Escolar Documentos
Profissional Documentos
Cultura Documentos
CD8227GP
GENERAL DESCRIPTION
CD8227GP is audio power IC wit h built-in
two Channels developed for portable radio
cassette tape recorder with power ON/OFF
switch.
Thermal
shut
down
protection
FEATURES
z
High
Power
Pout=2.5W/CH(Typ.)
:(Vcc=9V,R L =4 ,f=1kHz,THD=10%)
Pout=3.0W/CH(Typ.)
:(Vcc=9V,R L =3 ,f=1kHz,THD=10%)
Vo ltage Gain :
Output
Noise
Voltage
(Vcc=9V Vin=0)
BW=20Hz~20kHz)
z
Stand-By Switch
Soft Clip
1/8
SUM
SUM
CD8227GP
SYMBOL
RATING
IQ(peak)
1.50
PD
3.00
Operating Te mperature
Topr
-25~75
Storage Temperature
Tstg
-55~150
Output
Current (Peak/CH)
UNIT
ELECTRICAL CHARACTERISTICS
(Unless otherwise specified , Vcc=9V,f=1kHz, Rg=6 00, R L =4 ,Ta=25 C)
CHARACT ERISTIC
SYMBOL
Quiescent Current
ICCQ
Output Power
Total Harmonic Distortion
V I N =0
21
45
2.0
2 .5
mA
POUT(1)
THD=10%
POUT(2)
THD=10%, R L =3
3.0
P O U T =0.4W/CH
0.2
1.0
43
45
47
56.5
30
0.3
1.0
mV r m s
-52
dB
-50
dB
30
60
mV
THD
Rf=120
V O U T =0dBm
Rf=0,V O U T =0dBm
GV(1)
Voltage Gain
GV(2)
Input Resistance
RIN
VNO
R.R
Cross Talk
C.T
V6,V7
Stand-By Current
Istb
Rg=10k ,
BW=20Hz~20kHz
Rg=600 ,
fripple =100Hz
Rg=600 ,
V O U T =0dBm,
SW1-OFF
W
%
dB
Vcc 4.5
0 .03 0 .03 0 .7
10
11
12
5.0
8.7
4.5
Vcc
2/8
SUM
SUM
CD8227GP
*(1) T h i s I C c a n b e u s e d w i t h o u t c o u p l i n g c a p a c i t o r ( C I N ) , I f v o l u m e s l i d e n o i s e o c c u r r e d b y
i n p u t o ff s e t v o l t a g e i s u n d e s i r a b l e , i t n e e d s t o u s e t h e c a p a c i t o r ( C I N ) .
* ( 2 ) T h e c o n d e n s e r b e t w e e n t h e p i n a n d t h e G N D ( C 11 ) i s f o r r e d u c i n g p o p n o i s e w h e n t h e
p o w e r O N / O F F s w i t c h ( S W 1 ) i s s e t t o O N / O F F.
Gv=56.5dB(Typ.)
Gv=45dB(Typ.)
Fig 1 .
SUM
SUM
CD8227GP
3. INPUT STAGE
The input circuit of this IC is as
shown in Fig.2. PNP TR: Q1 is provided
in the input circuit so as to make its
usage
possible
without
the
input
coupling capacitor.
However , at pins
and , max
after
checking
volu me
Fig.2
SUM
SUM
CD8227GP
As the oscillation allowance varies according to the printed pattern layout, the
standard printed board is recommended to be referred to des ign it
5. INPUT VOLTAGE
When the excessive signal is in put, tu rning-up is produced in th e clip waveform.
Th e tu rn ing-u p po in t is V I N =300mVr ms(Typ.) : Vcc=9V, R L =4 , f=1kHz : Enough care
must be taken for this phenomenon.
7. GND LINE
GND pin is not separated for Pre-GN D a nd for Pw - GND. That is liable to cause
distortion and cross talk worse. Before use this IC, please check it.
CHARACTERISTIC CURVES
5/8
SUM
SUM
CD8227GP
6/8
SUM
SUM
CD8227GP
7/8
SUM
SUM
CD8227GP
8/8
SUM