Escolar Documentos
Profissional Documentos
Cultura Documentos
-----------------
15-6-2017
The install files for JKSimBlast can be found on the Flash Drive in the folder
[FD]:\JKSimBlast_v2\install.
*Note: Additional steps are required for a network license. See instructions in
[FD]:\JKSimBlast_v2\install\Hardlock.
LICENSE
-------
This flash drive contains a license for these JKSimBlast modules:
* 2DBench open cut blast design and analysis
* 2DFace tunnel blast design and analysis
* 2DRing underground ring blast design and analysis
INSTALL
-------
The install programs are located in [FD]:\JKSimBlast_v2\install
If you cannot run the setup programs from the flash drive, copy the files to a
temporary folder on the computer.
* Setup_JKSimBlast_v2.11.03.exe
To avoid security issues that prevent the JKSimBlast programs from writing
their own files, it is strongly recommended to install to the default
folder C:\Programs\JKSimBlast.
* To install only the design modules 2DBench, 2DFace and 2DRing, uncheck the
options for JKBMS, 2DView and TimeHEx.
2. During installation, the setup program will run the install for the dongle
drivers: HASPUserSetup.exe.
For a new installation, copy the pre-configured program folder from the
flash drive and paste over the installed folder:
5. That's it. Plug in the dongle, wait for the system to recognise it, and
then start the JKSimBlast programs from the Start menu, and run JKSimView3
from the new shortcut.
UPDATES
-------
Updates for programs and files are included in [FD]:\JKSimBlast_v2\update,
or can be downloaded from www.soft-blast.com/indexD.htm as zip files.
An update will usually consist of some folders containing the new files. The
folders will match corresponding folders in the main JKSimBlast program folder.
Copy the files to the same folders in JKSimBlast, replace any existing files.