Escolar Documentos
Profissional Documentos
Cultura Documentos
Users Guide
Table of Contents
CONTENT 2
1 OVERVIEW
3
2 ENGINE INTRODUCTION
3
3 ENGINE SPEC
4
4 IMAGE SIZE SPEC
5
5 OPERATION PROCEDURE
6
6 PROJECTION LENS FOCUS ADJUSTMENT
11
7 TROUBLE SHOOTING
11
1 Overview
This users guide presents an overview of the DataTree3D UV Light Engine and a general
description of the main features and functions. It will explain the first steps to get
started, shows a detailed description of the push buttons function, and the main
connectors. It will give the user a successful start with the first Data Tree 3D 1080p
UV Light Engine.
2 Engine Introduction
The DataTree3D UV Light Engine, based on UV LED and Texas Instruments DMD. All glass lenses and
optical coatings are optimized for 405nm. Besides, 0% offset optical architecture was chosen for getting smaller distortion.
Note: The operation temperature is 5~35 0C
3 Engine Spec
The DataTree3D UV Light Engine Performance is based below Standard Test Conditions:
Warm-Up Period
LED Duty Cycle
LED Current
LED Junction Temperature
Ambient Light
Ambient Temperature
Input Signal
3 minutes
100%
5A
System side need provide the cooling module to make
Tj below 90 0C
0mW @405nm (Dark Room)
25oC
1920 x 1080 Pattern @60Hz
Engine Performance:
Parameter
UV Output Power
FO:FO Contrast Ratio
TV Distortion
Typical Value
400
1000:1
1
Unit
mW
%
Note 1:
TV Distortion Definitions:
Horizontal: (W1+W3-2o W2) / 2o W2
Vertical: (V1+V3-2o V2) / 2o V2
Image Size
Image Pixel Size
Image Resolution
Image Width
Image Height
Projection Distance
2.2inch
25
1016
48
27
77.6
4.3inch
50
508
96
54
174.1
8.7inch
100
254
192
108
368.8
UNIT
um
ppi
mm
mm
mm
5 Operation Procedure
5.1 Part Check List
Part
Light Engine
Qty
1
Transfer Board
Picture
Assembly
5.2
Item
LED
Current Default
Video Source
Default Setting
OFF
5000mA
HDMI Input
10
7 Trouble Shooting
(1) If the light engine cannot be turned on or no image projected, please
turn off the light engine. Then, check the cable connections, and turn it
on again.
(2) If you cannot control the light engine via the software, please re-connect
the USB cable or check if the software is installed correctly.
11