Escolar Documentos
Profissional Documentos
Cultura Documentos
PUTRAJAYA CAMPUS
TEST
SEMESTER 1 2017/2018
INSTRUCTIONS TO CANDIDATES:
Page 1 of 4
CESB 333, Semester 1, 2017/2018
Beam AB and CD of steel structure shown in Figure 1 have same length of 8XXX.X mm.
The beam AB restrained at support and at several equal distances along its span. The beam
CD is fully restrained at one of its segment. It is restrained at the middle of its span and at
its both end supports. The steel grade of the structure is S275.
Q1. Evaluate the adequacy of beam AB and CD by comparing its buckling moment
design resistance, Mb,RD using appropriate clause in Eurocode 3. The beams are hot
rolled standard section of UB 533 x 210 x 82 kg/m. The overall Bending Moment
diagram of the structure shown in Figure 2. The Bending Moment Area (BMD) for
both beams are given in Figure 3 and Figure 4. The approximate value of C1 is
derived from the following expression, where C1 = 1.88 1.40 + 0.522
[50 Marks]
Page 2 of 4
CESB 333, Semester 1, 2017/2018
1XX.XX
11X.25
130.25 12X.XX
Page 3 of 4
CESB 333, Semester 1, 2017/2018
Q2. Apply the appropriate clause of Eurocode 3 to check the shear resistance of beam
CD and possible reduction of its bending moment resistance design on high shear
area. The shear force diagram for beam CD is shown in Figure 4.
[25 Marks]
6X.XX
5X.X1
Q3. If at the middle of span of beam CD, the secondary beam is attached on top flange,
determine the resistance to transverse force of beam CD if the length of stiff
bearing, Ss is 9X.XX mm. Size of beam CD is as stated in Q1.
[25 Marks]
Use your student ID to substitute the XXX (e.g. for XXX.X, use the last four number of your
student ID for substituting it).
Page 4 of 4