Escolar Documentos
Profissional Documentos
Cultura Documentos
1
Page 2 of 2
____________________________________________________________________
Technical Data
______________________________________________________________________________________________________
Density 0.9 0.01 Kg/L
______________________________________________________________________________________________________
Fibre Length Available in lengths of 6, 9, 12, 19 mm.
______________________________________________________________________________________________________
Fibre Diameter Approx: 15 30 micron
______________________________________________________________________________________________________
Absorption Nil
______________________________________________________________________________________________________
Tensile Strength 300 450 MPa
______________________________________________________________________________________________________
Elongation at Break = 15 %
______________________________________________________________________________________________________
Softening Point 160C
______________________________________________________________________________________________________
2
Specific Surface Area Approx 200 m /Kg
______________________________________________________________________________________________________
Thermal Conductivity Low
______________________________________________________________________________________________________
Alkali Resistance 100%
______________________________________________________________________________________________________
Application Details
______________________________________________________________________________________________________
Dosage Chemrite P.P. Fibre is ready to use. Dosage is 0.6 to
0.9 Kg/m3 (average 100 gm per 50 Kg cement) of the
mortar or concrete depending on the mix ratio.
______________________________________________________________________________________________________
Dispensing Chemrite P.P. Fibre should be ideally added at the
batching plant; although in some cases this may not be
possible, then site addition can be done. If mixing is at
the batching plant, the fibre should be added first along
with some mixing water (30%). After all the other
ingredients have been added, including the remaining
mixing water, the concrete or mortar should be mixed
for a further few minutes at full speed to ensure
uniform fibre dispersion.
______________________________________________________________________________________________________
Curing Standard curing practice must be followed.
______________________________________________________________________________________________________
Cleaning Clean all equipment and tools with water immediately
after use.
______________________________________________________________________________________________________
Remarks Application temperature +5C to 40C.
______________________________________________________________________________________________________
Safety Chemrite P.P. Fibre is non-hazardous & non toxic.
______________________________________________________________________________________________________