Escolar Documentos
Profissional Documentos
Cultura Documentos
2.0 Purpose
Everyday
5.0 Materials
Analog Multitester
6. Method
1. Firstly, check the pointer of the VOM if it is located at the 0 mark of the scale. If exactly equal to 0
a. Get a small flat screw driver; be sure that it fits the zero position adjuster.
b. Then slowly turn the zero position adjuster while looking at the pointer. Stop turning the zero
pointer adjuster when the pointer is exactly above the zero value of the scale (extreme left).
2. If the pointer cannot be positioned in the zero mark using the zero pointer adjuster; then the VOM
3. To check if the battery and meter is still in good condition. Do the following;
b. Short the two test probes by connecting the Black and Red test pins together.
c. Turn the zero-ohm adjuster (the pointer should move during this time) until the pointer is
d. If the pointer moves along the VOM scale and can be set to zero ohm; the VOM is in good
e. If in step 6 the pointer does not move along the VOM scale while adjusting the zero-ohm
7.0 Records
Check the Master Register. Documents that do not bear NVSU’s official QMS
Verify that this is the current revision before use Stamps are considered “ Uncontrolled”
Not to be reproduced without prior written authorization from QMR.