Escolar Documentos
Profissional Documentos
Cultura Documentos
Sample Goncrete Gylindrical Core IMix Proportion (as quoted): Not Mentioned ]
Year of Construction 2007-2008 No. ofFloors = 3
TEST REPORT
NOTE I *
The diameter of core specimens for the determination of compressive strength in load bearing structural members shall be at least 3.70 in. [94 mm]
For nonload bearing structural members or when it is impossible to obtain cores with length-diameter ratio (UD) greater than or equal to 1, core diameters less
than 3.70 in. [94 mm] are not prohibited.
IKIIE 2- Tte wtpressive stengt's of nominal 2-in. [50-mm] diameter cores are known to be somewhat lower and more variable than those of nominal 4-in.
"lffiqmml
fur*r .oiEs in d'0irn. s'naler darng qes ffir
b be more sensitive to the effect of the lenglh{iameter ratio.
COililENT
- Please compare the results with your conesponding design values and consult with your design engineer.
recommended that all test repotts are mllected by duly authorized person, and not by the Contractor/Supplier.
Page I of2
Baxcr-aDEsH f]Nrvnnsrrrr or ENcTNEERTNG AND TncrrNor.ocY (BUET)
Dnpa.RrMENT or Cwrr, EtrcrltnnRrNc
Mobile: 01819 557 964; PABX: 966 5650-80 Ext.7226i www.buet'ac'bd/ce/ BMY,g
Bureau of Research,
Testing & Consultation
Coucnere LaeonA,ronY
BRTC No. 1 I 00-88357,1 4-l 5lGE; Dt: 23161201 5
Sample Goncrete Cylindrical Core IMix Proportion (as quoted): Not Mentioned ]
TEST REPORT
*
Slab, 2nd Floor, Grid:(C- 4450 psi Combined
I TP-1S-2F 5.2 2.72 5.81 25,834
D) (1-2) (30.7 MPa) (Brick Chips)
*
Slab, 2nd Floor, Grid:(C- 3590 psi Combined
I D) (1-2)
TP.2S-2F 5.1 2.72 5.81 20,840
(24.8 MPa) (Brick Chips)
*
Combined = Mortar and Aggregate failure
NOTE I The diameter of core specimens for the determination of compressive strength in load bearing structural members shall be at least 3.70 in. [94 mm].
-
For nonioad bearing structural members or when it is impossible to obtain cores with lengthdiameter ratio (UD) greater than or equal to 1, core diameters less
than 3.70 in. [94 mm] are not prohibited.
The drpressive sfengths of nominal 2-in. [5Gmm] diarneter cores are known to be somewhat lower and more variable than those of nominal 4-in.
ilOTE 2
-Can* cnes ffiin, sn* ffi 6s b be rue sersitirc to the effed of the lengtMianeter ratio.
;" fi-m.mrrrf, Nn +er
C0tlllEllT
- Please compare the results with your conesponding design values and consult with your design engineer.
recommended that all tesl reports are collected by duly authorized person, and not by the Contractor/Supplier.
Page 2 ol 2