Escolar Documentos
Profissional Documentos
Cultura Documentos
: 02
AIM
Programming the AES-51 using the keypad and executing the program.
OBJECTIVES
1. To introduce new users to machine code programming using the AES-51 board as
a stand alone unit.
APPARATURES
The * on the top left corned disappeared on the data entry mode.
Sometimes 1 or 2 addresses are skipped after pressing the ENTER key after inputting the
value.
When the program is executed All four output LEDs switched on for a short time and then
turned off again.
DISCUSSION
As we can see in the data entry mode there are 3 data types we can enter.
Hex, Decimal and Binary.
Sometimes when we try to proceed to the next entry, addresses are skipped then we have
to manually enter the address using the GOTO key.
This program is stored on the RAM so the program can be reused unless the board is
powered down.
By converting this machine code into assembly language we can see how this delay
works.
ORG 0000H
SETB A8
RET
END