Você está na página 1de 2

SCOPE OF WORK

The construction procedures shall be done in accordance with the DPWH Standard
Specifications, and in full compliance with the approved plans and specifications.
Pertinent notes appearing in the Contract Plans or Drawings shall also be considered as
part and parcel of the technical specifications. Such notes shall take precedence over the General
Specifications.

Clearing and Grubbing


This item shall consist of the removal, hauling, and stockpiling of all materials including
trees, stumps, roots vegetation, logs wastes, debris and protruding objects except those that are
designated to remain in accordance with other items of these Specifications and where directed
by the engineer. The holes resulting from grubbing operations, where directed by the Engineer,
shall be filled with approved materials which shall be placed and compacted to the same dry
density as that of the adjoining soil.
Structure Excavation
All excavation shall conformed to the lines, and grades shown on the approved Plans or
established by the Engineer. It shall be finished to reasonably smooth and uniform surfaces and
no materials shall be wasted without authority of the Engineer.
Excavation operations shall be conducted so that the materials outside of the limits will
not be disturbed. All suitable materials removed from excavation shall be used for backfill and
for other purposes.
Structure Excavation shall include the furnishing and placing of approved foundation fill
materials to replace unsuitable materials encountered below the foundation elevations of
structure.

Water used in mixing, curing or other designated application shall be reasonably clean
and free from oil, salt, alkali, grass or other substances injurious to finish the product.

Reinforcing Steel
Placing of steel reinforcement shall be in accordance with the Specification and in
conformity with the requirements shown on the Approved Plans or as directed by the Engineer.
Steel reinforcement shall be stored above the surface of the ground upon platforms, skids,
or other supports and shall be protected as far as practicable from mechanical injury and surface
deterioration caused by exposure to conditions producing rust. When place in the work,
reinforcement shall be free from dirt, detrimental rust, loose scale, paint, grease, oil or other
foreign materials. It shall be accurately placed in the position shown on the plans or required by
the Engineer and firmly held there during the placing and setting of concrete.

Concrete
Furnishing, placing and finishing of concrete shall conform to the specifications and in
accordance with the lines, grades and dimensions shown on the approved Plans.
The concrete materials shall be proportioned in accordance with the requirements for
each class of concrete (21 MPa compressive strength for class A concrete) Composition and
strength of Concrete for use in structures of DPWH Standard specifications.
Concrete shall have a consistency such that it will be workable in the required position. It
shall be of such a consistency that it will flow around reinforcing steel.

Mobilization and demobilization


The Contractor upon receipt of the Notice-to-proceed shall immediately mobilize and
transport his plant, equipment, materials and labor forces to the site and demobilize or remove
the same at the completion of project and level/ clear the site acceptable to the Engineer.

Você também pode gostar