Escolar Documentos
Profissional Documentos
Cultura Documentos
Appendix One
Area 1
Top Landing
Decoration to ceiling, lift shaft walls, install 6 panel viewing window,
aluminium framing colour yellow, 6.4 laminated glass.
Re-new trimming to reveals at lift doors.
Floor covering
Kudos planking to match reception.
Stairs
Treads, risers and landings, aluminium nosings to steps.
Vinyl
Altro walkway
Area 2
Trim around lift door reveals.
Form vanity area
Laminate surface, wall mounted mirror, replace hot air dryers 3 no.
Decoration
Apply masonry/emulsion paint to column and ceiling/ductings.
(colour magnolia or cream) Stain door frames etc.
Floor covering
Take up existing, latex floor, install vinyl T20 Altro flooring.
Drain
Break out and install new gully to enable vinyl to be sealed within gully.
2 x disabled
1 x first aid room
1 x corridor
Disabled fittings
Remove existing, supply and install 2 no. drop down grab rails.
Swallows October 08
2
Area 3
Wet change washrooms ladies and gents
Remove all existing cubicles, screens & w.cs and dispose of.
Take up existing floor covering.
Prepare floors install Altro T20 vinyl flooring.
Install 2 x floor gullies as previously specified.
Remove bottom course of wall tiling, install Altro trim, replace tiles.
Install new
W.Cs and concealed cisterns, 4 x ladies, 2 x gents
(Cubicles by others)
Ceiling
Take down existing plywood ceilings.
Install timber framing as required.
Install eternit lamina cladding sheets.
Fix with matching caps to enable panels to be removed for maintenance
access (choice of colours).
Lighting
Replace fluorescent fittings with Thorn Aquaforce fluorescent lights.
Area 4
Changing area
To remove all existing changing cubicles and dispose of (lockers to remain)
Lighting
Take down all existing fluorescent lights within this area and re-new using
Thorn Aquaforce, sizes as existing (excluding emergency lighting)
Provide power supply to sliding doors and possible stair lift onto poolside.
Fire Doors
To install additional pair of fire doors in corridor.
Doors fitted with timber framing. Install 2 layers 12.5 mm plaster board to
both sides fire rating.
Ceramic tile finish to match showers.
Doors to have push bar escape mechanism to comply with fire regulations.
Doors also to have vision panels.
Swallows October 08
3
Ceiling/Ducting
I have not quoted for a suspended ceiling within these areas as there are
a lot of services within this roof that will need to be accessible.
Also a suspended ceiling would be very low and may be subject to vandalism.
Also once a void has been formed it may cause condensation.
We have however, made provision to spray the roof and ducting etc with a
suitable paint. Colour magnolia.
Area 5
Wet Change Showers
After several discussions regarding the temperature and hot water deadleg
to these showers we would propose to install the following system;
Provide and install in the area behind the showers.
1 x vented gas fired water heater.
Providing 280 litres of stored water.
Recovery rate 340 litres per hour @ 44* rise.
Max distance to flue to outside 4 m
Showers would operate at mains pressure
(use new blending valve recently installed)
Services required
25 mm water main supply, 28 mm gas supply (check distance from main).
Electrical supply
(Assume all services are within this area).
Swallows October 08
4
Following your recent enquiry, please find listed below our quotation for the SUPPLY &
INSTALLATION of the items from our ,Marathon range as required at the above project.
Fully framed system with Polyester powder coat finish to aluminium extrusions
Panel Specification: 12mm Laminate panels from the standard Formica large sheet range
Cubicle Height: 2006mm including a floor clearance of 150mm, adjustable for floor levels.
Accessories: Changing cubicles to have bench seat brackets with 12mm laminate seat &
Nylon coat hook.
Fully framed system with Polyester powder coat finish to aluminium extrusions
Panel Specification: 12mm Laminate panels from the standard Formica large sheet range
Cubicle Height: 2006mm including a floor clearance of 150mm, adjustable for floor levels.
Accessories: Nylon coat hook
Fully framed system with Polyester powder coat finish to aluminium extrusions
Panel Specification: 12mm Laminate panels from the standard Formica large sheet range
Cubicle Height: 2006mm including a floor clearance of 150mm, adjustable for floor levels.
Accessories: Arcus type toilet roll holder & Nylon coat hook. Door Restraint to outward
opening doors
Please Note ! The installation of this duct panel system is carried out in one visit to site.
Swallows October 08
5
Panel Specification: 12mm Laminate panels from the standard Formica large sheet range
Panel Height: 2006mm including a floor clearance of 150mm, adjustable for floor levels.
Specification: 18mm Composite board faced both sides and all exposed edges with
laminate with a 200mm postformed downstand and 100mm backstand
Specification: 18mm Composite board faced both sides and all exposed edges with
laminate with a 200mm postformed downstand and 100mm backstand
Bracket specification: Powder coated mild steel seat brackets, type 740.3525
Seat specification: Solid Grade Laminate slats from the standard Formica range.
Coat rail specification: Rail above with hooks @ 200 centres
Marathon Lockers
Swallows October 08
6
Changing Village
1 L Shaped Grooming Shelf @ 6250mm long x 350mm deep x 850mm high with 2 ends
1,246
1 @ 1962mm Floor mounted double island bench seat 862mm wide x 415mm high to seat
717
137 - 1830 / 2 Tier lockers in 14 block
274 - Half height compartments
5 - Single end panels
10 - Double end panels
3 - Infill Panels 35,794
Swallows October 08
7
Female Toilet
1 x Duct Panel to 5nr WCs @ 5000mm wide x 2400mm high with 1 end 2,738
1 Vanity Unit @ 2805mm long x 600mm deep x 850mm high with 2 Single end panels
3 Cut-outs per vanity for inset wash hand basins (WHB`s not supplied) 1,346
Male Toilet
1 x Duct Panel adjacent to WCs @ 1100mm wide x 2400mm high with 1 end 721
1 Vanity Unit @ 1763mm long x 600mm deep x 850mm high with 2 Single end panel
2 Cut-outs per vanity for inset wash hand basins (WHB`s not supplied) 895
1 - Modesty Partition @ 800mm wide 352
Extra Over price for Powder coated aluminium box section anti-peep rails above the bench
seats with 4 horizontal rails set at approx. 175mm centres to give an overall span of 700mm
from back to front to all changing cubicles = 2,395
Swallows October 08
8
Please note this quotation includes the provision of aluminium angle guards to the locker doors.
These will increase resistance to attempted break-ins, improving the level of security, now required
in all areas of high use public facilities throughout the UK. The amount included in this estimate is
1,740
Prospecs unique method of attaching the lock to the door, combined with these angle guards,
gives a much higher level of resistance by comparison to lockers with locks screwed directly onto
the door, without additional edge protection.
We have allowed for the above works to be carried out in 4 visits, we would need to make an extra
charge for any additional visits.
Please note our Terms and Conditions, which are contained on the rear of this quotation.
See attached Manufacture, Delivery & Installation Conditions for current lead times.
Swallows October 08
9
Poolside Features
Updated version of the large slide for Swallows. I can imagine this in the pool, and when you walk
in from the changing rooms it would certainly catch your attention.
It'
s two sharks bursting through a wave which is breaking above them.
There' s a low wavy wall to cut it into two lanes for the kids to go down. They could go down on
rings, inflatable body boards, or just by themselves.
There are loops on the underneath of the canopy for a hosepipe/s to be attached which shower the
children as they go down. Or there could be along the shark so they spray sideways.
The sides of the slide would be digitally artworked, so we could add a logo, or we could have fish
being caught in the slip stream of the shark etc. There are quite a few possibilities with the
artwork.
This would need to blowers to run it, we can discuss where is best for them to attach to the slide.
This concept is based on an Interactive Water Playground that can be configured and
themed to suit your requirements. The Water Playground features include:
Swallows October 08
10
Wireless transmitter
4 x Activator buttons
Price excludes any Civil works and is subject to a full site survey and final design.
Swallows October 08