ECET-2011
15"
152,
153.
154,
155,
158,
157,
158.
It is advisable to control speed of
induction motor by maintaining
1) voltage constant
2) frequency constant
3) vif ratio constant
4) slip constant
In digital computers, a BYTE denotes
1} an 8-bit binary word
2) a 6-bit binary word
3) a4-bit binary word
4) 2 12-bit binary word
In oder to enter a control word in the
control register of 8255, the instruction
to be used is
1) OUT 01 2) OUT 02
3) OUT 03 4) ENTER
A Zener diode is operated in the
41) forward bias
2) reverse bias
3) breakdown region
1) only if both inpu
2) only if both inputs are 0
3) only it one input is 1 and the otheris 0
4) if atleast one of the inputs are 0
RBC Is equivalent to
DA+BLE 2) ABC
3) AHBSC AVAB.C
The devices commonly used for making
digital circuits are
1) mechanical switches
2) relays
3) vacuum tubes
4) semiconductor devices
AGRO can display
1) ac signals
2)designals
8) both ac & de signals
4) time-invariant signals
EGETAR.
160.
We.
182.
Model
164,
165.
186.
3
The main advantage of crystal oscillator
is that its output is
1) a constant frequency
2) de
3) 50 Hz to 60 Hz
4) variable frequency
The input impedance of the operational
amplifier is
‘infinite 2) zer0
3) very high but not infinite
4) very small
ICs aro uewally made ot
1) Sllicon 2) Germanium
3)Aluminium 4) Silver
The most moder method of heating
used in food processing is
4) induction Ireating
2) resistance heating
3) dielectric heating
ORG“
if tion at various points on a
WEHZ8 StF Surface illuminated by the
same source varies as
1) Cos 8 2) Cost
4
Coo?
3) Coct 0 4) cose
Which of the following is present inside
the fluorescent tubc?
1) Heliuen & oxygen 2) Argon & Neon.
3)Argon&CO, 4) Mercury vapor
The value of coefficient of adhesion will
be high when rails are
4) wet 2) Ulead will send
3) greased 4) prayed with oil
The speed time curve for urban service
locomotive has no
1) coasting period
2) free running period
3) braking period
4) acceleration period
Roliet Books ~ECET ~Fou— Electrical and Electronics Engineering
of
Veekster.com
‘CONNECTING COLLEGE FRIENDS. SEND FREE SMS92.
ECET MODEL PAPERS
2 CET MODEL PAPERS,
167.
168.
169.
170.
474.
172.
173,
Long distance railways operate on
1) 25 KV single phase ac
2) 25 KV three phase ac
3) 15 KV three phase ac
4) 600V de
The machine having heavy fluctuation of
load is,
41) lathe 2) planer
3) punching machine 4) printing machine
The best suited motor for rolling mills is
1.00 enuint maree
2) DC cumulative compound moter
3) squirrel cage induction motor
4) synchronous motor
PLC stands for
1} proportional load controller
2) programmable load controll
3) programma
474,
178.
176.
477.
Mode
Ina 4-pole, 36 slot dc. armature, the coil
span of 180 electrical degrees will be
obtained wien the coil occupies
1)1and9slots 2) 1and 10 slots
3)2and9slots 4) 3and 10 slots
The essential condition forstable paralte!
operation of two identical DC generators
is that, they should have
1) same no-load and fullload speed
2) same kW output ratings
3) same percentage regulation
4) Droping voltaga
Ina DC series motor, the field flux is
1)nearly constant
2) proportional to armature current
3) inversely proportional to field current
44) proportional to square of the armature current
In a DC shunt motor, at 20A of load
current the torque developed is 30 Nm.
aisteniition
9).60 rh 2) 45 Nm
EC ETA P. pee doubled, the torque
4) proportional ee “i
The commuta giments0 hirrda:
machine are insulated form each other
by a thin layer of
1) paper 2) mica
3) rubber 4) PVC
A 200V DC machine has an armature
resistance of 9.02 ohms. The difference
in the induced voltages when the
machine is running as a motor and as a
generator and carrying a full load current
oF 200 A, is
1)4 volts 2)8 volts
3) Ovoits 4) 16 volts
Negative voltage regulation is obtained
in the following DC generator
1) flat compound generator
2) under compound generator
3) over compound generator
4) series generator
478.
179,
180,
Roller Books ~ ECET —rox— Electrical and Electronics Enginearing
tus
3) 30 Nm 4) 120 Nm
Hysteresis and Eddy current losses in
electrical machines depend on
4) flus dersily 2) speed
3) speed and flux density
4) voltage
The efficient way of obtaining damping
torque in electrical instruments is
4) air friction damping
2) fluid friction damping
3) hysteresis damping
4) Eddy current damping
Induction type wattmeter operation is
based on
1) Eddy currents flow
2) thermo-static effect
3) thermo-electric effect
4) photo-voltaic effect
Veekster.com
‘CONNECTING COLLEGE FRIENDS. SEND FREE SMSECET-2011
18
182,
183.
184,
185,
186.
187.
1838,
Basically, a megger
1) moving-iron type of instrument
2) electro-static type of instrument
8) hot-wire type of instrument
4) moving-coil type of instrument
The thermocouple instrument will
measure
‘)temperature 2) voltage
3) speed 4) flux
The load sharing between two
transformers operating in paraltel, is
cording ly thelr
1) efficiency 2) puimpedence
9) rating 4) leakage reactance
The primary and secondary induced
emf's, E, and E, in a two winding
transformer are always
1) Equal in magnitude
2) in-phase with each other
3) anti-phase wilt
4) depends on
A 200KVA trans’
hadeen torr ldee'4
of 1 kW and full ioad copper toss of 2
KW. The load kVA, corresponding to
maximum efficiency is
2) 100 kVA
4) 200 kVA
4) 60 kVA
3) 141.4 kVA
The main purpose of pertorming open-
circuit test on a lansformer is to tind its
1) core loss 2) copper loss
3) efficiency 4) insulation resistance
When compared to a A-A three-phase
transformer bank, the Capacity of V-V
transformer bank is
1) 57.7% 2) 50% 3) 66.7% 4) 86.6%
The equivalent primary resistance of the
transformior with k=5 is 0.1 ohm, When it
is referred to secondary, then it becomes
1) 0.5 ohms 2) 0.02 ohms
3) 0.004 ohms 4) 2.5 ohms
Roller Books ~ EC!
of
189.
190.
194
192.
dR
494,
195,
93
In the emf equation of a transformer, the
flux involved is
1) instantaneous value 2) average balue
3) maximum value 4) ms value
An ac current given by i=14.14
sin(ot+n/4) has anim. value of
1) 14.440 2) 108
3),7.078 4) 1.964
The reactance of a capacitor to
alternating current of frequency 50Hz is
102. If the frequénuy iy Iuereaed te
100Hz, then its reactance becomes
1) 5 ohme,
3) 20 ohms
The form factorin a.c. means the ratio of
2) 10 ulus
4) 2.5 ohms
1) peak value to average vaiue
2) peak value to rms value
3) ims value to average value
PECETAP-ORG===
sei! Due, waltmeter method of measuring
S-phase power and power factor is 0.5,
then one of the wattmeter will read
v we
Hy 2ze 3) Jew 4)
Acoil of resistance 1009 and inductance
100 His connected in eerics with 100pF
Capacitor across a 10V varlable
frequency supply. The resonance
frequency of the circuit is
1) 1.995109 Hz 2) 18910? Hz
3) 1600 | tz 4) 1.5910 Hg
A parallel circuit consists of a 2.5 xF
capacitor and a coil whose resistance
and inductance are 152 and 260 mH
respectively, the dynamic impedance of
the circuit is
1) 1560 ohms
3) 2500 ohms
2} 433.3 ohms
4) 6933 ohms
lecttical and Electronics Engineering
eekster.com
‘CONNECTING COLLEGE FRIENDS. SEND FREE SMS94 ECETMODEL PAPERS,
496. At leading power factors, the armature | 198. Zero power factor method of an
flux in an alternator the rotor flux. alternator is used to find its
4) opposes 2) distorts 4) efficiency
3) aids 4) does not effect 2) voltage regulation
197. The distribution factor is defined as the
: 3) armature resistance
ratio of
1) arithematic sum of coil emfs to phasor 2) Synatrancle inpetarice:
sum of coil emfs 199. Asinewave has a frequency of 50Hz. Its,
2) phasor sum of.emf per coil to the angular frequency is ___ radiansf
arthematic sum of emf per coil second.
3) phasor sum of coil emfs to the arthemaltic ra on
coun af Catal AiviES, 1) 7 2) an 3) 80r 4) 190
4) phasor sum of coil emfs to the per phase
voltage 200. {fan alternator winding has a fractional
pitch of 5/6, then the coil span is
1)300° 2) 150° 3)30° 4) 60"
KEY Anwar] UND [Answer] Gino, [Answer
fat | 3 | er Tet 2
1 | 162 182 a al
183 3
ver_|_ 3
[105 1 _|_ 3
106 of frevidGs Ni x 1
107 3 127 2 4
108 4 iz | 2 148 188 4
700 | 3 | a | 2 | 9 7e9 [3
110 i 130 % 180 480 2
mp4 pm] 3 [a] 161 t
12 | 2 132 a 1s 192 4
13) 4 133 4 153 483 = |
fia | 3 194 104 14 a
115 4 136 aq | is 175 i [4
T6 4 736 7 186 176 | 196 3
a7 3 137 4 157 [v7 187 | 3
118 3 138 3 18 176 18 4
Te 7 ae > 748 i Te 188 a
420 2 140 [ 4 160 180 200 2
KEY WITH EXPLANATION:
410. +; rotorinput: (1-S)xrotor input: Sxrotorin- 174.
as a generator 204V as a Motor 196
put) 1:(1-S):S 195. dynamic impedance
ja: ex — 12050 _ 4509 260x109
4 * CR (2.5% 10x18)
=5%= a SRE = 6933.
$= 5% = 0.05, S= asap Oe
Rover Booka ~ ECET —ro— Electrical and Electronics Engineering
%$ Veokster.com
‘CONNECTING COLLEGE FRIENDS. SEND