Escolar Documentos
Profissional Documentos
Cultura Documentos
SOLID SLABS
Originated from RCC11.xls v4.0 2006 - 2010 TCC
Notes
9 Stresses in N/mm2
Compression +ve
7 1
- - - Neutral axis
Disclaimer
All advice or information from MPA-The Concrete Centre is intended for those who will evaluate the significance and limitations of its contents
and take responsibility for its use and application. No liability (including that for negligence) for any loss resulting from such advice or
information is accepted by MPA-The Concrete Centre or its subcontractors, suppliers or advisors. Users should note that all MPA-The
Concrete Centre software and publications are subject to revision from time to time and they should therefore ensure that they are in
possession of the latest version.
This spreadsheet should be used in compliance with the accompanying publication 'User Guide RC Spreadsheets: v4' available from The
Concrete Centre www.concretecentre.com/rcdesign Tel +44 (0)1276 606800
Status of spreadsheet This spreadsheet is shareware but may not be used for commercial purposes until the user has
Public release version. registered with The Concrete Centre using the licence validation form available on The Concrete
Centre website www.concretecentre.com/rcdesign
24-Nov-00 RCC11 v1.3 SHEAR:C19 & C20 reformatted, and lateral link spacing check added (C Braidwood). 185
30-May-00 RCC11 v1.2 R Lawson comments incorporated (gc refs etc). 183
Revisions to TEE~BEAM. Option of required compression rebar added. Neutral axis, x
8-May-00 RCC11 v1.1 allowed below flange soffite - IStructE 'Green book' method followed where flanges 182
outside bw have z = d-hf/2, and bw acts as beam.