Escolar Documentos
Profissional Documentos
Cultura Documentos
81,,QWHUIDFH9HUVLRQ
F2 F1
UNI-Interfac e
-
+ 53V
GND
-
-
K1
K2
K3
K4
K5
J8
J4
J3
)XQFWLRQ
a) change over (SW - controlled) 24V or 53V to consumer at head (e.g. DRT)
b) activation of roll Off or roll Up units (relais contacts)
c) activation of a inverter with a voltage proportional speed signal
&RQQHFWRUV
(activation via SW is sep. described )
)DVWRQIRU'57SRZHU
The DRT needs 53V as a operational voltage, that gets based incl. GND from the terminal
block feed. The 53V are fused on a print with 6,3AF.
9SRZHU
The feed gets supplied from a amplifier-board (S6), fused with 4AF and with a diode in
forward directon to consumer conducted. Voltage on the consumer is either 24V or 53V.
DQDORJYROWDJHIRUWKHKDQGOLQJZLWKDFRQYHUWHU
Motors get controlled from the inverter. As a target for the drive, an analog voltage from the
system, proportionately to the speed of the x-axis, gets produced. This voltage is isolatet
from system power supply.
3OXJ-
FRQWDFWVIRUH[WHUQDO&RQWURO
For the control of external equipments (RollUp, RollOff) there are contacts usable. They are
controlled by SW. For each signal the 'normal open' and 'normal closed' contacts are
conducted to the plugs. Do not switch more than maximal 24V 200mA.
External power:
The current is taken by a external sources, you do not need an electrical connection to the
plotter feed. This is an important improvement of the interference resistance shoul be the
normal case!! The conductions must be fused.
Internal power:
Contacts can get provided from our internal feed +24V. Maximal voltage per contact 100mA.
The conductions must get fused.
SOXJ-5ROOXS
PIN Function Remarks
1 +24V internal feed
2 COM feed of common contact
3 NO_VOR contact forwards
SOXJ-5ROORII
PIN function Remarks
1 GND internal feed
2 COM feed of common contact
3 NO_VOR contakt forwards
4 NC_VOR contakt forwards
5 NO_RC contakt backwards
K
6 NC_RC contakt backwards
K
7 NO_ENA contakt enable
8 NC_ENA contakt enable
3ORWWHUPHQX
If the menu position is putted on <ESC>1291 roll-off or the menu position <ESC>1294 or
both together are on EXTERNAL and the menu position <ESC>1292 SENSOR on NONE
or 1 time stands, get agreed that an extraction table or an take-up table is joined. In this
case, functionality is like in the table above. For the activation of tables the PRATZEN
signals get used.