Escolar Documentos
Profissional Documentos
Cultura Documentos
for the
Danger:
signifies that death, serious physical injury or substantial material damage will occur if appropriate
precautionary measures are not taken.
Warning:
signifies that death, serious physical injury or substantial material damage may occur if appropriate
precautionary measures are not taken.
Caution:
signifies that minor physical injury or material damage may occur if appropriate precautionary
measures are not taken.
Qualified personnel Start-up and operation of equipment described in this manual (module,
device) may only be carried out by qualified personnel. For the purpose
of this instruction and product labels, a qualified person is one who is fa-
miliar with the installation, construction and operation of the equipment
and the hazards involved. In addition, he has the following qualifications:
> Is trained and authorized to energize, de-energize, clear, ground and
tag circuits and equipment in accordance with established safety prac-
tices.
> Is trained in the proper care and use of Power Line equipment in ac-
cordance with established safety practices.
> Is trained in rendering first aid.
Warning:
The equipment may be supplied by different and from each other independent dangerous voltages.
Before opening the equipment and starting the maintenance work, the device must be isolated with
the specified circuit breaker.
IZIER
TIF TE
R
The products and systems listed here are manufactured and marketed
ZE
LIT
TE
YS
A
T TS
SMA
NAGEMEN
Caution!
Do not operate the dummy load at more than 50W load for more than 5 minutes. Otherwise, sur-
faces could become hot and dangerous to touch. After use, allow the dummy load to cool down
properly!
Note:
This instruction is written for service and operation personnel in the high voltage power line envi-
ronment. All existing safety instructions in the client's environment have to be observed and only
trained and instructed personnel should work with the equipment.
Note:
The dummy load is not included in delivery of the PowerLink!
The dummy load serves for termination of the PowerLink HF output in case the system is not con-
nected to the transmission line.
Installation
The connection is carried out by means of the connection cable delivered with the dummy load.
Please connect first the cable with the safety BNC plug to the dummy load and then the RF con-
nector.
Ventilation openings !
Caution!
The device has ventilation openings at all sides which may not be covered! Please mount the
dummy load on a flat subsurface!
Warning!
Hot surface! Do not touch!