Escolar Documentos
Profissional Documentos
Cultura Documentos
,ltd
Attn :James
Email: jamesyihaoda@hotmail.com
Skype: jamesluis1162
Manual
YHD-101
1. Catalog Packing list
2.Equipment introduction
3.Device connection and setup
4.Drivers and software installation
Packing list
Product name
Quantity
1 Taiwan
HDMI HD line
1 pcs
1 pcs
power line
1 pcs
1 pcs
2. Equipment introduction
3.Drive installation: ( win8 win10 win7 system or no cut version of the system will automatically install the driver)
Open the control panel to open the device manager to find other devices (see below), the right mouse button, select
update driver, select browse to find the driver to find the computer software "drivers" folder, decompression
decompression next to wait for the driver installation is complete.
Drive
follows
installation
steps
are
as
Note: if you can not install the driver, can refer to the driver installation tutorial, re installation, as long as not genuine
system will have some of this kind of situation, because the copycat system after slimming treatment, many system
components are removed, resulting in the driver installation problems.
setthe
device
appiy
port
as
1 layer thickness, the proposed set 0.05MM thickness, printing speed and precision are more ideal. Set the range of 0.0250.1 (the smaller the thickness of the higher accuracy, but the printing time will be longer)
2 single exposure time, it is recommended to set the value of 8000-1300MS (the longer the single layer, the stronger the
light penetration, transparent resin will appear over curing, etc.)
3 first exposure time, the proposed use of the default parameters, (the first layer of curing time is longer, the more tight
the base)
4 first layer number, and the use of the first layer of long time exposure of the number of layers, the proposed use of the 3
layer
The 5 type fidelity value, improve the smoothness of the model surface (generally set 1.5-2)
6 platform lifting height (full size printing model proposed 4-5MM small model 1-2MM, such as the model of the large print,
uplift is not enough, the resin can not fully flow into the middle of the model, resulting in printing failure).
7 platform uplift rate (the proposed set of 30-80, the speed is too fast a small part may be directly pulled bad)
The rate of decline of 8 Platform (recommended to set the 80-150, fell too fast may cause crushing model of small parts)
10 slice X axis mirror 11 slice Y mirror image (such as the model of the direction of the model can be set up)
Note: for the first time, it is recommended to use the default parameters to print, follow up according to personal
experience, make the corresponding adjustment (software package to set good parameters)
C) software button introduction
15:
settings
view