Escolar Documentos
Profissional Documentos
Cultura Documentos
SERVICE MANUAL
Ver.3-2008K
Revision History
Area Model Lineup
l
VGN-AW50DB/H
VGN-AW70B/Q
a
VGN-AW80NS*
i
VGN-AW80S*
Japanese Japanese
t
VGN-AW80US*
VGN-AW90NS
n
VGN-AW90S
VGN-AW90US
e
VGN-AW110J/H
d
VGN-AW110N/H
VGN-AW120J/H
i
VGN-AW125J/H
f
US VGN- AW130J/H
VGN- AW150Y/H*
n
VGN-AW160J/Q
Canadian VGN-AW170C
o
American VGN-AW170Y/Q
VGN-AW180Y/Q
VGN-AW190
C
VGN-AW190C
VGN-AW110D
VGN-AW120D
y
Latin VGN-AW180AU
VGN-AW180FU
n
VGN-AW1RXU/Q
o
VGN-AW11M/H
VGN-AW11S/B
European AEP/UK VGN-AW11SR/B
S
VGN-AW11XU/Q
VGN-AW11Z/B
VGN-AW11ZR/B
Design and specifications are subject to change without
VGN-AW15G/H
Asian/Oceania/ International VGN-AW17GU/Q notice.
ʳCTO Model PERSONAL COMPUTER
9-852-394-03
Information in this document is subject to Caution Markings for Lithium/Ion Battery - The
change without notice. following or similar texts shall be provided on Service and Inspection Precautions
battery pack of equipment or in both the operating
Sony, VAIO and CLIE are trademarks or regis- and the service instructions. 1. Obey precautionary markings and 4. Inspect after completing service
tered trademarks of Sony. Microsoft, Windows, instructions
Windows Media, Outlook, Bookshelf and other CAUTION: Danger of explosion if battery is After servicing, inspect to make sure that all
Microsoft products are trademarks or registered incorrectly replaced. Replace only with the same Labels and stamps on the cabinet, chassis, and screws, components, and wiring have been
trademarks of Microsoft Corporation in the components identify areas requiring special pre- returned to their original condition. Also check
or equivalent type recommended by the manu-
United States and other countries. The word cautions. Be sure to observe these precautions, the area around the repair location to ensure that
facturer. Discard used batteries according to the
Bluetooth and the Bluetooth logo are trademarks as well as all precautions listed in the operating repair work has caused no damage, and confirm
of Bluetooth SIG, Inc. AMD, the AMD logo, other manufacturer’s instructions.
manual and other associated documents. safety.
AMD product names and combinations thereof
are trademarks of Advanced Micro Devices, Inc. CAUTION: The battery pack used in this device 5. When replacing chip components...
2. Use designated parts only
Intel Inside logo, Pentium, Celeron and Core are may present a fire or chemical burn hazard if mis-
trademarks or registered trademarks of Intel Cor- treated. Do not disassemble, heat above 60°C The set’s components possess important safety Never reuse components. Also remember that
poration. Transmeta, the Transmeta logo, Crusoe characteristics, such as noncombustibility and the negative side of tantalum capacitors is easily
(140°F) or incinerate. Dispose of used battery
Processor, the Crusoe logo and combinations the ability to tolerate large voltages. Be sure that damaged by heat.
thereof are trademarks of Transmeta Corporation promptly. Keep away from children.
replacement parts possess the same safety charac-
in the USA and other countries. Graffiti, Hot- teristics as the originals. Also remember that the 6. When handling flexible print
Sync, PalmModem, and Palm OS are registered CAUTION: Changing the back up battery. mark, which appears in circuit diagrams and boards...
trademarks, and the Hotsync logo and Palm are • Overcharging, short circuiting, reverse charg- parts lists, denotes components that have particu-
trademarks of Palm, Inc. or its subsidiaries. (M) ing, multilation or incineration of the cells must larly important safety functions; be extra sure to • The temperature of the soldering-iron tip
and Motrola are trademarks of Motrora, Inc. Other be avoided to prevent one or more of the fol- use only the designated components. should be about 270°C.
Motrola products and services with (R) mark like lowing occurrences; release of toxic materials,
• Do not apply the tip more than three times to
Dragomball are the trademarks of Motrola, Inc. release of hydrogen and/or oxygen gas, rise in
3. Always follow the original design the same pattern.
surface temperature.
when mounting parts and routing • Handle patterns with care; never apply force.
All other names of systems, products and services • If a cell has leaked or vented, it should be
in this manual are trademarks or registered trade- replaced immediately while avoiding to touch wires
Caution: Remember that hard disk drives are
marks of their respective owners. In this manual, it without any protection.
The original layout includes various safety fea- easily damaged by vibration. Always handle
the (TM) or (R) mark are not specified.
tures, such as inclusion of insulating materials with care.
(tubes and tape) and the mounting of parts above
the printer board. In addition, internal wiring has
been routed and clamped so as to keep it away
from hot or high-voltage parts. When mounting
7KH FRPSRQHQWV LGHQWLILHG E\ PDUN FRQWDLQ parts or routing wires, therefore, be sure to du-
FRQ¿GHQWLDOLQIRUPDWLRQ plicate the original layout.
6WU LF WO\ IROORZ WKH LQVWU XF WLRQV ZKHQHYHU WKH
FRPSRQHQWVDUHUHSDLUHGDQGRUUHSODFHG
2 [Sony Confidential]
VGN-AW Series (9-852-394-XX)
TABLE OF CONTENTS
Section Title Page Section Title Page
CHAPTER1. BLOCK DIAGRAM CHAPTER4. OTHERS
1-1.VGN-AW Series………………………………………….. 1-1 4-1.Replacing the CPU………………………………… 4-1
(to 1-1) 4-2. Holding Method of Main Board………………….. 4-2
CHAPTER2. FRAME HARNESS DIAGRAM (to 4-2)
2-1.VGN-AW Series (TOP)…………………………………… 2-1
2-2.VGN-AW Series (BOTTOM)…………………………….. 2-2
(to 2-2)
CHAPTER3. EXPLODED VIEWS AND PARTS LIST x SPECIFICATIONS are listed on page 3-1 of
Note……………………………………………………………. 3-2 “CHAPTER3. EXPLODED VIEWS AND PARTS LIST.
Screws x History of the changes is shown as the “Revision
S-1.Screws……………………………………………… 3-3 History” at the end of this data.
Palmrest
P-1.Palmrest………….………………………………… 3-4
Main Board
M-1.Main Board ……………………………………….. 3-5
Bottom
B-1.Bottom………….………………………………….. 3-6
CABINET KBCOVER
C-1.CABINET KBCOVER…………………………….. 3-7
ODD
D-1.ODD………………………………………………… 3-8
HDD
H-1.HDD………………………………………………… 3-9
LCD
L-1.LCD……………………………………………….… 3-10
ACCESSORIES
A-1.ACCESSORIES…………………………………… 3-11
DIP Switch…………………………………………………….. 3-12
(to 3-12)
[Sony Confidential]
3
VGN-AW Series (9-852-394-XX)
CHAPTER1.
BLOCK DIAGRAM
1-1.VGN-AW Series
EEPROM
(HDCP) GFX CPU
HDMI HDMI
Connector Connector HDMI
nVIDIA Intel C2D Clock Gen. X.TAL
NB9P/NB9M
LVDS/VGA GDDR3 Processor ICS9LPR321AKLF(MLF64) 14.318MHz
LVDS
Micro-FCBGA-478
18.4”’TFT SPDIF /HP OUT
SPDIF/HP (478 pin socket P)
Jack
VGA Ext.Mic in
PCIE X16
D-type-15p Jack SO-DIMM 0
FSB 667/800/1066MHz
667/800MHz
USB 2.0 DDR(II)
CONN*2 HDA
200pin
R+
1 Watt (8 0hm)
North Bridge
R- USB 2.0
1 Watt (8 0hm) Cantiga SO-DIMM 1
2W AMP GDDR3 VRAM 667/800MHz CONN.X2
L+ YAMAHA (R-ch) EQ R ALC889DSD PM45
1 Watt (8 0hm) NB9P-GS 32Mx32bitx4
YDA144B
Circuit L CODEC NB9M-GS 32Mx32bitx2 DDR(II)
L- (L-ch) FCBGA-1329
1 Watt (8 0hm) 200pin
Express Card
USB2.0
Sub Woofer 2W AMP
2 Watt (40)hm Controller X4 DMI Mini-Card
YDA153
Link0 (Direct Media Interface)
PCIE
Digital Mic
PCIE + USB2.0
RJ11
MDC1.5 South Bridge ROBOSON 1.7
Modem 12pin HDA PCIE
CAM (1.3M) USB2.0 ICH9-M/ USB2.0
PCIE ICH9-Enhanced USB2.0
676 mBGA
Bluetooth
Finger Print USB2.0 USB2.0
CF JIMICRON
JMB368
Sensor (UPEK) SATA 4
FeliCa
PCI BUS SATA 0
PCIE SATA 5
RICOH R5C833 IR Receiver
MS DUO POWER SATA 1
SWITCHES
CardBus
LPC
BD2056AFJ CardReader
SD i-LINK
Winbond
B-CAS
I.LINK WPCE775L
Mini PCI
(TV)
F/PAL LQFP-128
SATA SSD HDD SATA
Ethernet G-LAN SSD
Transformer ODD HDD2
Netswap 88E8055
RJ45
NS682403P MARVELL SATA HDD1
XBUS
PWM SMB Channel 1
10/100/1000
SMB Channel 2
PS/2
2-1
[Sony Confidential]
VGN-AW Series (9-852-394-XX)
2-2. VGN-AW Series (BOTTOM)
2-2
[Sony Confidential]
(END)
VGN-AW Series (9-852-394-XX)
CHAPTER3.
EXPLODED VIEWS AND PARTS LIST
ΗThe parts list is compiled by blocks of a Palmrest and bottom etc.
The sections of the parts list are different depending on the model. x Double-click on the paper clip mark in the Spec column to open the specifications list.
Please refer to list of contents shown. x To open the parts list, Microsoft office Excel or Excel viewer is required.
Section Page Palmrest Main Board Bottom ODD HDD LCD Accessories Spec
Note…………………………………………………………… 3-2 AW50DB/H P-1 M-1 B-1 D-1 H-1 L-1 A-1
P-1.Palmrest………….…………………………………… 3-4
AW90NS
P-1 M-1 B-1 D-1 H-1 L-1 A-1
AW90S
P-1 M-1 B-1 D-1 H-1 L-1 A-1
Main Board AW90US
P-1 M-1 B-1 D-1 H-1 L-1 A-1
M-1.Main Board …………………………………………… 3-5 AW110D P-1 M-1 B-1 D-1 H-1 L-1 A-1
AW110J/H P-1 M-1 B-1 D-1 H-1 L-1 A-1
Bottom AW110N/H P-1 M-1 B-1 D-1 H-1 L-1 A-1
B-1.Bottom…………………………………………………. 3-6 AW120D P-1 M-1 B-1 D-1 H-1 L-1 A-1
ODD AM
AW150Y/HҘ
P-1 M-1 B-1 D-1 H-1 L-1 A-1
AW160J/Q P-1 M-1 B-1 D-1 H-1 L-1 A-1
D-1.ODD…………………………………………………… 3-8 AW170C P-1 M-1 B-1 D-1 H-1 L-1 A-1
HDD AW170Y/Q P-1 M-1 B-1 D-1 H-1 L-1 A-1
H-1.HDD…………………………………………………….. 3-9
AW80AU P-1 M-1 B-1 D-1 H-1 L-1 A-1
AW180FU P-1 M-1 B-1 D-1 H-1 L-1 A-1
LCD AW180Y/Q P-1 M-1 B-1 D-1 H-1 L-1 A-1
L-1.LCD…………………………………………………….. 3-10 AW190
P-1 M-1 B-1 D-1 H-1 L-1 A-1
P-1 M-1 B-1 D-1 H-1 L-1 A-1
ACCESSORIES AW190C
AW1RXU/Q P-1 M-1 B-1 D-1 H-1 L-1 A-1
A-1.ACCESSORIES……………………………..………… 3-11 AW11M/H P-1 M-1 B-1 D-1 H-1 L-1 A-1
CTO Model
[Sony Confidential]
3-1 VGN-AW Series (9-852-394-XX)
Note
xParts List is attached on the upper right portion of each EXPLODED VIEW. x If there is the Remarks column in the parts list, the features of applicable models are indicated in it for
x Items marked “*” are not stocked since they are seldom required for routine service. the parts that are different depending on each model.
Some delay should be anticipated when ordering these items. For the abbreviations used in the remarks column, please refer to the <table 1>.
xThe mechanical parts with no reference number in the exploded views are not supplied.
xThe parts marks “$” are the Reuse Parts.
xThe parts marks with “&” indicates specific parts handling for Japan region.
<table 1>
Disregard “&” marking for other than Japan region.
x Color after description in [ ] shows color variation name of the main body.
x The model that is accompanied by asterisk (
) is the CTO model. Full-Name Short-Name
xWhen replacing the HDD of RAID setting, please exchange to the same HDD that was installed. Bluetooth BT
Felica Felica
Basically, the parts marked “z” should be used for service.
Wireless WAN WAN
The parts marked “” in the parts list are substitution parts. Wireless LAN WLAN
If the part marked “z” is not available, you can order the parts marked “”, 1seg Tuner 1seg
but it may not be stocked. Finger Print Sensor FP
Security Chip TPM
Flash Memory F Mem
Camera Camera
x If “No-” is described on the left side of the Short-Name, it means ‘not equipped’.
Example: “No-BT” “No-Felica” etc.
x When several descriptions are listed, each description is separated with “, (comma)” or “or”. “Comma” means plus.
Example.1: The parts for the model equipped with BT and Felica and WLAN ÆBT, Felica, WLAN
Example.2: The parts for the model equipped with BT or Felica ÆBT or Felica
x If the color is in the remarks column, it indicates the color of parts itself.
[Sony Confidential]
3-2
VGN-AW Series (9-852-394-XX)
S-1. SCREWS Parts List
x Double-click on the paper clip mark to open the parts list.
x To open the parts list, Microsoft office Excel or Excel viewer is required.
B1 B2 B3 B4 B5 B6 B7 B8 B9 B10
M2*L2.5 M2.6*L9 M2*L3 M2*L5 M2*L8 M2*L8 M2*L1.6 M3*L3 M3*L6 M3*L8
Silver Silver Black Silver Silver Black Black Silver Black Black
[Sony Confidential]
3-3
VGN-AW Series (9-852-394-XX)
P-1. Palmrest Parts List
x Double-click on the paper clip mark to open the parts list.
x To open the parts list, Microsoft office Excel or Excel viewer is required.
B5
27
B3 26 B5
24
28 27
10 6
26
B4
22 28
37 B3
12
15
B3
16
38
23 14
9
13
25
B3
31
33
5
B3
17 3
20 36
1
B3
19 B3
11
7 8 18
39 35 21
4
2
B3
B7
702
703
704
706
705
B7
701
2014
REMOTE CONTROLLER
Unlock Lock
2
Reference marks
2
Unlock Lock
4-1
[Sony Confidential]
VGN-AW Series (9-852-394-XX)
4-2. The Method of Holding Main Board
1. When operating with both hands, gently hold the middle of Main board edge as show.
2. When operating with one-hand, gently hold the middle of Main board edge and keep vertical.
(Level) (Vertical)
4-2
[Sony Confidential]
(END)
VGN-AW Series (9-852-394-XX)
VGN-AW Series (J/AM/EU/AO)
This manual and the constituent data may not be replicated, copied nor
reprinted in whole or in part without prior written authorization of Sony
Corporation
English
2008KF00-1
9-852-394-03 Sony Corporation © 2008 Sony Corporation
21 Published by Sony Corporation VAIO Business Group VAIO Global CS Dept.
Revision History
<Remarks>
324
[Sony Confidential]
VGN-AW Series (9-852-394-XX)