Escolar Documentos
Profissional Documentos
Cultura Documentos
FTP2.2E
AA
Service Manual SDI plasma panels: 3122 785 14990
E_14650_051.eps
220305
Published by WO 0563 Service PaCE Printed in The Netherlands Subject to modification EN 3122 785 14651
EN 2 1. FTP2.2E AA Technical Specifications, Connections, and Chassis Overview
Power supply:
- Mains voltage (VAC) : 220 - 240 Figure 1-2 Rear connections
Power consumption
- Normal operation (W) : 42" - ca. 450
: 50" - ca. 600
- Stand-by (W) : <2
EXT2: Video RGB/YC - In, CVBS - In/Out, Audio - In/Out DVI-I: Digital/Analogue Video - In
1 8 C1 C2
20 2 9 16 C5
17 24
C3 C4
E_06532_004.eps
050404
SCART 3 PANEL H
Device Replacement Use only adequate solder tools applicable for lead-free
The last step in the repair process is to solder the new soldering tin. The solder tool must be able:
component on the board. Ideally, the (LF)BGA should be To reach a solder-tip temperature of at least 400C.
aligned under a microscope or magnifying glass. If this is not To stabilise the adjusted temperature at the solder-tip.
possible, try to align the (LF)BGA with any board markers. To exchange solder-tips for different applications.
So as not to damage neighbouring components, it may be Adjust your solder tool so that a temperature of around
necessary to reduce some temperatures and times. 360C - 380C is reached and stabilised at the solder joint.
Heating time of the solder-joint should not exceed ~ 4 sec.
More Information Avoid temperatures above 400C, otherwise wear-out of
For more information on how to handle BGA devices, visit this tips will increase drastically and flux-fluid will be destroyed.
URL: www.atyourservice.ce.philips.com (needs subscription, To avoid wear-out of tips, switch off unused equipment or
not available for all regions). After login, select Magazine, reduce heat.
then go to Workshop Information. Here you will find Mix of lead-free soldering tin/parts with leaded soldering
Information on how to deal with BGA-ICs. tin/parts is possible but PHILIPS recommends strongly to
avoid mixed regimes. If this cannot be avoided, carefully
clear the solder-joint from old tin and re-solder with new tin.
2.3.4 Lead-free Solder
Use only original spare-parts listed in the Service-Manuals.
Not listed standard material (commodities) has to be
Philips CE is producing lead-free sets (PBF) from 1.1.2005 purchased at external companies.
onwards.
Special information for lead-free BGA ICs: these ICs will be
delivered in so-called "dry-packaging" to protect the IC
Identification: The bottom line of a type plate gives a 14-digit against moisture. This packaging may only be opened
serial number. Digits 5 and 6 refer to the production year, digits shortly before it is used (soldered). Otherwise the body of
7 and 8 refer to production week (in example below it is 1991 the IC gets "wet" inside and during the heating time the
week 18). structure of the IC will be destroyed due to high (steam-)
pressure inside the body. If the packaging was opened
before usage, the IC has to be heated up for some hours
(around 90C) for drying (think of ESD-protection!).
Do not re-use BGAs at all!
For sets produced before 1.1.2005, containing leaded
soldering tin and components, all needed spare parts will
be available till the end of the service period. For the repair
of such sets nothing changes.
E_06532_024.eps In case of doubt whether the board is lead-free or not (or with
230205
mixed technologies), you can use the following method:
Always use the highest temperature to solder, when using
Figure 2-1 Serial number example SAC305 (see also instructions below).
De-solder thoroughly (clean solder joints to avoid the
Regardless of the special lead-free logo (which is not always mixing of two alloys).
indicated), one must treat all sets from this date onwards Caution: For BGA-ICs, you must use the correct temperature
according to the rules as described below. profile, which is coupled to the 12NC. For an overview of these
profiles, visit the website www.atyourservice.ce.philips.com
(needs subscription, but is not available for all regions).
P You will find this and more technical information within the
"Magazine", chapter "Workshop information".
b For additional questions please contact your local repair help
desk.
Due to lead-free technology some rules have to be respected It makes sense to avoid exposure to electrical shock.
by the workshop during a repair: While some sources are expected to have a possible
Use only lead-free soldering tin Philips SAC305 with order dangerous impact, others of quite high potential are of
code 0622 149 00106. If lead-free solder paste is required, limited current and are sometimes held in less regard.
please contact the manufacturer of your soldering Always respect voltages. While some may not be
equipment. In general, use of solder paste within dangerous in themselves, they can cause unexpected
workshops should be avoided because paste is not easy to reactions that are best avoided. Before reaching into a
store and to handle. powered TV set, it is best to test the high voltage insulation.
It is easy to do, and is a good service precaution.
4. Mechanical Instructions
Index of this chapter: Notes:
4.1 Cable Dressing Figures below can deviate slightly from the actual situation,
4.2 Service Position due to the different set executions.
4.3 Assy/PWB Removal Follow the disassemble instructions in described order.
4.4 Plasma Panel / Glass Plate (Dis)Assembly Be aware that the internal (gold coloured) frame is made of
4.5 Set Re-assembly conducting material. So, be cautious during electrical
measurements!
4.1.1 Chassis
E_14650_002.eps
150604
4.2 Service Position face down on the (ESD protective) foam bars, a stable situation
is created to perform measurements and alignments.
By placing a mirror under the TV, you can monitor the screen.
For easy servicing of this set, there are a few possibilities
created:
The buffers from the packaging (see figure "Rear cover"). 4.2.2 Aluminium Stands
Foam bars (created for service).
Aluminium service stands (created for service).
E_06532_019.eps
170504
4.3.1 Metal Back Plate 1. Disconnect all cables from the Ambient Light Inverter
panel.
2. Remove all mounting screws from the Ambient Light
Caution: Disconnect the mains power cord before you remove
Inverter panel.
the metal back plate.
3. Take out the Ambient Light Inverter panel.
E_14650_003.eps
150604
1. Disconnect all cables from the Audio panel.
2. Remove all mounting screws from the Audio panel.
3. Take out the Audio panel.
Figure 4-4 Metal back plate
4.3.7 Side I/O Panel
1. Place the TV set upside down on a table top, using the
foam bars (see part "Foam Bars").
Caution: do not put pressure on the display, but let the 1. Disconnect the cable from the Side I/O panel.
2. Release the clamps and take out the Side I/O panel from
monitor lean on the speakers or the Front cover.
2. Remove all T10 parker screws (1) from the top, centre, and its bracket.
left and right sides of the back plate.
3. Remove all T10 tapping screws (2) from the bottom of the 4.3.8 Top / Side Control
back plate.
4. Remove the four "mushrooms" (3) from the back plate. 1. Remove the mounting screws from the Top / Side Control
5. Lift the back plate from the set. Make sure that wires and panel bracket.
flat foils are not damaged during the back plate removal. 2. Disconnect the cable.
3. Release the clamps and take out the Top / Side Control
4.3.2 Rear Cover panel.
E_14650_004.eps
150604
1
2
2b
2a 1
3
E_14650_006.eps
160604
4
E_14650_008.eps
150604
6
4.4 Plasma Panel / Glass Plate (Dis)Assembly
4 4 4 4 4
4 4 4
1
4
4
E_14620_032.eps
130504
4 4
4
Figure 4-8 SSB (photo from FTL2.x) 4
3
1. Remove the LVDS fixing tape (1).
4
2. Remove all fixing screws (2). 4
3. Disconnect the grounding wire from the mains filter (2a).
4. Shift, and lift the shielding at the top. The panel hinges at 4
the SCART side. 4 2 4
Caution: do not damage the EMC shielding foam while E_14650_009.eps
you remove the shielding. 170604
5. Remove mounting screws (3) from the connector plate.
Use a 5 mm socket screwdriver to remove both DVI Figure 4-10 Plasma panel removal (photo from 42 FHP)
connector distance bolts (4).
6. Remove the mounting screws from the SSB (5).
7. Disconnect the LVDS cable (6).
8. Lift the SSB, disconnect all cables, and take out the SSB.
EN 10 4. FTP2.2E AA Mechanical Instructions
Disassembly
1. Place the TV set face down on the foam bars. Place the SHIELDING
bars at the edges of the set so they will support the front STRIP
frame, and not only the glass plate!
2. Remove the four T25 screws (1) that hold the plasma
panel.
Note: In some models, the upper left T25 screw is hidden
under the Ambient Light Inverter panel. Remove this panel
to get access to it.
3. Remove the fifth T25 screw that is located near the SSB.
Note: In some models, this fifth screw is hidden under the
SSB. To get access, you have to remove the four T10
screws (2) that mount the "SSB connector plate" to the
frame. Then, lift the complete SSB unit away, so you can
remove the hidden screw (4).
4. Remove all T10 tapping screws around the frame (4). E_14650_005.eps
150604
5. Next step is to unplug the following connectors (see also
Wiring Diagram in chapter 6):
Mains plug on PSU. Figure 4-12 Metal shielding strip at the Ambilight Inverter
Audio panel supply plug on PSU.
LVDS plug on SSB.
Ambilight supply plug on PSU.
SSB supply plugs on PSU.
Side/Top Control plug on LED panel.
Side I/O plug on LED panel.
SSB grounding wire.
6. Lift the plastic frame together with all PWBs from the PDP
panel.
7. Now the PDP (incl. the PSU panel) can be removed. Lift the
panel at the two metal bars from the glass plate.
8. Before sending the plasma panel to the NSO for repair or
exchange, remove the PSU panel and the spacer (5) that
is placed upon the centre mounting stud.
Assembly
In order to centre the (new) plasma panel correctly w.r.t. the
glass plate, do the following:
1. Place the (new) plasma panel face down on foam bars.
2. Also, place the front assy (front panel with glass plate) on E_14650_007.eps
two other foam bars. 150604
How to navigate
5.2.1 Service Default Mode (SDM) When you press the MENU button on the RC transmitter, the
set will toggle between the SDM and the normal user menu
(with the SDM mode still active in the background).
Purpose
To create a pre-defined setting, to get the same
measurement results as given in this manual. How to exit SDM
To override SW protections. Use one of the following methods:
To start the blinking LED procedure. Switch the set to STANDBY via the RC-transmitter.
Press the EXIT button on the DST.
Via a standard customer RC-transmitter: key in 00-
Specifications
sequence.
Tuning frequency: 475.25 MHz for PAL/SECAM.
Colour system: SECAM L for France or PAL B/G for the
rest of Europe. 5.2.2 Service Alignment Mode (SAM)
All picture settings at 50% (brightness, colour, contrast).
All sound settings at 50%, except volume at 25%. Purpose
All service-unfriendly modes (if present) are disabled, like: To perform (software) alignments.
(Sleep) timer. To change option settings.
Child/parental lock. To easily identify the used software version.
Blue mute. To view operation hours.
Automatic volume limiter (AVL). To display (or clear) the error code buffer.
Auto switch-off (when no video signal was received for
10 minutes). Specifications
Skip/blank of non-favourite pre-sets. Operation hours counter.
Smart modes. Software version.
Auto store of personal presets. Option settings.
Auto user menu time-out. Error buffer reading and erasing.
Software alignments.
How to activate SDM
Use one of the following methods: How to activate SAM
Use the standard RC-transmitter and key in the code Use one of the following methods:
062596, directly followed by the MENU button. Via a standard RC transmitter: key in the code 062596
directly followed by the OSD [i+] button. After activating
EN 12 5. FTP2.2E AA Service Modes, Error Codes, and Fault Finding
SAM with this method a service warning will appear on the SAM menu. This feature can be helpful to quickly change
screen, you can continue by pressing any digit key on the some settings in the user menu.
RC. SW MAINTENANCE.
Short for a moment the two solder pads on the SSB with UPGRADE. More info see paragraph Software
the indication "SAM". Depending on the software version, downloading.
it is possible that a service warning will appear. You can EVENTS. Not useful for service purposes. In case of
continue by pressing any digit key on the RC. specific software problems, the development
Use the DST-emulation feature of ComPair. department can ask for this info.
Press the ALIGN button on the DST while the set is in the BDM INFO. Broadcast Debug Menu info. The purpose
normal operation of this menu is to debug the broadcast, not the TV. The
menu gives an overview of what is received on the
After activating this mode, SAM will appear in the upper right current preset.
corner of the screen.
Contents of SAM:
OPERATION HOURS. Displays the accumulated total of Following items are displayed:
operation hours (not the stand-by hours).
HARDWARE INFO.
Presetnr: -- UTC: --:--:--
ROM VERSION. Displays the date of the software and Presetname: ----- LTO: --:--:--
the software version of the ROM Time: --:--:--
Example: TX21EU_1.0_01234 = CNI NVM: ---- Date: --/--/----
CNI F1: ----
AAAABB_X.Y_NNNNN. CNI F2: ---- Time TXT: --:--:--
AAAA= the chassis name. CNI VPS: ---- Time 8/30 F1: --:--:--
Morning Prog: --- Date 8/30 F1: --/--/----
BB= the region: EU= Europe, AP= Asia Pacific Name 8/30 F1: ----- LTO 8/30 F1: --:--:--
PAL/Multi, AN= Asia Pacific NTSC, US= USA, LT= Name 8/30 F2: -----
Name TXT: ----- WSS G1: ----
LATAM. Signal Strength:--- WSS G2: ----
X.Y= the software version, where X is the main WSS G3: ---
EPG Service: --- WSS G4: ---
version number (different numbers are not
E_14620_050.eps
compatible with one another) and Y is the sub 170504
menu. Name 8/30 F2 Broadcaster Name extracted from status message of 8/30
Format 2.
DEALER OPTIONS. Extra features for the dealers.
Name TXT Broadcaster Name extracted from TXT header.
SERVICE OPTIONS. Extra features for Service.
Signal Strength FBX Noise figure measured for selected preset.
INITIALISE NVM. When an NVM was corrupted (or
EPG Service Set EPG Service stored in NVM for current preset
replaced) in the former EM3 chassis, the microprocessor displayed as "TXT", "MCP", "SCP", "OCP".
replaces the content with default data (to assure that the UTC Set UTC (Universal Time Code formerly known as
set can operate). However, all pre-sets and alignment Greenwich Mean Time) used in the set.
values are gone now, and option numbers are not correct. LTO Set LTO (Local Time Offset) used in the set. Used by
Therefore, this was a very drastic way. In this chassis, the EPG for all NextView displays. (= Time TXT
procedure is implemented in another way: The moment the header - Time 8/30 F1)
processor recognises a corrupted NVM, the initialise Time Set Current time running in the set. Was extracted at
start-up, then maintained by software.
NVM line will be highlighted. Now, you can do two things
Date Set Current date running in the set. Was extracted at
(dependent of the service instructions at that moment): start-up, then maintained by software.
Save the content of the NVM via ComPair for Time TXT Broadcaster TXT header time from the selected preset.
development analysis, before initialising. This will give Time 8/30 F1 Broadcaster UTC time from 8/30 Format 1.
the Philips Service department an extra possibility for Date 8/30 F1 Broadcaster Date from 8/30 Format 1.
diagnosis (e.g. when Development asks for this). LTO 8/30 F1 Broadcaster LTO from 8/30 Format 1.
Initialise the NVM (same as in the past, however now it WSS G1 Broadcaster WSS Group 1 (Aspect Ratio) bits 0 1 2 3
happens conscious). WSS G2 Broadcaster WSS Group 2 (Enhanced Services) bits 4 5 6 7
STORE. All options and alignments are stored when WSS G3 Broadcaster WSS Group 3 (Subtitles) bits 8 9 10
pressing the OK-button WSS G4 Broadcaster WSS Group 4 (Reserved) bits 11 12 13
FUNCTIONAL TEST. All devices are tested via the OK
button. Eventual errors are displayed in the error buffer.
The error buffer is not erased, the content returns when this How to navigate
test is terminated. In SAM, you can select the menu items with the CURSOR
DAILY MENUS. With the OK button, you can go to the UP/DOWN key on the RC-transmitter. The selected item
normal user menu. SAM is still active in the background. will be highlighted. When not all menu items fit on the
With the MENU button, you return from the user menu to
Service Modes, Error Codes, and Fault Finding FTP2.2E AA 5. EN 13
screen, move the CURSOR UP/DOWN key to display the values can be changed via the CURSOR LEFT and
next/previous menu items. CURSOR RIGHT keys on the RC-transmitter after
With the CURSOR LEFT/RIGHT keys, it is possible to: pressing the MENU button and selecting PICTURE and
(De) activate the selected menu item. BRIGHTNESS.
Change the value of the selected menu item. CONTRAST. Gives the last status of the contrast as set by
Activate the selected sub-menu. the customer. The value can vary from 0 (contrast is
minimum) to 100 (contrast is maximum). Contrast values
How to exit SAM can be changed via CURSOR LEFT and CURSOR
Use one of the following methods: RIGHT keys on the RC-transmitter after pressing the
Press the MENU button on the RC-transmitter, or MENU button and selecting PICTURE and
Switch the set to STANDBY via the RC-transmitter, or CONTRAST.
Press the EXIT button on the DST. COLOUR. Gives the last status of the colour saturation, as
set by the customer. The value can vary from 0 (colour is
minimum) to 100 (colour is maximum). Colour values can
5.2.3 Customer Service Mode (CSM)
be changed via CURSOR LEFT and CURSOR RIGHT
keys on the RC-transmitter after pressing the MENU
Purpose
button and selecting PICTURE and COLOUR.
When a customer is having problems with his TV-set, he can
HUE. Only relevant for NTSC-signals (e.g. some NTSC-
call his dealer. The service technician can than ask the DVD-discs).
customer to activate the CSM, in order to identify the status of
the set. Now, the service technician can judge the severity of
CUSTOMER SERVICE MENU 2
the complaint. In many cases, he can advise the customer how
to solve the problem, or he can decide if it is necessary to visit SHARPNESS. Gives the sharpness value. The value can
vary from 0 (sharpness is minimum) to 7 (sharpness is
the customer.
maximum). In case of bad antenna signals, a too high
The CSM is a read only mode; therefore, modifications in this
mode are not possible. value of the sharpness can result in a noisy picture.
Sharpness values can be changed via the CURSOR
LEFT and CURSOR RIGHT keys on the RC-transmitter
How to activate CSM
after pressing the MENU button and selecting PICTURE
Use one of the following methods: and SHARPNESS.
Press the MUTE button on the RC-transmitter
HEADPHONE VOLUME. Gives the last status of the head
simultaneously with the MENU button on the TV (top
phone volume, as set by the customer. The value can vary
control) for at least 4 seconds. from 0 (volume is minimum) to 100 (volume is maximum).
Key in the code 123654 via the standard RC transmitter.
Head phone volume values can be changed via the
CURSOR LEFT and CURSOR RIGHT keys on the RC-
Note: Activation of the CSM is only possible if there is no (user) transmitter after pressing the MENU button and selecting
menu on the screen! SOUND and HEADPHONE VOLUME.
DOLBY. Indicates whether the received transmitter
How to navigate transmits Dolby sound (ON) or not (OFF). Attention: The
By means of the CURSOR-DOWN/UP knob on the RC- presence of Dolby can only be tested by the software on
transmitter, you can navigate through the menus. the Dolby Signalling bit. If a Dolby transmission is received
without a Dolby Signalling bit, this indicator will show OFF
Contents of CSM even though a Dolby transmission is received.
SURROUND MODE. Indicates the by the customer
CUSTOMER SERVICE MENU 1 selected surround mode (or automatically chosen mode).
SOFTWARE VERSION (example: TX21EU_1.0_01234). Possible values are OFF, INCREDIBLE SURROUND
Displays the built-in software version. In case of field OR DOLBY VIRTUAL. These settings can be influenced
problems related to software, software can be upgraded after pressing the MENU button and selecting SOUND
(for more details, see paragraph Software downloading). and SURROUND MODE. It can also have been selected
You will find details of the software versions in the chapter automatically by signalling bits (internal software).
Software Survey of the Product Survey - Colour TUNER FREQUENCY. Indicates the frequency the
Television publication. This publication is generated four selected transmitter is tuned to. The tuner frequency can
times a year. be changed via the CURSOR LEFT and CURSOR
FEATURE BOX. The 12NC-number of the built-in Feature RIGHT keys for fine tune after opening the installation
Box software. menu and selecting INSTALL and MANUAL INSTALL.
SET TYPE. This information is very helpful for a help desk/ DIGITAL OPTION. Gives the selected digital mode,
workshop as reference for further diagnosis. In this way, it PROGRESSIVE SCAN, MOVIE PLUS or PIXEL
is not necessary for the customer to look at the rear of the PLUS. Change via MENU, PICTURE, DIGITAL
TV-set. OPTIONS.
CODE 1. Gives the latest five errors of the error buffer. As CENTRE TRIM. Not applicable for this set.
soon as the built-in diagnose software has detected an TV SYSTEM. Gives information about the video system of
error the buffer is adapted. The last occurred error is the selected transmitter.
displayed on the left most position. Each error code is BG: PAL BG signal received.
displayed as a 3-digit number. When less than 10 errors DK: PAL DK signal received.
occur, the rest of the buffer is empty (000). See also I: PAL I signal received.
paragraph Error Codes for a description. L/La: SECAM L/La signals received.
CODE 2. Gives the first five errors of the error buffer. See M: NTSC M signal received with video carrier on 38.9
also paragraph Error Codes for a description. MHz.
VOLUME. Gives the last status of the volume as set by the
customer. The value can vary from 0 (volume is minimum) CUSTOMER SERVICE MENU 3
to 100 (volume is maximum). Volume values can be BALANCE. Indicates the balance settings, between -50
changed via the volume key on the RC-transmitter. and +50. Change via MENU, SOUND, and
BRIGHTNESS. Gives the last status of the brightness as BALANCE. Not applicable for Dolby Pro Logic sets.
set by the customer. The value can vary from 0 (brightness CENTRE MODE. Indicates if centre mode is set ON or
is minimum) to 100 (brightness is maximum). Brightness OFF. When centre mode is on, all TV speakers are used
EN 14 5. FTP2.2E AA Service Modes, Error Codes, and Fault Finding
as one centre speaker. Change Centre mode via MENU, OPTIONS 1. Gives the option codes of option group 1 as
SETUP, SPEAKERS, and CENTRE MODE. set in SAM (Service Alignment Mode).
DNR. Gives the selected DNR setting (Dynamic Noise OPTIONS 2. Gives the option codes of option group 2 as
Reduction), OFF, MINIMUM, MEDIUM, or set in SAM (Service Alignment Mode).
MAXIMUM. Change via MENU, PICTURE, DNR AVL. Indicates the last status of AVL (Automatic Volume
NOISE FIGURE. Gives the noise ratio for the selected Level): ON or OFF. Change via MENU, TV,
transmitter. This value can vary from 0 (good signal) to 127 SOUND, AVL
(average signal) and to 255 (bad signal). For some DELTA VOLUME. Indicates the last status of the delta
software versions, the noise figure will only be valid when volume for the selected preset as set by the customer: from
Active Control is set to medium or maximum. -12 to +12. Change via MENU, TV, SOUND,
SOURCE. Indicates which source is used and the video/ DELTA VOLUME.
audio signal quality of the selected source. FRONT SPKR DIST. Not applicable for this set.
Example: Tuner, Video/NICAM) Source: TUNER, FRONT SPKR DIST. Not applicable for this set.
EXT1, EXT2, EXT3, EXT4, SIDE, AV1, AV2,
AV3 or AV4. Video signal quality: VIDEO, S-VIDEO, How to exit CSM
RGB 1FH, YPBPR 1FH 480P, YPBPR 1FH 576P, Use one of the following methods:
YPBPR 1FH 1080I, YPBPR 2FH 480P, YPBPR 2FH After you press a key on the RC-transmitter (with exception
576P, YPBPR 2FH 1080I, RGB 2FH 480P, RGB 2FH of the CHANNEL, VOLUME and digit (0-9) keys), or
576P or RGB 2FH 1080I. Audio signal quality: After you switch the TV-set OFF with the mains switch.
STEREO, SPDIF 1, SPDIF 2, or SPDIF.
AUDIO SYSTEM. Gives information about the audio
system of the selected transmitter: ANALOGUE MONO, 5.3 Problems and Solving Tips (related to CSM)
ANALOGUE STEREO, PCM 2/0, DD 1/0, DD 2/0
LtRt, DD 2/0 L0R0, DD 2/1, DD 2/2, DD 3/0, DD 3/ Note: Below described problems are all related to the TV
1, DD 3/2, DD 1+1, MPEG 1/0, MPEG 2/0, MPEG settings (visible in the CSM menu). The procedures to change
2/0 LtRt, MPEG 2/1, MPEG 2/2, MPEG 3/0, MPEG the value (or status) of the different settings are described
3/1, MPEG 3/2, MPEG 1+1 or MPEG 2+2. above. New value(s) are automatically stored.
TUNED BIT. Gives information about the tuning method of
the stored pre-set. If a channel is found via automatic 5.3.1 Picture Problems
installation, you will see the value YES. When you
change this (automatically found) frequency via fine tune
Snowy/noisy picture
adjustment (installation menu - manual installation), the
1. Check in CSM line NOISE FIGURE. In case the value is
displayed value will change to NO. Therefore, when you
"127" or higher, and the value is also high on other
see the value NO in this line, it is an indication that the
programs, check the aerial cable/aerial system. For some
received channel is a non-standard signal (e.g. of a VCR).
software versions, the noise figure will only be valid when
SURROUND SPEAKERS. Not applicable in this set.
Active Control is set to medium or maximum.
ON TIMER. Indicates if the On Timer is set ON or OFF
2. Check in CSM lines SHARPNESS and NOISE FIGURE. In
and if the timer is ON also displays start time, start day
case the value of line SHARPNESS is "3" or "4" and the
and program number. Change via MENU, TV,
value of line NOISE FIGURE is high ("127" or higher),
FEATURES, and ON TIMER.
decrease the "Sharpness value.
PRESET LOCK. Indicates if the selected preset has a child
lock: LOCKED or UNLOCKED. Change via MENU,
TV, FEATURES, CHILD LOCK, and CUSTOM Picture too dark
LOCK. 1. Press Menu, TV, Picture, Smart Picture. In case the
picture improves, increase the Brightness or the
Contrast value. The new value(s) are automatically
CUSTOMER SERVICE MENU 4
stored (in personal pre-set) for all TV channels.
CHILD LOCK. Indicates the last status of the general child
2. Check in CSM line BRIGHTNESS and CONTRAST. If the
lock: UNLOCK, LOCK, or CUSTOM LOCK. Change
value of these lines is low (< "10"), increase the
via MENU, TV, FEATURES, CHILD LOCK, and
Brightness or the Contrast value via the user menu.
LOCK.
AGE LOCK. Indicates the last status of the EPG rating for
child lock: OFF, 4 YEARS, 6 YEARS, 8 YEARS, 10 Picture too bright
YEARS, 12 YEARS, 14 YEARS or 16 YEARS. This is 1. Press Menu, TV, Picture, Smart Picture. In case the
only displayed if child lock is set to CUSTOM LOCK picture improves, decrease the Brightness or the
LOCK AFTER. Indicates at what time the child lock is set: Contrast value. The new value(s) are automatically
OFF or e.g. 18:45 (lock time). This is only displayed if stored (in personal pre-set) for all TV channels.
child lock is set to CUSTOM LOCK 2. Check in CSM lines BRIGHTNESS and CONTRAST. If the
CATEGORY LOCK. Indicates the last status of the EPG value of these line is high (> 50), decrease the Brightness
theme child lock: MOVIES, NEWS, SHOWS, value or increase the Contrast value via the user menu.
SPORTS, CHILDREN, MUSIC, CULTURE, or
SERIES. This is only displayed if child lock is set to White line around picture elements and text
CUSTOM LOCK. It is possible that more than one value 1. Press Menu, TV, Picture, Smart Picture. In case the
is shown. picture improves, decrease the Sharpness value. The
PROGRAM CATEGORY. Indicates the theme of the new value is automatically stored (in personal pre-set) for
selected transmitter: MOVIES, NEWS, SHOWS, all TV channels.
SPORTS, CHILDREN, MUSIC, CULTURE, or 2. Check in CSM line Sharpness. If the value is high,
SERIES. decrease it. The new value is automatically stored for all
TV RATINGS LOCK. Only applicable for US. TV channels.
MOVIE RATINGS LOCK. Only applicable for US.
V-CHIP TV STATUS. Only applicable for US. No picture
Check in CSM line TUNED BIT. In case the value is No, install
CUSTOMER SERVICE MENU 5 the required program again. Open the installation menu and
V-CHIP MOVIE STATUS. Only applicable for US. perform manual installation.
Service Modes, Error Codes, and Fault Finding FTP2.2E AA 5. EN 15
5.4.2 Specifications
activate protection algorithms for +8V and +5V and Figure 5-5 Stepwise start-up part 2: Initialise SDI
IC (start IC protection the moment the component
is initialised).
Trapped Startup 2
Read rest of NVM information
Note (*):
When the set is in stepwise mode and, due to stepping-up,
Initialize HIP: IF, source selection, 2fh input, video
processing
a protection is activated, the set will really go into protection
Switch on the syncoutput: set_syncout_tristate= off
400msec>t>200msec (blinking LED). The set will not leave the stepwise mode
Initialize tuner
however. If state X is the state where the set went to
Initialize 3D Combfilter protection, stepwise start-up will return to state X-1. At
or Initialize Columbus
state (X-1) diagnostic measurements can be performed.
Initialize PICNIC + screen info Also, in the short time the set is in state X but not yet in
Initialize rest of PIP/DW module
protection, you can also do some measurements.
Start TXT acquisition
and time extraction
5.4.4 How To Connect
Reset Audio = low
and Initialize MSP
PDP ON
no 5.4.5 How To Order
PDP: PDP ON =1
ComPair order codes (EU/AP/LATAM):
Wait 200 msec
Starter kit ComPair32/SearchMan32 software and
ComPair interface (excl. transformer): 3122 785 90450.
Power OK (POR OTC)?
no
no ComPair interface (excl. transformer): 4822 727 21631.
Time out 5 sec?
Starter kit ComPair32 software (registration version): 3122
yes
785 60040.
Starter kit SearchMan32 software: 3122 785 60050.
Wait 200 msec
ComPair32 CD (update): 3122 785 60070 (year 2002),
3122 785 60110 (year 2003 onwards).
no
Read CNDC SearchMan32 CD (update): 3122 785 60080 (year 2002),
yes
3122 785 60120 (year 2003), 3122 785 60130 (year 2004).
CNDC = 4 ? no
ComPair firmware upgrade IC: 3122 785 90510.
Transformer (non-UK): 4822 727 21632.
yes Time out 5 sec?
Ebild/ Power ON
Transformer UK: 4822 727 21633.
Trapped Startup 3
Output blanking: OFF
yes
ComPair interface cable: 3122 785 90004.
ComPair interface extension cable: 3139 131 03791.
Semi stand by Trapped Startup 4
Goto protection
PDP: ADEN = 1
ComPair UART interface cable: 3122 785 90630
The error code buffer contains all detected errors since the last Use one of the following methods:
time the buffer was erased. The buffer is written from left to By activation of the RESET ERROR BUFFER command
right, new errors are logged at the left side, and all other errors in the SAM menu.
shift one position to the right. With a normal RC, key in sequence MUTE followed by
When an error has occurred, the error is added to the list of 062599 and OK.
errors, provided the list is not full or the error is a protection When you transmit the commands DIAGNOSE - 99 -
error. OK with ComPair (or with a DST).
When an error occurs and the error buffer is full, then the new If the content of the error buffer has not changed for 50+
error is not added, and the error buffer stays intact (history is hours, it resets automatically.
maintained), except when the error is a protection error.
To prevent that an occasional error stays in the list forever, the 5.5.4 Error Codes
error is removed from the list after 50+ operation hours.
When multiple errors occur (errors occurred within a short time In case of non-intermittent faults, clear the error buffer before
span), there is a high probability that there is some relation you begin the repair. This to ensure that old error codes are no
between them. longer present. Before clearing the buffer, write down the
content, as this history can give you significant information.
5.5.2 How to read the Error Buffer If possible, check the entire contents of the error buffer. In
some situations, an error code is only the result of another error
Use one of the following methods: code and not the actual cause (e.g., a fault in the protection
On screen via the SAM (only if you have a picture). detection circuitry can also lead to a protection).
Examples: There are various errors:
0 0 0 0 0: No errors detected I2C device errors.
6 0 0 0 0: Error code 6 is the last and only detected I2C bus errors.
error Protection errors.
9 6 0 0 0: Error code 6 was first detected and error code Errors not related to an I2C device, but of importance:
9 is the last detected error FEM (Falconic with Embedded Memory) (Error 26):
Via the blinking LED procedure (when you have no at start-up, after initialisation of the PICNIC, the
picture). See next paragraph. presence of the FEM can be checked.
Note:
Error codes 1, 6, or 18 are protection codes and in this
case, supplies of some circuits will be switched OFF.
Also, in protection, the LED will blink the number of times
equivalent to the most recent error code.
EN 18 5. FTP2.2E AA Service Modes, Error Codes, and Fault Finding
5.6 The Blinking LED Procedure To get a quick diagnosis, this chassis has three service-modes
implemented:
5.6.1 Introduction The Customer Service Mode (CSM).
The Service Default Mode (SDM). Start-up of the set in a
predefined way.
Via this procedure, you can make the contents of the error
The Service Alignment Mode (SAM). In this mode, items
buffer visible via the front LED. This is especially useful for fault of the set can be adjusted via a menu.
finding, when there is no picture.
You can activate both SDM and SAM modes via the service
When the SDM is activated, the front LED will show (blink) the pads on the SSB, via an RC-transmitter (DST or standard RC),
contents of the error-buffer. Error-codes > 10 are shown as
or via ComPair. It is not possible to activate the SAM in stand-
follows:
by; the TV has to be in normal operation mode.
A long blink of 750 ms (which is an indication of the decimal
digit),
The Protection Diagram shows the structure of the protection
A pause of 1.5 s,
system. See diagram below.
n short blinks (where n = 1 - 9),
When all the error-codes are displayed, the sequence
finishes with a LED blink of 3 s, DC_PROT (from audio) IRQ-DIGITAL (98)
The sequence starts again.
+8V_CON +8V SENSE (105)
Example: Error 12 9 6 0 0.
+5V_CON +5V SENSE (106)
After activation of the SDM, the front LED will show:
1 long blink of 750 ms (which is an indication of the decimal
digit) followed by a pause of 1.5 s, OTC
5.7.1 Introduction FBX protection: the FBX protection is not available any more.
It is replaced by the DC/DC protection.
This chassis has only one microprocessor (OTC), which
remains active during Stand-by. This because power of the 5.7.3 OTC Related Protections
microprocessor and the attached memory chip set is coming
from the 3V3 supply, which is derived from the 5V Stand-by- If a protection is detected at an OTC input, the OTC will start to
circuitry. Therefore, in both Power-on as in Stand-by mode, the scan all protection inputs every 200 ms for 5 times. If the
microprocessor is connected to this power supply. protection on one of the inputs is still active after 1 s, the
microprocessor will put the set in the protection mode. Before
If a fault situation is detected, an error code will be generated the scanning is started, a so-called ESD refresh is carried out.
and if necessary, the set is put in protection mode. The This is done, because the interrupt on one of the inputs is
protection mode is indicated by the blinking of the front LED at possibly caused either by a flash or by ESD. As a flash or ESD
a frequency of 3 Hz (or by a coded blinking in special cases). can influence IC settings, the HIP, MSP, 3D Comb and wireless
module (not used in this set) are initialised again, to ensure the
The content of the error buffer can be read via the service menu normal picture and sound conditions of the set.
(SAM), the blinking LED procedure or via DST/ComPair.
Service Modes, Error Codes, and Fault Finding FTP2.2E AA 5. EN 19
8 V and 5 V protections: The microprocessor senses the 5.8.2 Power Supply Unit (for Samsung 42 plasma displays)
presence of the 8 V and 5 V (via the +5V_CON and
+8V_CON lines). If one (or both) of these voltages is (are) not Below, a troubleshoot method for the SDI 42 power supply is
present, an error code is stored in the error buffer of the NVM, given. First, a description is given for single board testing (so
and the set is put in the protection mode. without the surrounding electronics).
Audio DC protection: The OTC senses if the audio module is This PSU is for service a black box. When defective (this can
in protection via IRQ-DIGITAL (pin 98 of OTC). If this is the be traced via error-codes in the error buffer, or by strange
case, the OTC puts the set in protection. phenomena), a new panel must be ordered and after receipt,
the defective panel must be send for repair.
5.7.4 Hardware Protection
Main Power Supply (single board testing)
Short-circuiting the 3V3 supply from the DC/DC converter will
shut down the DC/DC converter. The absence of the 3V3
supply line is also sensed via I2C (see description DC/DC
protection above), this is useful if there is something wrong in
the detection circuit of the DC/DC converter. There are no
hardware protections in this chassis, which switch off the main 1
supply.
2
LLC Supply
1. 25V_HOT (from Stand-by supply) present?
2. 25V_HOT_SW (from Preconditioner) present? 3
3. 17V on pin 15 of item 7001 present?
4. Vcego= H and LATCH= H?
5. Vrs present? (Vrs=Vs/67).
6. Remark: Vs_unswitched = 65V when switch 7050 is open.
Va Supply
1. Vs_unswitched present?
2. 30V on item 3133 present?
3. Vsa_control= L (Vsago= H and Vs_lowlim= H)
4. Vra present? (Vra=Va/48).
E_14650_012.eps
Vcc Supply 150604
1. Vs_switched present?
2. Vccgo= H? (Vcego= H). Figure 5-9 Diagnose of SDI 42 main supply [2]
Vs (switched) 1. Place jumper BJ8002 (3). This simulates the Vs_on signal
1. 95V present on cathode of item 6054? (no LVDS, prevents protection).
2. POK= H and Vsa_control= L? (POK= H when Vs, Va, 2. Connect pin 11 with pin 13 on connector CN8004:
Vcc, 12V, and 8V6 are above their lower limit) This simulates the STANDBY signal.
LEDs L8001 and L8002 should light up.
All voltages should be present.
EN 20 5. FTP2.2E AA Service Modes, Error Codes, and Fault Finding
Sub Power Supply (single board testing) 4. Another possibility is to force the converter to start up by
There are two methods: short-circuiting (and keep short-circuited) resistor 3U25
1. First check the Main Supply. If it is ok, connect the two (B12).
supplies, and check the Sub Supply (attention: remove Caution: Be aware that this can damage the set. Even if
jumper BJ8302 first). All Sub Supply voltages should be you measure approximately 120 ohm over diode 6U06,
present now. there can still be something wrong in the converter itself.
2. Remove the Sub Supply from the TV: By short-circuiting resistor 3U25, the internal protection of
Connect 380 VDC between pin 1 and 3 of connector the converter is disabled.
CN9700 (+380 V on pin 1).
Connect 17 VDC between pin 4 and 5 of connector 5.8.4 ComPair
CN9700 (+17 V on pin 5).
All Sub Supply voltages should be present now. A Service (ComPair) connector is implemented at the rear
side of the set, which is directly accessible. In addition to this,
Power Supply (in set testing) there is also a blinking LED procedure to show the contents of
Both PSUs can also be tested in the set: the error buffer.
1. First, disconnect all boards that are not feeding the plasma
panel (SSB, Audio Amplifier, Ambi Light Inverter). Do not When you use ComPair, you have the possibility to activate a
unplug the Sub Supply from the Main Supply. stepwise start-up mode. With this mode, you can initiate the
2. Plug the PSU to the mains: the +9V_STDBY should be start-up sequence step by step. This also means that in certain
present. steps, some protections are not activated. This is sometimes
3. Connect pin 9 and 10 on connector CN9005 on the Sub very convenient during repair.
Supply:
This simulates the ON/OFF switch.
5.8.5 Protections
LED L8003 must light up and the PSU is in STANDBY
mode.
+5V2 should be present Activating SDM via the service pads will overrule the
processor-controlled protections, but not the hardware
4. Connect pin 4 with pin 7 on connector CN9005:
protections. This means, that the A/D-input protections (5 and
This simulates the STANDBY signal.
LEDs L8001 and L8002 should light up. 8 V) and the I2C not-acknowledging info of FBX + EPLD + 3D
Comb and of the tuner are overruled.
All voltages should be present.
Caution: When doing this, the service technician must know
Important: After testing, replace all items in their original what he is doing, as it could lead to damaging the set.
status!
Personal Notes:
E_06532_012.eps
131004
Block Diagrams, Testpoint Overview, and Waveforms FTP2.2E AA 6. EN 23
WIRING 42 FHP
8313 8311
8310 8302
A 1M10
C 1M02
7P
1002
4P
PDP AUDIO 3P
PDP SUPPLY 42 7P 9P
1739
3P
1736
1735
7P
0352
10P
0323
TO
Ambient light lamps right
0342
10P
2P 20P 9P 6P 1M03
11P
AL 0308 0307 0311 0306 1M46 7P
1M14
1M12
1M10
TO 8346
DISPLAY
Ambient 8352
8349
1M11
1M13
Light
1M48
8350
8303
1M52 1M48 1G50 1M49 1M17 1M46
1M03
9P N.C. 31P 3P 7P 11P
10P
8736
Connectors of Ambi-light inverter
Philips Applied Functions
Concepts
8199
1M20
12P
8735
1. GND (light)
1008 1M14
2. GND (light)
1009 1M12
3. GND (light)
1. Green light
1006 1M13
6. Blue light LVDS CONNECTOR
SSB
1M01
1007 1M11
11. Red light
1. +12V_A
2nd Tuner N.C.
DISPLAY
1001 1M08 2. +12V_A
1002 1M10 3. GND
4. GND 1T02 (Without 3th SCART)
8336
1M36
1. SCL-S
11P
Top ControL
DELTA Tuner
1M07
MODULE splitter 5P 8307 1M07 1M37 1M36
5P 11P 11P
1T01
8220
8345
1M36
0345
11P
LS LS
0350 1M20 0345 1M01 0244
LEFT
E
8313 8311
C 7P 1M02
1M14 1M13
1M12 1M11 PDP AUDIO 3P
9P 3P
1735
Ambient 8352 1739 1736
AL Light 8302
(OPTIONAL)
(OPTIONAL)
1M10 1M48
(OPTIONAL)
CN9007
Connectors of Ambi-light inverter
8310 4P
Philips Applied Functions
Concepts
Ambient light lamps right
CN9004
1008 1M14
2. GND (light)
1009 1M12
3. GND (light)
1. Green light
11P
PSU PDP
1006 1M13
SUB
8349
6. Blue light
1007 1M11
11. Red light
CN9006
1. +12V_A
1001
1002
1M08
1M10
2. +12V_A
3. GND
7P
PSU
4. GND
1. SCL-S
1003 1M48 2. GND
3. SDA-S 2P3
5P 10P
CN9005
8736
8346
8303
B
8735
1M52 1M48 1G50 1M49 1M17 1M46
1M03
9P N.C. 31P 3P 7P 11P 10P
1M20
12P
1M36
LVDS CONNECTOR 11P
8336
Top Control
DISPLAY 8337
(With 3th SCART) (With 3th SCART)
DELTA Tuner
1M07
MODULE splitter 5P 8307 1M07 1M37 1M36
5P 11P 11P
1T01
8220
8345
1M36
0345
11P
RIGHT
N.C. 12P 6P N.C. N.C.
LEFT Side I/O
J LED panel
D
E_14650_017.eps
230305
Block Diagrams, Testpoint Overview, and Waveforms FTP2.2E AA 6. EN 25
SUPPLY 42 FHP
A6 LLC SUPPLY AUX-SUPPLY
A5 PRECONDITIONER
HOT HOT COLD A7
LATCH 0323
+5V_STBY_SW VA 1
A3
4 NC 2
PRECONDITIONER 1
DC_PROT VCC 3
- LLC-CONVERTER - 7003 VS-SUPPLY - AUDIO SUPPLY - 4 TO
TCET1102 A3 1M10
6600 5 CN23
GBU8J 3 3 2 1 TO 1M10 6
F601 F600 +12V PDP
5600 6611 2 7
400V-HOT 400V-HOT AL NC
1 4 16 14 3 VS 8
- +
7610 4 AMBIENT 9
5612 A2 LIGHT 10
2603 STW26NM50
2 A - BIAS-SUPPLY - 7093 1002
1 2 4 6 3610 LM317T F001
G D 400V-HOT F293 TO 1002
DC_PROT 7
7608 25V-HOT 3092 BIAS 6291
S VSND_POS 6 C
5290 D458L20U
2616 7090 : 5
6606 7092 3095 GND_SND PDP AUDIO
3611 3614 1084 6291 2292 4
4 2 0333
2053 3
6605 PROT VSND_NEG
5002 F1A 2 VCC 1
F604 3096 2294 1 2
16 3 1 6292 0323
3
SW25V-HOT SW25V-HOT 6095 7007 7005 11
5001 4 TO
3608 7001
7020 STU16NB501 14 F294 +12V SUPPLY +9V_STBY
10 5 CN33
HIGH D VB +12V 9 6
MC34067P 15 10 G TO 1M46 NC PDP
SIDE 1200 8 VS 7
2663 VCC S 12 +30V VTUN
3663 6661 DRIVE 7 B21 8
I038 +5V_STBY_SW 6
11 3 T2A 7260 9
CONTROL +12V_OVP L4973 7,8 VCC 5 SSB
F003 F005
6660 2664 7017 4
7018 15 14 4 6 3 3
OA
11 +8V6 2
3 3345 6348
12 2 I083 2 1 0342
SOFT OB
START 6 7008, 7006 10 CONTROL VA 1
+ F004 7021, 7012 BZG03 3346
8 10 D NC 2
CURRENT FI 3345
LOW G 3 TO
PROTECTION 7 14 SIDE 9 12 NC
VCC 4 CN42
3011 DRIVE S 3072 VTUN 3346 5
I057 PDP
A7 6
3660 VCC NC 7
13
F608
V.S._UNSW VS
3668
7661
6641 70-90V VS- SWITCHED
MC34063AD
8 1 F609 VS
DC TO DC 5660 6665 D
7 CONVERTOR 2 S
7650 I622 6044 7050 6142
MC33368 16 16 3 STTH2003C PSMN035 2021 0352
BYD33D
LINE 6663 2662 3680 VS_UNSW VA VA VA 1
7
ZC
BIAS F016 G
2
14 2 70-90V NC
CONTROL NC 3 TO
12 4
VCC 2020 CN52
I625 12 5 PDP
F610
3605 3641 1 I200 6
11 VCC NC
GATE 7641 7
5 VS
MULT VB
CONTROL SWITCH ON
3 3
I618 VFB POK LOGIC
A3 VS
3651 6 CS D 3050
I629 2640 7640 6
G BSN20 6021
S I083 1083 BYU28
11 3053
F2,5A
+30V
3640 10
6045 A2 FITER STANDBY
3671 1082 BYU28 2022 0306
9 1
+3V3_STBY_SW
F2,5A I201
3666 3 TO
4 CN6
SWITCH D
LOGIC G 7052 PDP
2666 SEQUENCE IRFR18N15D VCC 1004
VSA-CONTROL S 6
A3 DISCHARGE
7010,7011 VRS I202 T2A
AC3 100-230VAC2 4 1 A3
7002 CONTROL VRS
TCET1102 CIRCUIT FEEDBACK
3 2 0311
1
HOT COLD 2
3
AC5 100-230VAC1
4
A7 AUX-SUPPLY VRA 5 TO
A3 VRS 6 CN11
70-90V A3 VCEGO 7 PDP
A3 VSAGO 8
A3 PFCGO 9
A3
t
2210 7
FILTERS STANDBY
3372
3355
3356
A2 2 7230
+9V_STBY_SW
CONTROL L4940 7366-2
3113 6113 +30V A3 5
4 VA
A3 DEMAG 3228 7
+8V6
6111 2114 VRA 4 1 6
A3 +2.5Vref
1M05 7465 7220
7460 7470 4 1 VSA_CONTROL 7227
1 A3 TCET1102
7120
VA TL431CZ 3224 6378 7326
SECOND 3 2 7327
2 STANDBY ACTIVATING
ACTIVATING TCET1102 ADJ. +5V_STBY_SW
DELAY A7 POK
3 2 DETECTION
3225 +8V6
CIRCUIT
6513 6512 +8V6 UNDER VA VS
A7
A3
A6
A6
BYG10 BYG10 3506 VOLTAGE PROT.
SUPPLY-ON
VCC_GO
DC_PROT
LATCH
STANDBY
+t 3396 3302
400V-HOT
A SUPPLY_ON
6510 6511 2503
A5 BYG10 BYG10
3397 3303
A3 PROTECTIONS
- STANDBY SUPPLY - +5V_STBY_SW
OVERVOLTAGE
F500 5500
6504 F502
2 6 RS1G +9V_STBY VS PROTECTION VA PROTECTION VCC PROTECTION 12V PROTECTION DC_PROT VCEGO LATCH STANDBY 3316 3305
3308
CONTROL
3507 3 7
7500 I510
TNY256
I508 8
3390 0307
4 5 3349
ENABLE DRAIN +5V_STBY_SW
9 VSK 1
VS_UNSW 7351 I900
7-8 6366 2
SOURCE 70-90V VA VCC +12V I943
3350 6347 3345 +5V_STBY_SW VAK 3
6312 3312 6321 3321 6333 3333 6340 3338 3358 3361 3353 I901
4 7352 7348 5
3300 3311 3320 3332 3347 3346
6505 F503 7308 A+B 7308 C+D 7330 A+B 7330 C+D 6364 3354 3391 A2,A6 VRS 7
SB34 +5V_STBY_SW 7391 I903 TO
1 7 11 7 11 A2,A7
1 13 1 13 VRA 9
I904 CN7
3501
2V5 CIRCUIT 6
6313
3313 10
6322
6
6334
10 PFCGO 11 PDP
2V5 2V5 2V5 2V5 6341 7362 F343
1 5 9 5 9 A2 VCEGO 13
4 +5V_STBY_SW 2 14 2 14 3344 7004 I905
3505 A3
7501 4 8 4 8 3364 +5V_STBY_SW A2 VSAGO 15
+9V_STBY 6362 I906
TCET1102 A3
1 3343
3 7502 3304 3341 7341
2 TS2431 2 7375 3317 20
7389 7393 NC
2V5 7376 +5V_STBY_SW
+12V_OVP
VSA CONTROL
SUPPLY_ON
TL43IC2 1 3324 CONTROL 3342
A7
VSAGO
VCEGO
LOGIC 3388
COLD 3
6503 I504
RS1G 3508 HOT
+25V-HOT +25V-HOT 2
2505
A2
A7
A2
E_14650_018.eps
240804
Block Diagrams, Testpoint Overview, and Waveforms FTP2.2E AA 6. EN 26
I6 V1 V2 LATCH
5T25 6TO8
AD(0-7)
7323 7719
TDA9321H 10 12 13 14 26 29 28 MSM56V16160F
1T01
SAW FILTER C Y
UV1318ST 7,3 9
5403 VIDEO
7713 7714 7760 7720
VIF1 2 SAA4998H TBF24EF DRAM
11 IF-TER PLL GROUP 7414 SAA4978H MS81V04160A
MAIN TUNER VIF2 3 512KX16X2
DEM DELAY F162
COR. EAG_SD
Y-PIP+MAIN-OUT 23 YG (0-7)
Y50
40,4 1410
5 4 1 1408
DIGITAL
Y Y 49 3x BUS C DA (0-15) MF (1-17)
Y PROC. SIGNAL PROCESSING
AGC TUNER AGC 62 HIP Y/U/V
SWITCH
U
V
50
51
U50 U-PIP+MAIN-OUT 25 ADC FIELD
MEMORY
UVG (0-7)
FM1
FALCONIC
S-SDA-PIP
S-SCL-PIP
1409-A
DEMO
C DECODER
MEMORY YF (0-7)
U-VOUT (0-9)
5 C PROC. PAL
AGC SOUND-OUTPUT NTSC
MONITOR SECAM UVF (0-7)
B5A QSS-AM SEE F165
B6A BLOCK DIAGRAM 3727
SYNC H-SYNC 60 HA50 HA50 28 SYNC PROCESSING 34
AUDIO SNDA
7410 SEPAR. PROC.
F166 41 CLK32I
CVBS-SC1_AV1-IN 16 3728 SNCL
B14b V-SYNC 61 VA50 VA50 29 B19b FALREF
1
SEL-SVHS-RR_STATUS2 17 PROC. SN-DA
UVF (0-7)
B19d REFIN
YF (0-7)
VA
B14b B19d 2
CVBS-AV3-IN 18 1305 SCL-F SN-CL B19d Vref
4
B15a 54 PAL 30 Href-EXT
Y-CVBS-SC2_AV2-IN SDA-F 5 B19d CLK64
20
B14b 4.43MHz B3c,d,B19d
SNDA HD-E B19b
C-SC2_SVHS-IN 21 1308 BUS A BUS B
B14b Y U V 57 NTSC M SNCL VD-E B3a
UVA / YA
Y-CVBS-FRONT-IN 23 3.57MHz Href B3a
UVB / YB
B14a RGB/YUV B3D COLUMBUS
46 SCL-F B19d CLK32E
C-FRONT-IN 24 MATRIX 7752-1 B19d
B14a
R G B R G B 47 SDA-F T6TU5XB
SCART1
SCART2
7753
MSN56V16160F-7TS
PIP-OUT
32 34 36 37 38 39 41 42 43 40 SDRAM COL_SD COLUMBUS
N.C. CVBS-SC2-MON-OUT 7415 I/O
Href-EXT
B14b R/G/B-SC1-Y/U/V-IN
B14c SC2-FBL-IN
B14g SC2-R_C-IN_AV2
SC2-G-IN
SC2-B-IN_C-OUT B3a
U-VOUT (0-9)
Y-OUT (0-9)
UVF (0-7)
7V01
YF (0-7)
EP1C12F256C8
1G50
R7 3V25 5Z01
+2V5-IO TXLCD0- 18
R (0-7) R5 3V26 TXLCD0+
+3V3-IO 17
SUPPLY UV DEMUX G6 3V27 5Z02
+1V5-INT CLK-2FH YUV TXLCD1- 16
UV CONTRAST OSD
CONVERTION SATURATION to 3V28
+1V5-PLL B19a CLK-64 INSERTION G (0-7) G7 TXLCD1+
RGB 15
BRIGHTNESS
B3c 4V29
G5 TXLCD2- 5Z03 14
H-2FH-AD-OUT VD-OTC B (0-7) 3V30
CLK-VID B0 TXLCD2+ 13
V-2FH-AD-OUT HD3-OTC B3a
B19a STANDARD CLKP 3V31
PWR-OK-PDP B5 TXLCD3- 5Z05 10
B19a SYNCDET DEFLECTION B3a
LCD-PWR-ON PARITY 3V32 TXLCD3+ 9
B19a 1:2 PATH
LAMP-ON FOR
3FH B1 3V33
TXCLKLCD- 5Z04 12
ONLY
CLK-OSD
B3a CLK32E CLKP 3V24
VA CLK-OUT TXCLKLCD+ 11
B3a Vref B19d
Href-EXT
B3a SYNC Href B3c
HD-E SDA-F3
B3a
VD-E
CONTROL
RSTR B3c B19C EPLD
REF SCL-F3
FALREF B3c
REFIN B3c SN-CL
SWITCH-1FH B3c
INPUT SN-DA
CONTROL SWITCH-2FH B19b 11,14,17,20,23,26,27,28,29
BL-OSD (0-4)
G-OSD (0-5)
R-OSD (0-5)
B-OSD (0-5)
UV-AD (0-7)
U-AD (0-7)
B19b
Y-AD (0-7)
SD-DQ
SD-A
7V03 B19b CLK32P_EPLD 7E03
MSM56V16160F
B19d SWITCH-2FH
B15B PIP SWITCH
7P56
M62320 B19d CLK32E 7E04
DRAM
512KX16X2
B19d SWITCH-2FH
CLK32I
SDA-S 3 I/O SWITCH-MAIN
10
EXP B14C
SCL-S 2
B3c
12 SWITCH-SUB
B14C
B14C IO3 SWITCH B14B B14B CONNECTIONS H SCART3 B21 CONNECT B14F DIGITAL INPUT 7I18
OTC PICNIC B19C
SII907 B14G I/O7 B19A B5A B3A EPLD OSD
1D01 7E23
1I59
49 RX2- AD9883AKST
1
7001
2 48 RX2+ 7L01 SAA5801H
SCART 1 AD9883AKST
SCART 3 3 +5VIO OTC
21 3064-1 3858 R-OSD R-OSD (0-5)
CVBS-SC1_AV1-IN 21 4 77 R-TXT 2FHR-GFX
B2 20 20 CVBS-SC3-IN
CVBS-TER-OUT 19 5 A/D
B2 19 7I51 7I55 3064-2 3859 G-OSD
20
2 f 3 G-OUT 19 11 A/D
STATUS-SC3-F SEL_FRONT_SC3 10 51 RX1+ G-DVI B19d
8 SC1-STATUS 4 IOG 26 9 G2-IN
C1 C2
C3 C4
8 5 2 COVERTER SYNC
B2 B-SC1-IN_U-IN 13 SC1-B 7 7 11 DVI HD3-OTC
14 B2 7I58 B3a PROC.
12 g 1M36 1M36 AV6-B B1-IN 12-19
1 FRONT-SC3-Y-CVBS FRONT-Y-CVBS-IN
12 RECEIVER 5
1 B-OUT 15
B-VGA U-2FH 43 VD-OTC
+
15 2 2 IOB 31 B-DVI B2-IN 10 B3a CLOCK
16
11
24
13
8
7I35 2 HD-S-SIG-DET
7I36 20 7E24
e 16 SDA-F3 SERIAL
C-SC2_SVHS-IN SC2-FBL 7I37 DET B15a AD9283BRS-80
15 C 1M36 1M36 21 REGISTER
B14a
FRONT-Y-CVBS SCL-F3 +
22 18 C-V-IN SYNC C-S-OUT 17
f Y Y 2 2 CONTROL POWER
SC2-G B5A OTC 1I53 SEPA BL-OSD
11 MAN.
Y-CVBS-FRONT-IN
g SEL-SVHS-RR_STATUS2 2 1 C 4 4 24 6 RXC-
8 GROUND
C-FRONT-IN
SC2-B_C-OUT 7 5 C1
B2
10
SC2-FBL
4
6
8
C2
CVBS C3 SC2-R_C-IN_AV2
SC2-G-IN
C4 B2
SC2-B-IN_C-OUT E_14650_019.eps
B14b
B2
B2
B14b,c
B2
180604
Block Diagrams, Testpoint Overview, and Waveforms FTP2.2E AA 6. EN 27
AUDIO
B2 IF SEE ALSO B14D AUDIO I/O B6A AUDIO I/O B21 CONNECTIONS
C PDP AUDIO
BLOCK DIAGRAM +8VP
VIDEO 7A02 -16V-19V +16 +19V
7323 MSP3411G
TDA9321H
3380 SOUND-OUTPUT 7410
5 7700
QSS_AM B65 TDA7490 24 22
HIP 50 IF1 7A03 1735
B66 LM833D B68 I722 I778
MAIN AUDIO-R AUDIO-R 5702 5730
LOUD- 20 5 7 AUDIO-R 1M52 1739 18 23 1 R
DE- PRESCALE SPEAKER LOUD PWM
ADC DAC 21 1 AUDIO-L AUDIO-L 1 1 15W/
MODULATOR PRE-PROCESSING SOUND 3
IF2 3 8
PROCESSING 3717
B67 7A00-A B69 2 2
23 AUDIO-SW
SND-CENTRE-IN MONO-IN 3 1 3 3
B14b 47 DACM-SUB 6 STBY-MUTE
I/O
B14B FRONT-DECT IRQ-AUDIOSUPPLY GND-AUD 4 4
OSC
B14d SNDR-MAIN-IN 45
17 HPN-R B5A
HEADPHONE/ N.C. 5 5
18 HPN-L +5V2-STBY 1736
SNDL-MAIN-IN SURROUND
SCART 1 B14d 44 DAC 18 MSP-CENTER I/O AUDIO-SW I776 5731
6
AL-SC1-IN 9I32 SNDL-MAIN-IN B6a
B14d SNDR-SC2-IN
SOUND
PROCESSING 18 MSP-SURR
N.C.
B14B 6 6 5701
AUDIO-L 10
PWM
3 5701 1 L
EXT 1 42 N.C. 7010 7
7
B6a SCART 15W/
AUDIO 3 AR-SC1-IN 9I33 SNDR-MAIN-IN SC1 7A00
B6C I711
2 B14d SNDLSC2-IN
41 DSP LM833D 2701 3 8
L/R IN 1 1I06 8 8 2 4 3718
INPUT SOURCE 23 DACM-SUB 5 7 AUDIO_SW 9ID0 SUBW SUBW
SCART 2 B14c SNDR-DVI-IN 39 SELECT OUT 9 9
SELECT
AL-SC2-IN 9I34 SNDLSC2-IN B6a SC3 SOUND-ENABLE +16V+19V
6 SNDL-DVI-IN ADC PRESCALE -16V-19V
EXT 2
B14c 38 SCART 1 B5A
3 AR-SC2-IN 9I35 SNDR-SC2-IN B6a SNDR-SEC-IN
AUDIO
L/R IN 1
2
B14d 36
SC4 B14D EXT 1 POR
7Y01
B14B HPN-R 5 7
HEADPHONE-R 11 11 FRONT-R 11 11 R
FRONT-DETECT 7 7 7 7
1I06 B5A
SND-CENTER-IN B6a DETECT
CENTER
IN
CONTROLS
D SIDE I/O B21 CONNECTIONS B5A OTC FLASH
7001
SAA5801H
B3A B19C
CVBS-TXT 5 77 R-TXT 3858 R-OSD
B2
HEADPHONE-OUT G-TXT 3859 G-OSD
1M36 1M36 7015 78
FRONT 7 7 HD3-EPLD 83
SEE ALSO B3A 79 B-TXT 3860 B-OSD
DETECT BLOCK DIAGRAM OTC
VIDEO 7016
80 FBL-TXT 3861 BL-OSD
VD-EPLD 84
B3A
88 SDA-F
CVBS-Y-RECORD-IN 7 SEE ALSO
N.C.
3073-2 BLOCK DIAGRAM
114 87 SCL-F VIDEO
+5V2-CON 7002 : SEE ALSO
7004 IIC DIAGRAM
86 SDA-S
E TOP CONTROL RESET
74
RESET
0345 7005 85 SCL-S
BLACKLIGHT-TC LF33AB 7013, 7014
4
6x IN OUT +3V3 RESET
KEYBOARD 2 FLASH RP 90 TXD
INTOTC
RAM
ON / OFF N.C.
1 89 RXD
CHANNEL+ STATUS_SC3 109
CHANNEL- B14B
VOLUME+ 3099-3 3081 SAM
STATUS_SC4 108 119
VOLUME- B14B
MENU 3074-4 3097
POR-FLASH 99 96 SDM
B4 6005
2060
2061
9006
9017
9018
9005
IRQ-DIGITAL 98
N.C.
7030
LED + SWITCH
JJ 7031
7032 0345 N.C.
HD@HOME 93
104 STANDBY
SA
BLACKLIGHT-TC 4
CONTROL IRQ-FTV 96 95 SOUND-ENABLE
KEYBOARD 2
N.C. A-PLOP B14B
94 RESET AUDIO B6A
6060 6061 CON-SND
118 SA
BLUE 7516
117 SEL_IN_2
6051 N.C. 74HC4053
P50 7009
116 SEL_IN_1
B14B H
RED 1M20 1M20
97 103 PWW-BLACKLIGHT
1 1 KEYBOARD B5B
CON-SND 120
2 2 B14E 7008
E_14650_020.eps
271204
Block Diagrams, Testpoint Overview, and Waveforms FTP2.2E AA 6. EN 28
3069 3079
3064-4 SDA-F SDA-F 3710 SDA-D
88
3064-3 SCL-F SCL-F 3709 SCL-D
87
SN-DA SN-DA
3377 3376 3826 3827 +5V2Pr B14F I/O6 DIGITAL INPUT 3V3-Si-IO
ERR
7001 +3V3-INTOTC 18
3A17 3A19 SN-CL SN-CL 7I52 G
47 46 5 4 DVI INPUT
SDA-EPLD
SCL-EPLD
SAA5801H CONNECTOR
3758 3IQ7
7323 9817 9818 9815 9816 9757 9755 7 SDA-DVI D S
7713
17
1
9
1
SET TDA9321H
PROCESSOR SAA4978H 3IQ6
3001 3002 A15 B15 C14 D14 33 24 34 41 6 SCL-DVI
2
91 SDA HIP PICNIC
7752-2 7720 7760 G
3I49 3I46
92 SCL T6TU5XB T6TX5AF SAA4998H/V1
ERR ERR COLUMBUS 5 6 14 15
EAGLE1C
16
24
8
5 6 8 3 D S
CTRL FEM 7I19 7I18
C1 C2
C3 C4
7011 7I51
M24C02 SII907BCQ
M24C64
C5
ERR
(NVM) 1 ERR ERR
ERR 27 26 EEPROM DVI
EEPROM B19B EPLD
CONTROL
35
RECEIVER
SDA-F-AUD +3V3-EPLD
7E10 HDI A/D B19C EPLD OSD B19D EPLD I/0 B21 CONNECTIONS
SCL-F-AUD
8
B19A
PCA9515DP CONVERTER
3E69
3E70
VCC
3 6 SDA-F3
2 1 4 5 +3V3-IO +5V
SCL-F3
7A02 7A06
7
3V50
2
3V51
3V52
MSP3411G TDA7309 3L06 3L03 3E18 3E19 3V38 3V37
AUDIO
DEMODUL AUDIO I2C BUFFER 57 56 57 56 2 1 7V04-1
DECODER AL-CL-IN AL-CL
7L01 7E23 7V01-4 +5V
ERR 1M49
ERR 9E57 RES AD9883AKST AD9883AKST EP1C12F256C8 +3V3-IO
14 82 1
TO CON2
3V55
9E58 RES
3V54
3V53
+5V2_CON A/D A/D BANK3 2 AL
CONVERTER CONVERTER 3 AMBI LIGHT
7V04-2
B15B PIP SWITCH B14E I/O5 B21 CONNECTIONS
ERR ERR
ERR
AL-DA-IN AL-DA
56
3088 3092 53 53
3064-2 SDA-S SDA-S
86
3064-1 SCL-S SCL-S
85 I/05 SCREEN
B14E +3V3_SIM B20
1M20 INTERFACE
3Y09
3Y40
3P66 3P65 7I10
ERR LED SWITCH PCA9515DP 8
3IB3
3IB1
6 3 2 11 PANEL VCC 1G50
12 (ITV) 3 6 SDA-DISP 3Z51 31
7P56
TO
M62320FP SCL-DISP 30 DISPLAY
SDA-SF
1M15 3Z50
I/O 2 7
1
EXPANDER COMPAIR
SCL-SF
2 SERVICE
ADDRESS
ERR 3 CONNECTOR
7006 21 RES
DATA M29W320DT 9I06
PROGRAM
FLASH-RAM 9I05
CONTROL B14B I/O2 CONNECTIONS
1I11 +5V
B13A MAIN TUNER B13B SUB TUNER
19
7T50
RES 8
20 P82B96TD
3T05
3T06
7007 FOR MMC VCC
MSM51V18165F 3 S-SDA-PIP
DRAM 1
(TXT) 2
S-SCL-PIP
5
7
6 9T08 9T07 9T10 9T09
5 4 5 4
SCL-S
SDA-S
7012 RES 1T01 1T02
M29W400DT 9T50 UV1318ST UV1318S
ERR
32 9T12 MAIN SUB
TUNER TUNER
ERR ERR
13 23
E_14650_021.eps
230804
Block Diagrams, Testpoint Overview, and Waveforms FTP2.2E AA 6. EN 29
CONTROL
5U01 B12 B19b +3V3_EPLD
+3V3PB +3V3PB 5756 +3V3CA B3d
3501 B3e 7774
4 1 7U03
3505 5753 +3V3CB B3d +3V3_
7501 B3e +3V3Pr +3V3Pr IN OUT
TCET1102
5U06 DCDCFBX B3a,B3c B14F I/O6 DIGITAL INPUTS SCREEN INTERFACE
1 RES
B20
3 7502 B3e +3V3PC +3V3PC 5764
2 TS2431 2 +5VF 5721 +5V_FBXA B14g
+8V-VIDEO +8V-VIDEO +3V3_SIM +3V3_SIM
B6a B12
B3e +3V3GA +3V3GA
3503 B19a +3V3-AD +3V3-AD B19a,B19c VDISP
3 5722 5775 +5V2Pr B13c VDISP
B3a,B3c,B3d
5I35 3V3-TMDS
COLD B21 +11V +11V
6503
RS1G 3508 7I18
+25V-HOT HOT +25V-HOT A6 B2 +8V_CON 5702 +8VPA B3a VCC-Si 3V3-Si-IO
N.C. 9 DVI 14,17
RECEIVER
2505 E_14650_022.eps
020205
Block Diagrams, Testpoint Overview, and Waveforms FTP2.2E AA 6. EN 30
CN9004 1M46 FALCONIC EMBEDDED MEMORY B13A MAIN TUNER SUB TUNER 3I40
B3B B13B B21 +8V 5I13 +8V-VIDEO B14f
1 1
+3V3FA +3V3FA +5V 5I12
2 B3e +5V
2 HOP B21
5Y06 +8V
B2,B6a, B4 3IG9 REF1
3 3 B14a,d,e,g,B15a +3V3FB
B3e +3V3FB +33V +33V
B21
4 4 3IW1
B6a,b,B13a,b,B14b,
+1V8FA +5V_VDP 3304 +5VS
5Y15 +5V c,d,e,B15a,b,19a,d B3e +1V8FA B14e B2
5 5 6I80
6 REF2
6 +8V_VDP 3329 +8VS
5Y07 +5V2-STBY B14e
7 7 B5a,B14b,e,
B3C EAGLE DC-DC CONVERTER 6IA1
8 +33V B13a,B13b
B13C
8
REF3
9 5Y02 +11V B14b,e,B20 +2V5EC +2V5EC +11V_DC +11V_DC
9 B3e B14e
10 10 5Y03 B14c +5VIO +5VIO
B3e +2V5ED +2V5ED OTC FLASH
11 11 5Y09 9V_STBY B5A 5T10
B21
+1V5EA +1V5EA 5000
B3e 7TO4
7T01-1 PIP HIP
CN9005 1M03 5001 DC-DC B15A
B3e +1V5EB +1V5EB
1 1
+5V2-STBY 1000 5003 +5V 5P03 5P00 3P00
B3e +2V5EA +2V5EA B21 +5V2_CON 5T11 5T14 VDISP B21 +5VHIP
2 2 B20
3 3 F500mA 5T15
B3e +2V5EB +2V5EB
7005 +8V 5P01 3P01
4 4 B21 +8VHIP
+3V3EA +3V3EA +3V3_INTOTC
+5V B3e B3c
5 5 B21
3P02
I/O1 MMC +8VPIP B15b
6 6
B3e +3V3EB +3V3EB B14A
B5c VPP-SW VPP_SW
7 7
B3e
+3V3EC +3V3EC +8V +8V
8 8 B2 +8V_CON +8V_CON B21
B15B PIP SWITCH
5Y09 9Y15 9V_STBY B21
9 9 B3e +5V2Pr +5V2Pr EAn EAn 3IK7
B5c +8VA
10 10 B15a +8VPIP +8VPIP
B3e +3V3ED +3V3ED
B21 +5V 5P51 +5VD
H SCART 3 I/O2 CONNECTIONS
BACKLIGHT CONTROL
B14B 3P74
1M07
B5B +5VPIP B15c
1M07
3 3 COLUMBUS +5V_CON +5V_CON B21 +5V2-STBY 7I21-2 7I05-1 +5V2-APLOP
B3D B14e 4 3
+11V_SF 4 +11V_SF 9IA5
4 B14e
+3V3CB +3V3CB +8V_CON +8V_CON PIP MUPPET
5 5
B3e B2
5
B15C
+11V_SFS 3511-3516
B3e +3V3CA +3V3CA 3I37
B15b +5VPIP +5VPIP
B3e +1V5CA +1V5CA 6I11
BACKLIGHT CONTROL +3V3_SIM 9PB2 +3.3V
J LED SWITCH PANEL 1M20 1M20 B5C 3ID9 B12
+5V2Pr +5V2Pr 6 5PA9
6 5Y11 +8V B3e +3V
6 B21 +3V3_INTOTC +3V3_INTOTC B21 +5V 2
B5a 7I21-1
+8V 7 7 5PB0 +3VD
8 8 3C01 EAn 1
B5a
9 9 B3E FBX SUPPLY
SUB +5V2-STBY 10 10 5Y12 9Y06 +5V2-STBY B21 +5V
HDI A/D CONVERTER
B19A
SUPPLY B12
+3V3_DCDCFBX 5719
5720
+3V3_DCDCFBXA
B3a B6A AUDIO DEMODULATOR
3IC1 +5V
7L02
+3V3-AD
SDI AL AMBIENT LIGHT
B21 +5V +5V B21 +11V 7I07 +11V_S B6a,B14e
B21 3
IN OUT 2
5L16 VD
B14f,B19c
CONTROL
5U01 B12 B19b +3V3_EPLD
+3V3PB +3V3PB 5756 +3V3CA B3d
B3e 7774
5753 +3V3CB 7U03
+3V3Pr +3V3Pr IN OUT B3d +3V3_
B3e 5U06 DCDCFBX B3a,B3c B14F I/O6 DIGITAL INPUTS SCREEN INTERFACE
RES
B20
B3e +3V3PC +3V3PC 5764
+5VF 5721 +5V_FBXA B14g
+8V-VIDEO +8V-VIDEO +3V3_SIM +3V3_SIM
B6a B12
B3e +3V3GA +3V3GA
B19a +3V3-AD +3V3-AD B19a,B19c VDISP
5722 5775 +5V2Pr B13c VDISP
B3a,B3c,B3d
5I35 3V3-TMDS
B21 +11V +11V
7I18
B2 +8V_CON 5702 +8VPA B3a
N.C. VCC-Si 9 DVI 14,17
3V3-Si-IO
RECEIVER
E_14650_023.eps
020205
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 31
A A
400V_HOT
100-230VAC1
400V_HOT
SW25V_HOT
25V_HOT
+5V_STBY_SW
100-230VAC1
100-230VAC2
100-230VAC2
+9V_STBY_SW
+9V_STBY
DIAGRAM
B B
DIAGRAM PRECONDITIONER
FILTER_STBY
SUPPLY_ON VCC
VRA
VRS
VCEGO
VSAGO
C PFCGO
C
GND GNDHOT GNDHOT
SUPPLY_ON
+9V_STBY_SW
+8V6 +5V_STBY_SW 70-90V +9V_STBY VS +5V_STBY_SW 400V_HOT
VS SW25V_HOT
+30V 25V_HOT
D 70-90V
D
+5V_STBY_SW
+8V6
SW25V_HOT
VS
+9V_STBY_SW
+5V_STBY_SW
400V_HOT
+9V_STBY
25V_HOT
70-90V
70-90V
VS
+30V
PFCGO
VSAGO
VCEGO
VRS
VRS VRS
E SUPPLY_ON
DC_PROT
DC_PROT
DC_PROT E
LATCH
LATCH LATCH
DIAGRAM VRA
VRA VB
VB DIAGRAM VTUN
VSA_CONTROL
PROTECTION
VSA_CONTROL
IAKS
LLC_SUPPLY
IAKS
VA
VA
VCC
VCC
F VCC_GO
VCC_GO
F
POK
POK
+5V_STBY_SW
G G
VS +30V 70-90V +8V6
VS
+5V_STBY_SW
70-90V
+8V6
+30V
VB
VRA
VTUN
H VSA_CONTROL H
IAKS
VA
VCC DIAGRAM
VCC_GO
POK
AUX_SUPPLY
I I
GND
E_14650_026.eps
3104 313 6017.3 180604
1 2 3 4 5 6 7 8 9 10 11 12
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 32
A MAINS
I400
FILTER +t AC5 +t
3452
A
1460 B10
1M05 D5
F511 G10
F512 H10
232266293 232266293 2001 B4 F513 G9
INPUT 1402 3404 600V 600V
t
2002 B3 I400 A4
220R SDT-SS-109DM SDT-SS-109DM 2003 B4 I401 A3
95-264Vac F404 F405
DSP
ERC12
B57464 6W7 B57464 2004 B5 I402 A4
1400 I401 I402 I520 I406 I409 3036 I410 2019 B4 I403 B4
F403 AC2 AC2 I521 6W7 AC5
0308 1 2 1 2 100-230VAC1 2400 B2 I404 B6
F401 T6,3AH/250V 1 5401 2 1 5005 2 1 5402 2 t 2401 B6 I405 B7
2322595
F402
2400
2403
19181
2402
470n
2002
470n
3400
2003
470n
2408
470n
2001
470n
2004
470n
470n
2401
470n
2402 B2 I406 A9
3401
470n
2 3 4 3 4
1M
VR37
495 V
2403 B5 I407 C8
1 3 4 3 4 3 4
F406 F407 F408 F410 1450 1460 2404 B4 I408 A10
B2P3-VH DMF28 DMF28 DMF28
2405 B4 I409 A10
B AC3 F409
2404
AC3 I403 2406 I404
I405 HOT
B 2406 B5 I410 A12
AC3 AC3 2407 B5 I411 C11
100-230VAC2
GROUND
470p 250V
470p 250V
470p 250V
47p
47p 1000 1000
2408 B4 I412 D10
2465 C11 I413 C12
2405
2019
2407
COLD 2502 E8 I414 D12
GROUND 2503 F6 I415 D12
I407 2504 G4 I416 D12
COLD 2505 F5 I417 C13
2507 E7 I501 D4
GROUND
2508 F7 I502 D5
2509 F7 I503 D5
C C 2510 F7 I504 E5
3467
10K
2511 I7 I505 E6
BAS316
BAS316
6461
6471
GROUND GROUND GROUND 2512 I7 I506 E7
BC857BW 2513 G4 I507 F7
I413
100u 16V
2530 G11 I508 G4
I411
I417
7465
2465
2531 G11 I509 G4
I415
2532 G13 I510 G6
BAS316
BAS316
F411
3465
6460
6470
10K
2533 I13 I511 G6
2540 I11 I512 H7
3469
4K7
3463 I414
2541 I12 I513 H7
1M05 I412 10K I416 3026 F4 I514 I8
7460 7470 3035 F4 I515 G11
1
D 2 BC817-25W(COL) BC817-25W(COL)
D 3036 A11
3400 B3
I516 G12
I517 H12
3460
3461
3470
B2P3-VH
4K7
10K
10K
3401 B1 I518 E6
SECOND STBY
3404 A4 I519 F9
3450 A10 I520 A7
3451 A10 I521 A6
6510 I501 6511 I502 6512 I503 6513 3452 A11 I522 E7
400V_HOT
387V(OV)
3467 C12
600V
E E
3506
3469 D12
220p 50V 220p
3470 D12
3501 H7
I504 3508 I518 6503 I505 6504 F502 8V7(9V7) 3502 H7
25V_HOT I506 +9V_STBY 3503 I8
10R PR02 RS1G RS1G 3504 I8
3505 H8
100u 16V
1m0 35V
2508
5500
3507 F4
5
100p 50V 3508 E6
680K
3507
6
4 I519 3520 G12
6505 F503 5V4(5V4) 5503
F 3
7
F 3530 G12
1m 16
F500 387V(22V) SS34 22u 5005 B5
680K
3035
2510
8
8V7(9V7) 5401 B4
CONTROL F501
2503
2
1
9
F504
TO
+9V_STBY_SW 5402 B6
5500 F7
TO
BAS316
F505
680K
3026
RES
6520
CN6 5503 F9
47u
7500 BS16322-01
PDP CN11 6460 D11
TNY256 6461 C11
I515
I508
ENABLE DRAIN
I510
(DISPLAY) SWITCH 6470 D13
6471 C13
1n0 50V
4 5
BZT03-C I511 BZT03-C
0311
RES
7530-A
2504
6501
0306 6501 G6
3520
+3V3_STBY_SW
10R
SOURCE2 SOURCE3 F513 1 VPR2 PFCGO F507 9
3 6 SI4936ADY 7 8
6502 H6
D
G SOURCE1 SOURCE4 F508 8 I516 RES2 G 6503 E6
RES
2 NC VSAGO
9021
2513 I509 2 7
6504 E7
G S 1
RES
BYPASS SOURCE5 F509 7
RES
1 8 3 VCEGO 3V4(3V4) 6505 F7
10u 16V
100n GND 6530
9023
6506
6506 G6
10u 16V
+3V3_STBY_SW
RES
25 4 VRS F510 6
2531
2530
100K
3530
6510 E3
BZX384-C18
2532
100u
16V
RES
5 NC VRA F511 5 6511 E4
I523 6512 E5
3501
1K0
F506
6 VCC F512 4
6513 E6
BZT03-C
6502
6520 F12
3
I512
T2A/250V
2 6531 I12
470R
3502
7460 D11
H 4 1 1
LD1117DT33C
H 7465 C12
7501 7470 D13
TCET1102 PH-B
1%
7500 F5
I513 3 2
IN OUT 7501 H6
3 2 SWITCH
3505
4K7
I517 7502 H7
VCC COM
16 100n
7530-A G12
2511
100u 16V
7502 1
100u 16V
7540
MEASURED DC-VOLTAGES TS2431 7530-B
2540
9022
7530-B I12
1
6
2541
K I514 SI4936ADY D 5 7540 I12
RES 5V4(5V4) 9021 G13
R 2 4
NORMAL . . HEATSINK
A +5V_STBY_SW 9022 I13
1%
G S 3
100n 16
0203 0201
6531 9023 G6
2
1
MECHPART
3504
I
2512
0309 F401 B1
3503
33K
3
4K7
1404 1405
SHIELDING 3.3 SHIELDING 3.3
F402 B1
BZX384-C18
100u 16V
STANDBY (. . .) 1 2 3
0-106451-1 RES F403 A1
F404 A1
2533
GROUND F405 A2
F406 B1
GROUND F407 B1
F408 B2
F409 B2
HOT COLD
E_14650_027.eps F410 B2
GROUND GROUND
3104 313 6017.3 180604 F411 D13
1 2 3 4 5 6 7 8 9 10 11 12 13 14
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 33
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
PROTECTION
A7
A7
VCC_GO
POK
A7
POK
5V(0V3)
A A
A6
A6
PH-B
1M03
F370 1
LATCH
DC_PROT
0V(0V)
F371 2
POR
VA VCC +12V 5V1(4V2)
F372 3
F374 4
TO 1M03
F375
9020 5
VCC
3372 F376
+5V_STBY_SW 70-90V
6
SSB
B VS VA
+T
KTY81 STANDBY F377
7 B
VCC 12V
220K 1%
1%
TION TION
11K 1%
TION TION F379 9
68K 1%
+9V_STBY_SW
220K
3311
3320
3332
10
F330
220K 1%
POWER_OK
3301
LATCH VCEGO
2.5 Vref
I332
C F368 C
232267191
3308 I302
3360 +9V_STBY_SW
3345
I313
BAT54 COL
3340
3361
3359
3358
I349 3349
4K7
5K6
2K2
3341 1K
BAT54 COL
BAT54 COL
BAT54 COL
1K
1K 4K7
DCPROT
6347
100n 16
3312
3321
3333
6312
6321
6333
6340
10K
1K
1K
1K
7308-B 7308-D 7330-B 7330-D I318 I363
470R +T
I913
2305
3 3 3 3
100u 16V
+T 120R
LM339D LM339D LM339D LM339D I937
3368
3366
7 11 I330 7 11
10K
I347
(0V3)F326 F328
I304 3304
2350
BC857BW 3370
I367
1K
330R
330R
7341
3347
3348
1 5V 13 F327 1 13 F329
11K 1%
6334
6 10 6 10
I341
I344
1K2
BAT54 COL
BAT54 COL
3K9 1%
3306
3350
4K7
BAS316
12 12 12 12
BZX384-C3V3 1K
4
7K5 1%
I321 F325
100n 16
3322
3344
6313
6322
6364
7366-3 10
BAT54 COL
I348
+5V_STBY_SW +5V_STBY_SW I319 I351
3313
3351
2306
D LM324D
D
3356
7351
100R
560R
3355
3357
3362
2K7
2K7
7348
6341
3342
I345
9
BAS316
10K
BC847BW 8
7308-A 7308-C 7330-A 7330-C
10K 1%
BC847BW 10K I323
2304
(2V5)
6362
3 3 3 3
1n0
50V
I350 BC847BW
100n 16
6344
7352 7362
P0102BL
I306 3324
7004
3367
3369
2 14 2 14 BC847BW
10K
1K0
1K
F343 I936
100n 16
100n 16
I316
100n 16
4 8 4 8
3354
3352
3353
3363
3364
2324
2352
2364
4K7
10K
10K
12 12 12 12
1K
1K
10K 1%
7K5 1%
15K 1%
BAS316
1
3317
3323
3343
2343
6365
2u2
1K
50V
12K 1%
K I307
3307
R 2
I339
3378 I379 4
A 5 7366-2
LM324D
E 3 7304
TS2431
10K
6 7
4V(0V1) E
11
100n 16V
VA VS
100K 0,1%
RES 0,1%
RES 0,1%
2366
100K 0,1%
+9V_STBY
BAT54 COL
3800
3803
3397 I309 3396
6378
CONTROL I934 S_GND F324 3388 I389 3389
STANDBY
100K 0,1%
RES 0,1%
RES 0,1%
100K 0,1%
220n 50
220n 50
I303
4K7 I901 VAK F314 1K 1K
3801
3804
2396
2303
47K
RES 0,1%
6K2 0,1%
0,1%
7K5 0,1%
13
220K 1%
7375 F312 14
100n 16
100n 16
2 I935
8V6 UNDER VOLTAGE
3390
BAS316
33K
BC847BW 3
3316
3802
3305
3805
3382
2316
2380
RES
3392
0V7
1K
5
(0V2) 1V8(0V6) I940
100n 16
6
IAK +5V_STBY_SW
BAS316
7 +8V6
3376
3394
BAT54 COL
2376
6376
47K
BZX384-C6V8
11
F321 12 PDP
3328
6325
G G
10K
4 13
100K
2393
7366-1
(DISPLAY)
100n
16V
9003 3
I387 3387 14
3377
LM324D
4K7
15 I327
2 1
470R I905 VCEGO F318 16
7327
9004
(0V) 3386 NC 18
NC 19 BC847BW
4K7
I311 I385 I386 100K I906 VSAGO F319 NC 20
470R
3325
3327
7376 3V3(0V) 3380
10K
BC847BW 20FMN-BMT-A-TFT
1u 1000
47K
100n 16
100K
3381
3385
2381
2385
47K
SUPPLY_ON
VCEGO
PFCGO
VSAGO
IAKS
VRS
VRA
A7
A2,A7
A2,A6
A2
A2
A2
A7
A2
E_14650_028.eps
3104 313 6017.3 180604
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 34
PRECONDITIONER 2603 C3
2604 C2
2605 C3
7608 C6
7610 C7
7640 H10
2608 H8 7641 G10
2610 B7 7642 G11
2611 B8 7650 G6
2612 B5 7654 H2
2613 C6 7661 D8
F996 F997 3999 F998 F999
2614 C7 F600 B10
A 1K A 2616 C9
2617 C9
F601 B3
F602 E2
6606
6605
S3J
S3J
2640 H9 F604 D10
2642 H11 F605 D10
2651 H4 F606 I10
5600
2653 H5 F608 D11
BS42228-02
2654 H1 F609 F9
PRECONDITIONER 2655 H3 F610 G9
16
14
2656 H2 F996 A10
100-230VAC2 2611
1n0 1000V
2660 E10 F997 A10
3 220p 2000V 2661 F8 F998 A11
2600
6
F601 6611 F600 387V(0V) 2663 E7 I602 D2
1 4
6600 400V_HOT 2664 F7 I603 B4
1n0 1000V
I605 6608
BYV29X-500
2601
2665 H8 I604 B7
GBU8J
5612
I634 2666 H4 I605 B5
2 SS14
2612 2670 I12 I606 C6
100-230VAC1 I608 2610 I614 5601 2671 H12 I607 C7
1n0 50V 7610 2672 H7 I608 B7
2602 1n8
220u 400V
220u 400V
STW26NM50 2673 G12 I609 C8
2n2 I606 3610 I607 I630
I609
2674 G12 I610 E5
2604
2603
2605
2616
2617
RES
RES
1u
1n0 50V
3606 BC369 3R3 6609 2676 G12 I612 E7
2613
I635
C 100R 7608
C 3601 D2 I613 E7
2W
2W
BZG03-C18
2W
2614
3602 D2 I614 B8
3621
3622
3611
2R2
3603 E3 I615 H1
2R2
1K
3608
3614
3615
3620
0R27
12R
0R27
0R27
1n0 3604 E3 I616 G5
3605 F3 I617 G2
3606 C5 I618 H4
F604 F605 3607 F3 I619 H4
3608 C5 I620 H5
3609 E3 I621 G4
3610 C6 I622 G7
F608
3611 C6 I623 G8
3602
4M7
RES
4M7
RES
3675
3623 G6 I635 C7
1R5
COLD GROUND 220u
3662 OSC TIMC 3 I642
RES 3639 H8 I636 H12
E NFR25
E
SL04
6663
41V 3640 H9 I637 F4
6665
SL04
470K
3603
2660
1R 6
VCC REGULATOR 3642 G11 I639 E8
470p
I610 I631 3663 I632 I611 I612 6661 I613
2663
3643 G11 I640 E11
470K
3604
I641 BIAS
100u 50V
1u0 50V BYG22D 3651 H3 I641 E8
1R NFR25 5 CIN_NEG GND 4
3652 G5 I642 E10
2664
BYG22D
25
MEASURED DC-VOLTAGES 15V(1V8) 3654 H1 I643 G7
2661
47K 3676
3677
6660
47K
4K7
3678 1n0
3655 H1 I644 G8
1m
I637
2662
BZX384-C39
3659 G5 I645 G8
6601
F I647 NFR25H
3668 F 3662 E6
3663 E6
I648 H12
I649 G6
STANDBY ( . . . ) 3664 H12
270R
220K
3607
3660
NFR25H
F609 1K 3665 F9
PRECONDITIONER
3673
1K
3666 H4
270K
3665
3619
3K3
I627 3667 H6
5V(0V) CONTROL
270R
150K
3668 F10
3661
3679
BC857BW
7602 3643
I645
3616 3669 I12
10n 500V
10n 500V
220R 3671 H12
3613
2675
2674
10K
I649 6602 I646 12K
3623 3642 3673 F12
2676
10n
3675 E8
220R
3659
220K
3680
7650 1K0 BZX384-C15 220R
I622
3676 F8
I628
I643 I644 F610
MC33368 3617 6640
G I621
47K
7601
BC847BW
G 3677 F8
3678 F8
SS14
330K
3683
1 VREF LINE 16
1M I616 3679 G12
3618
3681
220K
33K
3680 G12
10n 500V
2 RD NC1 15 I625
3652
7641 3681 G12
1n0 50V
330K
3684
NC2 14
2673
I617 3 VFB I623 BC817 7642 3682 H12
BAS316
3654
2642
6654
10K
BCP56
BAS316
3683 G12
SS14
6642
220K
6641
4 COMP
3682
I618 FC 13
3684 G12
CONTROL 3685 H12
330K
3685
5 MULT VCC 12 I626
I619 3641
3999 A11
I620 6 CS GATE 11 470p 50V 470R I629 5600 A5
3655 I633 5601 B8
H BC857BW 7640
H
2640
7
I615
ZC PGND 10
100n 16
5612 B7
120K
3664
2671
7654 BSN20 5V
1K 5660 E11
D
4n7 50V
680p 50V
8 AGND LEB 9
25
50
BZX384-C8V2
I624
100n 25
(0V)
47u 16V
1n0 50V
10n 50
BAT54 COL
1%
10
G 6600 B2
100R
SS14
3651
3666
2654
2656
100n
2655
2651
3612
2666
6651
2653
6653
2672
2608
2665
470p
6652
3639
I636
22K
S
2K2
6601 F3
1K0
1u
BZX384-C18
I648
3671
11K
6602 G7
100n 16
3667
330R
3640
6643
6605 A3
120K
3669
2670
10K
6606 A2
F606
6608 B6
6609 C7
6611 B8
6640 G11
I I 6641 H10
6642 H11
6643 H9
HOT GROUND HOT BORDER 6651 H5
6652 H4
6653 H5
6654 H1
6660 F7
E_14650_029.eps 6661 E7
3104 313 6017.3 180604 6663 E10
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 35
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
BAS316
6095
470R
BC807-25W
3095
7090 4 1
15V9 +5V_STBY_SW
19V3
(24V) 7003
I003
TCET1102 I061
18V6 2
LATCH
3096
22u 35V
5K6
(0V)
35
3 5V1(4V2) A3
I056
2090 7091 I004
2053
BC857BW
4u7
F040
35
3072
VTUN
3093
820R
400V_HOT
3097
1K
1m
4K7
2052
3091
I062
4 1
1K I005
B I006 I064
7002 B
TCET1102 I063 I299 6012
6029
I041 2
6075
HIGH SIDE 3 BZX384-C6V8 BZX384-C5V6
DRIVE BZG03-C270
Vs_unsw
3075
1M0
7005
330p 2000V
7001
CONTROL
STP15NK50ZFP
I042 I043 6018 I044 I070 2028 F016
MC34067P 15 5002 16 86V(6V)
70-90V
VS-CONTROLLER
2013
VCC 6007 3014 I038 F002
BAS316 220p 200
100V
100K
3037
3038
9 EN|UA VCC UVLO/ 5.0 V VREF
2020
10K
3m3
BAS316 33R 3
15n 1600
680R
3080
680R
3015
3022
I045
ENABLE
10R
I007 REFERENCE 5 5001
1n0 50V
1 OSCC 3016 I046 7020 2
S13932-04
6027
C BC517
C
2017
2038
I075
6
VARIABLE 1K0
50V
50V
100p
2049
100p
3002
100K
1
3003
6044
STTH2003C
1K0
I027 FREQUENCY BAS316 I037 F017
I008 14
2006 3005 3 OSCCC OA 14 F003 2071 BC327-25 3039
OSCILLATOR
100K
3076
4 I065 I072 PMST5401
7 I298 7007
F005
3
2044
7042 VS
GND4 I009 1n0 27K 1n0 1M
50V 16 OS STEERING 3 I078
ONE-SHOT 9 220p 200
FLIP-FLOP F004 2046 I067 3060 6042 I079
6 EAO OB 12 LOW SIDE DRIVE
2005
100p
50V
3004
2
15K
22n 25
6
22n 25
8 I+ PGND 13
2032
2036
7012 BZX384-C47
10K
3061
2042
330p
10 12
18K
7 I- SOFT-START FAULT DET/ FI 10 11
BAS316
BAS316
BAS316 180K 56K
6005
6004
I010
11 SOST
2033
100n
3073
2039
2040
2041
100p
1M0
4K7
2n2
27p
16
GND4 6077
D 3043 BAS316
GND
D
470R
3054
10
330p 2000V
6035 4 BZG03-C270
7006
F008 F009
STP15NK50ZFP
4K7
GND4
I011 6031 I012 GND4 GND4
3044 BAS316 GND4 GND4 GND4
470R
2012
3042
3018
7021
10R
3045 I015 6032 12K 100R 2043 I294
I030 6028 I051 BC517 5004 16
3010 3019
2047
100n
VRS
3065
3077
1M0
1K
2025
50V
1u0
15K I059
1K0 BAS316 I085
FEEDBACK
150K
3024
BC847BW
150K
3052
2034
2037 SOFTSTART
15n 1600
330R
BC327-25
3056
1K0
I088
7009
1000V
CONTROL 7008
2u2 50V
47p 47p
2u2 50
E E
3001
2011
I053
3046 I016 3023 I089 2024
GND4
560R
2009
2016
100K
3011
3070
3078
10K
100K
3040
5M6 14 47K 3n3
3029
2023
100n
I297
4K7
I019
25
VR25 3047 1n0 50V 6023
I032 U14 BAS316 U13 3
7010
150K I020 2022 1 TS2431
BZX384-C47 BAS316
2027
50
15n
1n0 50V
1V9(0V7)
I022
6
1K 4K7 GND4
PROTECTION
2007
100n
3009
7017
16
1K
12 A
4K7
2031
3066
3025
I023
3050 11 3
10n
10K
1K8
I024 6011 I033 2015 I036 I034 2014 I081 I082 I083 I084
K
I092
GND4 I025
100n 16
F2,5A/250V BYV28 R 2
10n 50 1n5 2000V
F BAS316 19370
F
2030
3064
I093
3R9
10K
220n
NFR25 10
3041
3
33K
I026 3071 F007 56K 220p 200
220R
3030
3034
7018 BAS316
3021
18K
6R8
10n 50
2010
6010
3067
9
2n2 50V
15K
I094
2008
3027
3013
BS42315-02
PR02
47K
10K
F2,5A/250V
F1A/250V
BYV28
2026
2048
220n
19370
19370
1084
I028 I029 2029 35V(4V)
+30V
220p 200
GND4 VB
I080
2000
G G
4
470p 250V
BD15403
5290
I290 5293
0204 F296 DC_PROT A3
SHIELDING 3.3 SHIELDING 3.3 SHIELDING 3.3
2
SHIELDING 3.3 2291 22u F297 F293 F292
MEASURED DC-VOLTAGES HEATSINK
STPS745F
1000 1001 1009 1006 2290
2292
6291
1m0
220p 50 VSND_POS
1 10n 50
NORMAL . . 2
3 3292 I291 5291 1002
22u GND_SNDF290 7
560R
TO 1M02
STPS745F
I095
I096
I098
6
H H
2294
6292
1m0
1008 5
STANDBY ( . . . ) SHIELDING 3.3
2293 5292 VSND_NEG
4
3
I292
22u
2
1
PDP AUDIO
220p 50 I293 F298 F294 F295
35V(4V)
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 36
3262
2262
220n
10K
2021 I4 3205 I6 F139 H13
4
47u 2050 G3 3206 F7 F140 G12
FROM
BT151X-500R
L4973V 16 7 8 2051 H7 3207 F8 F260 A6
A PH-B 1M10
A
1m0 50V
3265 I140
10 2054 C1 3208 F8 F264 A13
6260
3261
2261
1K0
V5.1
PROTECTION 1K0
INH VCC
I134 2055 E3 3209 F8 F265 A7
I141 17 9 TO
3263
2056 D1 3212 G7 I101 B2
10K
7260
SS BOOT
+5V_STBY_SW
I104 I130
11 AMBIENT 2057 E3 3213 I7 I102 C3
SL04
2268
220n
6268
COMP 2
+9V_STBY_SW 9000 2058 H2 3214 H7 I103 A7
OUT1 LIGHTING 2059 I2 3215 I8 I104 A8
F110
560R
12
2260
3260
2264
470n
2265
330p
3264
1K0
1u0
VFB 2061 I3 3216 H8 I105 D2
I138 5268 F264
18 3 12V6(ON) 9001
SYNC OUT2
2111 D2 3217 H9 I106 C3
I142 I133
1
100u 1M46 2112 D2 3218 I9 I107 C5
A6
3269
2269
2m2
2K7
+12V
SB540
2114 E2 3220 I9 I109 D2
19372
1110
2267
6267
4n7
4 5 6 13 14 15
VB
2266
4u7
11
2263
2118 C4 3225 H11 I111 D6
2n7
+9V_STBY
10 2121 D12 3226 G12 I112 D3
B I136 B
BAS316
2122 D9 3228 F12 I113 E2
6133
3268
1K0
9
2123 D8 3229 F11 I114 E3
VTUN
8
TO 1M46 2126 E8 3260 A7 I115 D2
+5V_STBY_SW 2133 E10 3261 A7 I116 D3
I101 7 2138 D6 3262 A8 I117 D3
SFR16
3055
10K
A2,A3
7120 BZX384-C5V6 BZX384-C6V8 VCC 2210 I7 3265 A8 I121 D8
5
A3
A3
1K
3111
TCET1102 2211 I7 3268 B12 I122 E11
10K
I158
VRA
VSA_CONTROL
1n 1000
IAKS
PMST5401 3 +8V6 2213 I4 5121 C5 I124 D7
7117
50
220p
3145
100R
3133
2K7
220p
220R 1%
220R 1%
75K 1%
1u 63
I105 0R051 I111 RES 0R51 VA
2 7
2122
2226 G11 6055 E1 I132 E9
BD21232
2W 1% I123
RES
GND HVS 3117 3063
RES
3138
3139
3122
3 CONTROL 6 VS 2227 G12 6061 I3 I133 B9
3120
1K8
1n0 50V
CTRL DRIVER 10K 2138 RES F111 1K0 2228 H12 6062 H7 I134 A10
3112
2112
I120
1K
I153
I154
3 4 I155 VCC
DEMAG SENSE 1u 10
3123
2230 I11 6111 D2 I136 B11
2274
18K
10n
I121 2123 VA
D 1K I110 330n 3121
D
F130
680R
3079
2273
100n
680R
3134
I115
I112 16
2231 I12 6112 E2 I137 B13
1 4
I124
1%
I109 3113 I116 6113 I117 I156 47K 3n3 6123 2232 I11 6113 D3 I138 A10
3130
BYW29EX
12K
7140-B
50V 2233 H13 6114 B9 I139 A9
3147
6120
10K
I108
I125
2 5 BC857BS 7121
220p 50
2200u 100V
F131
BAS316 BAS316
1M0
I126
6 3
BAS316
560K
3114
220K
RES
6111
3115
3150
2121
BC857BS 2V5 2236 H13 6123 D8 I142 B8
I113 7140-A 2 (0V3) 2237 H13 6133 B6 I147 C3
2114 A 7K5 1% 11K 1% 0323
7130 1 7134
BC847BW
3125 F121 2260 A7 6142 G4 I148 H10
3126
RES TS2431
I157
2K2
220u 25V
75K 1%
75K 1%
K
BAS316
7K5 1% F118
R 2262 A8 6202 I5 I153 D7
2113
6112
RES
22u 50V
47K 3V3
RES
3143
3140
3141
2
4K7
I131
9 2263 B8 6204 F5 I154 D7
BAS321
100n 16
A I132 (8V4)
2133
6054
I129
I114 2264 A8 6205 I6 I155 D7
5K6 1%
E E
1K 1%
TO
2126
3128
33K
3
VA 3136 8 2265 A8 6206 F5 I156 D6
RES
RES
220R
3132
3142
3148
6055 I160
Vs_unsw Adj. 47K F123 7
NC CN23 2266 B9 6211 I7 I157 E6
F119
5
2055 2057 2270 A9 6230 I11 I161 G3
2273 D13 6260 A7 I200 G3
POK
VCC_GO
F120
2274 D10 6267 B10 I201 H4
VCC
3 3051 G3 6268 A11 I202 I3
NC 3053 H4 6269 H9 I203 I2
F129 F133 F106 2 3055 B1 6270 I9 I204 I3
F VA
I211
11V5(0V7)
VCC-SUPPLY 1
VA
F 3058 G2
3062 H3
7050 G4
7052 I4
I207 I1
I208 H6
+30V 6204 6206 4 VH
I230 3063 D11 7058 I1 I209 H9
F134
3229
560R
7220
3079 D10 7059 I2 I210 G6
BZX384-C5V6 BAS316
3206 3207 3208 3209
TCET1102 TO 3083 H2 7110 C3 I211 F5
I212
150R
3228
3
2K7 2K7 2K7 2K7 I231
PDP
F135
3085 I1 7117 C4 I213 H6
0342 0352 3086 I2 7120 C5 I214 G7
VA 1 1 VA (DISPLAY) 3087 I1 7121 D8 I215 H7
87V F113 1200 I210 I233 2223 3088 I2 7130 E9 I216 H9
F136
2 2
(0V5) 7200 NC NC 3106 C2 7134 E10 I217 G8
T2A/250V 7212 100p 50V
BSH114 3 3 3107 C2 7140-A D6 I218 H7
3058
5220
1M
6225
6142
1 8
S3J
SEQUENCE 105V VCC DRAIN 7217 2 4u7 CN52 3109 C2 7142 D7 I220 H5
220K
3200
7050 1 14
I161 I200
VS I234
12K 1%
3051 (0V) I238 2227 3110 C3 7200 G6 I221 H7
PDP
F140
PSMN035 2 7 PSMN070 5 5
STPS20L40CFP
1600
GND HVS 3111 C6 7202 H5 I222 I5
DISCHARGE 1
2218
3224
13
CONTROL 3149 (DISPLAY)
220n 16
BZX384-C18
1u 100
2050
2212
3n3
50V
4 12
I235
3113 D2 7217 G9 I224 I8
22n
1K
I217 2226
4R7 3226 7 F137 7
2058
4 5 S
I213 DEMAG SENSE I216 100p 50V VCC VCC 3114 D3 7220 F10 I225 I1
0V 6216 5 11
87V 2229 100n 16 10K 1 3115 D3 7227 H12 I230 F11
(0V5) I209 5229 PH-B PH-B
(0V5) 7 8 TS2431 7227 3116 D3 7230 I12 I231 F11
I215 BZX384-C18 F138 F139
3117 D4 7260 A9 I233 G11
I218
BS29238-00 I237 K
220u
2m2 25
3217 470u 2V5(0V3) 2 R
3216
16V VCC
10u 16V
10u 16V
10K 3120 D7 9001 A13 I235 G11
11K 1%
H H
2225
3202
6.3V
6.3V
2228
2236
2233
2237
120K
47R
3214
10u
10u
2217 3121 D8 9002 C6 I236 G9
3225
+5V_STBY_SW 3
3122 D8 F102 D13 I237 H11
3083
232266293
1K0
I240 I148
BZX384-C18
I219 330n
600V
I208
+t
I221 16
3062
6062
2051
100n
BYG10
6269
6213
I201
0R051
3218
3220
10K
33R
BAS316
3219
2219
6202
10K
10p
I223 I245
2214
BYG10
0V1(8V)
3213
5V2(0V)
6270
33K
2u2 50V
2203
I222
I244 1 3 +8V6
104V(0V) IN OUT 3134 D10 F120 F12
3085
6205
2205
47K
COM
I
47u 16V
47u 16V
I204
MEASURED DC-VOLTAGES
2231
2213
2230
470u
2234
2235
RES
2 3136 E10 F122 C12
4n7
1u0
1u0
16V
100R
3203
2210
100K
3204
BZX384-C18
6211
7058 7059
3139 D6 F124 C12
2061
6061
PMST5550
BC847BW SS14 NORMAL .
100n 16
3088
47K
I243
3142 E7 F127 E12
3143 E6 F128 E12
STANDBY . 3145 C6 F129 F13
3146 C6 F130 D12
E_14650_031.eps
3104 313 6017.3 180604
1 2 3 4 5 6 7 8 9 10 11 12 13 14
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 37
Part 1
E_14650_024a.eps
170604
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 39
Part 2
E_14650_024b.eps
170604
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 40
Part 3
E_14650_024c.eps
170604
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 41
Part 4
E_14650_024d.eps
170604
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 42
E_14650_025.eps
3104 303 3904.3 141004
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 43
Ambi Light
1004 D1 2002 A3 2021 A7 2033 B8 2045 C8 2057 C8 2069 C8 2081 D8 3002 D1 3014 B7 3027 D2 5014 B10 6009 C6 7017-1 D7 F008 E1 F020 B2 F032 E10 F046 C5 I006 B5
1010 A2 2003 C2 2022 A7 2034 B8 2046 B8 2058 C8 2070 D7 2082 D8 3003 C4 3015 A7 3028 C2 5015 C10 6010 E5 7017-2 D7 F009 E1 F021 B1 F033 E10 F047 D5 I007 A6
1050 C4 2004 D2 2023 A8 2035 B8 2047 B8 2059 C8 2071 D7 2083 D8 3004 E6 3016 C2 3029 A4 5016 D10 6011 E6 7018 A5 F010 E1 F022 A1 F034 E7 F048 A5 I008 A6
1M08 A1 2005 D4 2024 A8 2036 A9 2048 B9 2060 D7 2072 D7 2084 D9 3005 E6 3017 B4 3030 B4 6000 A5 7001 C3 7019 B5 F011 E1 F023 A2 F035 D7 F050 B4 I009 B6
1M10 B1 2006 D4 2025 A8 2037 A9 2049 B9 2061 D7 2073 D8 2085 D9 3006 D6 3018 A4 3031 C5 6001 B5 7002 A2 7020 D5 F012 E1 F024 A2 F036 D7 F060 D5 I010 B6
1M11 B10 2007 E6 2026 A8 2038 B8 2050 C7 2062 D7 2074 D8 2086 D8 3007 D6 3019 A4 3999 E4 6002 C5 7009 B5 F001 C4 F013 E1 F025 A1 F037 C7 F098 E4 I011 D6
1M12 D10 2008 E6 2027 A8 2039 B8 2051 C7 2063 D8 2075 D8 2087 D8 3008 C6 3020 A4 5002 A9 6003 C5 7010 C5 F002 C4 F014 D1 F026 A3 F038 C7 F099 E5 I012 D6
1M13 C10 2009 C6 2028 A8 2040 C7 2052 C7 2064 D8 2076 C8 2088 D8 3009 C6 3022 E2 5004 A10 6004 D5 7011 D5 F003 C4 F015 D1 F027 A10 F040 B7 I001 A2
1M14 E10 2010 C6 2029 A8 2041 C7 2053 C8 2065 D8 2077 C8 2089 D8 3010 C7 3023 E2 5005 B10 6005 D5 7015-1 A7 F004 C4 F016 C1 F028 B10 F041 B7 I002 C2
1M48 C1 2011 B6 2030 B7 2042 C7 2054 C8 2066 C9 2078 C9 2090 D9 3011 B7 3024 D4 5006 D10 6006 B6 7015-2 A7 F005 C2 F017 C1 F029 C10 F042 A7 I003 D2
1M49 E1 2012 B6 2031 B7 2043 C8 2055 C8 2067 C9 2079 C9 2091 D9 3012 B6 3025 C4 5007 A9 6007 B6 7016-1 B7 F006 D2 F018 B1 F030 E10 F043 A7 I004 D5
2001 A2 2020 A7 2032 B7 2044 C8 2056 C8 2068 C8 2080 D8 3001 C1 3013 B6 3026 D2 5008 A9 6008 C6 7016-2 C7 F007 E2 F019 B1 F031 E10 F045 B5 I005 C5
1 2 3 4 5 6 7 8 9 10
AMBI LIGHT
15u
15u
15u
B11B-EH-A
F027
5007
5008
5002
11
I007 3015 F043 10
9
3018
3019
3020
2020 220n
2021 220n
2022 220n
2023 220n
2024 220n
2025 220n
2026 220n
2027 220n
2028 220n
2029 220n
2036 220n
2037 220n
10K
10K
10K
RED 1K2 8
7
8
7002 7018 5004
A LD1117DT BC847BW I008 7015-1 1 4
7 A
6
1M08 I001 2 SI4946
F025 1010 F026 3029 F048 5
3 2 +5V 2
1
1 IN OUT F042 4
TO 2nd AMBI
1m0 16V
3
2002
100n
LIGHT PWB COM 3 6
2030 220n
2031 220n
2032 220n
2033 220n
2034 220n
2035 220n
2038 220n
2039 220n
2046 220n
2047 220n
2048 220n
2049 220n
3 F023 2001 2
(OPTIONAL) 4 SI4946
4 BAS316 1
F022 1 7015-2 EFD20-01
B4B-PH-K 5014 1M11
5
6
I006 6001 3014 F041
1 13
F045 1K2
BZX384-C12
BZX384-C12
3017 BAS316
3012 220R
3013 270R
2011 6n8
2012 6n8
7009 3
BC847BW TO
6006
6007
4K7 * * CCFL
1M10 5 9
F021
B TO 1
J-IT21A B
1M10 2 F020
3 F019
4 F018 I009 3011 F040
+5V
2040 220n
2041 220n
2042 220n
2043 220n
2044 220n
2045 220n
2056 220n
2057 220n
2058 220n
2059 220n
2066 220n
2067 220n
B4B-PH-K F050 BLUE 1K2 5005
3030
7
8
7019 1 4 F028 B11B-EH-A
BC847BW 7016-1
4K7 I010 11
2 SI4946 2
10
1
F038 9
3028
3016
3 6
10K
4K7
7001 I005 8
6002
11
3
P87LPC760BDH
2050 220n
2051 220n
2052 220n
2053 220n
2054 220n
2055 220n
2068 220n
2069 220n
2076 220n
2077 220n
2078 220n
2079 220n
7
1M48 VDD 4 SI4946 EFD20-01
3025 F046 BAS316 6
FROM
B3B-PH-K
F017 100R I002 F001 7010
BC847BW
7016-2 5015
5
MICROCONTROLLER 1 13
5
6
C 1M49 1
9 14
4K7 6003 3010 F037 4 C
2 3001 TXD CIN1B 3
2003
8 13 F003 3
1n0
1K2 2
BZX384-C12
BZX384-C12
3 RXD CIN1A BAS316
3008 220R
3009 270R
7 12
2009 6n8
2010 6n8
F016 SCL CMPREF F002 F029 1
6008
6009
F005 T0 CMP1
10 F004 * * 5 9
3031
6 1M13
4K7
INT0 1050
P0<3:6> DSX840GA J-IT21A
SDA 3003
5
CLKOUT F060
P1<0:3> X2 220R I011
100R F006 20M 3007 F036 TO
F015 2 4
RST X1 CCFL
3024
220n
2061 220n
2062 220n
2063 220n
2064 220n
2065 220n
2080 220n
2081 220n
2082 220n
2083 220n
2084 220n
2085 220n
7020
4K7
7
8
BC847BW
2004
1 P2<0:1> 5006
1n0
P1.7
I012 7017-1 1 4
2060
VSS 2 SI4946
F047
2005
2006
3
2
1K0
1K0
3026
3027
15p
15p
1
D I004
F035 D
6004
3
3 6
2070 220n
2071 220n
2072 220n
2073 220n
2074 220n
2075 220n
2086 220n
2087 220n
2088 220n
2089 220n
2090 220n
2091 220n
4 SI4946
BAS316 7017-2 EFD20-01
5016
5
6
6005 3006
1004 1 13
F014 7011
1K2 1M12
BZX384-C12 F030
BZX384-C12
1 BC847BW BAS316 F034
3005 270R
3004 220R
F013
2007 6n8
2008 6n8
3
2 1
6010
6011
NC 3 F012 * * 2
5 9
4 3022 3
5 F031
F011 100R J-IT21A B3B-EH-A
B5B-PH-K TO
E F098 3999 F099 Panel 3104 328 3104 328 CCFL E
1M49
F010
10K
*Item 36647 36892
F032
1M14
1
TO 1M49 F009
2 F008 2007 X 1
SSB 3 F007 3023 2008 X 2
(2K5 SETS) 4 2009 X 3
B4B-PH-K
100R
2010
2011
X
X
WARNING HIGH VOLTAGE F033
B3B-EH-A
TO CCFL
2012 X
E_14620_160.eps
3104 313 6072.4 X = PRESENT, = NOT PRESENT
210305
1 2 3 4 5 6 7 8 9 10
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 44
Layout Ambi Light (Top Side) Layout Ambi Light (Bottom Side)
E_14620_162.eps
3104 313 6072.4
E_14620_161.eps
081004
3104 313 6072.4 131004
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 45
B2(3x),B15a(4x)
1406 E4 3463 B4
B2,B15a(2x)
1407 E5 3468 H11
1408-A G3 3473 D11
B3a,B6a
B3a,B6a
1408-B G3 3474 F8
1409-A C3 3475 G9
B14b
B14b
B2
1409-B D3 3476 H9
B 1410-A E3
1410-B F3
5309 H14
5310 H14
B5a
B13a
1411 G6 5311 I14
SOUND-OUTPUT
BG
LMN
SCL-F
AGC
SDA-F
AGC-MONITOR
SC1-STATUS
SEL-SVHS-RR_STATUS2
VA50
B14c
HA50
2350 2300 F7 5312 F14
R-SC1_V-IN
2302 H14 5318 F7
A 2351 100n G-SC1-IN_Y-IN
B14c A 2305 C11 5401 D2
2316 C11 5402 E5
100n 2352
B-SC1-IN_U-IN
B14c 2322 C11 5403 H2
2327 D12 5404 B6
+5VS +8V_VDP 100n 2339 H7 5405 B6
+8VP +8VP 2350 A11 5406 E5
2388
220n
2351 A11 5408 D6
c002
7408 7409
5416 2352 A11 5411 C1
100R
9407
9410
3377
+8V +8V_CON I453 BC857BW 2353 I12 5416 B3
3415
100R
3380
2K2
30R 2354 G12 6402 E2
2372
2355 C12 6403 D2
1u
2391
100n
2392
F407
F408
3400
1u0
I445 I444 F413 I443 5404 I441 I455 2356 F10 6404 G2
I411
2375
2374
7V7 BC857BW 2357 F11 6405 E2
22n
1u0
F440 I454
100R
3376
V9 2358 F11 7307 G11
6u8
2387
3448
2378
100n
2371
1u0
10K
4R7 2359 F11 7320 F9
4n7
B B
3463
3378
100R
2373
100n
2360 F11 7322 E7
3408
4K7
15K
I421
2394
2377
100u
+8VP 2361 F13 7323 D9
1u0
4V1
3R9 I452 I440 2362 F13 7401 F2
5405
680K
3444
3447
3449
5V0
2364 C12 7402 H7
2389
39K
2K2
7V7
V10
+5VCOM
1u0
I422
5V0
0V4
2365 F7 7403 D2
+5V_VDP 6u8 I442 2366 F8 7405 H1
2376
100n
3402
3401 2367 F8 7406 F5
3441
5 9 45 11 44 35 33 31 48 15 17 19 22 46 47 58 61 60
2425
100u
22K
2368 F8 7407 G5
QSS_AM
GND_2
+8_2
+8_1
GND_1
DEC
DIGDEC
DIGGND
ADSEL
SW0
SW01
SCL
SDA
AV1
AV2
HPLL
HA
VA
100K 2369 F8 7408 A11
F411 B14c 2370 F8 7409 A12
1409-A SYNC 2371 B10 7410 H5
OFWK3953L A411 SUPPLY CTRL 2305 9423 FBL-SC1-IN B14b,g,B15a 2372 B10 7411 D6
64
SAW-FILTER AUDIO SIF2 36 2373 B8 7412 F14
A412 2401 R1IN 2355 SC2-R_C-IN_AV2 2374 B8 7413 D13
10n 63 100n
C 2412 SIF1 C 2375 B8 7414 D11
IF-TER 2 7 2416 1u0 37 B14b,g,B15a
G1IN 2316 9424 10p 2376 B7 7415 H9
B13a 1
4n7 AGCSIF 2377 B6 9318 G11
2409 1u0 I402 38
+8VP 3 8 A409 2
VIF1
HIP B1IN
39
100n 2364 SC2-G-IN 2378 B7
2379 F12
9319 G11
9322 G8
5411
0u33
OUTP SWITCH
41
9415
4
F437
2K7
3460
3461
6
3K3
1K8
6403 2V8 2383 10p B14b,B15a 2385 G13 9406 F13
PLLRILT 43
1 4 5 6 9 10 13 14 15 1811 16 1 6 2387 B7 9407 B4
MODULATOR 100n 390R 7 B2IN
12 17 7323 SC2-FBL-IN 2388 A11 9408 H7
VCO1 9426 +8VP
9416
BA792 40
3416
2405
6R8
COIL
4n7
2418
2419
6u8
5p6
12p
D VCO2 10p 2327 I457 D
3 4 IF DEM 49 2392 B8 9412 G6
I447 YOUT
62 2394 B6 9413 F6
2432
100n
7414 7413
3414 TUNERAGC 50 2401 C6 9414 E7
7403 BC847BW BFR93AW
0V4 I446 F401 3437 UOUT B2,B6a 2402 G6 9415 C3
7411 10
2413
47u
BC847BW VIFOUT Y50
4K7 2403 F9 9416 D5
3462
51
1K2
BC847BW VOUT
1K0 2404 D6 9417 D6
3473
9417
1K0
V1 2405 D1 9418 E5
I6 B2,B6a 2406 G2 9419 E7
+8VP F404
LMN GROUP Y50 2407 G3 9420 F5
270R
3436
B2(3x) 12 DELAY COR. 57 B6a
3419 IN X3.579 F405 2408 H3 9422 H6
B15a(4x) U50 2409 C6 9423 C11
13 56 B6a
390R OUT X3.575 F406 I424 B2 2410 G9 9424 C11
1410-A
3410
9403 COMB-Y_CVBS-OUT
4K7
9419
6402 5402 5406 I448 2417 2413 D5 9427 G7
E 2 LUMA & CHROMA PROC. 54 E
X4.43 2414 H6 9428 H7
7 +5VS
2422
100n
3u9 3u3 2415 H6 A400 G2
1SS356 470n 9414 I/O SWITCH 52 2416 C6 A409 C5
1SS356
3
6405
2417 E6 A410 C5
L1101-98006-0E1
L1101-98007-0E1
L1101-96152-0E1
8 TPWKA TPWKA +8VP I467 53 2418 D6 A411 C4
COMBOUT
CVBSOUT
SVBCOUT
SEC_DEC
CCOMBIN
YCOMBIN
Y_CVBS3
Y_CVBS4
3439
3450
4M433619
7322
3G582056
3G575611
1 3 1 3
1K2
2419 D7 A412 C4
NTSC M
HC-49/U
1K
PIPOUT
SCOUT
3434 I O I O
CVBS1
CVBS2
3M58
9402 14
PAL M
1305
1306
1307
1308
PAL N
BC847BW 2420 G8 F401 D7
SYS1
SYS2
+8VP CVBSINT
100K
3393
2 2 2421 G14 F403 C7
C3
C4
4K7 7401 GND GND 2422 E13 F404 E12
1410-B
9401
2384
100n
+8VP
V2
0V
5V
7412 2425 B1 F407 B10
9406
1 4 5 6 9 10 13 14 15 1811 16
2426 H13 F408 B10
100R
3370
2360
2380
2382
2361
BC857BW
2367
100n
2369
100n
2356
2357
2358
2359
2379
2381
2362
12 17
100n
100n
3n3
15p
1p2
15p
1p5
15p
1p5
12p
1p2
I460 3382 2427 I14 F411 C6
2365
100n
2403
100n
3451 I426
F F 2428 I14 F413 B6
120R
3445
I449 7320
I428
3421 I461 560R 2432 D11 F437 D1
I464
3407
2370
100n
5K6
150R
9420
9413
3452
9404
2366
100n
2368
100n
5K6 2434 2434 F9 I401 H9
3474
10R
3413 2435 G9 I402 C7
7406 I427
2300 47p 5318 100n 5312 2436 C6 I411 B4
BC847BW
I417
BC847BW 270R 3300 G7 I415 H8
+8VP +5VCOM
2421
3300 33u +8V_VDP 33u 3301 I12 I417 F8
7407
9322
3422
RES
1K0
2420
3303 H10 I421 B8
470R
3385
2423
BC857BW
6p8
10p
1408-A 1K0 3370 F9 I422 B8
9412
OFWK3953L 3417 I462 3371 H9 I424 E13
+5VCOM
3409
9319
4K7
150p
3475
10R
5K6 3376 B9 I426 F14
2406 A400 2354 2385 3377 B10 I427 F14
3406 2 7 +8V_VDP 3378 B10 I428 F13
G +8VP I465 7307-p4 G 3380 B7 I430 H13
27R 220p +8VP 100n 100n B2
9427
4R7 2402
330p
9318
3 8
2435
3385 G7 I432 I12
3420
1n0
1K0
3412
TDA9181 6 5
2407
2410
100u
2433
100n
3393 F11 I433 I11
68p
3456
VCC VDD
3433
Y|CVBSO B2
1411
3435
14 3402 B1 I440 B4
4K7
NC 3405 H5 I442 B7
3371
7402
47R
3 1 COUT-3D
BC847BW
100n
7405 1 CIN
I451 100n I431 3409 G2 I446 D5
470R
3372
9428
BC847BW
4M5 I435 7 SC 3410 E3 I447 D5
SAND- FILTER CLOCK
H 3423 5309 H 3411 D2 I448 E6
I415
100K
100K
3405
3457
9408
3303
3468
RES
1K0
4K7
B2(3x)
6
100MHZ
10p
5K6 3413 F9 I450 H6
560R
3476
B15a(4x) B5a
OUTSEL
FSCSEL
3414 D2 I451 H5
2339
8
DGND
10p
AGND
I450 3415 B4 I452 B1
SYS1
SYS2
5CCE 5310
FSC
9422
2408
COUT-3D
I401
3p3
2426
RES
5403
7
10p
13 4 9 8 11 10 15 3418 D7 I455 B12
560R
3404
YOUT-3D
4V2
4V2
5311
3420 G6 I457 D14
1
2427
I433 100MHZ 3421 F4 I458 E4
B2
CVBS-SC2_MON-OUT
100K
3301
10p
2353
100n
COMB-Y_CVBS-OUT
3422 G9 I460 F2
Y-CVBS-SC2_AV2-IN
CVBS-SC1_AV1-IN
B14a,B14g,B15a
B2(3x),B15a(4x)
Y-CVBS-FRONT-IN
3423 H1 I461 F5
SOUND-OUTPUT
CVBS-3D-COMB
COUT-3D-COMB
C-SC2_SVHS-IN
CVBS-TER-OUT
YOUT-3D-COMB
COIL 40.4 SUPPRESSION 3433 G1 I462 G5
COMB-C-OUT
2428
AV3-CVBS-IN
CVBS-AV3-IN
3434 E2 I463 H5
C-FRONT-IN
I I
CVBS-TXT
CVBS-TXT
3435 G5 I464 F9
QSS_AM
PIP-OUT
7307-p4
3436 E6 I465 G9
SYS1
SYS2
SYS1
SYS2
3437 D7 I467 E7
LMN
FSC
FSC
BG
SC
SC
3439 E6 c002 A8
3441 B4
3444 B11
B2(2x),B5a
B2,B15a(2x)
B14a(2x)
B14b
B14a,b,c(2x)
B14b
B14a
B14a
B2
B2(2x),B5a
nc
B14b
B2
B2
B2
B14a,b
B2
B2
B2
B2
B2
B2
nc
nc
nc
B2
B2
B6a
3445 F6
B15a
3447 B11
3448 B12
3449 B12
3450 E14
3451 F13
E_14620_084.eps
8204 000 8345.4 070704
3452 F14
3456 G5
1 2 3 4 5 6 7 8 9 10 11 12 13 14
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 46
SSB: PICNIC
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 1702 K6 3928 I3
1703 K6 3929 I3
PICNIC 1710 L5
2707 C2
2708 I16
2709 A8
3930 J3
3931 J4
3932 J4
3933 J4
2710 C17 5703 A8
F107 5703 2711 C17 5705 J6
+3V3_DCDCFBXA
5
A 7706 A 2712 C15 5706 H5
74LVC1G14GW I802
3740 6701 3909 3V3_FAULT_FBX B3e 2713 G2 5707 I4
1 VCC
NC
+3V3_DCDCFBXA 4K7 BAS316 100R 2714 G3 5708 J4
I813 2 A Y 4
3732 2716 C16 5714 H6
9729
7705
B3b
2917
100n
2918
res 220n
2709
100n
RST-FEM BC847BW GND 2717 C15 5723 E5
47K
B3d RES
2718 H3 5724 F5
RST_COL B3a(2x),c B3a,b
3
3761
B3c I720 CLK32G CLK32NE 2719 J3 5725 C8
RST_PIC_EAG 9809
100R 2720 J3 5726 C7
B3a(2x),c B19b(2x)
CLK32G 9820 CLK32P_EPLD 2721 K3 5727 D7
+3V3_DCDCFBXA 2722 K3 5728 D7
B B
2724 F6 6701 A8
+1V8FA
2725 C16 6703 J7
RES
3751
9700
3K3
2726 F13 6710 H6
2727 E11 7702 H17
120K
3748
7708 3752
5726 +5V2Pr
BC847BW 2731 F9 7703 C4
+3V3Pr
AD(00)
AD(01)
AD(02)
AD(03)
AD(04)
AD(05)
AD(06)
AD(07)
3734 F145 F706 1R0 2732 C7 7705 A6
+3V3PC
RES
B19d 1K0 I814 100R F707 3753
2733 I14 7706 A7
5725
RST-FBX 7703
+3V3_DCDCFBXA
BC847BW 2734 K14 7707 D5
3722 1R0
13
14
15
18
19
20
21
22
17
12
26
100R
3747
3736
2743
100n
100n
47K
1
2735 L9 7708 B6
2744
100R
3754
VCC Q0
Q1
Q2
Q3
Q4
Q5
Q6
Q7
C C
FBX
2736 M10 7709 C5
16
2707
3733
NC
VSS
1K0
22p
32
2737 G6 7710 D6
100n
100n
100n
7711
2725
2711
100n
2710
100n
+3V3_DCDCFBXA
100n
PROM
2712
2717
2716
2738
2738 C18 7711 C8
2732
2745
100n
100n
+3V3Pr
+5V2Pr
1n0
M27C512
100K
3903
I815 2740 I5 7712 E7
SOFTWARE
3737 F708 B3a,d
7709 CL16
A10
A11
A12
A13
A14
A15
G_
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
E_
2741 I5 7713 I9
3746
3K9
BC847BW 1K0
RES
B3a,b
3749
5727
5728
CLK32NE
3K9
11
3
8
23
25
2
10
29
28
24
27
30
31
3738
1K0
7714
2743 C6 7715 G5
11
12
14
15
34
37
43
51
62
64
75
83
89
92
MS81V04160A
F709 VCC 2744 C6 7775 H4
100R
3760
RES
7710 2745 C8 7776 I3
BC847BW 2754
13 1 2746 D8 7777 J4
D 7707 CLK32FM1 63
SWCK
8
D
I820 I805 1n0 SRCK
BC847BW
B3a DUAL FIFO 18 2747 H5 9700 B7
2746 9728
85 25 2748 F6 9701 F5
MODE1
41
MODE2 (262,214 x 8) x 2 26
2749 H6 9702 E6
3739
100n
3755
3741
3742
3743
3750
RES
3756
36
4K7
22K
3K9
12K
10K
10K
20
10
19
18
17
16
15
14
13
12
32 38 2754 D8 9703 H7
WE1
DA(15) MF(17) 45 40
RE1 RES 2757 I7 9706 L6
B3a,b 31 42
Vcc
GND
IE1
DA(14) B3a(2x) 46
OE1
NC 47 9727 +3V3PC 2800 I6 9707 I5
3905
RSTW
+3V3_DCDCFBXA
+3V3PB 30 50
+1V5_FBXA
4K7
+1V8FA
+3V3_FBXB
74HC573
DA(13) RSTR_O 44 76
RSTR1
B3a,b,c 79 2806 H6 9709 J5
7712
1D
EN
C1
DA(12) 94 84
WE2 2807 K7 9710 F4
MF(17) 81 86
E RE2 E
100n
2727
1
9
B3a,b
11
95 88 2837 J18 9720 L3
+2V5_FBXA
F784 IE2
9702 B3a(2x) 80 90
AD(00)
AD(01)
AD(02)
AD(03)
AD(04)
AD(05)
AD(06)
AD(07)
OE2 2838 K17 9726 G4
B3a(2x),b B3a DA(11) RSTW 96
RSTW2
100
3702 10R
3711 1K0
MF(17) ALE B3a RSTR_O 82
RSTR2 2839 K18 9727 E18
RES intern
B3e,B19d 5723 DA(10) B3a,b,c
ALE 2840 L3 9728 D15
RES
HD_E_T0
F787 B3c
+5V2Pr
INT1
DA(00)
F786
AD(00)
AD(01)
AD(02)
AD(03)
AD(04)
AD(05)
AD(06)
AD(07)
100n
2731
DA(09) 29 52 MF(16) 2841 M3 9729 A4
5724 DA(01) 10 10
2748
100n
28 53 MF(15)
+3V3Pr DA(02) 11 11 2881 J6 9767 I18
9710
F151
FM1
DA(03) 12 12
B3b,c(2x),d +3V3PB 24 56 MF(13) B3b 2900 I4 9768 H17
2726 100n DA(04) 13 13
SN-DA F785
22
14 14
57 MF(12)
B3b,c(2x),d SN-CL DA(07)
DA(05) 21 58 MF(11)
2901 I4 9769 I16
DA(06) 15 15
20 60 MF(10) 2902 J4 9770 H16
160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 DA(07) 16 16
F B3d SCL-D 19
17 17
61 MF(9) F 2915 I5 9771 H16
3758
4K7
T1
T0
INT1
INT0
P0-0
P0-1
P0-2
P0-3
P0-4
P0-5
P0-6
P0-7
VDDO3
P2-0
P2-1
P2-2
P2-3
P2-4
P2-5
P2-6
P2-7
VSSD4
ALE
PSEN
EAN
VDDD4
VSSD3
VSSO5
UVC0
UVC1
UVC2
UVC3
UVC4
UVC5
UVC6
UVC7
UVC8
VDDO2
YC0
YC1
B3d 2724 DA(15)
SDA-D 97 74 MF(1) 2916 J5 9772 H16
DA(14) 20 20
98 73 MF(2)
F115 3709 F128 100p 1 SN-DA YC2 120 DA(13) 21 21 2917 A7 9809 B5
SCL-F DA(06) 99 71 MF(3)
DA(12) 22 22
100R 9701 P0 P2 2
23 23
70 MF(4) B3b 2918 A7 9820 B14
2 SN-CL YC3 119 DA(11) 4 69
F114 RES BUS C DA(05) 24 24 MF(5)
SDA-F
3710 DA(10) 5 68 MF(6)
2920 J7 9825 I4
F129 2737 3 VSSO6 YC4 118 DA(09) 25 25
DA(04) 6 66 MF(7) 2926 L17 9826 J3
100R DA(08) 26 26
100p 4 SCL MICRO-PROCESSOR YC5 117
7
27 27
65 MF(8)
2927 M17 9827 J3
2713
2714
CLK
res 22p
22p
DA(03)
9726
3
9
10
16
17
23
33
35
39
48
49
54
59
67
72
77
78
87
91
93
6 UP-RST YC7 115 DA(01) 2931 I5 F108 H2
G B3a(2x) G
RSTW
7 WD-RST YC8 114 DA(00) +3V3GA 2935 L5 F109 I2
+3V3PA 3719 F155 F148 3700 K14 F110 J2
7715 8 RSTW WE-C 113
+3V3GA 3701 L6 F112 K3
100R
3704
B3c(2x),d RSTR_I 3K3 PMBT2369 F156 9 RSTR IE-C 112 F149
3702 E11 F114 F3
B3e +3V3PA 5714 F788 10 FBL
3V3_FAULT_FBX 2806 N.C. 9703 VSSO4 111 3703 H16 F115 F3
2747
3703
4K7
RES 3704 G17 F118 I7
68p
I727
2749 100n 11 VDDA1 BACK END RE-D 110
9768
+5V2Pr I810
3720 3705 H18 F119 K3
+8VPA 100n F157 12 Y-OUT YD8 109
10K 3706 I6 F122 L6
+3V3GA
13 VSSA1 PEAKING YD7 108
B3a 7702
CY2302S 3709 F3 F123 L6
7
H 3721 100R I804 BAS316 CLK32P B3a H
680R 3724
F158 3 X DAC 9771 VDD CLK32FM1 3710 F3 F124 L6
100R
6710 14 U-OUT YD6 107
9772
3705
B6a 3713 3923 1 100R
F108 +3V3GA FBIN FREQ. 3711 E11 F125 L6
15 V-OUT YD5 106 2 MULTI. B3b,c
180R BC857BW 3924 F159 IN CLK32 3712 L7 F126 M6
& ZDB
Y-PIP+MAIN-IN 7775 5706 MUX B3a(2x),c
3713 H3 F127 M6
2718
4 6
15p
CLK32G
100K
3922 220R 0 1
9767
9770 3714 I3 F128 F6
6u8 17 BGEXT YD3 104 FS OUT
5 8
220R 1 2 3715 J3 F129 G6
2708
100n
9707
F160 18 H-D 7713
680R
YD2 103
2901
3925
PICNIC
9769
3
680R 19 V-D YD1 102 3717 J3 F145 C6
47p
F161
2931
150p
100n
U-PIP+MAIN-IN
3929 220R F118 22 VDDA2
SAA4978H HISTOGRAM UVD8 99 3721 H6 F152 L7
6u8 22n
680R
2900
3926
2915
150p
150p
47p
180R
24 VDDA3
ANALOG UVD6 97 3724 H18 F157 H7
2719
100R 6703
NOISE
100K
5705 6u8
3 X ADC
15p
3717
9709
9826
REDUCTION 3726 K3 F159 H7
6u8
680R
2881 27p 26 VIN UVD4 95
V-PIP+MAIN-IN 3931 100n 100n 3727 K4 F160 I7
B6a F110 3715 27 VSSA3 UVD3 94
B5a
J 3930 220R VD-EPLD J 3728 K3 F161 I6
680R
2902
3933
VD-OTC
15p
220R
CLK TIMING
TBC/SRC 3732 A6 F163 I5
47p
2837
100p
B3e 9827 B19c,d
3V3_FAULT_FBX 30 HREF-EXT
TIMING UVD0 91 3857
HD3-OTC 3734 C4 F165 J5
B2,B6a HA50 F119 3727 10R 3736 C5 F166 J5
31 VDDA4 VSSD2 90
2838
100p
150R 3723 MUX A139 3737 C6 F706 C6
3725
32 VSSA4 CLK32 89
2721
100p
2807
3K3
CLK32P B3a(2x),c
CLK 3738 D5 F707 C6
1M0 RES F140
100n
100p
1K2
2839
100p
1702 B19c
1 3 37 TRST UVB0 84 G-OSD
3859 3746 D6 F786 E8
B3c,d
9706
RES 2929
RES 18p
18p
2926
100p
VA 9720
B19b 39 TDI UVB2 82
SDA-EPLD
2 BUS A BUS B 3749 D4 I720 B4
SDA-F
3826 1710 40 TDO UVB3 81 3750 D6 I727 H6
100R N.C. 1
B5a 3751 B6 I802 A8
VDDO1
VDDD1
VSSO1
VSSO2
VSSD1
3701
1K0
res 22p
2FHB-GFX
2840
WE-A
WE-B
UVB8
UVB7
UVB6
UVB5
UVB4
L L
UVA0
UVA1
UVA2
UVA3
UVA4
UVA5
UVA6
UVA7
UVA8
2
YB8
YB7
YB6
YB5
YB4
YB3
YB2
YB1
YB0
YA0
YA1
YA2
YA3
YA4
YA5
YA6
YA7
YA8
B19c 3860
3712
3753 C6 I804 H6
47K
F123 B-OSD
3
B19b 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 B5a 10R 3754 C6 I805 D6
SCL-EPLD F124 F152 2FHFB-GFX
4
2928
100p
3827 B19c 3861 3755 D5 I810 H5
2735
100n
100n
100R 10R
2841
3758 F7 I814 C3
res 22p
F126 +3V3PB
6
2927
100p
3759 I6 I815 C5
HREF_EXT
7 F127
CLK-AS
UVB(7)
UVB(6)
UVB(5)
UVB(4)
UVB(3)
UVB(2)
UVB(1)
UVB(0)
UVA(0)
UVA(1)
UVA(2)
UVA(3)
UVA(4)
UVA(5)
UVA(6)
UVA(7)
UVA(8)
TDOC
TDO
TRST
WE-A
WE-B
YB(8)
YB(7)
YB(6)
YB(5)
YB(4)
YB(3)
YB(2)
YB(1)
YB(0)
YA(0)
YA(1)
YA(2)
YA(3)
YA(4)
YA(5)
YA(6)
YA(7)
YA(8)
+3V3PB
TMS
TCK
B3d
B3c,d,B19d
B3b,c,d
B3b,c,d
B3b,c,d
3827 L3
3856 J18
3857 J17
3858 K18
3859 K17
3860 L18
3861 L18
3903 C5
N
* SEE MAPPING I1 ON B3c N
3905 E6
3909 A9
3922 H3
3923 H4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 47
2875
100n
2876
100n
2877
100n
2887
100n
2888
100n
3876 C7
3880 F4
B B 3881 F4
3882 F4
B3a,c
B3c,B19d B3c
B3a
3883 F5
3884 G5
YG(6)
YG(7)
UVF(0)
UVF(1)
UVF(2)
UVF(3)
UVF(4)
CLK32
CLK32NE
3885 E4
3886 E4
3887 E5
RES
9808
+1V8FA +1V8FA +1V8FA
3888 E4
100R
3876
3889 E5
3890 E4
C C
3891 E4
7760 E6
9808 C7
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
9810 F4
YG6|DPIP6
VSSM4
VDDM4
VSSM3
VDDM3
YG7|DPIP7
VD
UVF0
UVF1
VSSA
UVF2
UVF3
VSSD3
VDDD3
VSSS2
VDDS2
CLK32
VSSE4
UVF4
9811 G5
VDDA
UVF(5) B3c
UVF(6)
YG(5) 1 80 UVF(7)
YG5|DPIP5 UVF5
B3c,B19d YG(4) 2 79 +3V3FA
YG4|DPIP4 UVF6
+3V3FA 3 78
VDDE1 UVF7
2878
100n
4 77
VSSE1 VDDE3
2886
100n
YG(3) 5 76 YF(0)
D 6
YG3|DPIP3 YF0
75
D
YG(2) YG2|DPIP2 YF1 YF(1)
YG(1) 7 74 YF(2)
YG1|DPIP1 YF2
YG(0) 8 73 YF(3)
YG0|DPIP0 YF3 B3c
UVG(7) 9 72 YF(4)
UVG7|QPIP7 YF4
UVG(6) 10 71 YF(5)
UVG6|QPIP6 YF5
UVG(5) 11 70
UVG5|QPIP5 VSSE3
12 69
UVG(4)
UVG(3) 13
UVG4|QPIP4
UVG3|QPIP3
FEM YF6
YF7
68
YF(6)
YF(7)
3885 14 67 RE_F
B3c,B19d NC|LLC 7760 REF B3c(2x)
1K0 15 SAA4998H/V1 66
3886 VSSE2 VSSD2
16 65
NC|SWCK2 VDDD2 +1V8FA
UVG(2) 1K0 17 64
UVG2|QPIP2 IE
2879
100n
UVG(1) 18 63 MF(17)
UVG1|QPIP1 REA
UVG(0) 19 62 MF(16)
E 3887 20
UVG0|QPIP0 YA7
61
E
NC|RSTW2 YA6 MF(15)
+3V3FB 3888 21 60
1K0 NC|OIE2 YA5 MF(14)
1K0 3889 22 59 MF(13)
NC|IE2 YA4 B3a
1K0 23 58 MF(12)
VDDP YA3
3890 24 57 MF(11)
NC|WE2 YA2
25 56 MF(10)
1K0 3891 ACV|RE2 YA1
2885
100n
B3a,c,d 26 55 MF(9)
NC|RSTR2 YA0
TRST 1K0 27 54 MF(8)
B3a,c,d TRSTN UVA7
B3d TMS 28 53 MF(7)
TMS UVA6
TDOA 29 52
B3c TDI VSSS1
TDOB 30 51
TWOFMON
TDO VDDS1
VDDM1
VDDM2
SNRST
VSSM1
VSSM2
VDDD1
VDDE2
VSSD1
9810
PIPON
SNDA
SNCL
UVA0
UVA1
UVA2
UVA3
UVA4
UVA5
TCK
RST
F F
3880
3881
3882
3883
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
47K
47K
47K
47K
9811
+1V8FA
+3V3FA +3V3FA +3V3FA +3V3FA 3884
2723
2880
100n
100n
+3V3FA
RST-FEM
47K
RSTR_O
SN-DA
SN-CL
MF(1)
MF(2)
MF(3)
MF(4)
MF(5)
MF(6)
TCK
G G
B3a,c(2x),d
B3a,c(2x),d
B3a(2x),c
B3a,c,d
B3a
B3a
+3V3FA +1V8FA
2884
100n
2883
100n
2882
100n
H H
E_14620_086.eps
8204 000 8343.4 070704
1 2 3 4 5 6 7 8 9 10 11
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 48
SSB: Eagle
1 2 3 4 5 6 7 8 9 10 11 12 13 14 2750 A3 3802 D8 I732 E1
2751 A3 3803 D13 I733 F1
2752 A3 3804 D13 I734 F12
EAGLE +3V3ED
2753 A3
2755 A3
3811 H8
3812 H8
I735 C7
I736 C10
+3V3ED 2756 A3 3814 H8 I806 H6
2758 A9 3815 H8 I808 E6
2758
2765 2759 A3 3817 H9 I809 E6
7721
CY2305SC-1 6 1n0 2760 A5 3818 H9 I811 E6
9711
1n0 2761 A5 3819 H1 I812 E6
VDD 2814
8 2762 A5 3820 H1 I816 F10
2K2
3897
CLKOUT
2763 A5 3821 E12 I817 D6
2750
2751
2752
2753
2805
2755
2756
2808
2809
2759
2760
2761
2762
2763
2764
2821
2822
2794
2768
2769
2770
2771
2772
2773
2795
2796
2797
2777
2778
2798
2780
2781
2782
2799
2784
2785
A 3 2815 15p A
2812 3896 1 CLK1 2764 A5 3822 F12 I818 D6
REF 2 10p 3898 2765 A8 3823 F12 I819 D9
1n0 82R CLK2
9822
2768 A4 3824 F12
1n0
1n0
1n0
1n0
1n0
100R
1n0
2816
1n0
1n0
1n0
1n0
1n0
1n0
1n0
5
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
1n0
+2V5EC CLK3 2769 A4 3825 F12
+1V5EB 10p
7 2770 A4 3850 H6
2K2
+2V5ED 3895 CLK4
GND
9821
+2V5EA 2771 A4 3894 E7
+1V5EA 4 3729 2772 A4 3895 A8
EAG_SD_CLKOUT
2830
2831
2832
2833
2834
2835
+2V5EB 2773 A4 3896 A8
EAG_SD_CLKIN
100R
EAG_SD_CLK
+3V3EA 2777 A4 3897 A8
2778 A4 3898 A10
100n
100n
100n
100n
100n
100n
9730
B B 2780 A4 3900 G7
+3V3EB +3V3EC
2781 A4 3901 G6
7720 2782 A5 3902 G7
104
111
101
112
113
131
143
151
167
182
199
152
125
139
149
162
172
185
198
B3c
29
83
90
95
30
87
10
21
44
78
96
69
76
60
61
22
51
EAGLE1C 7719 2784 A5 3906 D11
25
13
38
44
MSM56V16160F-6TS
7
AVDDU
AVDPLL
AVDDV
AVDDY
VDD VDD2 VDDC VDDS 2785 A5 3911-1 G6
B19d VDD VDDQ
B3a,19d
B19d
HD_E
HD_E_T0
VD_E
UVF(0) 2
0 INPUT BUS F LUMINANCE 0
116 YOUT(0) EAG_SD_A(0) 21
0 2786 D7 3911-2 G7
UVF(1) 3 115 YOUT(1) EAG_SD_A(1) 22 DRAM 33
2787 D9 3911-3 F6
+3V3EA
1 1 1
4 110 23 NC 37
UVF(2) YOUT(2) EAG_SD_A(2) 512K X 16 X 2
UVF(0:7)
2 2 2 2788 E2 3911-4 F7
B3b UVF(3) 5 109 YOUT(3) 9732 EAG_SD_A(3) 24
3 3 3
UVF(4) 6
4
UVF VIDEO ENHANCEMENT 4
106 YOUT(4) +3V3EA F714 EAG_SD_A(4) 27
4
2789 E2 3912-1 G6
7 Y 105 28 0
UVF(5) YOUT(5) EAG_SD_A(5) 2790 E2 3912-2 G7
UVF(6) 8
5 PROCESSOR 5
103 YOUT(6)
I736
EAG_SD_A(6) 29
5 A
512K-1 2 3762 EAG_SD_DQ(0)
9
6 6
102 30
6 1
3 68R 3763 2791 E2 3912-3 F7
UVF(7) 7 7 YOUT(7) 9751 EAG_SD_A(0:11) EAG_SD_A(7) 7 2 EAG_SD_DQ(1)
C C 2793 E2 3912-4 F6
3766
3765
9731
RES
12 100 9750 31 5 3764 68R
1K0
1K0
75R
75R
75R
YF(0) YOUT(8) EAG_SD_A(8) EAG_SD_DQ(2)
res
0 8 8 3
YF(1) 13 99 YOUT(9) res EAG_SD_A(9) 32 6 68R 3767 EAG_SD_DQ(3) 2794 A4 3918 F7
1 9 9 4
14 94 20 8 3768 68R
YF(0:7)
EAG_SD_DQ(0:15)
COLOUR DIFFERENCE
B3b YF(3) 15 93 U_VOUT(1) 9 68R 3769 EAG_SD_DQ(5)
3 1 I735 F715 PMBT2369 6 2796 A4 3921 G6
3771
3772
3773
YF(4) 16 YF 92 U_VOUT(2) EAG_SD_A(11) 19 11 3770 68R EAG_SD_DQ(6)
4 2 A11 7
YF(5) 17
5 3
91 U_VOUT(3) D 8
12 68R 3774 EAG_SD_DQ(7) B3c 2797 A4 7717 D8
YF(6) 18 89 U_VOUT(4) RES 39 3775 68R EAG_SD_DQ(8)
6 4 7717 +3V3EB 9 2798 A4 7718 C9
75R
75R
75R
YF(7) 19 UV 5 88 U_VOUT(5) PMBT2369 3778 40 68R 3777 EAG_SD_DQ(9)
7 10 2799 A5 7719 B11
RES 2786
RES 2787
UVG(0) 190 84 4K7 42 3779 68R
68p
68p
0 INPUT BUS G 6 U_VOUT(6) 11 EAG_SD_DQ(10)
UVG(0:7)
UVG(1) 191
1 7
82 U_VOUT(7) RES 12
43 68R 3780 EAG_SD_DQ(11) 2805 A3 7720 B3
UVG(2) 192 81 U_VOUT(8) I730 I819 EAG_SD_CLK 35 45 3781 68R EAG_SD_DQ(12) 2808 A3 7721 A9
2 8 3782 3783 CLK 13
B3b,B19d
3776
3794
3800
UVG(3) 193 80 U_VOUT(9) 34 46 68R 3784 EAG_SD_DQ(13)
UVG(4) 194
3
UVG
9
79 O_VAL
+2V5ED +2V5ED
9752 18
CKE 14
48 3804 68R 2809 A3 7725 F10
4 OUTP_VAL CS 15 EAG_SD_DQ(14)
1K0 1K0 2812 A7 9704 H2
UVG(5) 195 26 EAG_SD_RASN 17 49 68R 3803 EAG_SD_DQ(15)
D 5 HD RAS 16 D
UVG(6) 196 27 EAG_SD_CASN 16 68R 2814 A10 9705 H2
6 VD B3c CAS
UVG(7) 197 32 VAP_E EAG_SD_WEN 15 B3c
7 VA B3c WE 2815 A9 9711 A10
YG(0) 201 35 9753 HREF_EXT_E 36 EAG_DQM
0 HREF U 2816 A9 9712 E1
YG(1) 202 55 9754 DQM 14
1 AOUTNY VSS VSSQ L
YG(0:7)
3906
B3b,B19d 203 56 2821 A5 9713 G12
RES
75R
YG(2) 2 AOUTPY I818 3801 3802
EAGLE - IC I817
26
50
10
41
47
YG(3) 204 59 150R 2825 150R
3 FSADJY 2822 A5 9714 G12
YG(4) 205 YG 64 100n
4 AOUTNU 2823 E8 9715 G6
YG(5) 206 65 I811 3792 3757
RES 5 AOUTPU
I731 I732 YG(6) 207
6 FSADJU
68 I808 150R 2827 150R 2824 E2 9716 E7
2936
208 71
RES
9712 YG(7)
1n0
B3a,b,c,d 7 AOUTNV 100n 2825 D8 9717 F12
SN-CL 24 72 I812 3894 3795
B3a,c,d I713
SNCL SNERT AOUTPV
I809 2827 E8 9718 G12
B3a,b,c,d RSTR_I 9755 25 75 150R 2823 150R
SNRST FSADJV
B3a(2x),b SN-DA I714 9756 33 31 100n B3b,c 2830 B11 9719 G12
SNDA INTR
RSTR_O 9757 23 46 I715 RES RE_F 2831 B11 9721 G12
E 100n SNRSTO FALREF E
9758 57 47 I716 9759
100n 2788 VREFY REFIN B19d 2832 B12 9723 E1
58 9760 FALREF B3c
+3V3EA
+2V5EA
+5V2Pr
2789 100n VBSY 2833 B12 9730 B9
66 163 9716 I717 CLK32IN
100n 2790 VREFU CLOCK CLKI B3c
67
VBSU CLK32O
147 9761 F718 CLK32O B19b 2834 B12 9731 C8
2791 100n 73 118 I719 CLK64 B3a,b,d 2835 B12 9732 C8
100n 2824 74
VREFV CLK64O
157 4K7 TRST
B19b 3821
B3c VBSV CLKSEL 3796 +3V3EA B3a,b,d CLK32I
EAG_DQM 9723 2793 146 36 RES TMS 2925 H6 9740 F2
B3a DQM BOUNDARY SCAN TRST B3b 33R B3c
RST_PIC_EAG 48
RESET TMS
37 TDOB B3a B3a(3x) CLK32IN 2936 E11 9750 C8
3822
3744
3793
9740 159 38 RES
2K2
9763
2K2
IS0 TDI TDOC CLK32G 3729 B9 9751 C9
158 39 9764 3797 +3V3EA B3a,b,d 27R RES
RES 49
IS1 TDO
40 4K7 3744 F11 9752 D10
+3V3EA 3798 9765 BISTEN TCK TCK 7725 B3c B3a,b
3799 4K7 50 41 3823 3745 G10 9753 D6
PLLND2 0 PMBT2369 CLK32O CLK32
+3V3EA 9766
4K7 I733 42 9773 9762 INT1 B3a 3757 E8 9754 D6
RES TESTSEL 1 B3c 68R
EAG_SD_DQ(0) 176 45 9774
F 0 DATA SDRAM 2 F720 B3a,d 3824 RES B3c F 3762 C13 9755 E2
EAG_SD_DQ(1) 175 9775 VAP VAP_E
1 3763 C13 9756 E2
EAG_SD_DQ(2) 174 136 3912-3 EAG_SD_A(0)
2 ADDRESS SDRAM 0 B19d 10R
EAG_SD_DQ(3) 171 134 3912-4 68R EAG_SD_A(1) VREF 9717 3764 C13 9757 E2
EAG_SD_DQ(0:15)
3 1
EAG_SD_DQ(4) 170 133 68R 3918 EAG_SD_A(2)
4 2 3765 C9 9758 E2
EAG_SD_DQ(5) 169 132 3919 68R EAG_SD_A(3) I816 I734 B3c
166
5 3
119 B3a,d,B19d 3825 RES 3766 C8 9759 E6
EAG_SD_DQ(6) 6 4 68R 3911-4 EAG_SD_A(4) HREF_EXT HREF_EXT_E
EAG_SD_DQ(7) 165
7 5
120 3911-3 68R EAG_SD_A(5) B19d 10R 3767 C13 9760 E6
3745
177 DQ ADDR 121 9718
1K0
EAG_SD_DQ(8) 8 6 68R 3911-2 EAG_SD_A(6) HREF 3768 C13 9761 E6
EAG_SD_DQ(9) 179 122 3911-1 68R EAG_SD_A(7) EAG_SD_A(0:11)
180
9 7
126 9823 3769 C13 9762 F6
EAG_SD_DQ(10) 10 8 68R EAG_SD_A(8) B3b,c B19d
EAG_SD_DQ(11) 181 127 3921 68R EAG_SD_A(9) RE_F 9719 REF 3770 C13 9763 F1
11 9
EAG_SD_DQ(12) 186 137 68R 3912-2 EAG_SD_A(10) 3771 C7 9764 F8
12 10
EAG_SD_DQ(13) 187 138 3912-1 68R EAG_SD_A(11) B19d
13 11 B3a,b,c,d 3772 C7 9765 F2
EAG_SD_DQ(14) 188 140 68R 3900 EAG_SD_RASN SN-DA 9713 SN-DA_EPLD
+3V3EA
G 14 RASN G 3773 C7 9766 F2
EAG_SD_DQ(15) 189 141 3901 68R EAG_SD_CASN B3c B3a,b,c,d B19d
15 CASN
WEN
142 68R 3902 EAG_SD_WEN SN-CL 9714 SN-CL_EPLD 3774 C13 9773 F6
53 128 68R EAG_SD_CLKIN B19d
B3c SDCLKIN F765 F766 F767 B3a,c,d 3775 C13 9774 F6
153 129 EAG_SD_CLKOUT B19d RSTR_I 9721 RSTR_EPLD
SDCLKOUT 3776 D7 9775 F6
154 REFIN
AVSPLL
164 9715
DVSS
82R
4K7
2925
3780 D13 F714 C8
3811
3812
3814
3815
3817
3818
75R
75R
75R
75R
75R
75R
+3V3EA 3820 9705
4K7 RES 3781 D13 F715 C9
I806 1n0
3782 D8 F718 E8
3783 D9 F720 F9
H H 3784 D13 F765 G8
3792 E7 F766 G8
3793 F10 F767 G9
3794 D7 I713 E2
3795 E8 I714 E1
3796 E7 I715 E6
3797 F8 I716 E6
3798 F1 I717 E8
3799 F1 I719 E8
E_14620_087.eps
8204 000 8343.4 070704
3800 D7
3801 D7
I730 D8
I731 E1
1 2 3 4 5 6 7 8 9 10 11 12 13 14
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 49
SSB: Columbus
2792 G10
1 2 3 4 5 6 7 8 9 10 11 12 2819 H3
2836 H3
2850 A1
COLUMBUS 2851 A1
2852 A1
2853 A2
2854 A2
2855 A2
2856 G2
A A 2857 G2
+3V3CB 2858 G2
7752-1
COLUMBUS 2859 G2
2860 G3
B3d 2861 G3
2850
100n
2851
100n
2852
100n
2853
100n
2854
100n
2855
100n
COL_DQM COLUMBUS_IO 2862 G3
+3V3CB
L14 2863 G3
DQM
COL_SD_RASN K15 2864 G4
RAS_
B3d COL_SD_CASN K14
CAS_ DQ1
P12 3830 COL_SD_DQ1 2865 H2
COL_SD_CLK 9812 J14 R12 3831 68R COL_SD_DQ2
J15
CLK DQ2
P11 68R 3832
2866 H2
COL_SD_WEN WE_ DQ3 COL_SD_DQ3
P10 68R 3833 COL_SD_DQ4 2867 H2
DQ4
B COL_SD_A0 P6
A0 DQ5
R10 3834 COL_SD_DQ5 B 2868 H2
25
13
38
44
R6 P9 68R 3835 68R 2869 H3
7
COL_SD_A1 A1 DQ6 COL_SD_DQ6
COL_SD_A2 P5 P8 3836 COL_SD_DQ7
COL_SD_A0 21
22 0
VDD
VDDQ
33
COL_SD_A3 R5
A2
A3 Memory
DQ7
DQ8
R8 3837 68R 68R COL_SD_DQ8
B3d 2870 H3
3830 B11
COL_SD_A1 1 DRAM COL_SD_A4 R1
A4 DQ9
R13 68R 3838 COL_SD_DQ9
3831 B10
23 NC 37 R2 R14 3839 68R
COL_SD_A2
24 2 512K X 16 X2 B3d COL_SD_A5 A5 Interface DQ10 COL_SD_DQ10
3832 B11
COL_SD_A3 COL_SD_A6 R3 R15 68R 3840 COL_SD_DQ11
27 3 A6 DQ11
COL_SD_A4 COL_SD_A7 P3 P15 3841 68R COL_SD_DQ12 3833 B11
28 4 0 A7 DQ12
B3d COL_SD_A5 5 A 512K-1 COL_SD_A8 R4
A8 DQ13
N15 3842 68R COL_SD_DQ13 3834 B10
COL_SD_A6 29 2 COL_SD_DQ1 COL_SD_A9 P4 M14 68R 3844 COL_SD_DQ14
30 6 1 3 R7
A9 DQ14
M15 3843 68R COL_SD_DQ15
3835 B11
COL_SD_A7
COL_SD_A8 31 7
8
SDRAM 2
3
5
COL_SD_DQ2
COL_SD_DQ3
COL_SD_A10
COL_SD_A11 P7
A10
A11
DQ15
DQ16
L15 3845 68R COL_SD_DQ16 3836 B11
COL_SD_A9 32 6 COL_SD_DQ4 68R 3837 B10
20 9 4 8
Noise Reduct
COL_SD_A10 COL_SD_DQ5 CL16 H1 G1 3916-4 CLK-AS 3838 B11
10 5 CLKASA CLKASB
SWAN 3D
C C
3D Comb
9 COL_SD_DQ6 WE-A B13 A1 3914-1 22R WE-B
19 6 11 WEA / DAVA WEB / DAVB 3839 B10
COL_SD_A11 COL_SD_DQ7 22R
A11 7 12 B3d B7 G2
3840 B11
D 8 COL_SD_DQ8 YA(0) YA0 / Di9 YB0 / Do9 3915-2 YB(0) B3a
39 COL_SD_DQ9 YA(1) B9 F2 3915-1 22R YB(1) 3841 C11
7753 9 YA1 YB1
40 COL_SD_DQ10 YA(2) A9 E2 22R 3913-4 YB(2) 3842 C10
MSM56V16160F-7TS 10 42 B3a YA2 YB2
COL_SD_DQ11 YA(3) B10 E1 3913-3 22R YB(3) 3843 C11
11 43 YA3 YB3
COL_SD_DQ12 YA(4) A10 D2 22R 3913-2 YB(4) 3844 C11
35 12 45 YA4 MUX MUX YB4
COL_SD_CLK COL_SD_DQ13 YA(5) B11 D1 3913-1 22R YB(5)
4K7 34 CLK 13 46 A11
YA5 YB5
C2 22R 3914-4
3845 C10
+3V3CB CKE 14 COL_SD_DQ14 YA(6) YA6 YB6 YB(6)
B3d 18 48 COL_SD_DQ15 YA(7) B12 656 656 C1 3914-3 22R YB(7) 3846 D1
3846 CS 15 YA7 YB7
COL_SD_RASN 9802 17 49 COL_SD_DQ16 YA(8) A12 Decod Encod B1 22R 3914-2 YB(8) 3847 G5
16 RAS 16 YA8 YB8
COL_SD_CASN 9801 B3a,c 22R 3848 G6
15 CAS
COL_SD_WEN 9800 B3d VAP A13 3849 H10
WE 36 B3a,c,B19d A14
VA
COL_DQM HREF_EXT
U HREF 3851 H10
D VSS VSSQ
DQM
L
14
UVA(0) A2 M2 3917-1 UVB(0)
D 3853 H5
UVA0 / Di0 UVB0 / Do0
3854 H6
9803
22R UVB(1)
4
10
41
47
26 50 UVA(1) B3 M1 3917-2
UVA1 / Di1 UVB1 / Do1 3917-3
UVA(2) A3 L2 22R UVB(2) 3855 I6
UVA2 / Di2 UVB2 / Do2 22R UVB(3)
UVA(3) B4 L1 3917-4 B3a 3913-1 D10
UVA3 / Di3 UVB3 / Do3
UVA(4) A4 K2 22R 3916-3 UVB(4)
B3a UVA4 / Di4 MUX UVB4 / Do4 22R UVB(5) 3913-2 C10
UVA(5) B5 K1 3916-2
UVA5 / Di5 UVB5 / Do5 3913-3 C10
UVA(6) A5 J2 22R 3916-1 UVB(6)
UVA6 / Di6 UVB6 / Do6
UVA(7) B6 J1 3915-4 22R UVB(7) 3913-4 C10
UVA7 / Di7 UVB7 / Do7
UVA(8) A6 H2 22R 3915-3 UVB(8) 3914-1 C10
UVA8 / Di8 UVB8 / Do8 22R
3914-2 D10
3914-3 D10
3914-4 D10
E E 3915-1 C10
3915-2 C10
3915-3 E10
(ONLY FOR 3D COMB) 3915-4 E10
3916-1 E10
3916-2 D10
3916-3 D10
3916-4 C10
3917-1 D10
3917-2 D10
+1V5CA 3917-3 D10
3917-4 D10
F +3V3CA +1V5CA
F 5800 F10
7752-1 A7
7752-2 G6
5800
7753 C3
I718 9722 H11
9800 D2
C4
C12
G3
G13
L13
M3
N3
N8
N11
N14
P13
C8
C7
D3
C11
H13
E13
N6
N9
K3
9801 D2
9802 D2
2792
100n
7752-2
COLUMBUS 9803 D2
9804 G6
B3a VDDS VDDC 9805 G6
COLUMBUS_CTRL +3V3CA RST_COL 9804 G15 N1
AVD 9806 H5
G 4K7
H15
RESET
P1
G 9807 H5
G13 L13 P13/N14 +3V3CA CLKSEL AVS
C4 G3 M3/N3 N8 N11 C12
3848 I801 SN-DA B3a,b,c(2x) 9812 B6
H14 C14 9815 9815 G11
CLKEXT SNDA
9805 B3a,b,c(2x) 9816 G11
4K7 COLUMBUS_CTRL
2856
100n
2857
100n
2858
100n
2859
100n
2860
100n
2861
100n
2862
100n
2863
100n
2864
100n
3851
3849
N6 N9 C11 E13 H13 9807 A8
4K7
4K7
TST1
F1 D4
TST2 NC_2
3853
H3 N2
47K
TST3 NC_3
2865
100n
2866
100n
2867
100n
2868
100n
2869
100n
2870
100n
2819
100n
2836
100n
3854
B8
4K7
BISTEN +5V2Pr
+5V2Pr
VSS
I807
+3V3CA
3855
4K7
M13
C13
D13
C10
N12
N13
N10
R11
P14
B14
K13
F13
J13
C3
C5
C6
C9
N4
N5
N7
R9
B2
P2
E3
F3
L3
J3
I I
E_14620_088.eps
8204 000 8343.4 070704
1 2 3 4 5 6 7 8 9 10 11 12
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 50
2932
100n
2933
100n
3V3_FAULT_FBX
10u 16V
2820 B6 6714 D2
A A
2938
100R 6711 +3V3_FBXB 5750 F740 2826 E7 6715 E2
+3V3EA 2828 B6 6716 E2
B3e +3V3_DCDCFBXA 2829 B7 6717 A9
3870
3V3_FAULT_FBX +5V_FBXA 2843 F2 6718 B9
2811
100n
100R I758 7774 2844 E7 6719 C3
5775
+3V3_DCDCFBXA 2845 E9 6720 E9
KF25BDT
I743 2846 F9 6721 F9
BAS316
1 3
6712
5777
B3e I746 BAS316 2849 D6 7701 B4
2 3867 2871 D4 7770 B7
2802
100n
2889
100u
2924
100n
5754
3V3_FAULT_FBX
100u 16V
2872 E6 7772 C4
2739
100u
2939
2895
7770
10u
100R 6718
LD1117 RES 2873 F6 7773 F2
2890
100n
100u
3V3_FAULT_FBX
2892 D2 F734 B1
2828
2820
100n
2810
100n
10u
100u 16V
100R 6722 1 2893 D2 F740 A9
2829
2937
7701 2894 E2 F741 B9
5779 F734 +3V3GA LF15AB F799 +3V3_DCDCFBX 2895 B3 F743 F9
5709 5719 2896 C4 F744 E9
1 3
2914 2897 C4 F745 D7
res IN GND OUT
+3V3_DCDCFBXA +1V5_FBXB 5720 2898 D3 F746 E7
res 2 2899 D4 F747 F7
100n 2715
res 2897
100n
2896
100u
10u
B3e 3829 I759 BAS316 +3V3_DCDCFBXA B3e 3V3_FAULT_FBX 3877 I712 BAS316 2914 C2 F748 E2
3V3_FAULT_FBX 2919 F2 F749 C6
res
100R 6702 5721 F749 5755 F750 100R 6709 2921 E6 F750 C7
+5VF +5V2Pr 2922 E4 F789 D9
C +5V_FBXA
C
5761
5768 F791 +3V3PB 5722 +3V3_FBXB 5780 2923 E5 F790 B2
+5V_FBXA +3V3ED 2924 B4 F791 C1
2847
2848
100n
2932 A5 F792 D2
10u
2891
2933 A5 F793 D2
2818
100n
2937 B7 F794 E2
100n 7772
B3e I747 BAS316 2938 A4 F795 F2
3871 LF15AB F713 2939 B1 F796 F3
3V3_FAULT_FBX 6719 5760 I748
1 3 3707 F1 F797 F6
100R 6713
IN GND OUT 3805 D9 F798 D6
S1D +1V5_FBXA 3829 C1 F799 B4
5769 F792 +2V5_FBXA 5752
+3V3PC 2 F798 3864 F9 I712 C9
2898
2899
100n
2871
100u
10u
2849
100n
5801 3869 A1 I744 B1
D B3e 3872 I749 BAS316
100n
+3V3_FBXB
F789
+3V3EC D 3870 A1 I745 B7
3V3_FAULT_FBX 3871 C1 I746 B9
100R 6714 3872 D1 I747 C1
2813
100n
5757 F745 3873 E1 I748 C3
5770 F793 +1V5EA 3874 E1 I749 D1
+3V3FA
+2V5_FBXA 5764 F712 +1V5_FBXA 3875 B1 I750 E1
B3a(3x)B3e(14x)
2893 3V3_FAULT_FBX +2V5EC 3877 C9 I751 E1
2844
100n
5702 A5 I752 F2
B12 5778 B3e 3865 I754 BAS316 5709 B3 I753 F1
100n
2921
100n
B3e I750 3V3_FAULT 3V3_FAULT_FBX 5713 E5 I754 E9
3873 BAS316
3V3_FAULT_FBX 6u8 100R 6720 5719 B5 I755 F9
100R 6715 5720 C5 I756 A1
F794
2922
2923
10n
2845
100n
100n +2V5EA
5753 F9
2826
100n
B3e 3874 I751 BAS316
3V3_FAULT_FBX GND 5754 B6
5755 C7
2872
2874
100n
IN GND OUT F743
10u
100u
2 +3V3CB 5767 B2
2729
100n
2919
100u
2817
100n
2873
100n
5768 C1
5769 D1
2728
2846
100n
5770 D1
5771 E1
5772 F1
5773 E1
8204 000 8343.4 E_14620_089.eps 5775 A3
070704 5777 B7
1 2 3 4 5 6 7 8 9
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 51
SSB: HOP
1 2 3 4 5 6 7 8 9 10 11 12 13 1301 G4 3342 C13 7314 A10
1304 G3 3343 D12 7315 B10
B4(2x)
B4(2x)
B4(2x)
B4,B5a
B4(2x)
2304 G7 3347 D9 7319 C12
B4
B5a
B5a
B5a
B4
nc
B4
B4
nc
B4
2306 I9 3348 D9 7340 A5
2398 +8VS +8VS +8VS +8VS +8VS +8VS +8VS +8VS
+8VS B 2307 F4 3349 F2 7361 H7
V100
U100
Y100
Yltp
BCL
R-TXT
G-TXT
B-TXT
FBL-TXT
B_2FH
G_2FH
R_2FH
B4,B5a
FBL-TXT
Yltp
FBL_2FH
2308 G9 3350 B10 7362 H7
+8VS +8VS
Y-SCAVEM
100n
3353
A A 2309 D3 3351 B9 7375 B8
1K
680R
3338
V21
100K
3325
BC847BW
2310 E3 3352 A9 9302 A3
100K
100K
3360
3471
3467
10K
7302 7314
100K
9303
9304
3352
3354
13 12 2 10 23 24 18 20
9302
2K2
V20
V19
TDA9178 BC847BW 2311 H5 3353 A10 9303 A4
1K
1K
1K
7316
NC GND VCC 3340 2312 F9 3354 A10 9304 A4
3358
BC857BW nc
2330
100n
7340 7306 R-CRT
1K8
I369
3332
3335
3330
SOUT 21 9305 7313
B4 BC847BW 2342 2343 3337 5313 I308 47R 2313 F9 3355 B7 9305 A4
6 YIN LUMA
3465
33K
Y100
I320
YOUT 19 2429 2314 E2 3356 G12 9308 B4
2329
100n
2331
100n
3470
I370
I319
PROCESSING 7375
33K
I368 820R 5u6
B4 100n 100n 7315
SPEC- BC847BW 2315 E2 3357 F12 9309 B4
I330
100n PMBT2369 2337 +8VS
100K
3351
3359
I331
8 UIN UOUT 17
3355
3350
10K
33K
U100
1K
TRAL 2317 F3 3358 A11 9310 B4
3388
3399
3459
CHROMA
10R
PMBT2369
10K
2K2
B4
9 VIN PROC VOUT 16 6p8
2323
100n
I332
V100 PROCESSING 2328 2318 F3 3359 B9 9311 I1
2431
100n
WIN- ONLY FOR NO HOP BC847BW GND-RGB-CRT 2319 G10 3360 A7 9312 I1
680R
3383
22 CF
B CONTROL ADC DOW 22p B
2321
100n
I326 7305 2320 G3 3361 G7 9313 F13
9308 V28 9421 BC857BW nc
3341 2321 B3 3362 F11 9314 H1
ADR
DEC
SDA
SCL
AD1
AD2
AD3
I304 7317 G-CRT
SC
9309
3454 I309 3369 5314 I310 47R 2323 B4 3363 F3 9315 H1
SDA-F 14 11 7 15 3 4 5 1
9310 2324 I6 3364-A F11 9316 I6
I366
100R 7301 820R 5u6
2325 G5 3364-B G11 9421 B9
2301
100n
3339
6K8
SCL-F
RI2
GI2
BI2
BL2
PWL
6p8
B5a,B21 100R 2328 B7 3364-D G10 F309 D11
LIGHT-SENSOR
28 YIN GND-RGB-CRT 2329 B6 3365 F13 F311 C2
680R
3389
B3a,B4(3x) Y R R R R RO 40
6308 SATURN CONTRAST OUTPUT
B5a HD100 CONTROL G WHITE AMPL 2330 A6 3366 H11 F312 E9
27 UIN U AND G G G GO 41 BC857BW nc
C MCL4148 I333 SWITCH COLOUR RGB-INSERTION POINT + BUFFER V30 3342 C 2331 B6 3367 F11 F329 H9
B BRIGHTNESS 7319 B-CRT
26 VIN DIFF CONTROL + BLUE
3305
V B B B BO 42
68K
B4 3453 CONTROL I313 3384 5315 I317 47R 2332 E2 3369 B11 F347 D12
SANDCASTLE MATRIX STRETCH
3395 2333 D10 3383 B13 F348 G3
F311 33K 820R 5u6
100R 3302 3346 2341 2334 E8 3384 C12 F349 H3
33 BL1 SAT WHITE P.
B4(2x) FBL_2FH Y 6316 +8VS 2335 F10 3386 F13 F350 H3
1K Y U V 33K 6p8
I314 nc 2336 E8 3387 G2 F351 H3
B4(2x) R_2FH 3396 2395 30 RI1 BAS316 3348 GND-RGB-CRT CUTOFF
CONTR 2337 B12 3388 B5 F352 H3
B4(2x) 3397 100R 2396 RGB-YUV BLACK PWL + CONTINS 3345 2K2
G_2FH 100n 31 GI1 BLKIN 44
BEAM CURR CATHODE 2338 C12 3389 C13 F353 H3
3347
STRETCH
22K
B4(2x) 100R 3398 100n 2397 32 BI1 MATRIX I311 10K 2340 I11 3390 D9 F362 H3
B_2FH LIMITER CALIBRN B4(2x)
F309 3343
BRIGHT EHT-INFO
D 100R 100n D 2341 C12 3391 G12 F364 F4
3320 I315 6319 68K
SCL-F 10 SCL BCL 43 6310 BAS316 BZX384-C22 2342 A7 3394 E9 I302 E2
BZM55-C6V8 2333 3344 3322
100R 2343 A9 3395 C3 I303 F4
BAS316
2309
10p
2 DACOUT 25
I316 3390 2u2 I367 2K2 6309 6311 F347 1K B4 2344 H3 3396 D3 I304 B11
V22 I C 6-BITS TILT
3321
HOP DAC 220R EW-DRIVE
nc 2345 H2 3397 D2 I305 G5
I358 2346 H2 3398 D3 I306 G5
3394
11 SDA
2334
2336
SDA-F
4K7
2u2
2u2
EHT-INFO B4(2x)
+8V_VDP 100R 2347 H2 3399 B5 I307 G7
2310
+8VS
10p
470K
3308
V23
7318 2349 H2 3443 E13 I309 B11
BAS316 22K
2393
220K
3443
1u
3306 I365 3313 2363 F3 3453 C2 I310 B12
3310
3329
EWO 3 I357
47K
6R8
E 5301 I338 EW E
7V9 17 VP1
SYNC+GEO 220R 100K 2386 G12 3454 B1 I311 D8
I302 5302 6u8 I339 BC857BW
7V9 2393 E13 3455 C1 I312 E3
3307
39 VP2
2303
100K
3312
18K
+8VS F20 B4
1u
RGB F312 6317 3319
EHTIN 4 HFB_X-RAY-PROT
6u8 I312 2395 D3 3459 B11 I313 C11
SUPPLY
18 DECBG
2314
100u
2332
100n
100n
2326
10n
19 GND2 VDOB 2 1V1 1412 B5b
2317
2318
22n
ANAGND
2307 I303 FRAME
7 DECVD VDOA 1 1V5 B21 2398 A3 3470 B8 I316 D9
DIGSUP 3367
B4 F18 BACKLIGHT-CNTRL 2429 B4 3471 A8 I317 C12
GND-RGB-CRT 100n 6 GND1 DIGGND 3328
c200 +8VS 220R +8VS +8VS 2431 B3 3472 I6 I319 B11
9313
0V2 23 VD START/STOP
F PHI-2 F
8 3364-A 1
4K7 VSC 15 4V0 2313 3304 I11 5302 E2 I321 F3
I321 1K H-DRIVE GENERATOR
24 HD SC
680K
100K
3386
3365
4K7
NC +5VS +8VS 100n 3305 C3 5303 G1 I326 B7
PHI- 1 HOUT 8 2V5
2363
470p
3362
3357
3K9
3K9
2312 PDTC144EU 3307 E9 5305 H1 I331 B4
F364
FBCSO
FLASH
XTALO
L13
XTALI
LPSU
2 3364-B 7
+8VS 1n 3308 E9 5306 H1 I332 B3
3333
3318
SCO
DPC
HFB
1K
1K
33n 2386 3391
680K
L12 3310 E9 5307 H1 I333 C2
B4 7309
NOHOP1A 20 21 9 13 14 29 22 5I307
0V2
6 3364-C 3
0V
I306
6 3
680K
3312 E11 5313 A12 I339 E4
1
1K 220R
CSTCV
2 5
2308
7310-A
V31
10p
I305
100K
3311
2320
2304
3314
10p
10p
10K
B4 3387 2319 BC847BS
+8VS
1301
0V8
4 3364-D 5
100R 1n 7310-B 3315 H8 6301 E12 I359 F4
12M
B4(3x),B5a
3356
2K2
BC847BS
680K
HD100 3316 H10 6303 H9 I363 H5
4
3
RES
47K
100K
3327
2325
100n
3315
7362 3320 D3 6308 C2 I368 B7
1K
1K
B4(2x) B_2FH 5305 100MHZ F350 220R 3366 B5a
3 7303 HD@HOME
BC847BW
3321 E3 6309 D11 I369 A8
6312
B4(2x) 100MHZ F351 6303 6304 F329
FBL_2FH 5306 4 LINEDRIVE1 nc
RES
RES
HD100
BAS316
H BC857BW H
3323
6334
2311
2348
10p
10p
2347
10p
2346
2344
2345
10p
10p
10p
9315
2306
470p
VSYNC 7361 3328 F9 6317 E12
BZX384-C5V6
1K
BAT54 COL
PDTC144EU
3329 E2 6319 D9
3324
6306
6307
4K7
ONLY FOR NO HOP
3472
2324
22K
10n
B4 3330 A7 6334 H5
3304
3R9
NOHOP1B
3331 G3 7301 B4
3332 A7 7302 A1
B14b,B21(2x)
DYN-FASE-COR
9312
2340
9316
10u
B5a HD100 3334 H5 7304 F2
SANDCASTLE
POR_FLASH
2FH-HD100
2FH-VD100
3336 H6 7306 A9
2FH-G
2FH-R
2FH-B
POR
HFB
TILT
B4,B5a
nc
nc
B5a
B4
B4
B4
nc
B14b
B14b
SSB: OTC-Flash
1 2 3 4 5 6 7 8 9 10 11 12 13 1000 F7 3031-1 B11 3078-1 D4 9017 A4 IC43 G12
1001 G3 3031-2 D13 3078-2 B3 9018 A3 IC44 G12
OTC-FLASH +5V_CON +8V_CON FC57 FC60 1401 I12 3031-3 D13 3078-3 B3 9021 A1 IC45 I1
+3V3_INTOTC A +3V3_INTOTC
2002 G3 3031-4 D13 3079 E3 9022 B3 IC46 J2
SAM
100n 2023
2024
2025
2026
2027
2028
2029
B +3V3_INTOTC +3V3_INTOTC 2031 FC01 2040
SDM
VPP-SW 2003 J4 3033 C3 3080 A2 9023 B3 IC48 E3
9017
470R
9018
9006
3097
9005
IRQ-FTV
470R
2061
100p
2060
100p
3081
B5a
100n 100n 2004 J4 3034-1 G7 3081 A4 9024 A1
3020
3018
SEL_IN_2 37 13
100n
100n
100n
100n
100n
100n
10K
10K
A LED2 7001 7012 A
VCC VCCW 2005 J3 3034-2 H7 3082-1 A13 9025 C3
10K
FC02 3089 100R M29W400BT
3068
+5V2_CON 25 37
2K7
AA(0) A(0) A(0) 3087 100R
SAA5801H A0 29 3 3072-3 6 2006 J3 3034-3 H7 3082-2 C13 FC01 A9
+3V3_INTOTC
9 19 20 AA(0) 25 DD(0)
3049-3 A0 VCC DQ0 100R
3009
7006
H
3
24
C
3080
38 49 75 111 OTC AA(1) 6 3 A(1) A(1)
VDDN1
VDD1
VDDP1
VDDP2
VDDD2
VDDD3
VDDP3
VDDA
101 2007 J3 3034-4 H7 3082-3 B13 FC02 A7
3074-4
6005 A1 3086-3 31 1 3072-1 8
3099-3
470R
LH28F320BJE 6 24
470R
B14d FC22 3049-4 AA(1) 3 DD(1) 100R
PLVA2650A 23 A1 DQ1 2008 H4 3035-1 H7 3082-4 C13 FC03 C7
9024
9021
A2 3086-4 33 8 3082-1 1
3019
5 23
4K7
AA(2) 4
2070
6
3078-2 3050-1 A2 DQ2 100R
3021
2 7 2V9 105 P2-2|ADC0 A1 45 8 1 22
10K AA(0) AA(3) A(3) A(3)
A3 3055-3 3029-1 EPG- 3082-3
29 D(0) D(0) 6 3 DD(0) AA(3) 1 8 22 35 6 3 DD(3) 2010 I9 3035-3 H7 3083-2 C13 FC05 C10
100n
NC
99 P1-6|INT3 A18 63 A(20) 10 14
D
RC 0V2 AA(17) AA(20) 6 3 A(20)
A20 FLASH-RAM 28 D
B4 EP_OE 2037 H8 3050-3 B8 3095 I1 FC29 B10
POR_FLASH 3
3076-3
6 98 P1-5|INT2 A19 65 AA(18) +3V3_INTOTC
3084 IC29 47 (Set SW) G_ 9 7
3031-2
2 AA(19) 100R
BYTE_ 11 2038 E9 3050-4 B8 3096 J2 FC30 B7
B14b,B21 FC16 EP_WE
3076-2 470R 3076-1 97 P1-4|INT1 A20 64 10K 26 W_ 10 3031-3
IRQ-DIGITAL 2 7
+3V3_INTOTC
1 8 AA(19) B5c(3x) SW_CS
CE_ 15 FC17 F 12
6 3 AA(20) 100R 2039 H12 3051-1 B8 3097 A3 FC31 G10
IC05 470R 7009 470R 96 P1-3|INT0 A21 66 AA(20) B5c(3x) SW_WE
FC18
11 RY|BY_ B5c(3x) 3V4
RP_ 2040 A12 3051-2 C8 3098 J10 FC32 G12
VSS1
VSS2
3024 WE_
3093
BC847BW 47
10K
B14b 2020 +5V2_CON FC19 BYTE_ 2041 H1 3051-3 C8 3099-1 B4 FC33 F9
P50 1PS76SB10 IC40 95 P1-2|T2 A22 67 B5c(3x) 28
47K
27 46
220p
A
3062
92 P0-7 A23 68 3V4 12
10K
7008 RP_ 2053 J11 3052-1 C8 3099-3 A4 FC35 G9
BC847BW IC07
1PS76SB10
+3V3_INTOTC
IC48 6003 +5V2_CON 3V4 C FC50
2054 J12 3052-2 C8 3099-4 B4 FC36 F10
3005
91 P0-6|CORN 14
10K
WP_
3026
2022
100n
4K7
3053
3069
3079
3088
3092
+3V3_INTOTC
4K7
10K
1K8
1K8
1K8
1K8
220R 27 46
3010
89 P0-4|RxDo D1 32
10K
DD(1) 2057 I12 3053 E2 3102-1 C13 FC39 G9
+5V2_CON +3V3_INTOTC
3064-4 88 P0-3|SDA1 D2 28 2058 C2 3054-1 D10 3102-2 B13 FC40 C10
SDA-F 4 5 DD(2) 100n 7005
100R +3V3_INTOTC LF33AB 2059 C2 3054-2 C10 3102-3 C13 FC41 C10
SCL-F 3 3064-3 6 87 P0-2|SCL1 D3 24 DD(3) 2038 2060 A4 3054-3 D10 3102-4 B13 FC42 C10
100R +3V3_INTOTC 5V3 3V4
SDA-S 2
3064-2
7 86 P0-1|SDA0 D4 23 DD(4) G 100n H IN GND OUT
2061 A3 3054-4 B10 3103 D3 FC43 G10
2013
100u
BAS316
FC20
1 3064-1 8 100R
RES
IC37 2067 I7 3055-1 B10 3C09 I1 FC44 C10
9007
3004
85 P0-0|SCL0 D5 27
RES 15K
SCL-S DD(5) 5000 2019
B14b,B21 3074-3 100R 93 P1-0|T0 D6 31 MSM51V18165F 1 6 21 +3V3_INTOTC 2068 J2 3055-2 C10 3C10 I1 FC45 H8
6002
SOUND-ENABLE 3 6 DD(6) 100MHZ FC21
A(6) 17 2 D(2) 2070 B2 3055-3 B10 3C11 J1 FC46 H9
VCC1
VCC2
VCC3
B6a,B14b IC09 470R 3074-2 5001 A0 DQ1
RESET-AUDIO 2 7 94 P1-1|T1 D7 35 DD(7)
F 18 3 FC23 F 2071 B1 3055-4 C10 3C12 J7 FC47 J6
2016
100u
B4 3074-1 470R 100MHZ A(2) D(5)
A1 DQ2
+5V2-STBY
HD@HOME 1 8 D8 34 DD(8) 1000 IC42 2072 B1 3056-1 B10 5000 F7 FC48 G2
5003 FC33 19 7007 4 FC25 BC857BW 3013
470R +5V2_CON A(1) D(4) 2073 C3 3056-2 C10 5001 F7 FC49 G3
D9 30 A2 DQ3
DD(9) 7002
+3V3_INTOTC
F 500mA 30R DRAM FC27 10K
220R
3002
3100
20 5
4K7
4K7
3017
D10 26
2075
100n
4K7
DD(10) (TXT) 2075 F8 3056-4 C10 6001 E2 FC51 D7
3101
2017
100n
VSS WC_ DD(13) FC35 26 IC43 BC847BW 3004 F12 3057-4 C10 6005 A4 FC55 J12
CX-5F
33p
3016
16 OSCOUT 10
1001
1K5
SCL-F 7 A(5) D(7)
6M
FC49 A7 DQ8
D14 33 DD(14) +3V3_INTOTC 3005 E13 3058 C1 6006 C4 FC56 I12
G M24C32 SCL 2002 17 OSCIN FC37 27 33 +3V3_INTOTC G
CLOCK GENERATOR
3065
4K7
E1 IC14 B5a(2x) 3007-2 J6 3061-2 C11 7003 G12 FC60 A4
AND
0V 74 RESET B5c(3x) 14 35
2 RAS RAS D(9)
ROM_OEn 40 3034-1 ROM_OE RAS_ DQ11 3007-3 J6 3061-3 C11 7004 G13 FC61 E4
1 8 B5a(2x) IC44
VCC E0 83 HSYNC 31 36 3066 7014
1 B5a(2x),C(3x) CASL CASL D(8) 3007-4 J6 3061-4 C11 7005 E12 FC66 I7
RAM_OEn 41 100R 3034-2 RAM_OE LCAS_ DQ12 BC857BW
8 2 7 IC15 B5a(2x) FC68
84 VSYNC 30 38 3067 47K 3008-1 J6 3062 E11 7006 A9 FC67 H13
CASH CASH D(13) 7013
3034-4 100R B5c(3x) UCAS_ DQ13
+3V3_INTOTC ROM_CSn 43 4 5 ROM_CS BC847BW 3V4
IC17 IC18 B5a(2x),C(3x) 470K 3008-2 J7 3064-1 F3 7007 F10 FC68 H12
TxD 82 FRAME 13 39
B5c(3x) WE WE D(10)
RAM_CSn 42 100R 3034-3 WE_ DQ14 3008-3 J7 3064-2 F4 7008 E1 FC69 J1
2039
100n
B5a 3 6 RAM_CS B5a(2x),C(3x) FC67
RxD RAM_OE RAM_OE 29 40
B5a(2x) D(11) 3008-4 J7 3064-3 E3 7009 D3 FC70 J11
RASn 69 3035-4 100R RAS OE_ DQ15
B5a 4 5 FC45
H RESET
IC20 11 41 D(12)
H 3009 A1 3064-4 E4 7010 C3 IC03 B2
100R 3035-1 B5a(2x) DQ16
CASLn 72
2033
2034
2035
2036
2037
1 8 CASL
82p
82p
82p
82p
82p
VSS1
VSS2
VSS3
47K 15 NC 32
2041 2008 IC22 B5c(3x) FC46 B4 3012-1 I8 3067 H11 7013 H12 IC09 F1
100R 3035-3
E
9001
2014 2067
PMBT2369 7 CVBS1 B-TXT 3012-4 I8 3072-1 A13 7016 J2 IC14 G8
4K7 B4 (2X)
B3a,B4 (4X) IC23 3013 F12 3072-2 B13 7022 B1 IC15 H8
EPG
3C09 3012-1
TXT
100n 100n
3040
6 CVBS1_R R 77
4K7
HD100 8 1 FBL-TXT
IC24 RES B3a 3014 F12 3072-3 A13 9001 H2 IC17 H4
10K 1 IREF_DEC G 78 100R 3012-2 1401 10p
7 2 2FHFB-GFX
INTERFACE
I B3a HD3-EPLD 3C10 9010 100R FC52 I 3015 G11 3072-4 B13 9002 I2 IC18 H8
DISPLAY
IC26 IC27
USA
3012-3 100R
TXT
2 3008-2 7
3008-3 6
FC56 2056
9002
9012
RES 2009
RES 2010
RES 2011
RES 2012
B3a
3008-4
47p
47p
47p
47p
VIDEOn 2FHG-GFX
3020 A2 3074-1 F2 9007 F12 IC24 I9
100R
100R
100R
100R
7
100R 3046-2
2 7
FC54
VSSD1
VSSD2
VSSD3
3003
VSSP1
VSSP2
VSSP3
9013
2007
100n
2006
100n
2005
100n
2004
220n
2003
220n
2055
TEST0
TEST1
TEST2
TEST3
TEST4
24K
10p
FC69 IC46
VSSA
100R 3046-1
3024 D3 3074-3 F3 9009 J11 IC27 I9
4K7
10 21 39 50 76 102 112 11 12 13 14 15 FC70 2054 5 B3a
B3a 3C11 FC47 3098 3025 E1 3074-4 A3 9010 I11 IC28 I8
3C12
3096
2068
47K
PMBT2369
68R
CVBS-Y-RECORD-IN
2n2
VD-EPLD 2FHR-GFX
3026 E4 3075 C1 9011 I11 IC29 D8
1
6 3007-33
5 3007-44
470R 3007-1
470R 3007-2
4 B5a
3006
470R
470R
470R
N.C.
8
B2(3x)
CVBS-TXT 10p 2
100R FC58 3029-2 B11 3076-3 D3 9014 C2 IC40 E3
E_14620_092.eps
RxD
TxD
B5a
2052 1 070704
3029-4 B11 3077 D3 9016 C2 IC42 F12
1 2 3 4 5 6 7 8 9 10 11 12 13
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 53
3C00
2K2
+5V_CON +5V_CON +8V_CON
A A
3C01 3V3 EAn
* * * 10R
9C00
3022
3030
3036
+3V3_INTOTC
RES
1K2
4K7
4K7
2C00
100n
IC50 RES
7021-1
B BC847BPN B
10K IC51
*
3C03
FC72 7018
10K
BC847BPN ANTI-MOIRE B4
2C01
74LVC245APW
100n
7021-2
B5a
PWM_BACKLIGHT
3028
4K7
* IC52
7020
3032
BC847BW * ( CONTROL)
BACKLIGHT
B
3C08 FC71
0V1
19
G3 VCC
20
B
* *
9019
7017
PDTC144EU
10K
1
3EN1
3EN2
GND
10
B5a,c
SWITCH
* * * * SSSS8 b5a,c(2x)
3023
2063
100n
3070
3037
b5a,c(2x)
RES
2K2
27K
10K
b5a,c(2x) 2 18 SW_OE 3C06-1
1404 ROM_OE SW_OE 8 1 ROM_OE
1
C C 10R
9C01
1402
2 b5a,c(2x)
b5a,c(2x) 3C06-2 b5a,c(2x)
ROM_CS 3 17 SW_CS SW_CS 7 2 ROM_CS
SSSS8
b5a(3x),c(2x) b5a,c(2x) 10R 3C06-3 b5a(3x),c(2x)
RAM_OE 4 16 EP_OE EP_OE 6 3
RAM_OE
FC65
C b5a,c(2x)
RAM_CS 5 15 EP_CS
b5a,c(2x) 3C06-4
EP_CS 5 4
10R
RAM_CS
b5a,c(2x) C
b5a(3x),c(2x) b5a,c(2x) 10R 3C07-1 b5a(3x),c(2x)
WE 6 14 EP_WE EP_WE 1 8 WE
b5c(2x) b5a,c(2x) 3C07-2 10R b5c(2x)
WP 7 13 SW_WE SW_WE2 7 WP
b5a,c(2x) 10R 3C07-3 b5c(2x)
8 12VPP-EPG VPP-EPG 3 6 WP
b5c(2x) b5a,c(2x) 3C07-4 b5c(2x)
D D SWITCH 9 11 VPP-SW 10R
9C02
VCCW VPP-SW4 5 VCCW
FOR SOFTWARE 10R
DOWNLOAD
10K
+3V3_INTOTC
1 2 3 4 470R 7019
2C02
100n
74LVC245APW
3V3 19 20
G3 VCC
1 10
3EN1 GND
3EN2
SWITCH
E b5c(2x)
VCCW 2 18 VPP-EPG
b5a,c(2x) E
1
2
b5a,c(2x)
3 17 VPP-SW
b5c(2x) FC64 b5a,c(2x)
WP 4 16 EP_WE
b5a(3x),c(2x) b5a,c(2x)
WE 5 15 SW_WE
b5a,c(2x) b5a,c(2x)
RAM_CS 6 14 SW_CS
b5a(3x),c(2x) b5a,c(2x)
RAM_OE 7 13 SW_OE
F b5a,c(2x)
ROM_CS 8 12 FC63
EP_CS
b5a,c(2x) F
b5a,c(2x) FC62 b5a,c(2x)
ROM_OE 9 11 EP_OE
E_14620_094.eps
8204 000 8344.3 070704
1 2 3 4
Circuit Diagrams and PWB Layouts FTP2.2E AA 7. EN 54
B6a(3x),C(3x)
2A04 B3 3A20 C10 IA13 E2
B5a,B14b
2A05 B1 3A21 B11 IA14 E2
B6b,c
2A06 B1 3A22 I3 IA15 F2
B14d
B6b,d
B6b,d
B6a
B6c
B6d
B6c
B6b
B6c
B6c
nc
A A 2A07 B2 3A23 D10 IA16 F2
2A08 B2 3A24 I8 IA17 F2
RESET-AUDIO
SYS-CLK0
REG-SW
I2S-DPL-CLK
I2S-DPL-WS
I2S-DPL-OUT
I2S-MSP-OUT
I2S-MSP-IN
I2S-MSP-CLK
I2S-MSP-WS
SUBW-SPI-SW
REF-AUD
DACM-SUB
+5DA +5DB 2A09 B3 3A26 D9 IA18 G2
+11V_S +11V_AUD +11V_AUD
2A10 B13 3A27 D10 IA21 I10
SYS-RESET
+5V +8V +11V_AUD
5A00 IA10 2A00 2A11 B10 3A28 D9 IA22 B8
2AB8
30R 9A18 2A14 B13 3A40 I6 IA23 D2
1n
2A01
5A01
1u
30R
1n0
2A02
1u
100K
3A01
3A11
2K2
FA28
3A03
6R8
100n 2A16 B12 3A46 I3 IA25 C2
2A09
2A11
100n
10n
FA12 2A17 B7 3A47 H5 IA35 D7
3A21
5
2A03
2A04
3A12
100u
27K
8
47K
FA13 B6a(3x),
1u
+5DB LM833D
2A06
3A00
3A13
3A14
22K
REF-AUD
47K
47K
100u 16V
B C(3x) B
2A05
2A16
2A14
100u
100n
100K
3A15
7A01
2A15
1n
5A03 IA12 7A00-B 2A20 B11 3A49 I3 IA40 I8
PDZ-10B
FA14 7
6
2A18
2A17
6A00
100u
2A21 B7 3A51 I6 IA41 I8
1n
2A20 3 4
2A08
2A07
8 FA17
1n0
IA22 BC847BW
1u
2A21
100n
6V3
3A09
22K
7A02 2A23 C9 3A53 I6 IA43 I6
IA25 7 9 8 57 60 61 14 15 12 5 6 3 4 2A22 7A03-B IA04 100R
MSP4450 31 5 8 2 2A25 C11 3A55 I4 IA46 I8
3A19 LM833D 7A00-A
SCL-F 4 2A26 C10 3A60 I6 IA47 I8
I2S-CL
I2S-WS
I2S-DA-IN2
I2S-DA-O1
I2S-DA-IN1
ADR-CL
ADR-WS
D-CTR-IO1
D-CTR-IO0
ADR-DA
AUD-CL-OUT