Escolar Documentos
Profissional Documentos
Cultura Documentos
ni c
so
pe
Ma
GEV EMICODE
Mapesonic CR has been specifically developed With very low emission of volatile organic compounds
for application in existing buildings to improve (EMICODE EC1 Plus).
soundproofing without removing the floors and screeds.
May be applied on heated floors.
It is particularly suitable, therefore, for all buildings
(residential units, hotels, offices, rest-homes, schools, Certified according to current standards.
etc.) under renovation.
RECOMMENDATIONS
Typical application examples
Only apply on horizontal internal surfaces.
Mapesonic CR may be used:
Do not apply in areas subject to heavy traffic.
under resilient floor coverings (PVC, rubber, linoleum);
under all types of parquet; Do not apply under lightweight or shiny resilient floor
coverings or under cushion-floor.
on all types of substrates (cement-based);
Apply Mapesonic Strip around the perimeter to
on old ceramic, stone, wooden and resilient floors. avoid the formation of acoustic bridges.
Easy and quick installation. Make sure the product is applied on solid substrates.
Thickness: 2 mm 4 mm
Length (m): 30 20
Width (m): 1 1
Colour: brown-black
Packaging: rolls
* n PX21361-1
Do not apply over expansion joints or pipe-work) the substrate must be levelled
structural cracks. before laying Mapesonic CR.
Do not apply on substrates subject to To even out laying surfaces please refer to
continuous rising damp. the catalogues which illustrate the various
ranges of MAPEI products for the preparation
Preparation of the substrate of substrates or contact the MAPEI Technical
Mapesonic CR may be applied on all types Assistance Department.
of cementitious or anhydrite substrates as
After suitable long as they are well cured, mechanically APPLICATION PROCEDURE
preparation of the strong, coherent, dry, flat, have no cracks Before laying rolls of soundproofing material,
substrate, spread on and are free of dust and other material which and before removing the protective plastic
the adhesive to bond
the soundproofing could compromise adhesion. backing sheet, apply Mapesonic Strip
sheets adhesive tape around the perimeter of
Cracks may be repaired with products such the room and around pillars and all other
as Eporip, Eporip Turbo or Epojet. abutments.
Mapesonic CR may be laid on old ceramic On clean, dry surfaces unroll the sheets
and stone, floor coverings as long as they of Mapesonic CR in the direction of the
are well bonded to the substrate and have longest side of the room. Leave 24 hours to
been cleaned to remove traces of grease, oil, acclimatise before cutting them to size.
wax, varnish, etc.
Roll the sheets up again to half their length,
On uneven surfaces and areas where fittings with the remaining part lying on the substrate,
Unroll the sheets of pass through (such as electric cables and and spread the adhesive dependant on
Mapesonic CR on
the surfaces to be
soundproofed
the characteristics of the substrate on the To use the aforementioned MAPEI products
exposed part of the surface. correctly, please refer to the specific
technical data sheet for each product
Ultrabond Eco V4 SP must be used on available at our website www.mapei.com.
absorbent substrates, such as screeds and
smoothing and levelling compounds. PRODUCT FOR PROFESSIONAL USE.
915-7-2012