. . ). . . (.. is pushed.
The fan operates.
The amount of the wind can be adjusted in seven stages.
[Wo] is pushed.
184
Ant on _ KA
Howtouseoftheindo requipment.
185
Ant on _ KA
The cloudy weather of ventilation and the glass is taken in one's feet.
186
Ant on _ KA
[Wo] is pushed.
Adjustment of wind
When the balloon entrance is shut, the knob is
moved outside of the vehicle until "[Kachi]" and the
sound are heard.
187
Ant on _ KA
Howtouseoftheindo requipment.
Knowledge
- About a shy circulation
- It is effective when shyly circulating around the inside and outside nature switch switch to improve the
effect of air-conditioning when the outside temperature is high in time when to be put dirty air in the car due to
in the tunnel and congestion, etc. and wanting air-conditioned early.
[Nishitatoki]
The wind sent to one's feet is warmed from the wind sent to the upper-body and ventilated depending on the preset
temperature because of the balloon to aim at keeping one's head cool and feet warm.
Warning
- To prevent the cloudy weather of the windshield
Please ..[wo].. do not push when you operate when humidity is very high by the preset temperature
with a low air conditioner. It is cloudy outside of the glass in the temperatures fluctuate
of air and the glass, and might disturb view.
Attention
- To prevent the battery rising
Please do not use the air conditioner while the engine is stopping.
188
Ant on _ KA
Knowledge
Howtouseoftheindo requipment.
Warning
- Warning of mirror heater operation
The surface of the door mirror becomes very hot. The burn might not be done and do
not touch, please.
Attention
- To prevent the battery rising
It causes the battery rising when continuously using it for a long time.
189
Ant on _ KA
[Furontowaipa-deaisa-] *
Please use it to prevent the windshield and the wiper blade being
frozen.
ON / OFF
[Furontowaipa-deaisa-] will be
automatically turned off in about 15
minutes.
Warning
- Warning of operation
The surface of the lower side of the reception desk window glass and the driver's seat side
reception desk pillar side is hot, the burn might not be done, and do not touch, please.
190
Ant on _ KA
3
Howtouseoftheindo requipment.
191
Ant on _ KA
Knowledge
- About the automatic turning off function
When the door synchronization switch of a reception desk personal light is a door position,
it will turn it off automatically in about 20 minutes in the state of reception desk personal
light/[riya] reading light and "Engine start stop" switch lighting (Smart entry & start system
non-installation car illuminates it the engine switch) lighting by the door open form.
- [Irumine-teddoentori-shisutemu]
Smart entry & start system installation car
Lighting * of each part is lit, and turned off automatically by the state of the detection of an electronic
key, lock and unlock of the door/opening and shutting, and "Engine start stop" switch.
Lighting * of each part is lit and turned off automatically
by the position of the lock and opening and shutting and unlocking/engine switch of smart entry &
start system non-installation car door.
- Reception desk personal light/[riya] reading light operates according to the control of
Attention
- To prevent the battery rising
The automatic turning off function doesn't work when reception desk personal light/[riya] reading
light is lit with the independent switch. Please note the battery rising.
192
Ant on _ KA
3
Howtouseoftheindo requipment.
Door synchronization
OFF door synchronization (door position)
lighting always
193
Ant on _ KA
194
Ant on _ KA
Glove box
Glove box
The lever is improved.
Knowledge
- About the glove box light
The light lights when the glove box is opened when the front position light lights.
Howtouseoftheindo requipment.
Warning
- Warning of running
Please shut the glove box.
It might undertake an open cap by the body at a rapid brake etc. , dash out the
stored thing, cause an unexpected accident, and be dangerous.
195
Ant on _ KA
Console box
Console box
The cap is lifted.
Knowledge
- About the cap of the console box
It is possible to use it as an armrest.
In the position of the cap, the slide is possible before and after.
Warning
- Warning of running
Please shut the cap of the console box.
It might undertake an open cap by the body at a rapid brake etc. , dash out the
stored thing, cause an unexpected accident, and be dangerous.
- The cap of the console box to [ushiro] when you do the slide
Please ..hand.. do not attach to the rear end of the cap. The cap opens unexpectedly,
and it is likely to injure.
196
Ant on _ KA
Cup holder
Cup holder
Reception desk
The cap is opened.
[Riya]
3
Howtouseoftheindo requipment.
Knowledge
- About the reception desk cup holder
When a tall bottle and the cup, etc. are
put, an inside pig is lifted.
197
Ant on _ KA
Cup holder
Warning
- Thing not stored
Please do not put things other than the cup and the can on the cup holder.
It falls due to the sudden braking and the accident and it is likely to injure. Moreover, the
burn might be done with a warm drink.
Attention
- To prevent the reception desk cup holder being damaged
Please ..hand.. do not attach to the cap of the cup holder, and step by the foot.
198
Ant on _ KA
[Riya]
3
Howtouseoftheindo requipment.
Knowledge
- About the bottle holder
- Please store it after closing the cap of the PET bottle without fail.
- It is not likely to be able to store it according to the size and the shape of the PET bottle.
Attention
- Thing not stored
Please do not store the glass etc. the paper cup and made of the glass the inclusion
of the bottle holder of the juice etc.The juice etc. might spill,
and glassware crack.
199
Ant on _ KA
Small putting
Small putting
Driver's seat side
It pulls forward and it opens it.
Central box
The cap is pushed.
200
Ant on _ KA
Small putting
Warning
- Warning of running
Please guard the following. It might hit an open small putting by the
body at a rapid brake etc. , dash out the stored thing, cause an unexpected
accident if it doesn't guard, and be dangerous.
- Please do not leave a small putting that opening and shutting is possible open.
- Please do not put height in the console
side pocket.
3
Howtouseoftheindo requipment.
201
Ant on _ KA
Sun visor
It lowers.
It spends from the hook to the feretory
and side while lowered.
202
Ant on _ KA
Vanity mirror
The vanity mirror ceiling lighting
lights when the cover is opened.
3
Howtouseoftheindo requipment.
203
Ant on _ KA
Clock
(H) that adjusts "Time"
(M) that adjusts "Worth" *
that adjusts "Worth" to 00 (:00)
- (example) 1:00 . 1:29 1:00
Knowledge
- When time is displayed
Smart entry & start system installation car
When smart entry & start system non-installation car engine
switch is . ACC " or
. ON " when "Engine start stop" switch
is accessories mode or ignition ON mode
204
Ant on _ KA
Ashtray
Reception desk
The switch is pulled and opened.
When detaching it, it has both ends of the main
body of the ashtray, and it draws it out forward.
[Riya]
The cap is pulled forward and opened.
Howtouseoftheindo requipment.
Warning
- About after it uses it
Please shut the cap. It might undertake an open cap by the body at a rapid brake
etc. , dash out an inside thing, cause an unexpected accident, and be dangerous.
205
Ant on _ KA
Cigarette writer
The cigarette writer is pushed.
It is possible to use it when returning to former
position.
Knowledge
- Use conditions
Smart entry & start system installation car
When smart entry & start system non-installation car engine
switch is . ACC " or
. ON " when "Engine start stop" switch
is accessories mode or ignition ON mode
Warning
- About after it uses it
Please shut the cap. It might undertake an open cap by the body at a rapid brake
etc. , dash out an inside thing, cause an unexpected accident, and be dangerous.
206
Ant on _ KA
Attention
- To prevent rear center arm Wrest being damaged
207
Ant on _ KA
Warning
- About the coat hook
Please do not use the suspender etc. for the coat hook because it is likely to fly
when the SRS curtain shield air bag operates, and wear clothes directly.
(SRS side & curtain shield air bag installation car)
Attention
- To prevent damage
Please do not put an excessive load.
208
Ant on _ KA
Floor mat
Please firmly fix the thing suitable for the car on the floor carpet
and use it.
In the carpet, there is a hole
for the fixed clip installation of
the floor mat.
Warning
Howtouseoftheindo requipment.
209
Ant on _ KA
210
Ant on _ KA
Maintained method
4
212 method that maintains 4-1
2
t i r e s
a r e 2 1 8 .
cleaning of
2 4 7
a i r
conditioner
f i l t e r
a n d
e x c h a n g e
211
Maintenance of exterior
Please execute the following items to maintenance.
- It is washed off the grime from on to the under in order in the circumference under the body and the underside
while sprinkling water enough.
- The body is washed in the soft one such as the sponges and the chamois.
- It flushes it enough by using the car shampoo in water when dirt is awful.
- Water is wiped off.
- When shedding water worsens, wax disregards it.
When water doesn't become like the gem even if the dirt of the surface of the body is washed off, the
body puts wax when the temperature is cold (Please give below about the temperature to me as a standard).
When the Toyota Chemical commodity such as the body court, the wheel courts, and
the glass courts is constructed, the maintenance method is different. Please
inquire of the Toyota shop in detail.
Knowledge
- When you use the automatic car-washing machine
- Please confirm the fill opening of the vehicle has closed firmly before it puts it in the automatic
car-washing machine.
- Please store the door mirror, and wash a car from the front side of the vehicle.
- The wound might place to the body with the brush, and painting be ruined.
212
Ant on _ KA
- Please do not bring it close to the bearing and oil seal parts of the drive and the system
parts (differential gear etc.) too much.
Bring close..hydraulic pressure..high..inside..temporary
halt..grease..outflow..performance..deteriorate.
- Backing & clearance sonar installation car must not appropriate water directly to the
sensor. ( P. 149)
Aluminum foil *
Please wash off dirt ahead of time by using the soapless soap. Please use neither detergent
that the abrasive ground enters nor a hard brush.
- Bumper
Please do not rub with the detergent with the abrasive ground.
- About the hydrophilicity coating of the door mirror (cold-weather model car)
Please note the following to continue the effect of [oyamizumaku].
- It cleans with the car shampoo and the glass cleaner without the silicone and the abrasive
ground, and it flushes it enough in water.
213
Ant on _ KA
Warning
- When you wash a car
Please do not sprinkle water in the engine room.
It might cause the vehicle fire when water splashes to electric parts etc. and is dangerous.
Attention
- To avoid the damage of painting
Please do not use organic solvents such as benzine and gasoline.
- Cleaning of light
- Please wash carefully. Please use neither organic solvent nor a hard brush.
The light might be damaged.
214
Ant on _ KA
Maintenance of interior
Please execute maintenance according to the sequentes.
- Maintenance in car
Dust is removed with the cleaner etc. , and it wipes off with the cloth to contain water or
lukewarm water.
- The cloth soaked with the fresh water is squeezed hard, and the detergent that remains on the surface is wiped off.
- Moisture on the surface is wiped off with a cloth that dries and is soft, and it is dried
because of airy shade.
4
Maintained method
- It leaves just as it is for several minutes, and dirt is washed off, and the detergent is wiped off
with the beautiful cloth squeezed hard.
215
Ant on _ KA
Knowledge
- When you clean the inside of [riyauindou;garasu]
Please do not use the glass cleaner etc. because heat ray might be damaged, and blow lightly
with the cloth to contain water or lukewarm water along heat ray.
- Washing of carpet
We will recommend the carpet to keep a dry state as much as possible. A
bubble type cleaner on the market can be used for washing.
Please rub into as you expand the bubble to the carpet with a sponge or a
brush, and draw yen. Please dry it directly after without putting, and wiping water off.
- Seat belt
Please wash with a cloth or a sponge in the detergent and lukewarm water with a little stimulation.
Please check wear-out, becoming loose, and the wound etc. of the seat belt regularly.
( P. 49)
Warning
- Infiltration of water to vehicle
- Please do not sprinkle water on the floor and do not spill the liquid.
- Please wet neither complete parts nor the wires of the supplemental restraint system airbag. ( P. 71)
The air bag develops by electric trouble, and it doesn't function normally, and it might
cause the fatal accident and the serious injury.
216
Ant on _ KA
Attention
- About the solvent used when cleaning it
Please do not use the following solvents to cause discoloration, the bristletail, and the painting peeling off.
- Parts other than seat: Organic solvent, acids such as benzine and gasoline or alkaline
solvent, dye medicine, and bleach
- Dust and the sand that places to leather are removed at once.
- It doesn't expose it to direct sunshine for a long time. Especially, the car is kept because of shade at the summer time.
- The thing of made of the vinyl, made of plastic, and the wax content is not put on a leather -lined
might stick in leather when becoming a high temperature in the car.
It might cause the car breakdown, and the body rust when water splashes
to electric parts under audio and the floor carpet.
Maintained method
217
Ant on _ KA
218
Ant on _ KA
Knowledge
- Numerical value of tire inflation pressure
Tire inflation pressure label
Rear wheel
230
(2.3)
200
(2.0)
220
(2.2)
200
(2.0)
219
Ant on _ KA
Warning
- Warning when checking, and exchanging it
Please guard the following.
It might cause the fatal accident and the injury if it doesn't guard by damage of the drive and
the system parts and an unstable control characteristic.
- The tire must use all tires without the wear-out difference in the same manufacturer and
the same brand and the same tread pattern.
- Please use neither tire nor wheels other than the manufacturer specification size.
- Please use a radial tire or neither bias belted tire nor the bias ply
tire existing together.
- Please use a summer tire or neither all-year tire nor the tire for winter existing
together.
- The damage of the explosion of the tire etc. that cannot be repaired is received.
- It ..car.. sideslips.
- An original performance (fuel cost and direction stability and slip distance for brake etc. of the vehicle) of the car is not demonstrated.
Attention
- When the air leakage happens while running
Do not keep running.
The tire or the wheel might be damaged.
220
Ant on _ KA
Bonnet
The lock is released in the car, and it opens the hood.
The bonnet opener is pulled.
The bonnet comes to the surface a little.
4
Maintained method
Knowledge
- When you remove the battery terminal
Information memorized to remove the battery terminal in the computer is
deleted. Please consult the Toyota shop when you remove the battery terminal.
221
Ant on _ KA
Warning
- Confirmation before it runs
Please confirm the bonnet is firmly locked.
The bonnet opens suddenly while running when running without locking, and it is likely
to lead to danger or important injury of the life.
Attention
- To prevent damage to the bonnet
Please do not push strongly by putting weight when closing the bonnet.
The bonnet might dent.
222
Ant on _ KA
Garage jack
Please set the garage jack in the right place when you
lift the vehicle with a garage jack. The vehicle might be damaged,
and it injure if it doesn't set it in the right place.
Maintained method
223
Ant on _ KA
Warning
- When you lift the vehicle
Please guard the following to decrease the danger of a death or important
injury.
- Please do not use the jack installed by the car. The vehicle
might fall.
- Please do not put the segment of the body under the vehicle supported only with
the garage jack, and slip.
Please use the jack stand for the car.
- Please do not start the engine with the jack improved to the vehicle.
- The vehicle is stopped on a flat, hard ground, and please firmly put the
parking brake, and make the gear-shift P.
- Please do not lift the vehicle when there is a crew in the car.
- Please do not put the thing on the top and bottom of the garage jack when you lift the vehicle.
224
Ant on _ KA
Headlight
high beam
4
Reception desk Fogra Ito *
Maintained method
Number-plate light
Retreat light
225
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
226
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
227
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
* :Different equipment and option equipment in vehicle model etc.
228
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
Maintained method
229
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
230
Ant on _ KA
- Retreat light and braking light and [riya] direction instruction and taillight/emergency blinking light
It opens a trunk, the clip (2 pieces) is
removed, and the cover is turned over.
The clip comes off when pulling it forward
after the center of the clip head is pushed.
When installing it, it installs it in the reverse order of the detached time.
231
Ant on _ KA
- Number-plate light
It opens a trunk, the clip (4 pieces) is
removed, and the cover is turned over.
The clip comes off when pulling it forward
after the center of the clip head is pushed.
When installing it, it installs it in the reverse order of the detached time.
232
Ant on _ KA
- Other lamps
Please exchange it in the Toyota shop when the following lamps cut.
- Headlight low beam ([dei;sucha-jibarubu] *)
- Side direction instruction and emergency blinking light
- High mount stoplight
Knowledge
- When you exchange the headlight, the front position light, and the reception desk direction instruction and the emergency blinking light on
the passenger side
When the upper part of the air cleaner duct is removed, it becomes easy to exchange.
Please firmly install the upper part of the air cleaner duct without fail, and fix with the
clip after it exchanges it.
Maintained method
- How to install it
[**] does the clip with the center
that installed the air cleaner duct drawn
out.
The center of the clip head is pushed.
233
Ant on _ KA
234
Ant on _ KA
Warning
- When you exchange lamps
- Please turn off the light. Please do not exchange immediately after turning off to be hot.
It is likely to do ..combustion...
- Please install parts to fix the lamp and the lamp firmly.
When the installation is insufficient, cloudy weather might be generated in the breakdown due to
the flood generation of heat, the ignition or in the headlight and the lens.
- Please repair or resolve the lamp, the socket or neither electric circuit nor complete
parts.
The important injury that is gotten an electric shock, and related to the life might be received and it is dangerous.
- About [dei;sucha-jiheddoraito] *
4
- Please consult the Toyota shop when you exchange it (The lamp exchange is included).
- Please do not touch the high voltage socket while lighting.
Maintained method
The important injury related to the life might be received by the electric shock because the voltage of
20,000 volts is momentarily generated and it is dangerous.
Attention
- To prevent the car breakdown and a fire
Please confirm the firm installation on the position where the lamp is correct.
235
Ant on _ KA
236
Ant on _ KA
The fuse that should be checked is confirmed from the situation of the breakdown by
"Arrangement and load of the fuse" ( P. 238).
There is a fuse not installed by the specification of the car either.
The fuse is pulled out, and whether the fuse cuts is checked.
The feretory must buy the fuse in the Toyota shop.
Normality
Blowing the fuse
237
Ant on _ KA
- Engine room
Fuse name
238
Ant on _ KA
Amperage
EFI NO.2
10 A
EFI system
EFI NO.1
10 A
EFI system
H-LP RH HI
10 A
H-LP LH HI
10 A
H-LP RH LO
H-LP LH LO
ETCS
10 A
EFI system
TURN-HAZ
10 A
AM2 NO.2
7.5 A
10
AM2
30A
start system
11
STRG LOCK
20 A
12
IGT/INJ
15 A
13
IG2 NO.2
7.5 A
start system
15 A *1
10 A *2
15 A *1
10 A *2
Fuse name
14
ECU-B2
Amperage
10 A
15
ECU-B
10 A
16
RAD NO.1
15 A
17
DOME
10 A
18
EFI MAIN
20 A
EFI system
19
HORN
10A
horn
20
IG2
15A
start system
21
PSB
Unused
30A
22
FR DEICER
20 A
[Furontowaipa-deaisa-]
ETC
Interior light and "Engine start stop"
switch lighting (engine switch lighting)
Maintained method
239
Ant on _ KA
Fuse name
Amperage
TAIL
10 A
PANEL
7.5 A
FR DOOR
20 A
Power window
RL DOOR
20 A
Power window
RR DOOR
20 A
Power window
CIG
15 A
Cigarette writer
Audio, navigation system, air
ACC
7.5 A
MIR HTR
10 A
RR FOG
7.5 A
[Riyafoguraito]
Steering wheel lock, supplemental
10
IGN
7.5 A
240
Ant on _ KA
11
METER
7.5 A
Meter
12
HTR-IG
10 A
13
WIPER
25 A
Fuse name
Amperage
14
RR WIPER
15 A
[Riyawaipa-]
15
WASHER
15 A
Washer
Automatic optical axis adjustment
system and the main body ECU, electric
16
ECU-IG NO. 1
10 A
17
ECU-IG NO. 2
10 A
18
OBD
7.5 A
19
STOP
10 A
DOOR
25 A
[Pawa-doarokkushisutemu]
21
ACC-B
25 A
Cigarette writer
22
FR FOG
15 A
23
AM1
7.5 A
Maintained method
241
Ant on _ KA
Knowledge
- After exchanging fuses
- Please exchange lamps when lights do not light even if it exchanges it.
( P. 225)
Please receive the check in the Toyota shop when the fuse cuts again even if it
changes it.
Warning
- To prevent the car breakdown and the vehicle fire
Please guard the following.
It is likely to injure the car breakdown and a fire if it doesn't guard.
- Please do not use fuses other than regulated capacity or the one other than the fuse.
- Please use a Toyota pure fuse or equal goods.
- Please remodel neither fuse nor the fuse box.
242
Ant on _ KA
4
Maintained method
243
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
244
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
Knowledge
- When the battery is consumed
The following states happen.
- Neither smart entry & start system (Only the installation car :) nor a wireless
function operate.
Maintained method
LED
LED
245
Ant on _ KA
Warning
- About detached battery and parts
Please do not let the child touch.
It might be blocked in the throat etc. when swallowing by mistake because parts are small.
Attention
- To function normally after it exchanges it
Please guard the following.
- It doesn't touch parts other than the battery and it moves it.
- The electrode is not bent.
246
Ant on _ KA
Warning
- When you replenish the washer fluid
Please do not replenish the washer fluid when time when the engine is hot
and the engine start. It might break out when hanging to the engine etc. because an
alcoholic element is included in the washer fluid and is dangerous.
4
Attention
Maintained method
247
Ant on _ KA
- Method of exchange
Smart entry & start system installation car
The glove box where smart entry & start system non-installation
car engine switch that turns off "Engine
start stop" switch is made . LOCK " is
removed and the pin of opening
[danpa-sute-] is removed.
248
Ant on _ KA
When installing it, it installs it in the reverse order of the detached time.
Knowledge
- About the cleaning and the exchange of the air conditioner filters
Please clean the following time to the standard or exchange the air conditioner filters. .
[ G o t o ]
Maintained method
- District where a lot of traffic and dust such as big cities and cold districts exist
Attention
- Attention when air conditioner is used
When the air conditioner is used without installing the filter, it might cause the
breakdown. Please install the filter.
249
Ant on _ KA
250
Ant on _ KA
5
First of all, 5-1252.
252 pulling is258. 254
event data recorder
the departure
flame cylinder
n o t
start.
When
281
electron
key doesn't
w o r k
n o r m a l l y
(smart entry & start
system installation car) ...
2 9 1
a
t
2 8 9
s t a c k s .
251
Ant on _ KA
The main body is done, and it pulls out, the main body is done,
and [**] is done inverted though the loincloth.
The cap of the point is taken, the point of the print medicine
and the departure flame cylinder is rubbed, and it is ignited.
Print medicine
Knowledge
- Expiration date of departure flame cylinder
Please buy it in the Toyota shop before the displayed validity term cuts.
252
Ant on _ KA
Warning
- Place where departure flame cylinder cannot be used
Please do not use the departure flame cylinder in the following places.
It is dangerous because view might worsen by smoke, and it ignite.
- In tunnel
- Near combustible such as gasoline
- About the handling of the departure flame cylinder
Please guard the following.
Important injury might be received if it doesn't guard and it is dangerous.
- The departure flame cylinder is not turned to the face and the body, and brought close while using it.
- The departure flame cylinder doesn't allow the child to touch.
5
When the trouble oc urs
253
Ant on _ KA
About pulling
Please request pulling to a Toyota shop or a special trader as much as possible.
- Before it pulls it
In the following cases, the breakdown of driving system is thought, and contact
the Toyota shop, please.
- The car doesn't move though the engine starts.
- An abnormal sound is heard.
- When it is pulled
The draw hook is roped so that the
wound should not place to the body.
Please pull it in the direction of advancement.
Draw hook
Size of cloth:0.3
5 m or less
Direction of pulling
White cloth
254
Ant on _ KA
Knowledge
- Use of draw hook
The draw hook is the one using it when pulled, and no one to
pull another car.
5
When the trouble oc urs
255
Ant on _ KA
Warning
- When you transport the vehicle (4WD car)
Please transport it with four-wheel earth or four wheels while lifted.
Driving device might cause burning, and the car dash out from the truck.
Moreover, please lift and transport four wheels when it seems that the drive and the system
parts broke down.
256
Ant on _ KA
Attention
- To prevent the vehicle being damaged
- Please guard the following when you pull it.
The wire rope is not used.
30 km/h or less in speed is pulled within the distance 80km.
It pulls it in the direction of advancement.
The suspension etc. are not roped.
- Please pull neither another car nor the boat (trailer), etc. with this car.
Serious damage might be given to the drive and the system parts etc.
5
When the trouble oc urs
257
Ant on _ KA
Recorded data
The following data is recorded when it is near the collision of the event
data recorder installed in the air bag computer and the collision.
- Engine revolutions
- Velocity of car
- Operation situation of brake pedal
- Operation situation of gas pedal
- Position where automatic transmission is shifted
- Passenger's seat crew's presence
- Presence of seat belt installation of those who drive and passenger's seat crew
- Seat position of driver's seat
- Information on air bag operation
- Failure diagnosis information on air bag system
The event data recorder records neither the voice nor the image of the conversation etc.
258
Ant on _ KA
5
When the trouble oc urs
259
Ant on _ KA
The car is started without releasing the parking brake, and the velocity of the car is about 5 The warning
buzzer rings when becoming km/h or more.
Please release the parking brake when the warning buzzer rings.
260
Ant on _ KA
5
When the trouble oc urs
261
Ant on _ KA
[Dei;sucha-jiheddoraitoo-toreberingu]
warning light *
Abnormality of automatic optical axis adjustment system
262
Ant on _ KA
Coping process
In meter
Half door warning light/half door warning display
In multi
information display
it sets it again.
Please receive the check in
the Toyota shop when it is
not possible to set or it is
released at once.
Dirt is removed.
Please receive the check
in the Toyota shop when it is
warned though the sensor assembly
is not dirty.
263
Ant on _ KA
Coping process
The velocity of the car is about 20 like non-wearing as for the driver's seat and the passenger's seat seat belt The warning buzzer
rings intermittently for about 30 seconds when becoming km/h or more. The sound of the buzzer rings the driver's seat and the
passenger's seat seat belt afterwards as non-wearing and the change rings for about 90 seconds.
Knowledge
- About the operation of the crew detection sensor of the passenger's seat seat belt non-wearing warning light
- The sensor might blink the warning light detecting weight when luggage etc. are
put on the seat even if there is no crew.
- The sensor might not detect the crew when the square cushion etc. are paved and the warning
light not operate.
264
Ant on _ KA
Please treat it at once. (smart entry & start system installation car)
Please treat according to each coping process, and confirm the alert
message is turned off.
Warning buzzer
In car
Outside car
None
once
Smart entry
& start system
warning light
Content of warning
Coping process
It tried to start up an
engine with an electronic key An electronic key is carried.
(lighting for about eight seconds) not carried.
The state that an electronic key
was not carried and "Engine start stop"
switch were opened and shut and doors
other than the driver's seat were opened
times once
turning off.
Neither the state nor the
gear-shift not to carry an
electronic key did "Engine start stop"
switch to turning off in the
state of P and the driver's
seat door was opened and shut.
"Engine start
stop" switch
is turned
off.
continuousness
The gear-shift is P.
[Nisuru]
An electronic key is carried.
265
Ant on _ KA
State of
indicator
Content of warning
Coping process
wheel lock system or the power supply It contacts the Toyota shop.
system.
266
Ant on _ KA
Mat
Cover
Wheel nut
wrench
Jack
steering wheel
Jack
267
Ant on _ KA
Tightened
loosening
Please fix surely so that the jack may
engage in the fastening device when you
Fastening device
store it.
268
Ant on _ KA
Rear wheel
Position of trig
269
Ant on _ KA
270
Ant on _ KA
Installation of tire
The dirt of the wheel contact side is wiped off.
The nut loosens while running when
the wheel contact side is dirty, and the
tire might come off.
The tire is installed, and the nut is tightened up to extent to which the tire doesn't shake by
the hand temporarily.
When you substitute it from the steel wheel to the steel wheel (The
temporal spare tire is included)
Taper part
Seat
It spends until the taper part of the nut lightly hits the
Taper part
Seat
271
Ant on _ KA
Washer
Wheel
272
Ant on _ KA
All tools and tires that the jack blow out are stored.
Knowledge
- About the temporal spare tire
- It is written TEMPORARY USE ONLY against the side wall of a tire.
Please use it only for the emergency.
5
When the trouble oc urs
273
Ant on _ KA
Warning
- About the use of the jack
The car falls when the handling of the jack is mistaken and it might cause the death
or the injury.
Please guard the following.
- The jack is not used by the purposes other than the tire exchange, the tire chain installation,
and detaching.
- The jack of equipment doesn't use for other cars because it is possible to use it only for
customer's car, and use the jack of other cars for customer's car.
- It is confirmed that the jack correctly hangs to the jack set position.
- The body is not put under the car supported with the jack.
- It doesn't start up an engine while supported with the jack and they are made to run.
- The car is not lifted with the person taken in the car.
- When the car is lifted, the thing is not put below on the jack.
- When the car is lifted, it doesn't raise it more than height in which tires can be exchanged.
- Please note that neither oneself nor a surrounding person are especially
injured when you lower the vehicle where the jack stand is used when the car under slips and
it works.
274
Ant on _ KA
Warning
- About the tire exchange
Please guard the following to decrease danger of owing the injury.
- When the hand and the foot, etc. touch the disc wheel and the brake circumference,
etc. by the tire exchange etc. because the disc wheel and the brake circumference immediately after running
that doesn't touch are high temperatures immediately after running, the burn might be done.
- 103 after wheels are exchanged at once The nut is tightened by the power of N. m(1050
kgf. cm).
- The nut only for the wheel used is used for the installation of the tire.
- When abnormalities such as collapsing and the cracks are found in the bolt hole of the screw and the
wheel of the bolt and the nut, the nut loosens if the
above-mentioned that receives the check in the Toyota shop is not guarded, the wheel comes off, it falls, and
it might cause the accident that owes the death and the serious injury.
- Please do not use it for other cars for the car alone of the customer.
- Please do not use two temporal spare tires or more at the same time.
275
Ant on _ KA
Warning
- While installing the temporal spare tire
An accurate speed of the vehicle might not be able to be detected, and the following
system might not operate normally.
- 4WD system *
276
Ant on _ KA
Attention
- About running in the state of blowing out
Do not keep running while having had tire punctured.
It becomes damage without the tire and the wheel's being repaired by even driving the small distance.
5
When the trouble oc urs
277
Ant on _ KA
When neither/where the starter turns slowly interior light nor the headlight
are small the sound of darkness/the phon or ring
The following causes are thought.
- There is a possibility of the battery rising. ( P. 284)
278
Ant on _ KA
- When neither/where the starter doesn't turn interior light nor the
headlight's lighting/the phon rings
The following causes are thought.
- There is a possibility that the terminal of the battery has come off.
- There is a possibility of the battery rising. ( P. 284)
There is a possibility that abnormality is found in the steering wheel lock system.
Please do not understand the hoop or contact treatment the Toyota shop
when not engining starts only treatment.
Engine start in emergency (smart entry & start system installation car)
The engine might start according to the following procedures when the engine
doesn't start by a usual engine start operation. Please do not start it by this method
excluding the emergency.
"Engine start stop" switch
that puts the gear-shift
that puts the parking brake in P is changed to the accessories
mode.
Even if the engine starts by the above-mentioned method by which it keeps
279
Ant on _ KA
280
Ant on _ KA
5
When the trouble oc urs
281
Ant on _ KA
When an electronic key doesn't work normally (smart entry & start system installation car)
It becomes impossible to use smart entry & start system and wireless remote control
when the communication between an electronic key and the vehicle is disturbed or
the battery of ( P. 30) and an electronic key cuts. For this case, the door can
be opened according to the following procedures, and the engine be started.
282
Ant on _ KA
5
When the trouble oc urs
283
Ant on _ KA
The cover of + terminal of the battery is removed, and the booster cable ties
in the following order.
A red booster cable ties to + terminal of the battery
of the car.
Red..booster..cable..other..edge..rescue..c
ar..battery..terminal..tie.
.black..booster..cable..rescue..car..battery..terminal..tie.
The other edge of a black booster cable is connected to the
metal department of unpainting away from the battery (fixed
part shown in figure).
284
Ant on _ KA
that charges with the battery of the car for about five minutes opens
and shuts either of door while turned off (smart entry & start system
installation car).
285
Ant on _ KA
The cover in the upper part of the engine is obtained like being original
(The car equipped with 1NZ-FE engine is excluded).
It fixes into a fixed pin on the engine side in the same order as the detached time and it
matches it.
Please receive the check ahead of time in the Toyota shop even if it engines starts.
Knowledge
- About the start when the battery rises
This vehicle cannot be started by the jump-start.
- Please turn off the power supply of needless electrical equipment when stopping for a long time due to
congestion etc.
Ant on _ KA
Warning
- To prevent the battery from igniting or exploding
Please guard the following to ignite to the combustible gas generated from the battery,
might explode, dangerous, and to generate neither the fire nor the spark.
- The booster cable is not touched except a correct terminal or connected part by mistake.
- The booster cable never touches the terminal of . -" with . +".
- It doesn't smoke and it strikes a light as a match and a writer, etc. in the vicinity of the battery.
- About the handling of the battery
Acid electrobath it is poisonous in the battery and with the causticity enters,
related parts contain lead or the compound of lead, and guard the following
for handling, please.
- When the battery is handled, the eye shield is worn, and the liquid (acid) is prevented from adhering to
the skin, clothes, and the body.
- More than the necessity and no face and no head, etc. are brought close to the battery.
- The sponge and the cloth to contain water until it washes in volumes of water at once when the battery liquid adheres
to the body or it catches one's eye by mistake,
the doctor's examination is received at once, and the doctor's examination is received are appropriated to the
5
diseased part.
- After the handling of a prop, a terminal, and other related parts of the battery, the hand is washed.
Please connect it firmly so as not to drop out because of the vibration when the engine
starts when you install [buru]. It might cause an unexpected accident when dropping out because it is
at a position near V [ribudoberuto] and coming in contact with the belt and is dangerous.
287
Ant on _ KA
Attention
- About the handling of the booster cable
Please note not rolling in the cooler fan and the belt enough when the
booster cable is connected or is detached.
- Please do not improve at it simultaneous, and do not remove forward when you about
detach the cover.
- Please do not suppress by strong power, and do not beat the upper surface of the installation
part when attaching a cover.
288
Ant on _ KA
When overheating
When overheating
The car is stopped to the place of safety, and whether steam has
occurred from the engine room where the air conditioner is stopped is confirmed.
When steam has occurredWhen
the engine is stopped, and steam doesn't occur, it opens
the hood carefully.
When steam has not occurredWhether
the fan for the radiator cooling that opens the
hood noting it while started up an engine operates is confirmed.
When the fan operatesAfter
the display of the water temperature meter falls, the engine is stopped.
When the fan doesn't operateAfter
the engine is stopped at once, and the engine reported
to the Toyota shop gets cold
enough, cooling water (heat radiation
part) for the cooling water leakage is
checked.
5
When the trouble oc urs
Please receive the check ahead of time in the nearest Toyota shop.
289
Ant on _ KA
Knowledge
- What is overheating?
The following states are overheating.
- The display of the water temperature meter reaches the top, and it blinks, and the engine power decreases.
- Steam occurs from the engine room.
Warning
- To prevent the accident and the injury checking the engine room
- Please wear the hand and clothes from the fan and the belt when engining
starts.
- Please do not open the radiator cap while the engine and the radiator
are hot.
Steam and the cooling water of the high temperature spout according to pressure, and the serious injury such as
the burns might be owed.
Attention
- Attention when cooling water is put in
Please put it after getting cold enough the engine.
Please put cooling water in slowly.
When suddenly cold cooling water is put in when the engine is hot, the engine
might be damaged.
290
Ant on _ KA
When stacking
Please try the following methods when it becomes impossible for the tire to run idle on mud,
sands, and the snow road, etc. or to move being buried and crowding.
The parking brake is put, the gear-shift is made P, and the
engine is stopped.
The engine that allots the tree and the stone,
etc. under the tire that remove the soil and the snow before
and behind the tire is started again.
The gear-shift is surely put in D or R, and it steps on the gas
pedal noting it.
The VSC installation car must stop TRC or VSC when TRC. VSC
operates and it is not easy to escape. ( P. 132)
Knowledge
- About the hook for the emergency (cold-weather model car)
( P. 255)
Warning
- When escaping
Please confirm there is nothing in surroundings to avoid the collision with other cars, things or the
people when escaping from the stack repeating advancement and the retreat, too.
Please note that the car might dash out forward or backward when
escaping from the stack especially.
291
Ant on _ KA
Attention
- To avoid damage to the transmission and other parts
- Please do not avoid the idling of the tire, and ..engine.. do not rev.
- When it is not possible to escape by the above-mentioned method, it is necessary to rescue it by pulling.
292
Ant on _ KA
Vehicle specification
6
294 6-1 specification lists
Maintenance data
(capacity and brand of oils and fats)...... 294
293
Ant on _ KA
Fuel
Specified fuel
60
Engine oil
Capacity L (reference value)
Brand
Oil and
oil
Filter
exchange
Engine
Only oil is
exchanged.
1NZ-FE
3.4
3.7
3.9
4.2
2ZR-FE
294
Ant on _ KA
3ZR-FAE
295
Ant on _ KA
Radiator
Brand
Pure Toyota super-long life coolant frozen
guarantee temperature
Engine
Capacity L
(reference value)
1NZ-FE
5.3
2ZR-FE
Density 30%-12 .
5.4
3ZR-FAE
density 50%-35 .
Automatic transmission
Brand
Engine
Drive system
Capacity
L(reference value *)
1NZ-FE
FF (front-wheel drive)
8.09
FF (front-wheel drive)
8.11
7.98
FF (front-wheel drive)
8.70
2ZR-FE
3ZR-FAE
296
Ant on _ KA
0.9
Brake
- Brake Froude
Brand
Toyota pure brake Froude 2500H
- Brake pedal
Item
Play
Reference value mm
1 . 6
81 or more
- 294 when engine rotates Minimum value of space with alcove slab when force on pedal of N (30 kgf) is put
- Parking brake
Item
It steps.
Operating physical force 300 Number of notches * at N (30 kgf)
is put.
297
Ant on _ KA
V [ribudoberuto]
Item
Engine
Reference value mm
Flexible volume
1NZ-FE
11 . 13
Generator
Water pump
2ZR-FE
Crank shaft
8. 10
Air conditioner
Compressor
3ZR-FAE
Washer
Capacity L (reference
value) 2.5
Tire
Size of tire
185/70R14 88S
Standard tire
195/65R15 91S
195/55R16 86V
Temporal spare
298
Ant on _ KA
Rear wheel
230 (2.3)
200 (2.0)
220(2.2)
200(2.0)
420 (4.2)
Lamp (valve)
Lamp
Number of W (watt)
Headlight
High beam (Valve type: HB3)
60
low beam
([dei;sucha-jiheddoraitobarubutaipu]: D4R)*
Low beam (Valve type: H11)
Front position light
Outside car
55
5
55
21
In car
35
LED *
21
21 / 5
16
LED *
Number-plate light
3.8
8
1.2
Console lighting *
LED *
- LED is abbreviation of Light Emitting Diodes (light emitting diode), and the semiconductor luminescence electron element.
299
Ant on _ KA
Vehicle specification
Model
NZT260
ZRT260
ZRT265
ZRT261
300
Ant on _ KA
Engine
1NZ-FE (1.5L gasoline)
2ZR-FE (1.8L gasoline)
3ZR-FAE (2.0L gasoline)
Drive system
FF (front-wheel drive)
4WD (four-wheel drive)
FF (front-wheel drive)
Item
Content of function
Initialization
After it changes
It is.
None
Smart entry
& start
system
system *
It is.
None
It is.
None
Wireless function
It is.
None
( P. 22)
2 [Kaio]
1 [Kaio]
Wireless
door lock
( P. 31)
About 60 seconds
and about 120 seconds
It is.
None
It is.
None
It is.
None
It is.
None
About 30 seconds
Level 3
Level 1-5
Vehicle specif cation
Standard
Length
301
Ant on _ KA
Item
Content of function
Time until turning off
[Irumine-teddoentori-shisutemu]
Initialization
After it changes
About 7.5 seconds
About 15 seconds
It is.
None
It is.
None
About 150 Cm
About 60 Cm
Backing &
clearance sonar *
( P. 140)
Buzzer volume
Level 3
302
Ant on _ KA
6-3. Initialization
Item
Backing guide monitor *
Intelligent
parking assistance *
6
Vehicle specif cation
303
Ant on _ KA
6-3 initialization
304
Ant on _ KA
It is of sparing
Syndrome ..307..
another is not
regretted.
317.
305
Ant on _ KA
Abbreviation list
Katakana mark
ABS
ACC
Accessories
DISP
Display
ECO
Economy/ecology
ECU
EDR
EPS
ETC
LED
[Raitoemittei;ngudaio-do]
SRS
[Sapurimentaruresutoreintoshisutemu]
TRC
Traction control
VSC
[Bi-kurusutabiritei;kontoro-ru]
306
[Karo-rarumion] _ J
[U] W i n k e r
C
.
Lamp..exchange..
direction..instruc
tion..lever..wattage.
Window
d
Washer..power..window.
[I]
1 5 9
1 5 7
Defogger.
t o
Window..lock..switch.
h o w s
take it out
Warning..light..washer.
ETC system
1
Liquid..replenishment
confirmation
..switch..tank..capa
city..winter..ahead..
h i s t o r y
1 6 5
u s e
Environment
ETC unit
1 6 0
1 6 4
lamp display
a
preparation..check.
Driving
notification
s o u n d
. . 2 5 8 . .
friendly..drive..cold
..drive..correct..sa
y..posture..procedure.
Driver's seat seat belt
Horizontal small articles Enter. 200 of 264
driver's seats. non-wearing warning light
[irumine-teddoentori-shisutemu] 103
event data
recorder
Operation..light.
.part..user..custo
mize..function.
5 7
1 1 5
inner mirror
307
Ant on _ KA
2 4 8
Overheat..put..warning
manual air
conditioner
Air bag
light..bonnet.
Engine
General..warn..supplemental
immobilizerSystem..engine..oil.
restraint system
airbag..child..Mr...a
Winter..ahead..prep
ttention..curtain..shield..air
aration..check..oil
pressure..warning light..capacity.
bag..warn..curtain..shield..air
bag..operation..co
ndition..remodel..aban
"Engine start
stop"
103
Switch
donment..warning light..side..air
b a g .
Indicator..operation..method.
72 operation
condition
of 71 reception
desk supplemental
restraint
system airbag
[O] O i l
Oils and fats..capacity..brand.
Temporal spare tire
Air..pressure..take
o
..131.. ..electronic..
Auto..air conditioner..aut
..toll..
omatic..transmission.
..collection.. system 91
electric power steering
6
confirmation
o
wheel
1
Automatic transformer
h i s t o r y
1 6 5
u s e
light..operation.
Overheat..engine..opener.
Engine
Ignition
9
308
Ant on _ KA
F i l l
opening..trunk..bonnet.
Mechanical..key..wireless..door
The 76 children's
l o c k .
53 children
are taken.
opening
T o
t h e
E n g i n e
starts..overheat
h a n d l i n g
..key..batter
o f
y..cut..key..l
3 6
ose..urgent..f
[honootsutsu]
or..hook..warning
63 warning
o f
light..attach..pull..stack.
2 8 7
.gear-
p o w e r
shift..shift.
w i n d o w
.electron..
key..normal..work..battery..go
[Ka] . . 2 2 3 . .
k
up..blow out.
[Ku] Air..pressure..air-conditioning.
g a r a g e
Auto..air conditioner..fil
ter..cleaning..exchange..manual..air
conditioner.
[Ki]
Windshield..mirror..heater.
ar..plate..key..co
mposition..key..batter
Defogger.
y..cut..keyless..e
Clearance..son
ntry..key..lose..
ar..cruise..control..glove
electron..key..elec
tron..key..normal..work
..electron..key
..operation..range.
309
Ant on _ KA
[Ke] Meter
Multi information
Light..cancel..reverse.
114 112-meter
Make-up..for..m
illuminance
irror..pull..exchange.
adjustment screen
Warning by warning light and pilot light
[Ko]
A
Brake..assistan
conditioner..fi
ce..supplemental
lter..key..b
attery..tire..lamp..fuse.
r e s t r a i n t
s y s t e m
Tool..flying..dist
ance..retreat..light.
airbag..engine..cruis
e..control..seat
Lamp..exchange..wattage.
Coat hook..small
articles..put..console
..side..pocket..
belt..wear..charge
. . s m a r t .
console..lighting..
console..box..side..air
.entry..start..system.
2
[Sa] bag..side..direction..instruction..light.
2 6 0
o i l
p r e s s u r e s
Warning buzzer
Direction..instru
ction..lever..wattage.
S u n
2 6 0
b r a k e s
310
Ant on _ KA
v i s o r .
[Shi] Seat
Shift lock..system..car..velocity.
Good posture..child
110 and 112 speed
seat..fixation..maintenance..reception
desk..seat..adj
meterAverage..car..velocity.
Jack
ustment..reception
desk..seat..adjus
tment..warn..headrest..rear
Garage..jack..tire..exchange.
Jack..steering wheel..car..width..light.
seat..adjustment..rear
seat..adjustment..warn.
Seat belt
Lamp..exchange..light..s
witch..wattage.
Child..Mr...wear..urgent..seat
belt..fixation..mechanism..seat
belt..pretensioner..cleanin
g..maintenance..height..a
djustment..correct..say..for..child
seat..fixation..mechanism..child
model
..one..wear..wear..warning
light..pretensioner..warning
Ignition..window..lock..eng
ine..engine..st
light..separation..storage..method.
..206.. ..room.. light cigarette
art..sto
p..cruise..control..door
writer
2 9 9
1 9 3
lock..back..clearanc
w a t t a g e
e..s
Shift lever
onar..power..
Automatic transformer
106 shift lever
window..emerge
ncy..blink..light..reception
cannot
be shifted.
280.
desk..Fogra..Ito.
311
Ant on _ KA
[Se] Cleaning
Exterior..seat
[riyauindou;] 190
lights
1
belt..interior.
7
Braking light
and
1
Lamp..exchange..wattage.
Starter
mileometerCarwash..ahead.
Manual operation..light..axis..adjustment..dial.Switch..warning
It stacked.
291.
Steering wheel
light..warn..lamp..ex
a n d
change..li
ght..cancel..war
104Adjustment..power
steering..warning light.
n..buzzer..lig
ht..cancel..
Stoplight
2 3 1
prevention..f
w a t t a g e
unction..light
2 9 9
..sensor..wattage.
110 and ..112.. ..turn..
tires
2 9 8
2 6 7
air pressure
[Ta] c e n t r a l b o x
s t a r t
Lamp..exchange..
system
2
l
a
3
o
direction..instruc
c
n
k
d
u n l o c k i n g
tion..lever..wattage.
Tire
T e m p o r a l
s p a r e
d o o r s
312
Ant on _ KA
tire..air..pressure
..exchange..chain..check.
r o t a t i o n s
Electronic key
. . 1 7 1 . .
[Chi] g e a r - s h i f t 1 1 2
Check..component replacement..door.
chains
Automatic transformer
106 gear-shifts
Door..glass..do
cannot be
shifted.
or..mirror..door
280.
lock..door..warning
Child seat
81 fixation
light..door..warn..display.
Door..glass.
Storage compartment in the door..door..mirror.
. . 1 1 8 . .
maintenance
Adjustment..mirror..heater.
[Tsu] 2
7
Anti-theft system
[Te] d i s p l a y s
2 1 5
Engine immobilizerSystem.
Reading light
2 1 6
Switch..wattage.
i n t e r i o r s
Rear light
2
trunk opener 80
traction control 204
w a t t a g e
[topputeza-anka-] clock
Defogger
. . 1 8 9 . .
[riyauindou;] 186 mirror
[Ni]
heater
189 defogger
Pile..attention..trunk.
Lamp
2 9 9
2 2 5
w a t t a g e
313
Ant on _ KA
Valve
Exchange..wattage.
c o s t
Fuel
Power..window..blowout.
er..amount..fuel
gauge..capacity.
Door..warn..display..steering
wheel.
parking brake
2 9 9
1 9 3
w a t t a g e
Lamplight [Bi-kurusutabiritei;]
Control..heater.
Hazard light
2
Auto..air
conditioner..manual..air
w a t t a g e
..252.. ..backup.. light departure
conditioner..mirror..heater.
Emergency blinking light
flame cylinder
2 9 9
2 3 1
Switch..lamp..exchange..wattage.
w a t t a g e
..140.. battery backing & clearance
Taillight
sonar
The battery rising
Switch..lamp..exchange..wattage.
170 preparation
for previous of 284
Fuse..pilot
l i g h t .
2 0 3
w a t t a g e
314
Ant on _ KA
[Fu] Hook
To [dei;sucha-jiheddoraito]
2 0 8
2 5 4
Concern..warn..lamp.
c o u r t
.exchange..light..ca
ncel..warn..buzze
..179.. brake
r..light..cancel.
.prevention..function.
.light..sensor..wattage.
2 9 7
1 0 9
Headrest
maintenance
d
Adjustment.
. . 2 0 9 . .
..reception desk..
light wheel
seat 97 floor
Lamp..exchange..
m a t
direction..instruc
41 warning of
tion..lever..wattage.
adjustment of 41
Bottle..holder..b
onnet..manual..air
1 9 3
[Ma] c o n d i t i o n e r . . m u l t
w a t t a g e
i..informa
tion..display..mirror.
[Mi]
w a t t a g e
Inner..mirror.
.door..mirror..v
anity..mirror..
mirror..heater.
w a t t a g e
190 [furontowaipa-deaisa-]
[Me] Meter
Analog..meter..
[He] . . 1 1 9 . . h e a d l i g h t
button..display
..switch..button..m
cost
ulti..informatio
n..display.
.illuminance..adj
ustment..screen.
l i g h t .
315
Ant on _ KA
Maintenance
2 9 4
Rear seat
3 0 3
maintenance data
Fold..adjustment..move
u p . . r e a r
seat..adjustment..warn.
Rear center..arm..Wrest..turning
[Ra] o i l s a n d f a t s
indicator.
Lamp..exchange..d
irection..instruct
w a t t a g e
ion..lever..wattage.
Light
G l o v e
[Ru] R o o m . . m i r r o r . . c o o l i n g
box..light..console..lighting..
room..light..lamp..excha
nge..vanity..mirror..ce
[Re] water.
Winter..ahead..preparation..check.Capacity.
iling..lighting..reception
Refrigerator
desk..personal..light..reception
desk..Fogra..Ito..headlight..directio
Engine..overheat.
Furnace Lock
n..instruction..lig
Window..lock..s
ht..luggage..room..ligh
hift..lock..sy
t..read..light..wattage.
stem..child..protector..door
l o c k .
3 9
w a t t a g e
[Wa] W i p e r
Reception
1 9 3
w a t t a g e
189 [riyauindou;defogga-]
d e s k .
Wireless..remote
control.
Battery..exchange..remote
c o n t r o l .
316
Ant on _ KA
P. 267
P. 278
P. 68
P. 284
P. 280
P. 289
When overheating
P. 281
P. 284
P. 22
P. 31
P. 34
Door
P. 291
When stacking
P. 260
317
Ant on _ KA
[Oputei;toronme-ta-]/[supo-tsuoputei;toronme-ta-]
Analog meter
318
Ant on _ KA
P. 261
[Dei;sucha-jiheddoraitoo-toreberingu]
P. 262
warning light
P. 263
P. 262
P. 263
P. 262
- Please confirm lighting and blinking the warning light. ( P. 260) Please confirm the following when the warning light is not lit,
has blinked, and it sounds it warning outside the car.
Situation of car
Reference page
It is running.
P. 27, 28
P. 107
P. 97
319
Ant on _ KA
Bonnet hook
Fill opening
P. 221
P. 64
Bonnet opener
P. 221
Capacity of fuel
(reference value)
Kind of fuel
P. 64
P. 298
60L
Nonlead regular gasoline
P. 65, 294
Standard tire
Front wheel
185/70R14 88S
195/55R16 86V
Rear wheel
230(2.3)
kPa(kg/cm2)
200(2.0)
kPa(kg/cm2)
220(2.2)
kPa(kg/cm2)
200(2.0)
kPa(kg/cm2)
Kind of engine
oil
320
Ant on _ KA