Valves does 1)Foreign object Try running irrigation Open NRV top cover (for openable not seal - trapped inside while knocking with aNRV only) or remove the NRV from backflow NRV hammer on the NRV line Check the presence of foreign objects 2)Organic / Back flow leak does -take them off clean the parts / Inorganic not stop seal sediments on Check the presence of sediments valve seal or -clean them with chlorine / acid sealing seat Check if parts / seal are damaged -replace the parts / seal if necessary * -replace the NRV if necessary * Leak through 3)Shaft sealing Open plugs of shaft Replace O rings and reassemble the shaft is damaged and check the O-ring * Micro switch is 4)Short circuit Change limit switch Open the micro switch and look for out of function position manually exposed wires in contact couple of times, a Cut damaged wires and reconnect click can be heard but Replace it if necessary * the circuit remains closed 5)Contact does Change limit switch Open the micro switch and look for not occur position manually cut or disconnected wires couple of times, a Cut damaged wires and reconnect click can be heard but Replace it if necessary * the circuit does not close 6)Limit switch Check whether the Readjust limit switch wheel location position / limit switch is so that switching will take place at adjustment is activated when the the right timing / flow condition not correct system change position from "no flow" to "flow" and vice versa 7)Contacts does Close irrigation valves Add a "counter weight" to the NRV not cut at "no manually to force it to rotate all the way down flow" condition -limit switch does not to its seat stop the pump