Escolar Documentos
Profissional Documentos
Cultura Documentos
solution.
Flexi Multi radio BTS introduces a new way to build BTS sites using modules,
without a specific BTS cabinet.
Due to its small weight and size, modular design and full frontal accessibility.
Flexi architecture provides a smooth evolution from WCDMA/HSPA to LTE,
without compromising performance or capacity.
A Flexi Multi radio BTS consists of one Remote Radio Head (Or RF Module) per
frequency band and one System Module with a transmission sub module.
The same Multi radio modules are used in both WCDMA/HSPA and LTE indoor
and outdoor sites.
All modules can be accessed from the front, are outdoor weather protected and
fresh air cooled.
Flexi System Module with Transmission Module, 3-sector RF Module and
Remote Radio Head are IP65-classified outdoor modules.
Flexi Multiradio BTS LTE can also be mentioned as Flexi eNB.
System Module
Flexi Multi radio BTS System Module hosts the telecom control,
Power consumption of the FSME (not including transmission) and FSME used as a System Extension Module
* During cold start-up (module heating on, high load)
** Operational power consumption at room temperature
*** Module in idle state, fans off, +0C
All above with nominal 48V voltage input.
Contents
Introduction to the FlexiBTS architecture
FlexiBTS installation options
Description of TD-LTE FlexiBTS modules and sub-modules
FCMD Functionalities
FCMD -- Flexi Control and Multiplexing Sub-Assembly, version D
Takes care of controlling of System Module O&M features for FTM and FSPCs
intelligence temperature control,
clock distribution to the BTS
baseband- and RF-synchronization
power distribution
Platform for user plane resource manager, optical interfaces to/from another
modules and summing & multiplexing for baseband pooling
FSPC Functionalities
FSPC Flexi Signal Processor, version C
User plane signal processing including L1 and part of L2
Frame protocol termination
Radio link signalling
Local O&M
Boot SW download fail recovery
FPFB Interfaces
FPFB functionality
The FPFB does not have any circuit breakers but instead electrical fuses and a
dedicated power switch for the System Module.
There are five membrane switches on the FPFB front panel for the outputs. The
switches control power control circuits and have two states: On and Stand-by.
This allows to individually connect or disconnect the power supply from each of the
max 5 modules:
System Module
RF Module / RRH 1
RF Module / RRH 2
RF Module / RRH 3
Extension System Module
The fuse rates for the FPFB are RF1-3 31.0A (+/-2A), EXT 25.0A (+/- 4.5A)
AXIS FZNB/FZHB