Escolar Documentos
Profissional Documentos
Cultura Documentos
About cards:
CPU: It is a main processing unit of the system which must be installed on extreme left slot
of the mother board. The different connectors are used for following.
KTS1: First KTS port with default number 400.
KTS2: Second KTS port with default number 401
J2 for external music input. (Remove JP5 while using external music)
J11 for relay, paging and sensor ports
J7 is serial port for ASMDR
J1 is for PRI in put.
FXS: It is an 8 line analogue extension card to be installed on slot 0 ~11 (slot 0 is the first
slot after the CPU slot)
The extension out put can be taken from RJ-45 connector J3 for Extn 1, 2, 3 and 4) and J4
for extn 5, 6 , 7 and 8.The default extn numbers are 100 onwards. and the KTS numbers
are 400, 401
FXO: It is a 4 line analogue trunk card to be installed on slot 0~11. The trunk in put can be
given to RJ-45 connector J1.The other connectors J2 and J3 are to get P& T dial tone to
any four extensions when there is a power fail. To get P&T on first 4 extns, connect a
straight cable from J3 on FXS card to J2 on FXO. Take extn out put from J3 on FXO. The
default trunk numbers are 600 onwards.
User commands:
Extn numbering - 100, 101,....
Trunk numbering- 600, 601,....
KTS numbering - 400, 401
Trunk group numbering 800~807
Extn group numbering 890~899
Operator code - 9
Global speed dialing - 7000~7999
Personal speed dialing - 8100~8109
Redial - *
Call pick up in group - 8*
Call pick up from other group - 8# extn
ACB - flash 825
Set DND 8241
Cancel DND 8240
Call fwd 822 A B extn (A=0 all calls, 1 only external calls, 2 only internal calls,
Y= 0 forwarding off, 1 on for all calls, 2 on for only busy, 3 on for only no answer,
4 on for no answer and busy.
ECF 823 AB XXX
AB= forwarding type
XXX= global number
Programming codes:
1) Set time: Psw (by default #* 1234) 000 hhmmss (24 hour format)
See following table for default slot numbers, port numbers and extension numbers.
10) Set DSS keys for KTS PSW ext 006 CC extn/trk/global number
To program TK1(600) on key 1 and 110 on key 5 for extn 400
dial,
PSW 400 006 00 600 #
PSW 400 006 04 110 #
11) Dynamic lock Extn unlok - 8214 personal PSW ( by default no psw)
12) Set personal psw 829 **** nnnn nnnn (nnnn = new psw)
---xxx---