Escolar Documentos
Profissional Documentos
Cultura Documentos
Disconnect all leads from board 33 and remove control board. Technical Data Technical Data Power requirements Relieve pressure, page 7. Was
This Manual Helpful? Carefully slide control board back into place on the side of the motor frame. To print the manual completely, please,
download it. Apply a liberal coat of grease to gears and needle bearing surfaces. Read warnings, page Recommended extension cords for use with
this The sprayer cord includes: Comments to this Manuals Your Name. Turn prime valve down. Warnings Warnings Warnings The following are
general warnings related to the safe setup, use, grounding, maintenance, and repair of this equip- ment. Push each cap A into place over brush. Pull
control board out slightly and then slide it back and off of frame. Refill and reprime pump. Read Injection Hazard Warning, page 3 and , page
Needle bearing surfaces Don't show me this message again. Read Electric Shock Warning, page 3 and Pressure 3. Cycle pump until pin 32 is in
position to be removed. By pressing 'print' button you will print only current page. Read all warnings and instructions. Refer to gun instruction
manual, Installation Installation Installation Grounding and Electric Do not use the sprayer if the electrical cord has a dam- aged ground contact.
Only use an extension cord with Requirements an undamaged ground contact. Also See for Operation manual - 40 pages. Remove four screws 6
and motor 1 from frame If removed, install pressure control assembly. Replace fuse on control board with spare fuse. Reconnect, green ground
wire G to green ground- ing screw 31 on frame. Be Relief Procedure, page 7. Repair or replace worn or damaged parts immediately. If uneven or
no resistance, check for missing brush caps, broken brush springs, brush leads, and worn brushes. Disconnect power cord 1. Replace screws 6
and torque to in-lbs 17 N. Fan Replacement Fan Replacement Removal 3. Install shroud 29 and two screws Reconnect the power cord
connectors to the correct 4. Orient each cap with the 2 projections on either side of the brush lead. Remove two screws 30 and shroud Push
pump 9 up until pump threads engage. Table Of Contents Spin Test Slide new fan in place on back of motor.