(ft): Shank Bore (ins): 2.750 Shank Diam (ins): 8.000 Connection std: Y Connection Size 6.625 (ins): Connection Type: Api Reg Pin Make up Torque 47500 (ft-lbs):
Drift Diam (ins): 12 1/4"
Drill Diam (ins): 14 1/4" Max Tool (ins): 9 6250" Drift Diameter : 12 1/4" Drill Diameter : 14 1/4" CSDX6413S-A1 Pilot Dia (ins): 10 3/8" Max Tool Size: 9 6250" Pilot Gauge Design Features of this Hole Opener Length (ins): 2.3250 100% TReX* cutters - Thermostable PDC cutters featuring a unique layer of thermostable PDCGeometry: Straight that is 200% more heat tolerant and 400% more abrasion resistant than premium PDC. The thermostable layer dramatically improves abrasion resistance by maintaining a sharp, Profile: Flat slow-wearing, tough cutting edge. When a wearflat finally develops, the thermostable layer Reamer Gauge wears more slowly than the multimodal polycrystalline diamond behind it, forming a sharp Length (ins): 2.850 lip that maintains ROP. This allows the bit to drill significantly further and faster than Geometry: Straight premium PDC cutter bits. Profile: Flat Stabilizing Cutters cutters which are specially designed and placed to produce a beneficial increase in cutting force. These cutters are used to reduce the bit imbalance or to provide cutting forces that centralize the bit thus improving bit stability. Blade Qty Typically a bit will contain one stabilizing cutter per blade. Pilot: 6 CSD* - Bicenter bits that have the capability to drill the cement and float equipment, Reamer Full: 4 then drill a new hole section with a larger diameter than it passed through. These bits reduce the number of bits used and trips required, saving significant time and money. The Reamer Half: 6 CSDs patented design features not only allow it to drill out the casing equipment but Body Materials also demonstrate excellent directional control. The improved force balance (now comparable Pilot Body: Steel to standard PDC drill bits) allows the CSD to slide effectively during steering operations on PDM. Reamer Body: Steel IMPORTANT NOTE : If a motor is run behind a bicentre bit ALWAYS ensure that there is no part of the motor that will cause pass though problems - even when using "slick" motors. The size of the "slick sleeve or lower stabiliser thread protector" and wear pads on the bearing housing can cause problems. In some applications this bit is run successfully beyond these parameters. Contact your ReedHycalog Representative for recommended operating parameters in your application. ReedHycalog reserves the right to revise these specifications, based on advances and improvements in technology.
Cutting Structure Nozzles & Ports
Pilot Qty Location Dia(mm) Shape Pilot Qty Type Size Primary 42 PILOT FACE 13 BULLET 5 AAK VARIABLE Primary 5 PILOT FACE 13 STABILISING Reamer Qty Type Size Primary 11 PILOT TRIMMERS 13 BULLET 6 AAK VARIABLE Reamer Qty Location Dia(mm) Shape Primary 39 REAMER FACE 13 BULLET Primary 5 REAMER FACE 13 STABILISING Primary 4 REAMER GAGE 13 BULLET Primary 4 REAMER GAGE 13 CHAMFERED Primary 4 REAMER TRIMMERS 13 BULLET