Escolar Documentos
Profissional Documentos
Cultura Documentos
Assessment 2
Description OH&S: Safety boots and lab coats must be worn during lab sessions in the Control Lab
building. Foods and drinks are strictly prohibited.
The main aim of this assignment is to investigate effects of quantization and sampling
on digital data using DAQ cards and LabVIEW and analyse provided data set/s. You
need to:
To complete this assessment you need to use Control Lab facilities (you MUST attend
at the specified time to gain access). In the Control Engineering Lab
(NH.AN28.L01.103, the Old Cavitation Tunnel Building) there are the following
transducers, data acquisition boards and software:
You are recommended to run 1 experiment using the following transducers and data
acquisition boards:
1 DR. JONATHAN BINNS, DR AHMED SWIDAN AND SANAZ JAHANGIRI ON 19TH JULY 2017
Experiment 1 (unknown frequency signal): USB-6351, Maxon DC motor with
imbalance mass rotor and motor drive, encoder, charge mode accelerometer and charge
amplifier to get raw data including acceleration, speed and current signals.
The data will be saved in text-formatted files. Please take your USB memory stick to
copy data files.
Task Length Sufficient to describe the experiment, the fundamentals of the analysis method, the
results and the meaning of the results. Typically this will be a report of approximately
5-10 pages (excluding Appendix) like a journal/conference paper. You can use the lab
report template at https://www.amc.edu.au/beng.templates.
Due Date 11:59 pm 21 August 2017 (you can submit the electronic copy with analysis programs
via MyLO or email. No hardcopy is required.)
ASSESSMENT CRITERIA
The extent to which the three elements listed above are defined.
2 DR. JONATHAN BINNS, DR AHMED SWIDAN AND SANAZ JAHANGIRI ON 19TH JULY 2017