Escolar Documentos
Profissional Documentos
Cultura Documentos
o password: skills
Send an email from CE-PC1 to Home Laptop
When the email can be received by the Home Laptop and the pings are completed to
the servers you are completed with this activity.
Question 1
Marks: 5
Your first task was to add an IP phone to the Battery Storage research area. Wha
t is the port through which IP phones communicate with a Cisco Unified CME route
r according to the configuration?
Choose one answer.
192.168.5.1 port 2000
192.168.1.1 port 2000
192.168.1.1 port 8080
192.168.2.1 port 2020
192.168.2.1 port 2000
Question 2
Marks: 5
What interface is used as the default route on the University-RT router? (Answer
Example: FastEthernet0/1)
Answer:
Question 3
Marks: 5
Why would you use the redistribute static command line on the University-RT rout
er?
Choose one answer.
Because there are multiple routing protocols used on the University rout
er.
Because it is a default command when configuring routes on any router.
Because the NAT addresses are used on more than one network of the Unive
rsity router.
Because the ACLs need to be controlled via the NAT configuration.
Question 4
Marks: 5
Which routers initially have all ports inactive?
Choose at least one answer.
ISP2
ISP3
University-RT
Engineering-RT
ISP1
Question 5
Marks: 5
This command is used so that in the DHCP broadcasts an IP phone can see the TFTP
server that has its IP address and number. (ANSWER: command only, no IP number)
Answer:
Question 6
Marks: 5
How many broadcast domains exist in this activity? (Answer with a numeral. Examp
le: 3)
Answer:
Question 7
Marks: 5
In which router configuration would you find the command line you see below?
access-list 1 permit 10.0.7.0 0.0.0.255
Choose one answer.
Home Office router
Engineering-RT router
ISP1
University-RT router
ISP4
Question 8
Marks: 5
Which two command lines on the University-RT are used to set the QoS of the IP p
hone network? (Choose two)
Choose at least one answer.
option 150 ip 192.168.3.1
access-list 100 permit ip any any dscp cs3
priority-list 1 protocol ip high list 100
redistribute static priority 100
service-policy output TelephonyFirst
Question 9
Marks: 5
On the Engineering-RT router how many networks are being advertised via EIGRP? T
his included the directly connected and those via another port. (Answer with a n
umeral. Example: 3)
Answer:
Page: 1 2 (Next)
Time Remaining
1992-2012 Cisco Systems Inc. All rights reserved.Terms of UsePrivacy Statement T
rademarks of Cisco Systems, Inc.Contact Us
Cisco Networking Academy
Marks: 5
The engineering department requests that they need another network added to the
solar panel area. The engineering group does not have any money to add another r
outer or switch. How could you add a new network using existing equipment with t
he least amount of cost to the IT department? NOTE: Plenty of cabling is already
in place. (Choose three)
Choose at least one answer.
On the Solar Switch create a new VLAN for the new network.
On the Engineering-RT router use 801q protocol to route multiple network
s to the Solar Switch.
Add a wireless router to a port on the Solar Switch.
On the Solar Switch and the Engineering-RT router setup trunking on the
connected interface.
Add a new network by using Engineering-RT router's FA0/1 interface to cr
eate two sub-interfaces.
On the Engineering-RT add a new interface card.
On the Solar Switch create VLAN and setup routing on the switch using EI
GRP 1.
Question 20
Marks: 5
What would be the access list to allow the NAT to work properly on the Universit
y-RT router? (ANSWER: begin with access-list)
HINT: One line
Answer:
Page: (Previous) 1 2
Time Remaining
1992-2012 Cisco Systems Inc. All rights reserved.Terms of UsePrivacy Statement T
rademarks of Cisco Systems, Inc.Contact Us