Escolar Documentos
Profissional Documentos
Cultura Documentos
(Note : PRI line from PBX is terminated to VTEP as per above setup diagram)
Description
Open the Web GUI of Elastix server in web browser as shown below (IP of server will be
same as IP of System on which Elastix is installed).
http://192.168.51.6/admin/config.php# (here, 192.168.51.6 IP is allocated for Elastix WEB
GUI access)
Enter username & password as entered while installing Elastix.
Default username: admin, Password: admin
In Route Name field configure any desired Rule Name ( interop name used in this
Example)
In Dial Pattern field configure desired number pattern which has to be routed via VTEP
(_1. Used in this example, all Outgoing numbers with prefix 1 has to be routed via VTEP)
Prefix can be used before dialing the desired number. ( 9 used in this example)
Configure desired caller id in Caller ID field
In Trunk Sequence for Matched Routes configure the SIP trunk which we created.(In
this example, we have created VTEP)
Click on Submit Changes and Apply Configuration Changes Here as well.
Configure Description field as name of Incoming route. (In this example it is configured
as Incoming_VTEP )
Set Destination for Incoming call Router ( selected 7700 extension in Example)
Click on Submit
Click on Apply Configuration Changes Here.
Under Basic Settings on the left navigation bar, click the SIP Trunk link. The SIP Trunk
parameters page opens.
On the SIP Trunk page, choose any SIP Trunk number from 01 to 32 to register with
Asterisk, by clicking the SIP trunk number tab; for example, SIP Trunk number 1.
For the SIP Trunk number you select, make sure the SIP Trunk Enable check box is
selected.
Assign a Name to the SIP trunk as identification; for example, Elastix.
Click Registrar Settings to expand. In SIP Trunk Mode, select Peer to peer.
Click on Arrow Button beside peer to peer. A second window will pop-up
Under Basic Settings on the left navigation bar, click the SIP Trunk link. The SIP Trunk
parameters page opens.
Click Vocoder Preference to expand
Set Vocoder preference. As 1st Preference and 2nd Preference, set either G.711 A-Law
or G.711 - Law.
From the Selected Codecs list box, move all other codecsGSM FR, iLBC 30ms, iLBC 20
ms, G.729 one by one, to the Available Codecs box, by selecting the codec, and then
clicking the BACK ARROW.
Make sure only G.711 (A-law) and G.711 (- Law) remain in the Selected Codecs list
box. You may set one of these codecs as the First preference, by selecting it and using
the UP ARROW
Click Submit to save
Click on submit
Click
Click on submit
Under Basic Settings on the left navigation bar, click the T1E1 Port. The T1E1
parameters page opens.
Click Handling of Outgoing Calls to expand.
Select Radio button Port Wise
Click Handling of
Click Handling of
Tick mark flag Connect Source Port when Progress Indicator is Received on T1E1 Port
Once you have completed configuring the SIP Trunk, you may view its status.
To do this,