Escolar Documentos
Profissional Documentos
Cultura Documentos
High voltage
DISCLAIMER
TRANSPORTATION - WARNING
THE GENERATOR SET DOOR(S) MUST BE LOCKED
BEFORE TRANSPORTATION, AND MUST REMAIN LOCKED
DURING TRANSPORTATION AND SITING.
BEFORE ANY TRANSPORTATION,
THE FLUID CONTAINMENT AREA MUST BE INSPECTED
AND EMPTIED OF ANY SPILLAGE OR ENGINE WASTE.
Performance?
Sound?
Breaker Open
DD
Engine
Appearance? Close
Breaker
Manual Stop
Breaker Open
Auto Start-up
L
D
WARNING: Set may start automatically as soon as Auto Mode is selected.
! In Auto Mode, the set is started or stopped with a Remote Signal.
Genset Engine Model Oil (Premium Blue) Coolant Air Filter Fuel Filter
Qty Filter Qty Part No.
Litres Imp. Gall Part No. Litres Imp. Gall Primary Secondary Part No.
C1250 D2R KTA50G3 203 53.6 LF777/LF3325 555 146.6 AF25544 AF25545 FS19870
! Personnel working on generator plant must be familiar with normal operating procedures and hazards!
! Failure to observe safety precautions may result in severe personal injury or death!
! Ear protection must be used at all times!
Control Panel
EMERGENCY STOP
Push to
Display Module -
Front Panel ! STOP THE GENERATOR SET
IMMEDIATELY !
To Reset:
Investigate and correct the fault.
Pull the activated Emergency Stop Switch
to unlatch it.
Press the Off Mode button.
Press the Manual Run or Auto Mode
button as required.
WARNING
DO NOT
use the Emergency Stop b u t t o n
for a Normal generator set shutdown.
AUTO:
Generator set is started Stop Button
automatically Four Change Auto Button
via a remote start signal. Selection Buttons
Start Button
Circuit Breaker Closed Button
OFF: Item Select Button
Circuit Breaker Open Button
Initiates the shutdown of the
generator set. Manual Run Button
Previous Screen Button
! WARNING: All checks must only be carried out on a switched off, isolated and cold generator set!
! Personnel working on generator plant must be familiar with normal operating procedures and hazards!
! Failure to observe safety precautions may result in severe personal injury or death!
! Ear protection must be used at all times!
OK
Com Gas
bus
tible
DAILY MAINTENANCE
Check for Loose or Damaged Electrical and Mechanical Parts. If in doubt, contact your Rental Company.
Electrical Connections
! WARNING: All checks must only be carried out on a switched off, isolated, and cold generator set!
! Personnel working on generator plant must be familiar with normal operating procedures and hazards!
! Failure to observe safety precautions may result in severe personal injury or death!
! Ear protection must be used at all times!
Note: The Hirer is responsible for the Daily checks of the system.
Further, more extensive, monthly and yearly checks must be carried out by the Rental Company.
1. Check Hoses, Fuel Lines, and 2. Check Oil Level: Use Premium Blue or Equivalent
Exhaust System for Leaks
5. Check Fuel Level 6. Check Fuel-Water Separator 7. Check Air Inlet/Outlet 8. Check
Air Restriction Indicator
! !
WARNING
Do NOT refill fuel tank
if the set is running
CAUTION: The set must not be run off-load for more than fifteen minutes.
For Additional Assistance: Decal for Rental Sets
Tel: E-mail: A041F701 Issue 01 12-2011
Sheet 5 of 5
Fax: Web Site: English - Original Instructions