Escolar Documentos
Profissional Documentos
Cultura Documentos
CONTENTS
1 SCOPE
1.1 Note:
The application of this EURONORM to other steels may be
This EURONORM applies to non-coated steel strip hot- agreed on ordering.
rolled in widths < 600 mm from:
mild unalloyed steels for cold forming (for quality require- 1.2
ments see EURONORMS 46 and 111), This EURONORM does not apply to hot-rolled wide strip
general structural steels (for quality requirements see and steel strip (< 600 mm wide), which has been produced by
EURONORM 25 and, slitting hot-rolled wide strip. (The requirements on the toler-
fine grain weldable structural steels (for quality require- ances on dimensions and shape for these products are speci-
ments see EURONORM 113). fied in EURONORMS 51 and 112.)
2 DEFINITIONS
The definitions in EURONORM 79 apply for the terms hot rolled, strip, hot-rolled wide strip and narrow steel strip.
4 TOLERANCES ON DIMENSIONS
Variations in width shall be gradual and not occur irregularly. * L = ordered length.
4.3.2
The tolerances for cut lengths having ordered lengths differing
from those in 4.3.1 shall be agreed at the time of ordering.
5 TOLERANCES ON SHAPE
5.1.1 The permissible edge camber for cut lengths of less than
2 500 mm shall be agreed at the time of ordering.
The permissible edge camber related to a measured length of
2 500 mm, shall be: 5.2 Form of coils
20 mm for products ^ 40 mm wide The coils should be tightly wound, as round as possible and
10 mm for products > 40 mm < 600 mm wide. straight edged. Gradually stepped displacement of the edge of
(Testing as in 6.3). the strip to one side should not exceed 35 mm.
6 TESTING
7 PACKING
The coils shall be secured in such a w ay that they are not damaged nor unw ind in the course of normal careful loading,
transportation and storage.
L - 2 9 8 5 Luxembourg