Escolar Documentos
Profissional Documentos
Cultura Documentos
Buzzer
Water-filling entrance Outer cover of the spin tub
Water inlet selector handle
Inner cover of the spin tub
Wash selector
Wash timer Spin timer
Control panel Spin tub frame
Overflow filter Spin tub
Water level adjusting lever
1
Safety precautions
Please insert the power cord into When the machine is normally
special receptacle with rated vol- using, please put the power plug
tage.Be sure to use single-phase at the location easily to be insert-
three pins receptacle.The earthing ed and extracted by hand. Be sure
terminal of the receptacle must be to pull the plug off when there's
earthed reliably.If possible,please power failure, or the machine is
adopt electric leakage protector. being moved, cleaned orwhen it
is idle.
Do not put the machine at damp Do not use water hotter than 50 C .
place like the bathroom . Never
wash it with water. Do not place
wet laundries on the control panel.
In case the washing machine is installed Do not wash water-proof laundries like
on ground with carpet , do not block the the raincoat, bike covers etc. to avoid
ventilation hole with carpet. abnormal vibrations in spinning.
Ventilation hole at
the bottom of the
washing machine
2
Safety precautions
Do not stretch hands into the working Do not decompose, repair or alter the
machine. It is dangerous even if the machine by yourself.
rotation is slow. Take special care of
the children.
Do not put any hot or heavy items Do not wash laundries with volatile
( such as the kettle with hot water ) materials (such as thinner, petrol etc.).
on the washing machine.
l
Petro Thinner
Handicapped or children without care Keep the machine away from direct
shall not use the machine. sunlight and heat source like the
heater.
To protect your laundries and wash- Please check if the water faucet is open,
ing machine, please take out all of the and if the connection of the water inlet
coins, buttons, sand, hairpin and pipe is proper.
other foreign materials before washing. It is suggested to use foamless washing
powder.
3
Installation and adjustment
Please install and adjust the machine according to the requirement of
the manual. It is very important to your security and correct
operating the machine.
H 0.7m<H 1.2m
4
How to change the direction of the drain hoses
Drain hose
Take off the drain hose from the hanging fixing hook Figure 1
hole of the cabinet. Pull the drain hose
fixing hook outwards gently to take out
Side sectional view
the drain hose from the two fixing hooks.
Drain hose Fixing hook
(As per Figure 2) fixing hook installation hole
Drain hose
Pull outwards
Rotate the drain hose fixing hook for 90 slightly
to take it out from the installation hole Take off Figure 2
the drain hose
(As per Figure 3).
5
Preparation before washing
Preparation before washing
1.Connect the water inlet hose.
2.Confirm that the washing machine is earthed
reliably . Then insert the power plug into the
receptacle. Do not connect the earth terminal
to the gas pipe and tap water pipe.
3.Put the drain hose up to suitable position.
6
The musts in washing
7
Washing sequence
Wash selector Water-filling selector handle
(standard current,
gentle current)
Wash timer Water-filling entrance Overfilling sign
(To set to below 2 minute,
first set to 5 minute then Buzzer Spin timer
turn it back. it can increase
the service life of the timer). (The buzzer will ring when (to set to below 1 minute,
the washing finishes) first set to 2 minute then
turn it back. it can increase
the service life of the timer).
STANDARD
OFF OFF OFF
GENTLE
15 3 5 1
DRAIN
MAX
12 6 BUZZER 2
4
9 WASH SELECTOR 3
WASH TIMER SPIN TIMER
Wash
WASH SPIN
1.Water-filling selector
(1) Set the water-filling selector at the "WASH" side.
(Figure 1) Figure 1
(2) Set the water level adjusting lever to needed line.
2. Fill the water and add the dissolved washing
powder to make the water level reach the preset
position. (Figure 2)
Run washing program for some time to stir and
Figure 2
dissolve the powder completely.
STANDARD
GENTLE
DRAIN
GENTLE
6.After washing, the buzzer will ring. Set the "WASH DRAIN
8
Midway spinning
1.Put the laundries into the spin tub evenly and smoothly.
2.Spin
(1) Put the gland in properly.
Please put in the gland properly even if the
laundries quantity is small.
Push Gland
Push
Outer cover of
The spin tub
Inner cover of
The spin tub
(3) Spin for 1-2 minutes.
9
Rinsing
3.Rinse
Adjust the wash timer to 5-7 minutes to do
rinsing.
3. Rinse
Adjust the wash timer to 2-3 minutes to do rinsing.
10
Spinning
Spin time
2. Press the gland in the tub properly. Laundries (minutes)
Close the inner and outer cover of
the spin tub. Bed sheet or
blanket About 4~5
In spinning, it will pause the work if you open the outer cover of
the spin tub. Close it to resume the spinning.
11
Disposal after washing
After using, please clean the lint and foreign materials of the lint filter and
overflow filter in time. Otherwise it may influence your using the machine.
Please first pull off the power plug from the receptacle before cleaning.
12
Cleaning the overflow filter
2. Take off the corrugation pipe.
Dismantle the upper part of the Water level
adjusting lever
corrugation pipe inside the
overflow filter ( as indicated in
Corrugation
Figure 1). Pipe
13
Trouble-shooting Answer to question
14
Trouble-shooting Answer to question
(If there's breakdown, please pull off the power plug before checking) The following
phenomena are not breakdowns sometimes. Please confirm again before sending
it to repair. If there are real breakdowns, please come to the special maintenance
department or after-sale service department of our company. Do not repair it by yourself.
There's abnormal
sound during washing Are there hair pin, coins or metal items brought
inside the tub?
15
Packing list
Name Quantity
Specification
16