Escolar Documentos
Profissional Documentos
Cultura Documentos
Sporlan Division
206 Lange Drive
Washington, MO 63090
U.S.A.
ACTI-KLEAN AK1 (P/N 475107); AK5 (P/N 475111); AK55 (P/N 475114)
SECTION 1. IDENTIFICATION
OSHA: This material is classified as hazardous under OSHA regulations (29CFR 1910.1200). Hazardous classification:
Label elements
The following label information is applicable only to the United States according to OSHA Regulations (29 CFR
1910.1200) (Hazcom 2012):
Signal Word
DANGER!
Hazard statement(s)
Causes severe skin burns and eye damage.
.
Parker Hannifin Corporation
Sporlan Division
206 Lange Drive
Washington, MO 63090
U.S.A.
ACTI-KLEAN AK1 (P/N 475107); AK5 (P/N 475111); AK55 (P/N 475114)
Precautionary statement(s)
Do not breathe mist.
Wash hands thoroughly after handling.
Wear protective gloves/clothing and eye/face protection.
The following label information is applicable only to Canada according to the Canadian Controlled Products Regulations
(CPR/WHMIS):
DANGER!
Corrosive material. Causes skin and eye burns. Toxic. Toxic if swallowed, in contact with skin or if inhaled. May
cause respiratory irritation. Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea.
Use only in well-ventilated areas. Wear protective gloves/clothing and eye/face protection. Do not breathe mist. Avoid
contact with skin, eyes and clothing. Avoid contact with incompatible materials. Keep containers tightly closed when not
in use.
IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF INHALED: Remove person to fresh air and keep
comfortable for breathing. IF ON SKIN: Wash with plenty of soap and water. IF IN EYES: Rinse cautiously with water for
several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Seek immediate medical
attention/advice.
Other hazards
Other hazards which do not result in classification: Burning produces obnoxious and toxic fumes. May cause respiratory
tract irritation. Ingestion can cause irritation and corrosive action in the mouth, stomach and digestive tract.
Extinguishing media
Suitable extinguishing media
: Use media suitable to the surrounding fire such as water fog or fine spray, alcohol
foams, carbon dioxide and dry chemical.
Unsuitable extinguishing media
: Do not use a solid water stream as it may scatter and spread fire.
Special hazards arising from the substance or mixture / Conditions of flammability
:
Not flammable. However, may burn if exposed to extreme heat and flame. Closed
containers may rupture if exposed to excess heat or flame due to a build-up of internal
pressure. Vapors are heavier than air and may spread along floors.
Flammability classification (OSHA 29 CFR 1910.106)
: Not flammable under normal conditions of handling.
Explosion Data: Sensitivity to Mechanical Impact / Static Discharge:
: Not expected to be sensitive to mechanical impact or static discharge.
Hazardous combustion products
:Carbon oxides; Sulphur oxides; hydrogen sulphide; Phosphorus compounds; Other
unidentified organic compounds.
Special protective equipment and precautions for firefighters
Protective equipment for fire-fighters
Parker Hannifin Corporation
Sporlan Division
206 Lange Drive
Washington, MO 63090
U.S.A.
ACTI-KLEAN AK1 (P/N 475107); AK5 (P/N 475111); AK55 (P/N 475114)
: Firefighters must use standard protective equipment including flame retardant coat,
helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA.
Special fire-fighting procedures
: Firefighters should wear proper protective equipment and self-contained breathing
apparatus with full face piece operated in positive pressure mode. Move containers
from fire area if safe to do so. Water spray may be useful in cooling equipment
exposed to heat and flame.
Exposure Limits:
Exposure controls
Ventilation and engineering measures
: Use general or local exhaust ventilation to maintain air concentrations below
recommended exposure limits.
Respiratory protection : If the TLV is exceeded, a NIOSH/MSHA-approved respirator is advised. Advice should
be sought from respiratory protection specialists. Respirators should be selected
based on the form and concentration of contaminants in air, and in accordance with
OSHA (29 CFR 1910.134) or CSA Z94.4-02.
Skin protection : Impervious gloves must be worn when using this product. Advice should be sought
from glove suppliers.
Eye / face protection : Chemical splash goggles are recommended. A full face shield may also be
necessary.
Other protective equipment : Wear resistant clothing and boots. An eyewash station and safety shower should be
made available in the immediate working area.
General hygiene considerations
: Handle in accordance with good industrial hygiene and safety practice. Avoid
breathing vapour or mist. Avoid contact with skin, eyes and clothing. Wash
contaminated clothing before reuse. Wash hands thoroughly after using this product,
and before eating, drinking or smoking.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
LC50(4hr) LD50
2-butoxyethanol 450 ppm (2.175 mg/L) 530 mg/kg 400 - 500 mg/kg
Ecotoxicity data:
Toxicity to Fish
Ingredients CAS No
LC50 / 96h NOEC / 21 day M Factor
Handling for Disposal : Handle waste according to recommendations in Section 7. Empty containers retain
residue (liquid and/or vapour) and can be dangerous.
Methods of Disposal : Dispose in accordance with all applicable federal, state, provincial and local
regulations. Contact your local, state, provincial or federal environmental agency for
specific rules.
RCRA : If this product, as supplied, becomes a waste in the United States, it may meet the
criteria of a hazardous waste as defined under RCRA, Title 40 CFR 261. It is the
responsibility of the waste generator to determine the proper waste identification and
disposal method. For disposal of unused or waste material, check with local, state and
federal environmental agencies.
TDG None.
Additional
information
49CFR/DOT None.
Additional
information
ICAO/IATA None.
Additional
information
SARA TITLE III: Sec. 311 and 312, MSDS Requirements, 40 CFR 370 Hazard Classes:Immediate (Acute) health
hazard; Chronic Health Hazard. Under SARA Sections 311 and 312, the EPA has established threshold quantities for
the reporting of hazardous chemicals. The current thresholds are 500 pounds for the threshold planning quantity (TPQ),
whichever is lower, for extremely hazardous substances and 10,000 pounds for all other hazardous chemicals.
Canadian Information:
Canadian Environmental Protection Act (CEPA) information: All ingredients listed appear on the Domestic Substances
List (DSL).
WHMIS information: Refer to Section 2 for a WHMIS Classification for this product.
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the
information required by the CPR.
International Information:
Components listed below are present on the following International Inventory list:
Parker Hannifin Corporation
Sporlan Division
206 Lange Drive
Washington, MO 63090
U.S.A.
ACTI-KLEAN AK1 (P/N 475107); AK5 (P/N 475111); AK55 (P/N 475114)
2-butoxyethanol 111-76-2 203-905-0 Present Present (7)-97; (2)-407 KE-04134 Present HSR001154
Dodecylbenzenesulfonic 27176-87-0 248-289-4 Present Present (3)-1907; (3)-1884 KE-12947 Present HSR003407
acid
Distillates (petroleum), 64742-47-8 265-149-8 Present Present (9)-1700 KE-12550 Present No
hydrotreated light information
available.
Tetrasodium EDTA 64-02-8 200-573-9 Present Present (2)-1265 KE-13654 Present HSR003275
Poly(oxy-1,2-ethanediyl), 9014-92-0 N/Av Present Present (7)-172 KE-13016 Present Not listed
alpha-(dodecylphenyl)
-omega-hydroxy-
sodium hydroxide 1310-73-2 215-185-5 Present Present (2)-1972; (1)-410 KE-31487 Present HSR001547
: 13/05/2015
Revision No. : 3
Revision Information : (M)SDS sections updated
Other special considerations for handling
: Provide adequate information, instruction and training for operators.
- Chronic hazard 0 - Minimal 1 - Slight 2 - Moderate 3 - Serious 4 - Severe
HMIS Rating : *
Health: *3 Flammability: 1 Reactivity: 0
NFPA Rating 0 - Minimal 1 - Slight 2 - Moderate 3 - Serious 4 - Severe
: Health: 3 Flammability: 1 Instability: 0 Special Hazards: None.
Prepared for:
Parker Hannifin Corporation - Sporlan Division
206 Lange Drive; Washington, MO 63090, U.S.A.
Telephone: ( 636) 239-1111
www.sporlan.com
Direct all enquiries to: Parker Hannifin Corporation - Sporlan
Division.
Prepared by:
ICC The Compliance Center Inc.
Telephone: (888) 442-9628 (U.S.): (888) 977-4834 (Canada)
http://www.thecompliancecenter.com
DISCLAIMER
This Material Safety Data Sheet was prepared by ICC The Compliance Center Inc. using information provided by /
obtained from Parker Hannifin Corp and CCOHS Web Information Service. The information in the Material Safety Data
Sheet is offered for your consideration and guidance when exposed to this product. ICC The Compliance Center Inc and
Parker Hannifin Corp expressly disclaim all expressed or implied warranties and assume no responsibilities for the
accuracy or completeness of the data contained herein. The data in this MSDS does not apply to use with any other
product or in any other process.
This Material Safety Data Sheet may not be changed, or altered in any way without the expressed knowledge and
permission of ICC The Compliance Center Inc. and Parker Hannifin Corp.
END OF DOCUMENT